charging FORD AEROSTAR 1997 1.G Owners Manual

13 [IS05575(ALL)01/96]
one inch art:0020529-B
Electronic 4-wheel drive warning light
%*
[IS05900(ALL)01/96]
Charging System Light
*
[IS06000(ALL)05/96]
This light indicates that your battery is not being
charged and that you need to have the electrical
system checked.
[IS06050(ALL)01/96]
one inch art:0095040-A
Charging system light
*
[IS06100(ALL)03/96]
This light illuminates every time you turn the
ignition to the ON or START position (engine
off). The light should go off when the engine
starts and the alternator begins to charge.
*
[IS06300(ALL)03/96]
If the light stays on or illuminates when the
engine is running, have the electrical system
checked as soon as possible.
%*
[IS06305(ALL)05/96]
Supplemental Air Bag Readiness Light and
Tone Generator
*
[IS06310(ALL)05/96]
This light illuminates for six seconds when the
ignition is turned to the ON position. If the light
fails to illuminate, continues to flash, remains on,
or if a series of five beeps is heard, have the
system serviced as soon as possible.
File:03cpisa.ex
Update:Fri Jun 7 14:23:36 1996

15 %
*
[IS06400(ALL)05/96]
Battery Voltage Gauge (Voltmeter)
*
[IS06601(ALL)04/96]
This gauge shows you the battery voltage when
the ignition key is in the ON position.
*
[IS06700(ALL)01/96]
If you are running electrical accessories (when
the engine is off, or idling at a low speed), the
pointer may move toward the lower end of the
normal band. If it stays outside the normal band
area, have your vehicle's electrical system
checked as soon as it is safely possible.
*
[IS06701(ALL)04/96]
If the battery is operating under cold weather
conditions, the pointer may indicate in the upper
range of the NORMAL band while the battery is
charging. If you are running electrical accessories
with the engine off or idling at a low speed, or
the battery is not fully charged, the pointer may
move toward the lower end of the NORMAL
band.
*
[IS06750(ALL)04/96]
If it stays outside the NORMAL band, have your
vehicle's electrical system checked as soon as it
is safely possible.
*
[IS06900(ALL)03/96]
quarter page art:0020052-D
Battery voltage gauge
File:03cpisa.ex
Update:Fri Jun 7 14:23:36 1996

222
*
[ER24200(ALL)01/96]
Also retighten to the specified torque at 500
miles (800 km) of operation after any wheel
change or any time the lug nuts are loosened.
*
[ER24301(ALL)01/96]
RWARNING
Failure to retighten wheel lug nuts at
mileages specified could allow wheels to
come off while the vehicle is in motion.
[ER24315(ALL)01/96]
eight pica chart:0020313-A%*
[ER24400(ALL)02/96]
Jump-Starting Your Vehicle
*
[ER24410(ALL)02/96]
Your vehicle's battery may die if you leave the
lights on or any electrical equipment on after
you turn the engine off. If this happens, you
may be able to jump-start your vehicle with a
booster battery.
*
[ER24420(ALL)02/96]
RWARNING
The gases around the battery can explode
if exposed to flames, sparks, or lit
cigarettes. An explosion could result in
injury or vehicle damage.
*
[ER24430(ALL)02/96]
RWARNING
To protect yourself when charging a
battery, always shield your face and eyes.
Make sure that you can breathe fresh air.
File:10cpera.ex
Update:Thu Jun 6 14:45:00 1996

249
%*
[MC15000(ALL)01/96]
Battery
*
[MC15010(ALL)01/96]
Your vehicle may have a Motorcraft
maintenance-free battery. The Motorcraft
maintenance-free battery does not require
additional water during its life of service. The
vents are part of the cover and cannot be
removed. For longer, trouble-free operation, keep
the top of the battery clean and dry. Also, make
certain the battery cables are tightly fastened to
the battery terminals.
*
[MC15020(ALL)01/96]
If you see any corrosion on the battery cables or
terminals, remove the cables from the terminal
and clean them both with a wire brush. You can
neutralize the acid with a solution of baking
soda and water. Reinstall the cables when you
are done cleaning them, and apply a small
quantity of grease to the top of each battery
terminal to help prevent corrosion.
*
[MC15030(ALL)01/96]
Battery replacement
*
[MC15040(ALL)01/96]
If your original equipment battery requires
replacement (under warranty), it may in some
cases be replaced by a Motorcraft
low-maintenance battery. The low-maintenance
battery has removable vent caps for checking the
electrolyte level and for adding water, if needed.
*
[MC15045(ALL)01/96]
Check your battery's electrolyte level, at least
every 12 months or 12,000 miles (20,000 km), in
temperatures up to90ÊF (32ÊC) andmore often
in temperatures above90ÊF (32ÊC).Keep the
electrolyte in each cell up to the ªlevelº
indicator. Do not overfill the battery cell.
*
[MC15050(ALL)01/96]
If the electrolyte level in your battery gets low,
you can add plain tap water to the battery, as
long as you don't use hard water, or water with
a high mineral or alkali content. If possible,
however, try to only fill the battery cell with
distilled water. If the battery needs water often,
have the charging system checked.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

336 Index
Autolamp system (see Headlamps)..... 72
Automatic transmission
fluid, adding............. 248
fluid, checking............ 247
fluid, refill capacities......... 294
fluid, specification........... 296
Axle
lubricant specifications......... 296
refill capacities............ 294
traction lok............177, 254
B
Basic vehicle warranty........... 3
Battery
acid, treating emergencies.....223, 250
charging system warning light...... 13
disconnecting............. 226
how to service............ 249
jumping a disabled battery....... 222
maintenance-free........... 249
proper disposal, recycling....... 250
replacement, specifications....... 293
servicing............... 249
voltage gauge............ 13,15
when storing your vehicle....... 285
Brake fluid
brake warning light........... 9
checking and adding......... 236
description.............. 236
specifications...........237, 296
Brakelamp, high-mount brakelamp..... 72
Brakes
adjustment.............. 163
anti-lock............... 163
applying the brakes.......... 166
brake warning light........... 9
fluid, checking and adding....... 236
fluid, refill capacities.......236, 294
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

338 Index
Charging system gauge.......... 15
Charging system warning light....... 13
Child safety restraints
built-in child seat........... 141
child safety belts........... 150
child safety seats........... 130
Child safety seats
and air bags............. 130
attaching with tether straps...... 139
automatic locking mode (retractor) . 112, 130
built-in child seat........... 141
in front seat............. 130
in rear outboard seat......... 130
in rear seat.............. 130
tether anchorage hardware....... 139
Chime
headlamps on.............. 14
key in ignition............. 14
safety belt............... 11
Circuit breakers
checking and replacing........ 209
see also fuses............. 200
Cleaning your vehicle
built-in child seat........... 283
CD player and discs........... 32
chrome and aluminum parts...... 280
engine compartment.......... 281
exterior............... 280
exterior lamps............ 281
fabric................ 282
headlamps.............. 281
instrument panel......... 61,281
instrument panel lens......... 282
interior................ 282
interior lamps............. 282
mirrors................. 91
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

344 Index
G
Gas cap (see Fuel cap).......... 260
Gas mileage (see Fuel economy) . . . 264, 268
Gasohol................ 265
Gasoline (see Fuel)............ 260
Gauges, Mechanical
battery voltage gauge.......... 15
charging system gauge......... 15
engine coolant temperature gauge.... 17
engine oil pressure gauge........ 16
fuel gauge............... 17
odometer................ 20
speedometer.............. 18
trip odometer.............. 20
GAWR (Gross Axle Weight Rating)
calculating.............. 187
definition.............179, 185
driving with a heavy load....... 179
location............... 185
Gearshift
automatic operation.......... 170
column-mounted........... 170
gearshift override.........155, 171
locking the gearshift........... 74
positions............... 170
shifting the gears........... 170
shift-lock.............155, 171
Gearshift:shifting the gears........ 170
GVWR (Gross Vehicle Weight Rating)
calculating.............. 187
definition.............179, 184
driving with a heavy load....... 179
location............... 185
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996

346 Index
Instrument panel............. 59
cleaning............... 282
registers................ 61
Integrated child seat
(see Built-in child seat)........ 141
Interval wipers.............. 76
J
Jack
operation.............216, 219
positioning............216, 219
storage................ 211
Jump-starting your vehicle
attaching cables............ 224
disconnecting cables.......... 226
K
Keys
key in ignition chime.......... 14
positions of the ignition......... 74
stuck in lock position.......... 74
L
Lamps
checking............... 272
daytime running light system...... 72
hazard flashers.......... 78,199
headlamps............... 71
high-mount brakelamp......... 72
illuminated entry system......... 73
interior lamps.............. 71
replacing bulbs............ 272
trailer................ 195
Lane change indicator (see Turn signal) . . . 75
Lap belts................ 116
Lights, warning and indicator
airbag................. 13
brake................. 9
charging system............. 13
check engine.............. 12
door ajar................ 11
File:cpixa.ex
Update:Fri Jun 7 14:33:41 1996