light FORD ASPIRE 1997 1.G Service Manual

184
*
[MC48950(ALL)07/96]
The driving modes required to reach the ready
condition consist of a minimum of 30 minutes of
city and highway driving as described below:
*
[MC48960(ALL)03/96]
q
20 minutes of driving in stop and go
city-type traffic with at least four idle periods.
*
[MC48970(ALL)03/96]
q
10 minutes of driving on an expressway or
highway.
*
[MC48980(ALL)05/96]
Before completing the above driving modes, the
engine must be warmed up and at operating
temperature. Once started, the vehicle must not
be turned off during the above driving modes. If
the vehicle owner is unable to meet the I/M
requirements by using these driving patterns, an
authorized service center can perform a detailed
OBD II drive cycle as it would any other type of
repair work.
%
*
[MC60000(ALL)03/96]
Lights and Bulb Replacement
*
[MC60100(ALL)01/96]
It is a good idea to check the operation of the
following lights frequently:
*
[MC60200(ALL)01/96]
q
headlamps
[MC60300(ALL)01/96]
q
high mount brakelamp
*
[MC60400(ALL)01/96]
q
tail lamps
*
[MC60500(ALL)01/96]
q
brakelamps
*
[MC60600(ALL)01/96]
q
hazard flasher
*
[MC60700(ALL)01/96]
q
turn signals
*
[MC60800(ALL)01/96]
q
side markers
*
[MC60900(ALL)05/96]
q
license plate lamps
*
[MC61000(ALL)01/96]
q
fog lamps
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

185 %
*
[MC61100(ALL)01/96]
The alignment of your headlamps should be
checked if:
*
[MC61200(ALL)01/96]
q
oncoming motorists frequently signal you to
turn off your vehicle's high beams when you
do not have the high beams on
*
[MC61300(ALL)01/96]
q
the headlamps do not seem to give you
enough light to see clearly at night
*
[MC61400(ALL)01/96]
q
the headlamp beams are pointed substantially
away from a position slightly down and to
the right
%*
[MC61500(ALL)01/96]
Headlamp Bulb
*
[MC61600(ALL)03/96]
The headlamps on your vehicle use replaceable
bulbs. When the lamp burns out, simply replace
the bulb, rather than the whole lamp.
*
[MC61700(ALL)01/97]
WARNING
Handle a halogen headlamp bulb carefully
and keep out of children's reach. Grasp
the bulb only by its plastic base and do
not touch the glass. The oil from your
hand could cause the bulb to break the
next time the headlamps are operated.
*
[MC61800(ALL)01/97]
Do not remove the burned-out bulb unless you
can immediately replace it with a new one. If a
bulb is removed for an extended period of time,
contaminants may enter the headlamp housing
and affect its performance.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

192
%*
[MC69000(ALL)04/96]
Cleaning Your Vehicle
%*
[MC70100(ALL)01/96]
Washing and Polishing Your Vehicle
*
[MC70200(ALL)01/96]
Wash the outside of your vehicle, including the
underside, with a mild detergent.
*
[MC70300(ALL)01/96]
DO NOT:
*
[MC70400(ALL)01/96]
q
Wash your vehicle with hot water
*
[MC70500(ALL)01/96]
q
Wash your vehicle while it sits in direct
sunlight
*
[MC70600(ALL)01/96]
q
Wash your vehicle while the body is hot
*
[MC70700(ALL)01/96]
Pollen, bird droppings and tree sap can damage
the paint, especially in hot weather. Wash your
vehicle as often as necessary to keep it clean.
*
[MC70800(ALL)01/96]
Take similar precautions if your vehicle is
exposed to chemical industrial fallout.
*
[MC70900(ALL)01/96]
Paint damage resulting from fallout is not
related to a defect in paint materials or
workmanship and therefore is not covered by
warranty. Ford, however, believes that continual
improvement in customer satisfaction is a high
priority. For this reason, Ford has authorized its
dealers to repair, at no charge to the owner, the
surfaces of new vehicles damaged by
environmental fallout within 12 months or 12,000
miles (20,000 km) of purchase, whichever comes
first. Customers may be required to bring their
vehicle in for inspection by a Ford
representative.
*
[MC71000(ALL)01/96]
Polish your vehicle to remove harmful deposits
and protect the finish.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

193 %
*
[MC71100(ALL)01/96]
Cleaning Chrome and Aluminum Parts
*
[MC71200(ALL)01/96]
Wash chrome and aluminum parts with a mild
detergent. Do not use steel wool, abrasive
cleaners, fuel or strong detergents.
%*
[MC71300(ALL)01/96]
Cleaning Plastic Parts
*
[MC71400(ALL)01/96]
Some of your vehicle's exterior trim parts are
plastic. Clean with a tar and road oil remover if
necessary. Use a vinyl cleaner for routine
cleaning.
*
[MC71500(ALL)01/96]
Do not clean plastic parts with thinners, solvents
or petroleum-based cleaners.
%*
[MC71600(ALL)01/96]
If you have your vehicle rustproofed, remove
oversprayed rustproofing with a tar and road oil
remover. If rustproofing is not removed from
plastic and rubber parts, it can cause
deterioration.
%*
[MC71620(ALL)03/96]
Cleaning the Wheels
*
[MC71630(ALL)03/96]
Wash the wheels with the same detergent you
use to wash your vehicle's body. Do not use
acid-based wheel cleaners, steel wool, abrasives,
fuel, or strong detergents. These substances will
damage protective coatings. Use tar and road oil
remover to remove grease and tar.
*
[MC71640(ALL)03/96]
NOTE: Before going to a car wash, find out if
the brushes are abrasive.
%*
[MC71700(ALL)01/96]
Cleaning the Exterior Lamps
[MC71800(ALL)01/96]
Do not use dry paper towel, chemical solvents
or abrasive cleaner to clean the lamps, as they
may cause scratches or crack the lights.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

195 %
*
[MC74000(ALL)02/96]
Cleaning the Safety Belts
*
[MC74100(ALL)02/96]
Clean the safety belts with any mild soap
solution that is recommended for cleaning
upholstery or carpets. Do not bleach or dye the
belt webbing because this may weaken it.
*
[MC75000(ALL)05/96]
Cleaning the Instrument Panel Lens
*
[MC75100(ALL)01/96]
Clean the instrument panel lens with a soft cloth
and a glass cleaner, such as Ford Ultra-Clear
Spray Glass Cleaner, or equivalent. Do not use
paper towel or an abrasive cleaner to clean the
lens as these may cause scratches.
%
*
[MC80000(ALL)01/96]
Vehicle Storage
*
[MC80100(ALL)01/96]
Maintenance Tips
*
[MC80200(ALL)01/96]
If you plan on storing your vehicle for an
extended period of time (60 days or more), refer
to the following maintenance recommendations
to ensure your vehicle stays in good operating
condition.
*
[MC80300(ALL)01/96]
General
*
[MC80400(ALL)01/96]
q
Store all vehicles in a dry, ventilated place.
*
[MC80500(ALL)01/96]
q
Protect from sunlight, if possible.
*
[MC80600(ALL)01/96]
q
If vehicles are stored outside, they require
regular maintenance to protect against rust
and damage.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

196
*
[MC80700(ALL)01/96]
Body
*
[MC80800(ALL)01/96]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[MC80900(ALL)01/96]
q
Periodically wash vehicles stored in exposed
locations.
*
[MC81000(ALL)01/96]
q
Touch-up raw or primed metal to prevent
rust.
*
[MC81100(ALL)01/96]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[MC81200(ALL)01/96]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[MC81300(ALL)09/96]
q
Cover interior soft trim to prevent fading.
*
[MC81400(ALL)01/96]
q
Keep all rubber parts free from oil and
solvents.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

197 %
*
[MC81500(ALL)01/96]
Engine
*
[MC81600(ALL)01/96]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[MC81700(ALL)01/96]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[MC81800(ALL)01/96]
Fuel system
%*
[MC81900(ALL)01/96]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[MC82000(ALL)01/96]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
*
[MC82100(ALL)01/96]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[MC82200(ALL)01/96]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
%*
[MC82300(ALL)01/96]
Cooling system
*
[MC82400(ALL)01/96]
q
Protect against freezing temperatures.
%*
[MC82500(ALL)01/96]
Battery
*
[MC82600(ALL)01/96]
q
Check and recharge as necessary.
*
[MC82700(ALL)01/96]
q
Keep connections clean and covered with a
light coat of grease.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

215
*
[HS02850(ALL)04/96]
What Kinds of Cases Does the Board
Review?
*
[HS02900(ALL)04/96]
The Board reviews all warranty performance
complaints on Ford, Mercury and Lincoln cars
and Ford and Mercury light trucks under the
new vehicle limited warranty that have not been
resolved by either a dealer or Ford Motor
Company, except those involving:
*
[HS03000(ALL)04/96]
q
a non-Ford product
*
[HS03050(ALL)04/96]
q
a non-Ford dealership
*
[HS03075(ALL)04/96]
q
a vehicle sales transaction
*
[HS03100(ALL)04/96]
q
request for reimbursement of consequential
expenses. Expenses incidental to the warranty
complaint being reviewed are eligible for
consideration
*
[HS03125(ALL)04/96]
q
items not covered by the new vehicle limited
warranty
*
[HS03150(ALL)04/96]
q
items covered by a service contract
*
[HS03175(ALL)04/96]
q
alleged liability claims
*
[HS03200(ALL)04/96]
q
property damage where the damage is
significant when compared to the economic
loss alleged under the warranty dispute
*
[HS03250(ALL)04/96]
q
cases currently in litigation
*
[HS03300(ALL)04/96]
q
vehicles not used primarily for family,
personal or household purposes (except in
states where the Dispute Settlement Board is
required to review commercial vehicles)
*
[HS03350(ALL)04/96]
Complaints involving vehicles in which
applicable new vehicle limited warranties have
expired at receipt of your application are not
eligible. Eligibility may differ according to state
law. For example, see the unique brochures for
California and Wisconsin purchasers/lessees.
File:14ichsf.ex
Update:Tue Mar 4 08:58:16 1997

Index 243
Index
A
ABS warning light (see Anti-lock
brake system)............. 15
Accessory position on the ignition..... 44
Additives, engine oil.......... 149
Air bag supplemental restraint system . 69, 78
and child safety seats........77±78
description............. 69,71
driver air bag........... 69,71
indicator light............. 14
operation............... 71
passenger air bag............ 71
service and information labels.... 71,75
tone generator............. 74
Air cleaner filter, specifications...... 199
Antenna, radio (see Electronic
sound system)......... 19,27,42
Antifreeze (see Engine coolant)...... 155
Anti-lock brake system (ABS)
description.............. 105
see also Brake............ 105
warning light.............. 15
warninig light............. 9
Appeals (see Dispute settlement board) . . 214
Assistance (see Customer assistance) . . . 211
Audio system (see Electronic
sound system)............. 19
Autolamp system (see Headlamps)..... 46
Automatic transaxle
fluid, adding............. 161
fluid, checking............ 161
Automatic transmission
driving an automatic overdrive.... 112
fluid, adding............. 161
File:icixf.ex
Update:Tue Mar 4 08:59:36 1997

244 Index
B
Backing up.............112, 116
Basic vehicle warranty........... 3
Battery................. 162
acid, treating emergencies . . . 139, 164±165
charging system warning light...... 11
disconnecting............. 142
how to service............ 162
jumping a disabled battery....... 138
maintenance-free........... 162
proper disposal, recycling....... 164
replacement, specifications....... 199
servicing............... 162
voltage gauge.............. 11
when storing your vehicle....... 197
Brake fluid............... 152
brake warning light........... 9
checking and adding......... 152
description.............. 152
Brakelamp............... 191
bulb replacement........... 191
high-mount brakelamp........ 191
Brakes................. 105
adjustment.............. 105
anti-lock............... 105
anti-lock brake system (ABS)
warning light............. 15
applying the brakes.......... 105
brake warning light........... 9
fluid, checking and adding....... 152
fluid, refill capacities......... 152
front disc............... 105
if brakes do not grip well....... 105
master cylinder............ 152
new brake linings............ 5
noise................. 105
parking............... 108
power braking............ 105
servicing............... 152
when storing your vehicle....... 198
File:icixf.ex
Update:Tue Mar 4 08:59:36 1997