fuel filter FIAT ULYSSE 2007 2.G Owners Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2007, Model line: ULYSSE, Model: FIAT ULYSSE 2007 2.GPages: 254, PDF Size: 3.42 MB
Page 61 of 254
GETTING TO KNOW YOUR CAR
60
GLOW PLUGS
(Amber)
The light comes on when
the ignition key is turned to Mand
then goes off when the glow plugs
have reached the set temperature.
Start the engine immediately after
the warning light goes off.
IMPORTANTWhen the environ-
ment temperature is very high, the
warning light might come on for less
than a second.FUEL RESERVE
(Amber)
The warning light comes on
when 8 litres of fuel have remained in
the tank. SERVICE WARNING
LIGHT (Red)
This warning light will turn
on in the following cases: low coolant
level, particulate filter failure, low par-
ticulate filter additive level, risk of
clogged particulate filter.
DIPPED HEADLIGHTS
(Green)
When the dipped-beam
headlamps are turned on.
RIGHT DIRECTION
INDICATOR (Green)
The warning light starts
flashing when the direction indicator
control stalk is lifted or together with
the left direction indicator, when the
hazard light button is pressed.
K
2
E
m
The warning light will come on when
the front passenger air bag is deacti-
vated.
REAR FOG LIGHTS
(Amber)
When the rear fog lights
are turned on.
ESP SYSTEM (Amber)
The light comes on when
you turn the ignition key to
M, but it should go out after a couple
of seconds.
If the warning light either stays on or
comes on while travelling contact a Fi-
at Dealership.
Warning light flashing when driving
indicates that the ESP system is active.
4
ñ
è
Page 136 of 254
GETTING TO KNOW YOUR CAR
135
PROTECTING THE
ENVIRONMENT
Protecting the environment has been
a constant guiding factor of the
Ulysse’s design and manufacture at
every stage. The result of this atten-
tion is to be seen in the choice of ma-
terials and installation of devices able
to drastically limit or reduce harmful
influences on the environment.
Devices for reducing emissions from
JTD engines are:
– oxidising catalytic converter;
– exhaust gas recirculation system
(E.G.R.);
– particulate filter (where fitted): its
purpose is to trap and burn particulate
(unburnt particles) to reduce harmful
exhaust emissions.
The vehicle, therefore, has great ad-
vantages with respect to the strictest
international anti-pollution directives. Do not put open flames
or lighted cigarettes near
the fuel filler hole as there
is a danger of fire. Do not lean out
too close to the hole either so as
not to breathe in harmful
vapours.
Where necessary, to
avoid compromising the
efficiency of the fuel
vapour recovery system, replace
the fuel cap with another genuine
spare part.
IMPORTANTThe waterproof fu-
el filler cap lock may be slightly pres-
surised. Therefore, do not worry if
some air comes out when the cap is
released.
After filling, drive in the cap by turn-
ing it clockwise until it clicks twice or
thrice, then turn the key clockwise and
remove it. Close the flap.
Page 177 of 254
IN AN EMERGENCY
176
FUSEBOX IN THE ENGINE COMPARTMENT fig. 39
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
17
1810A
15A
10A
10A
10A
15A
20A
20A
15A
15A
10A
10A
15A
10A
30A
30A
40AReverse light switch, Xenon lights, electric fan controls, engine coolant level,
heated diesel filter, preheating spark plugs,
speed control system, air debit gauge
Fuel pump, exhaust gas recirculation and turbo-compressor control system
ABS, ESP
Keyed service power supply, for main electronic control unit
Particulate filtering system
Front fog lights
Headlight washers
Relay power supply for main electronic control unit, electric fan relay controls ,
diesel pressure adjusting solenoid valve and exhaust gas
recirculation
Left dipped beam headlight, headlight beam corrector
Right dipped beam headlight
Left main beam headlight
Right main beam headlight
Horn
Windscreen wiper pump - rear window wiper
Lambda sensor, injectors, spark plugs, canister solenoid valve,
injection pump solenoid valve
Windscreen wiper
Additional fans
Page 187 of 254
30 60 90 120 150 180
●●●●●●
●
●
●●●
●●●●●●
●●●
●●●●●●
●●●
●●●●●●
CAR MAINTENANCE
186
Thousand of kilometres
Check engine control system operation (through diagnostic socket)
Top up special particulate filter fluid (2.0 JTD 136 HP and 2.2 JTD version)
Replace particulate filter (2.0 JTD 136 HP and 2.2 JTD version)
Replace timing belt*
Replace diesel fuel filter
Bleed diesel fuel filter
Change air cleaner cartridge
Change engine oil and oil filter
Change brake fluid (or every 2 years)
Change pollen filter (or every 2 years)
(*) The timing belt shall be replaced every 180.000 km or 10 years..
Page 189 of 254
CAR MAINTENANCE
188
Should prevailing use of the vehicle
be under one of the following special-
ly heavy conditions:
– trailer or caravan towing;
– dusty roads;
– short distances (less than 7-8 km)
repeated and with external tempera-
tures below zero;– frequently idling engines or long
distance low speed driving (e.g. door-
to-door deliveries) or in case of a long
term inactivity;
– driving in the city;
carry out the following checks more
frequently than required in the Service
Schedule:
– check front disk brake pad condi-
tions and wear;– check cleanness of locks, bonnet
and boot and lever cleanness and lu-
brication;
– sight inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
– check battery charge and fluid lev-
el (electrolyte);
– visual check on various drive belt
conditions;
– check and replace pollen filter, if re-
quired;
– check and replace air cleaner, if re-
quired.
HEAVY-DUTY
Page 201 of 254
DIESEL FUEL FILTER
DRAINING THE CONDENSE
fig. 12
The presence of water in the fuel
feed circuit can severely damage the
injection system and make the engine
misfire. For this reason, drain the con-
dense every 5,000 km.
Contact a Fiat Dealershipto have
this operation carried out.The following procedure is only for
information:
– loosen knob Ain the filter lower
part;
– tighten Aup again when diesel
without water starts flowing out.Dispose of the water and
diesel fuel drained from
the filter correctly. You
should have the operation car-
ried out by a Fiat Dealership
which is properly equipped for
disposing of it out in a way that
respects nature and the current
legislation.
fig. 12
F0B0172b
CAR MAINTENANCE
200
Page 230 of 254
TECHNICAL SPECIFICATIONS
229
CAPACITIES
2.0 JTD
120 HP
litres
80
8
9
5.25
1.9
–
1.2
1.2
0.519
7.52.0 JTD
136 HP
litres
80
8
9
5.25
1.9
–
1.2
1.2
0.519
7.5Recommended fluids
and lubricants
Recommended products
Diesel for motor vehicles
(EN590 specifications)
Mixture of distilled water and
PARAFLU11(blue) at 50% or
PARAFLU UP(red) at 50%
SELENIA TURBO DIESEL (❏)
TUTELA MATRYX
TUTELA GI/E
TUTELA GI/A
TUTELA GI/R
TUTELA TOP 4
50-50 mixture of distilled
water and TUTELA
PROFESSIONAL SC 35 2.2 JTD
170 HP
litres
80
8
9
4.75
–
–
1.2
1.2
0.93
7.5
Fuel tank:
– including a reserve of:
Engine cooling system:
Engine sump and filter:
Transaxle:
Automatic gearbox
Hydraulic power steering:
Electro-hydraulic power steering
Hydraulic brake circuit with:
ABS (with ESP)
Windscreen, rear mirror and headlight
liquid reservoir:
(❏) For temperatures lower than –15°C we recommend using SELENIA WR DIESEL SAE5W-40.
Page 242 of 254
INDEX
241
- maintenance indicator............ 54
- scheduled servicing ................ 184
- service
schedule ............................ 185-186
Ceiling lights
(central and rear) ..................... 103
- bulb replacement ................... 168
Central door locking system ..... 22
Central glass/can holder ............. 97
Chassis marking ........................... 216
Cheap running that respects
the environment ....................... 145
Checking fluid levels ................... 189
- brake and hydraulic
clutch fluid ................................ 197
- engine coolant.......................... 195
- engine oil ................................... 193
- power steering fluid ............... 196
- windscreen/rear window/
headlight washer fluid ............ 195
Child restraint systems .............. 42
- passenger seat compliance
with regulations on child’s
seat use...................................... 46
- presetting for mounting
“Isofix Type” child' seat ......... 47
Child safety lock
- electrical .................................... 23- mechanical ................................ 23
Child surveillance (mirrors)....... 35
Cigar lighter ................................. 101
Climate control system ............. 62
- air vents ............................ 63-64
Clutch
- technical specifications........... 221
CO
2emissions in exhaust ......... 233
CODE card
(Fiat CODE system) ................ 11
Compartments under front
seats .............................................. 98
CONNECT ................................... 56
Containing running costs
and pollution .............................. 145
Cruise Control ............................. 88
Dashboard ................................. 48
Diesel fuel filter
(draining the condense) .. 190-200
Dimensions ................................... 226
Dipped beam headlights
- control ....................................... 79
- halogen bulb replacement ..... 163
- Xenon light replacement ....... 164
Direction indicators
- control ...................................... 82- replacing front bulbs ............. 162
- replacing side bulbs ............... 165
- types ........................................... 161
Document compartment............ 98
Door lights ................................... 104
Doors super lock ......................... 22
Driving your car ........................... 136
EBD (Electronic braking
force distributor) ...................... 118
Elastic bands .................................. 100
Electric windows ......................... 105
- anti-crushing system ............... 105
- driver’s door controls ........... 105
- passenger’s door controls .... 106
- sliding door controls .............. 106
Electrical sockets .......................... 104
Electro-chromatic mirror........... 34
Electronic alarm .......................... 14
- deactivation without the
remote control ....................... 17
- programming the system....... 17
- request for additional
remote controls ...................... 17
- switching the volumetric
protection off ........................... 17
Page 245 of 254
INDEX
244
Main beam headlights
- bulb replacement .................... 163
- control ...................................... 79
- flashing ...................................... 81
Maintenance indicator ................. 54
- operation .................................. 55
- reconfiguration ........................ 55
- resetting .................................... 56
Manual climate control system 64
- Air distribution ........................ 64
- Air quality ................................ 65
- Climate control ...................... 67
- Controls ................................... 66
Manual gearbox ........................... 89
- technical specifications ......... 221
MBA system................................... 118
Model plate .................................... 215
MSR system ................................... 122
Number plate lights
- bulb replacement .................... 167
Oddment compartments......... 98
Odometer display ........................ 54
- engine oil level gauge.............. 54
- scheduled maintenance
indicator .................................... 54- trip kilometre counter ........... 54
Paint
- maintenance ............................. 210
Paint identification plate ............. 216
Parking ............................................ 139
Parking sensor ............................. 130
- general notes............................ 131
- towing a trailer ....................... 131
Passenger's compartment
air vents ............................... 63-64
Performance .................................. 227
Pollen filter ............................ 190-199
- maintenance ............................ 190
Power steering fluid level .......... 197
Pretensioners (seat belts) ......... 37
Protecting the environment ...... 135
Puddle lights
- bulb replacement .................... 170
Rain sensor ................................... 83
Rear fog lights
- bulb replacement .................... 166
- controls .................................... 81
Rear heated window ...... 72-73
Rear seats ..................................... 27
- adjustment ....................... 27-28- armrests ................................... 33
- dismantling ................................ 29
- head restraints ........................ 32
- interior settings .............. 31-32
- third row bench seat.............. 29
Rearview mirrors
- adjustment ................................ 36
- door mirrors ........................... 35
- driving mirror ......................... 34
Rear window blades
- replacement.............................. 209
Rear window opening/
closing ........................................... 106
Rear window washer
- control ....................................... 85
Rear window wiper
- blade replacement ................. 209
- control ...................................... 85
Rear windows
- calliper opening ....................... 107
Refuelling ....................................... 229
Rev counter ................................... 53
Reverse lights
- bulb replacement .................... 166
Roof rack bars............................... 113
Rubber tubing
(maintenance) ............................ 207
Page 253 of 254
Fiat Group Automobiles S.p.A.
Quality - Assistenza Tecnica - Ingegneria Assistenziale
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print no. 603.81.281 - 09/2007 - 1
stedition
COLD TYRE INFLATION PRESSURE (bar)
ENGINE OIL CHANGE
FUEL CAPACITIES
2.0 JTD - 2.2 JTD
Tank capacity litres 80
Reserve litres 8
Refuel diesel engines with diesel fuel for motor vehicles (EN590 specifications) only.
Front
2.5
2.5 Tyre
215/60 R16
215/65 R15Rear
2.5
2.5Front
2.5
2.5Rear
3.4
3.0 Empty Full load
Add +0.3 bars to the prescribed inflation pressure when the tyres are warm. In any case. check the correct value again when the tyres are cold.
2.0 JTD 2.2 JTD
Engine sump and filter litres 5.25 4.75
#Dispose of waste oil properly.