power steering FIAT ULYSSE 2007 2.G User Guide

Do not travel with the
windscreen washer reser-
voir empty. The wind-
screen washer is fundamental for
improving visibility.Do not start the wind-
screen washer when the
fluid is finished to prevent
damaging the pump engine.
POWER STEERING FLUID
fig. 9
The oil level, with the vehicle on lev-
el ground and the engine cold should
correspond to the MAX reference
line.
This check should be performed
when the engine is cold and with the
car on level ground.When topping up (where necessary)
make sure that the oil has the same
specifications as the oil in the system.
Apply the following procedure:
– when the engine has been started,
turn the steering wheel repeatedly on
the left and on the right; then bring it
back to its central position;
– remove cap Aand wait for the oil
level in the reservoir to stabilize;
– top up to reach the MAX refer-
ence line and put the cap back to its
place. Certain commercial ad-
ditives for windscreen
washers are inflammable.
The engine compartment con-
tains hot components which may
set it on fire.
CAR MAINTENANCE
196fig. 9 - Versions 2.0 JTD 120 HP - 136 HP
Versions 2.2 JTD 170 HP
F0B0443b

CAR MAINTENANCE
197
Do not let the power
steering fluid come into
contact with hot engine
parts. It catches fire very easily.The brake fluid is poiso-
nous and very corrosive.
In the event of accidental
contact, immediately wash the
affected parts with water and
mild soap and rinse under run-
ning water. Immediately call a
doctor if the fluid is swallowed.
Oil consumption is ex-
tremely low. If the oil lev-
el needs topping up again
in a short period of time, have the
system checked for leakage at a
Fiat Dealership.Make sure that the high-
ly corrosive brake fluid
does not trip onto the
paintwork. If it does, wash it off
immediately with water. BRAKE AND HYDRAULIC
CLUTCH FLUID fig. 10
Remove cap Aand check that the
fluid in the reservoir is at the maxi-
mum level.
The symbol πon the
container indicates syn-
thetic brake fluid distin-
guishing it from mineral fluid. Us-
ing mineral type fluid would dam-
age the special rubber braking
system gaskets beyond repair.

CAR MAINTENANCE
207
To ensure the front and rear tyres all
wear evenly, you are advised to change
the tyres every 10-15 thousand kilo-
metres keeping them on the same side
of the car so as not to reverse the di-
rection of rotation.RUBBER TUBING
Follow the Service Schedule to the
letter as concerns braking, power
steering and fuel line rubber tubing.
Ozone, high temperatures and long ab-
sence of fluid in the system can in fact
cause the hardening and cracking of the
pipes with possible loss of fluid. A care-
ful check is therefore essential.
WINDSCREEN/
REAR WINDOW
WIPERS
BLADES
Periodically clean the rubber part
with suitable products. We recom-
mend TUTELA PROFESSIONAL
SC 35.
Change the blades if the rubber edge
is warped or worn out. You should in
any case change them approximately
once a year. Do not change the tyres
over in criss-cross fashion
by moving a tyre from the
left hand side of the car to the
right and vice versa.
Travelling with worn
wiper blades is dangerous
because it reduces visibil-
ity in bad weather.

TECHNICAL SPECIFICATIONS
229
CAPACITIES
2.0 JTD
120 HP
litres
80
8
9
5.25
1.9
–
1.2
1.2
0.519
7.52.0 JTD
136 HP
litres
80
8
9
5.25
1.9
–
1.2
1.2
0.519
7.5Recommended fluids
and lubricants
Recommended products
Diesel for motor vehicles
(EN590 specifications)
Mixture of distilled water and
PARAFLU11(blue) at 50% or
PARAFLU UP(red) at 50%
SELENIA TURBO DIESEL (❏)
TUTELA MATRYX
TUTELA GI/E
TUTELA GI/A
TUTELA GI/R
TUTELA TOP 4
50-50 mixture of distilled
water and TUTELA
PROFESSIONAL SC 35 2.2 JTD
170 HP
litres
80
8
9
4.75
–
–
1.2
1.2
0.93
7.5
Fuel tank:
– including a reserve of:
Engine cooling system:
Engine sump and filter:
Transaxle:
Automatic gearbox
Hydraulic power steering:
Electro-hydraulic power steering
Hydraulic brake circuit with:
ABS (with ESP)
Windscreen, rear mirror and headlight
liquid reservoir:
(❏) For temperatures lower than –15°C we recommend using SELENIA WR DIESEL SAE5W-40.

TECHNICAL SPECIFICATIONS
231
(*) IMPORTANTDo not add or mix with fluids with specifications other than the specified ones. Use
Drive lubricants
and grease
Brake fluid
Radiator
antifreeze
Windscreen /
rear window/
headlight washer fluidFluid and lubricant specifications
for correct car operation
Synthetic oil SAE 75W-85 complying with API GL4 and
MIL-L-2105 D LEV specifications
ATF DEXRON II D oil, LEV
Synthetic fluid for hydraulic and electro-hydraulic systems
ATF DEXRON III oil
Molybdenum disulphide grease high temperature resistant
specific for homocinetic joints, NLGI 1-2consistency.
Synthetic fluid, F.M.V.S.S. n° 116, DOT 4, ISO 4925,
SAE J-1704, CUNA NC 956-01
Protective with antifreeze action, blue color, based on inhibit-
ed monoethylene glycol, CUNA NC 956-16
Protective with antifreeze action, red colour, based on inhibited
monoethylen glycol, with O.A.T.-based organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications
Mixture of alcohol, water and surfactants CUNA NC 956-11Recommended
fluids and lubricants
TUTELA
MATRYX
TUTELA GI/A
TUTELA GI/R
TUTELA GI/E
TUTELA
ALL STAR
TUTELA TOP 4
PARAFLU 11 (*)
or
PARAFLU UP (*)
TUTELA
PROFESSIONAL
SC 35Applications
Mechanical gearbox
and differential
Hydraulic power
steering
Electro Hydraulic power
steering
Electronic
automatic gearbox
CV joints
Hydraulic brakes
and clutch
Cooling ducts
Percentage:
50% down to –35°C
To be used diluted
or neat in windscreen
washer/wiper systems

INDEX
241
- maintenance indicator............ 54
- scheduled servicing ................ 184
- service
schedule ............................ 185-186
Ceiling lights
(central and rear) ..................... 103
- bulb replacement ................... 168
Central door locking system ..... 22
Central glass/can holder ............. 97
Chassis marking ........................... 216
Cheap running that respects
the environment ....................... 145
Checking fluid levels ................... 189
- brake and hydraulic
clutch fluid ................................ 197
- engine coolant.......................... 195
- engine oil ................................... 193
- power steering fluid ............... 196
- windscreen/rear window/
headlight washer fluid ............ 195
Child restraint systems .............. 42
- passenger seat compliance
with regulations on child’s
seat use...................................... 46
- presetting for mounting
“Isofix Type” child' seat ......... 47
Child safety lock
- electrical .................................... 23- mechanical ................................ 23
Child surveillance (mirrors)....... 35
Cigar lighter ................................. 101
Climate control system ............. 62
- air vents ............................ 63-64
Clutch
- technical specifications........... 221
CO
2emissions in exhaust ......... 233
CODE card
(Fiat CODE system) ................ 11
Compartments under front
seats .............................................. 98
CONNECT ................................... 56
Containing running costs
and pollution .............................. 145
Cruise Control ............................. 88
Dashboard ................................. 48
Diesel fuel filter
(draining the condense) .. 190-200
Dimensions ................................... 226
Dipped beam headlights
- control ....................................... 79
- halogen bulb replacement ..... 163
- Xenon light replacement ....... 164
Direction indicators
- control ...................................... 82- replacing front bulbs ............. 162
- replacing side bulbs ............... 165
- types ........................................... 161
Document compartment............ 98
Door lights ................................... 104
Doors super lock ......................... 22
Driving your car ........................... 136
EBD (Electronic braking
force distributor) ...................... 118
Elastic bands .................................. 100
Electric windows ......................... 105
- anti-crushing system ............... 105
- driver’s door controls ........... 105
- passenger’s door controls .... 106
- sliding door controls .............. 106
Electrical sockets .......................... 104
Electro-chromatic mirror........... 34
Electronic alarm .......................... 14
- deactivation without the
remote control ....................... 17
- programming the system....... 17
- request for additional
remote controls ...................... 17
- switching the volumetric
protection off ........................... 17

INDEX
244
Main beam headlights
- bulb replacement .................... 163
- control ...................................... 79
- flashing ...................................... 81
Maintenance indicator ................. 54
- operation .................................. 55
- reconfiguration ........................ 55
- resetting .................................... 56
Manual climate control system 64
- Air distribution ........................ 64
- Air quality ................................ 65
- Climate control ...................... 67
- Controls ................................... 66
Manual gearbox ........................... 89
- technical specifications ......... 221
MBA system................................... 118
Model plate .................................... 215
MSR system ................................... 122
Number plate lights
- bulb replacement .................... 167
Oddment compartments......... 98
Odometer display ........................ 54
- engine oil level gauge.............. 54
- scheduled maintenance
indicator .................................... 54- trip kilometre counter ........... 54
Paint
- maintenance ............................. 210
Paint identification plate ............. 216
Parking ............................................ 139
Parking sensor ............................. 130
- general notes............................ 131
- towing a trailer ....................... 131
Passenger's compartment
air vents ............................... 63-64
Performance .................................. 227
Pollen filter ............................ 190-199
- maintenance ............................ 190
Power steering fluid level .......... 197
Pretensioners (seat belts) ......... 37
Protecting the environment ...... 135
Puddle lights
- bulb replacement .................... 170
Rain sensor ................................... 83
Rear fog lights
- bulb replacement .................... 166
- controls .................................... 81
Rear heated window ...... 72-73
Rear seats ..................................... 27
- adjustment ....................... 27-28- armrests ................................... 33
- dismantling ................................ 29
- head restraints ........................ 32
- interior settings .............. 31-32
- third row bench seat.............. 29
Rearview mirrors
- adjustment ................................ 36
- door mirrors ........................... 35
- driving mirror ......................... 34
Rear window blades
- replacement.............................. 209
Rear window opening/
closing ........................................... 106
Rear window washer
- control ....................................... 85
Rear window wiper
- blade replacement ................. 209
- control ...................................... 85
Rear windows
- calliper opening ....................... 107
Refuelling ....................................... 229
Rev counter ................................... 53
Reverse lights
- bulb replacement .................... 166
Roof rack bars............................... 113
Rubber tubing
(maintenance) ............................ 207