check oil FORD AEROSTAR 1997 1.G Owners Manual

16 %
*
[IS07500(ALL)04/96]
Engine Oil Pressure Gauge
*
[IS07601(ALL)01/96]
This gauge indicates the engine's oil pressure,
not the oil level. However, if your engine's oil
level is low, it could affect the oil pressure. With
the engine running, the pointer should move
into the NORMAL band. If the pointer drops
below the NORMAL band while the engine is
running, you have lost oil pressure and
continued operation will cause severe engine
damage.
*
[IS07701(ALL)05/96]
If you lose engine oil pressure:
*
[IS07801(ALL)04/96]
1. Pull off the road as soon as safely possible.
*
[IS07901(ALL)04/96]
2. Shut off the engine immediately or severe
engine damage could result.
*
[IS08001(ALL)01/96]
3. Check the engine's oil level, following the
instructions on checking and adding engine
oil. Refer toEngine oilin the Index. If you
do not follow these instructions, you or
others could be injured. To assure an
accurate reading, your vehicle should be on
level ground.
*
[IS08051(ALL)01/96]
4. If the level is low, add only as much oil as
necessary before you start the engine again.
Do not overfill. Do not operate the engine if
the pointer is below the NORMAL band,
regardless of the oil level. Contact your
nearest dealer for further service actions.
*
[IS08200(ALL)03/96]
quarter page art:0020057-D
Engine oil pressure gauge
File:03cpisa.ex
Update:Fri Jun 7 14:23:36 1996

234
*
[MC06085(ALL)05/96]
NOTE: Ford production and aftermarket
(Motorcraft) oil filters are designed for
added engine protection and long life.
If a replacement oil filter is used that
does not meet Ford material and design
specifications, startup engine noises or
knock may be experienced. It is
recommended you use the appropriate
Motorcraft oil filter (or another brand
meeting Ford specifications) for your
engine application.
%*
[MC06090(ALL)01/96]
Checking and Adding Engine Oil
*
[MC06095(ALL)01/96]
Since the proper amount of engine oil is
important for safe engine operation, check the oil
using the dipstick each time you put fuel in
your vehicle. Remember the engine must be off,
the oil must be warm and the vehicle must be
parked on level ground.
%*
[MC06100(ALL)01/96]
Checking the engine oil level:
*
[MC06110(ALL)01/96]
1. Turn the engine off after it has warmed up
and allow a few minutes for the engine oil
to drain back into the oil pan.
*
[MC06120(ALL)01/96]
2. Set the parking brake, making sure the
gearshift is securely latched in P (Park).
*
[MC06130(ALL)01/96]
3. Open the hood. Protect yourself from engine
heat.
*
[MC06140(ALL)01/96]
4. Locate the engine oil dipstick (highlighted in
yellow) and carefully pull it out of the
engine.
*
[MC06150(ALL)01/96]
5. Wipe the dipstick clean and put it back into
position, making sure it is fully seated.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

235 [MC06160(ALL)01/96]
quarter page art:0095016-A
Engine oil dipstick
*
[MC06170(ALL)03/96]
6. Carefully pull the dipstick out again. If the
oil level is below the ªADD 1 QTº line, add
engine oil as necessary. If the oil level is
beyond the letter ªFº in Full, engine damage
or high oil consumption may occur and
some oil must be removed from the engine.
*
[MC06180(ALL)01/96]
7. Put the dipstick back in and make sure it is
fully seated.
%*
[MC06190(ALL)01/96]
Adding engine oil
*
[MC06200(ALL)01/96]
It may be necessary to add some oil between oil
changes. Make sure you use a CERTIFIED
engine oil of the preferred viscosity. Your
vehicle's warranty coverage may not apply if
engine damage is caused by the use of improper
engine oil.
*
[MC06210(ALL)01/96]
Add engine oil through the oil filler cap
highlighted in yellow. To add oil, remove the
filler cap and use a funnel to pour oil into the
opening. Be careful not to overfill the engine.
Recheck the oil level after you finish adding oil.
[MC07000(ALL)05/96]
Engine Oil and Filter Changes
*
[MC07100(ALL)05/96]
Change your engine oil and oil filter according
to these mileage and time requirements,
whichever occurs first.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

236
*
[MC07200(ALL)05/96]
one third page art:0060618-C
Oil change intervals
*
[MC07300(ALL)05/96]
Refer to theMaintenance Schedulebooklet for
additional information.
%
*
[MC08000(ALL)05/96]
Brake Fluid
*
[MC08025(ALL)01/96]
Your vehicle is equipped with a brake fluid level
indicator in the master cylinder which lights the
BRAKE warning light on the instrument panel
when the brake fluid level is low.
*
[MC08050(ALL)01/96]
Under normal circumstances, your vehicle
should not use up brake fluid rapidly. However,
expect the level of the brake fluid to slowly fall
as you put more mileage on your vehicle and
the brake pads wear.
*
[MC08075(ALL)01/96]
Check the brake fluid at least once a year. You
can do this by looking at the fluid level in the
plastic brake fluid reservoir on the master
cylinder. The fluid level should be at or near the
MAX mark.
*
[MC08090(ALL)01/96]
RWARNING
Brake fluid is toxic.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

251 %
*
[MC15150(ALL)05/96]
RWARNING
Batteries contain sulfuric acid which burns
skin, eyes, and clothing.
*
[MC15170(ALL)02/96]
If the acid touches someone's skin, eyes, or
clothing, immediately flush the area with water
for at least 15 minutes. If someone swallows the
acid, have him or her drink lots of milk or water
first, then Milk of Magnesia, a beaten egg, or
vegetable oil. Call a doctor immediately.
%*
[MC15190(ALL)02/96]
RWARNING
Applying too much pressure on the ends
when lifting a battery could cause acid to
spill. Lift the battery with a carrier or
with your hands on the opposite corners.
%
*
[MC24500(ALL)02/96]
Wiper Blades
*
[MC24600(ALL)01/96]
Check the windshield wiper blades at least twice
a year. Also check them whenever they seem
less effective than usual. Substances such as tree
sap and some hot wax treatments used by
commercial car washes reduce the effectiveness
of wiper blades.
*
[MC24700(ALL)01/96]
If the blades do not wipe properly, clean both
the windshield and the wiper blades. Use
undiluted windshield washer solution or a mild
detergent. Rinse thoroughly with clear water. Do
not use fuel, kerosene, paint thinner, or other
solvents to clean your wiper blades. These will
damage your blades.
*
[MC24800(ALL)01/96]
To make reaching the wiper blades easy, simply
turn the ignition to the ACC position and turn
your wipers on. Wait for them to reach a
vertical position and turn the ignition to the OFF
position. Do not move the wipers manually.
Manually moving the wipers across the
windshield may damage them.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

270
*
[MC38250(ALL)01/96]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[MC38300(ALL)01/96]
RWARNING
On vehicles without original equipment
floor covering or insulation, do not let
passengers ride in your truck in a manner
that allows contact between skin and the
metal floor.
*
[MC38400(ALL)01/96]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
*
[MC38410(ALL)01/96]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[MC38420(ALL)01/96]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[MC38430(ALL)08/95]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

342 Index
Engine oil
changing oil and oil filter....... 234
checking and adding......... 234
dipstick............... 234
disposal.............230, 248
engine oil pressure gauge........ 16
filter, specifications.......... 293
refill capacities............ 294
specifications...........233, 296
synthetic oil............. 233
ªbreak-inº oils............. 5
viscosity............... 233
Entry system, illuminated......... 73
Exhaust fumes............. 160
Extended Service Plan, Ford........ 3
F
Fan, engine fan, avoiding injury..... 230
Federal Communications Commission.... 58
Federal Highway Administration
Regulation............... 5
Flashers, hazard........... 78,199
Flat tire................. 209
Fluid refill capacities........... 294
Ford Customer Assistance Center..... 305
Ford Dispute Settlement Board...... 306
Ford Extended Service Plan........ 3
Ford Motor Company of Canada..... 310
Ford of Canada Customer
Assistance Centre........... 310
Foreign registration........... 312
Four-Wheel Drive vehicles, special notice . . 5
Four-wheeling with Ford supplement.... 5
French owner guides, how to obtain.... 3
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

348 Index
N
National Highway Traffic Safety
Administration............ 301
New vehicle break-in........... 5
O
Octane rating.............. 264
Odometer
description............... 20
trip odometer.............. 20
Oil filter................ 293
Oil (see Engine oil)........... 233
Oil viscosity.............. 233
On-board diagnostic (OBD II) system . . . 271
Order forms, service information.... 25,50
Overdrive................ 173
Overseas offices............. 312
P
Parking brake
operation............... 166
warning light.............. 9
Parts (see Motorcraft Parts)........ 293
PCV valve, specifications......... 293
Power door locks............. 88
Power features
door locks............... 88
lumbar support............ 106
mirrors................. 91
windows................ 89
Power steering
dipstick............... 244
driving with power steering...... 168
fluid, checking and adding....... 244
fluid, refill capacity.......... 294
fluid, specifications.......... 296
servicing............... 168
Prop rod, hood............. 231
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

Index 353
Transmission
automatic operation.......... 170
fluid, checking and adding
(automatic)............ 247
fluid, refill capacities......... 294
lubricant specifications........ 296
Trip odometer.............. 20
Tune-up specifications (VECI)...... 271
Turn signal
indicator lights............. 75
lever................. 75
U
Used engine oil, disposal......230, 248
V
Variable interval wipers.......... 76
VECI (Vehicle Emission Control Information)
decal................ 271
Vehicle Identification Number (VIN) . . . 300
Vehicle loading............. 181
calculating the load.......... 187
understanding loading information . . . 179
Vehicle storage............. 283
Ventilating your vehicle
(see Climate control).......... 61
Viscosity (see Engine oil)........ 233
Voltmeter (see Battery voltage gauge) . . 13, 15
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996