towing FORD CAPRI 1974 Workshop Manual

)
Contents
Introductory pages
About th is manual 5
Introduction to the Capri VB 5
General dimensions, weights and capacities 6
Jacking and towing 7
Buying spare P M 'S and vehicle identification numb ers 8
G en eral rep air procedures 9
Tools and workrllU facilIties 10
Safety f irs t! 12
Routine main tenance
Recommended lullricants and flUids
Conv ersion !,I CIOIS
F aull dlilgn osis
Chapter 1
EIlUlne
C[Hlple r 2
Coolin\) system
Ch Fue l ,mel exhaust sy~telll
Chapter 4
Ignition sys!Cm
Chapter 5
Clutch
Chllptcr 6
Manllill IJCil,hox a nd 'llltonlil!'!.: lrililsn'IS~IOII
Chopler 7
Propeller shalt
Ch(liltcr 8
IlCilr ilxl<:
Chapter 9
l3ulklilU sy~lem
Chapter 10
Suspension ilnd SluCIIIIU
Chapter 1 1
Bodyw or k and trl1il19S
Chapter 12
Electrical s y s!Cm
In de x
13
17
18
19
23
57
66
87
"
102
12 8
132
142
1 [is
171
196
248
procarmanuals.com

Jacking and towing
Jilckillg poillls To chan!IC ,I WhUt:1 111 ,11 ,-,"W'!ICIICY. usc the t:]ck slIpplled wilh the ve'lIe!!.!. Ensurf! 1hal the Hhldwh,:cl nuIS;OH! ,ciC;lSCd Imlole Ii, cklll\j up thO ca. and make SlUe Ih;u the .lOIn of the 1,1Ck IS luU.,. cnua\Jcd wI,h the body bracket and thatlhe hase allhe Jilek IS st;lIldlt '!J on a 111111 surface. The Jilek supplied w!lh lhe vehIcle IS 1101 $",,;,l)le lor lISC when laislflg the ve!.iclc lor U\;J",l()II;IIlCC or 'Cp,1If up,:r;J110ns. For this walk, use a trol ley. hyd'ilui,c Of screw-Iype tad IOCille(1 und!:. thO f,OIll crOSSlllcmbcr. bodylrame s,(ic-mcmbcls 01 ,ea, il~le cnsing, .1$ ,UuSlr Usin g the lilling jnck
Fronl IOwin9 pain I S (ll • • owed )
Towing poillls II you/ vehIcle ,s bCIIl9 IOWl;d, m,lke SUfe lhal the lOw rope IS auached to Iho 110111 cmssmembcr or, where Ilued. the towlog eye auachcd 10 Iho 11001 ClOssmember II Ihe vehicle IS equipped wilh atilOma llC Iraosrlllsslon, the d.slanCe lowed rnuSI nOI exceed 15 miles (24 km). 00' Ihe speed 30 mph (48 km/h), olhe.wise sefious damage 10 Ihe Ir I f you me lowrnn another vehicle, minch a lOW rope 10 Ihe lowc. shock absorber mounting brilCkct at thc axlc lube or, If fined, Ihc rCilf
10Wlflg eye.
, 'I I -J ' ,;
~)
'J
: .. ': .... 111"'"' ..... _-.___ •• _...:. __ ... ,
Jacking l)oinl S
Rear towing I)oio \s (arrowe d )
procarmanuals.com

Chapter 6 Manual gearbox and automatic transmission 123
When towing a vehic le wIth automl11ic uansmission it is impoltllllt to observe the precautIons gIven til ,he 'Jading and Towing' se<:,ion at the Iront 01 the manual. Due to the complexity of the au'oma',c tran smission unit. If performance IS not up 10 s tandard, or overhaul is necessary, it IS impera tive that this be left to the locallllain agents who will have the special equipment for fault diagnosis and rectiflcallon. The content of the following sections is thereforc confined to supplying gener", Informl11ion 1'Ind any service information and ins t.uc tion tha i cnn be used by the owner.
19 Routine Illilinte,wno
At the i!lle.vnls SI)CClfiecllll Iho ROllllne Milintennnce seCIlOll in the I.onl 01 th e Illanllal cnllY Oul Ihe follOWIng p'ocp.dwe
Luuricow selector link'1[}() , Applv the h;rrldh.,lke th(:n J,lck \lp the front of Ihc Cill ,'lid Support
,n nxle Slnnds
2 Orlthe Irnkn!JCs at cndl end 01 Ihe genrsh ,h rml on the Icfl·hnnd "le 01 Ihe Iransnll~s,on lowel the cnr \0 Iho wound,
Check /mn.Wllissioll fluid level 4 Elrlll!! the engIne and trnnsnllSSlon to nOllllal ope.IlIUl!IIp.llIperillllfe
and I)alk tho vehlchl on le vel grOllnd 5 Wi,h Ihe engIne idllll(l. move tht: 1.,lnsnllSj"on St:leclt>r lev!]r through ill! pOSlllons 1!lIee lImes. Ihen onuaue '1" ,11111 wall for ;rt lea~t one minute. 6 With ,he engine 51111 idling, wllhd.ilW Ihe lr.1nSnllSSIOll d,psllck.
Wipe it dean, reinsert II, wilhd •• 1W 11 for Ihe second !line nnd read off the levol. 7 Two tv pes 01 automatic transnllssion fluid a.e nvarlilblc (sec SpccifiCiltions 10' tv,>c numbe.s) .1nd It is ImpO,I,ln , Ihilt IheV 'lIe nOI mixed. The colour 01 the dipstick. 10' flUId level checklllg denotes which fluid tvpe to use , 8 If a tlr1nsnllssion requlII"U 1,1ter tvpe fluid IS I'lled 10 " to' COllsult your I'ord dealer rI thIS cond,t ron arIS"~ 9 If III)r.CS~.1rv IOp·up with til'.! spec.rlled orl, thr ough tire drpSlrck tube. 10 tire MAX m, uk, The '1" Adjust Iront brake /)(In(/ '" ApplV Iho handb."ko tholl lack 1'1) th'.! ',ollt 01 the ca. and sUPPO.I axlo stands 11 D,sconnoC t the downshIft ca!)le at Iho t'.1nsmISSlon 12 Slacken Iho brnke band adJusto, sClew locknut and unSClew the
adjus'or screw n lew h,fIlS . 13 Tlghlolllhe adJuslo, sOcw to 14 Nm (10 Ihl II) IISIilU a SUItable lo,que wrcnch From Ih,s poSlllon slaCken the adJusle r screw bv exact Iv I'll \Urns (pre·1983 models) or 2 Iwns ( 1983 and late,
model), Ihen tighten Ihe locknut Wllhoul diSlUrblllg Ihe pOsition of Ihe adjuster sc,ow .
14 R econnec t the downshift cable and lowe' Ihe car 10 Ihe ground.
20 Automalic transmission -removal (HId refining
If l)Osslble, ,aise the car on a hOlsl o. place it over an inspectIon pit. Alternatively, it WIll ho necessary 10 Jack up Ihe car to obtain the Illaximum possible amount of wOlking room undernealh. 2 Place a large d.ain pan benealh the transmiss.on sump (011 pan)
Ihen. working horll the ,car, loosen the a!laching boilS and allow ,he lIuld to drain. nemove all thO bohs excep t tho two I.onl ones to draIn as mIlch fluid as pOSSIble, th on temporarilV .efit Iwo bolls at th e re,1I 10 hold it in place . 3 Remove tho Slilrte. moto. as desc.ibed in Chapter 12 . • jWhero apphcable, rernove the access cover Dnd ad3pto, plale bolts,
Ie the engine untrl the to.qu e converter drain plug is visible, then
unsc.ew Iho plug and d.ain Iho Ihud Into a suit3ble con winer. Refl! and l'Uh ten Iho plug.
Fig. 6 .25 Checkill{J tho au tomatic transmission lIuid lovel (Soc 19)
Fig. 6.2 6 FrQ,1 bn'ko band adjustment (Sec 19)
A Arllf/SICI sc/t'w a Locknut
C Downslu/t Icvel D Downs/u/t c.lblc
Fig. 6.27 Torquo convorter to driveplato boll -arrowod (Sec 20)
'I
.' i
!
,
{ ,
I , .::
.1 , I, , i:
i 'i; ; I
:1
procarmanuals.com

fault diagnosis -172 leaf spling .emoval. bush renewal and refitting -165 maintllnance. louline -161 shock absorber remoyal and refitting -165 stabiliser bar removal and refitting -165 lorque wrenCh settings -158 R"ays -225 Rep.ir procedures, general - 9
Rocker e rms (3.0 litre engine) examinat ion and renovation -51 removal - 49 Rocker arms and coverl (3.0 litre engine) ref itting -55 Rocker assembly (2.8 litre engine) dismantling. examina tion and reassembly -34 Routine maintenance stt Maintenance. routine
5
Safety precautions - 12 Seat belts -191 Seats .emoval and refining -192 Sidelight bulb renewal -213 Spare parta buying -8
to carry in ca. - 19 Spark p lugs conditions (colour) -91 lemoval. servicing and .elilling -95 Speedometer cable renewal - 226 Stabiliur bar Iront -163 rear -165 Starter moto r
description -207
d ismant ling and reassembly -207
removal and refi tting -207 testing on engine -207 Steering column removal. overhaul and refitt ino -170 desc.iption -158 faull diagnosis -172 f,on t wheel alignmenl ~nd steering angles -171 gear (manual)
ove,haul and adjustment -166 removal and refittin g -166 maintenance. rouline -161 power steering bleeding -168 gear removal and refitting -168
pump femoval and refining - 168
specifications _ 157 torque wlench senings -158 track rod end balljoint renewal-167
whea' removal and refitt ing -168 Sump 2.8 litra engine
refining -44
removal and refining with engine in car -34 3.0 litre engine refitting -55 removal -50 Sunroof bracket and dr ive assembly lemoval and refitting -191 panel adjustments -189 removal and refining _ 190 Suspension lfnd steering _ 15 7 tl seq Suspension see Front suspension Imd Re ar suspension jtches removal and relining
Index
T
central facia - 225
door p illar - 224 handbrake warning light _ 225 hazard warning -223
ignition -224
instr um
ent cluster illum ination _ 224 light and windscreen wiper (Series II) -225 load sp':)ce lamp -225 steerin g column multi-Iunction -224
s top lamp - 152
Tailgate priv ate lock removal and relining -187 .emoval and refilling -187 striker plate removal and relin ing - 188 wnsher
nozzle removal and refitting -217
pump rllmov31 and refitting -217 window glass removal and relitting -180 wiper mOlOr and linkage remoyal and refitting -217 Tappets (3.0 litre engine) remoyal -50 Tappets and push rods el u
care and maintenance -171 presswes -158 size -15 8
Underframe
maintenance -16. 176 Upholstery maintenance -176
v
Vacuum servo unit (braking system) description -156 lemov~! and refining -156 Valves clearances checking and adjustment -46 . 55 Valves (3.0 titre engine) removat -49 Valves and va lv e seats (3.0 litre engine) examination and renovation -52 Vehicle identification numbers - 8
255
procarmanuals.com