checking oil FORD AEROSTAR 1996 1.G Owners Manual

83 %
*
[LG07500(ALL)05/94]
Engine Oil Pressure Gauge
*
[LG07601(ALL)06/93]
This gauge indicates the engine's oil pressure,
not the oil level. However, if your engine's oil
level is low, it could affect the oil pressure. With
the engine running, the pointer should move
into the NORMAL band. If the pointer drops
below the NORMAL band while the engine is
running, you have lost oil pressure and
continued operation will cause severe engine
damage.
*
[LG07701(ALL)03/95]
If you lose engine oil pressure:
*
[LG07801(ALL)03/95]
1. Pull off the road as soon as safely possible.
*
[LG07901(ALL)04/95]
2. Shut off the engine immediately or severe
engine damage could result.
*
[LG08001(ALL)02/95]
3. Check the engine's oil level, following the
instructions on checking and adding engine
oil. Refer toEngine oilin the Index. If you
do not follow these instructions, you or
others could be injured. To assure an
accurate reading, your vehicle should be on
level ground.
*
[LG08051(ALL)03/93]
4. If the level is low, add only as much oil as
necessary before you start the engine again.
Do not overfill. Do not operate the engine if
the pointer is below the NORMAL band,
regardless of the oil level. Contact your
nearest dealer for further service actions.
*
[LG08200(ALL)03/93]
quarter page art:0020057-D
Engine oil pressure gauge
File:05cplga.ex
Update:Tue Aug 29 17:36:50 1995

283 %
*
[SV13775(ALL)01/95]
Checking and Adding Engine Oil
*
[SV13800(ALL)03/95]
Since the proper amount of engine oil is
important for safe engine operation, check the oil
using the dipstick each time you put fuel in
your vehicle. Remember the engine must be off,
the oil must be warm and the vehicle must be
parked on level ground.
%*
[SV13900(ALL)03/95]
Checking the engine oil level:
*
[SV14000(ALL)02/95]
1. Turn the engine off after it has warmed up
and allow a few minutes for the engine oil
to drain back into the oil pan.
*
[SV14050(ALL)03/95]
2. Set the parking brake, making sure the
gearshift is securely latched in P (Park).
*
[SV14100(ALL)02/95]
3. Open the hood. Protect yourself from engine
heat.
*
[SV14200(ALL)03/95]
4. Locate the engine oil dipstick (highlighted in
yellow) and carefully pull it out of the
engine.
*
[SV14300(ALL)01/95]
5. Wipe the dipstick clean and put it back into
position, making sure it is fully seated.
[SV14400(ALL)06/95]
quarter page art:0095016-A
Engine oil dipstick
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

284
*
[SV14500(ALL)03/95]
6. Carefully, pull the dipstick out again. If the
oil level is below the ªADD 1 QTº line, add
engine oil as necessary. If the oil level is
beyond the letter ªFº in Full, engine damage
or high oil consumption may occur and
some oil must be removed from the engine.
*
[SV14600(ALL)01/95]
7. Put the dipstick back in and make sure it is
fully seated.
%*
[SV14700(ALL)03/95]
Adding engine oil
*
[SV14800(ALL)01/95]
It may be necessary to add some oil between oil
changes. Make sure you use a CERTIFIED
engine oil of the preferred viscosity. Your
vehicle's warranty coverage may not apply if
engine damage is caused by the use of improper
engine oil.
*
[SV15000(ALL)03/95]
Add engine oil through the oil filler cap
highlighted in yellow. To add oil, remove the
filler cap and use a funnel to pour oil into the
opening. Be careful not to overfill the engine.
Recheck the oil level after you finish adding oil.
%
*
[SV17300(ALL)03/95]
Engine Coolant
%*
[SV17400(ALL)03/95]
Checking the Engine Coolant
*
[SV17500(ALL)02/95]
NOTE: Be sure to read and understand
Precautions When Servicing Your
Vehicleat the beginning of this chapter.
*
[SV17700(ALL)08/95]
Your vehicle's engine coolant protects the engine
from overheating in the summer and from
freezing in the winter. Check the level of the
engine coolant at least once a month, but
preferably each time you stop for fuel. Simply
look at the engine coolant recovery reservoir
located in the engine compartment. To locate
this reservoir, see the diagram of your vehicle's
engine underEngine Compartmentin this chapter.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

366 Index
Engine coolant temperature gauge..... 85
Engine fan............... 266
Engine idle speed control......... 67
Engine knocking............. 276
Engine oil............... 282
checking and adding......... 283
dipstick............... 283
disposal............... 266
engine oil pressure gauge........ 83
filter, specifications.......... 337
refill capacities............ 335
specifications...........282, 338
synthetic oil............. 282
ªbreak-inº oils............. 7
viscosity............... 282
Entry system, illuminated........ 107
Exhaust fumes.............. 71
Extended Service Plan, Ford........ 4
F
Fan, engine fan, avoiding injury..... 266
Federal Communications Commission . . . 184
Federal Highway Administration
Regulation............... 6
Flashers, hazard............. 113
Flashing the lamps........... 110
Flat tire................. 229
Fluid refill capacities........... 335
Ford Customer Assistance Center..... 247
Ford Dispute Settlement Board...... 248
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 253
Ford of Canada Customer
Assistance Centre........... 253
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 377
Trailer towing
calculating maximum trailer weight . . 211
safety chains............. 219
trailer brakes............. 219
trailer lamps............. 219
Transmission
automatic operation.......... 186
fluid, checking and adding
(automatic)............ 307
fluid, refill capacities......... 335
lubricant specifications........ 338
Transmission control switch....... 188
Trip odometer.............. 88
Tune-up specifications (VECI)...... 332
Turn signal............... 109
indicator lights............ 109
lever................ 109
U
Used engine oil, disposal........ 266
V
Variable interval wipers......... 110
VECI (Vehicle Emission Control Information)
decal................ 332
Vehicle Identification Number (VIN).... 5
Vehicle loading............. 205
calculating the load.......... 211
understanding loading information . . . 207
Vehicle storage............. 342
Ventilating your vehicle
(see Climate control).......... 91
Viscosity (see Engine oil)........ 282
Voltmeter (see Battery voltage gauge).... 82
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995