fuel FORD CONTOUR 1998 2.G Service Manual

Maintenance and care
168
Do not park, idle or drive
your vehicle in dry grass or
other dry ground cover. The
emission system heats up the
engine compartment and exhaust
system, which can start a fire.
Important emission control
imformation
By law, anyone who manufactures,
repairs, services, leases, trades
vehicles or supervises a fleet of
vehicles is not permitted to
intentionally remove an emission
control device or prevent it from
working. Do not make any
unauthorized changes to the
vehicle or engine. Changes that
cause more unburned fuel to reach
the exhaust system can increase
the temperature of the engine or
exhaust system.
When your vehicle is serviced,
never use a metal exhaust
collector. The use of a metal
collector may melt or deform
plastic parts.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 168

Maintenance and care
181 Repairing paint chips
Minor scratches or paint damage
from road debris may be repaired
with touch-up paint, paint repair
foil or aerosol spray from the Ford
accessories line. Observe the
application instructions on the
products.
Cleaning the wheels
Wash the wheels with the same
detergent you use to clean the
body of your vehicle. Do not use
acid-based wheel cleaners, steel
wool, fuel or strong detergents.
Never use abrasives that will
damage the finish of special wheel
surfaces. Use a tar remover to
remove grease and tar.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 181

Maintenance and care
183 Cleaning plastic exterior parts
Use a vinyl cleaner for routine
cleaning of plastic. Clean with a tar
remover if necessary. Do not clean
plastic parts with thinners, solvents
or petroleum-based cleaners.
Cleaning the exterior lamps
Wash the exterior lamps with the
same detergent you use to wash
the exterior of your vehicle. Use
glass cleaner or tar remover if
necessary.
To avoid scratching the lamps, do
not use a dry paper towel, chemical
solvents or abrasive cleaners to
clean the lamps.
Cleaning the wiper blades
If the wiper blades do not wipe
properly, clean both the windshield
and wiper blades using undiluted
windshield wiper solution or a mild
detergent. Rinse thoroughly with
clean water. To avoid damaging the
blades, do not use fuel, kerosene,
paint thinner or other solvents.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 183

Maintenance and care
184Cleaning the interior fabric
Remove dust and loose dirt with a
whisk broom or a vacuum cleaner.
Remove fresh spots immediately.
Follow the directions that come
with the cleaner.
Cleaning leather seats
(if equipped)
For routine cleaning, wipe the
surface with a soft, damp cloth. For
more thorough cleaning, wipe the
surface with a leather and vinyl
cleaner or a mild soap.
Cleaning the instrument panel
HM:
I0 20OFF LOPNL/FLR
PANEL
A/CFLOOR
DEF FLR
DEF
MAX
A/C HI/
POWERAUDIOAM/FM
SCAN
SEEK 312645ANSSIDE1-2EJECTVOLUME
000123000010 20 3040506070
80
90
100
110
120
130MPH20 406055
80120 100
140
160
180
200EF 1
/
2UNLEADED FUEL ONLY12
03x 1000
4
5
6
7
8NORMALBRAKE
CHECK
ENGINE TRACTION
CONTROLO/D
OFF
MIRRORS
Clean the instrument panel with a
damp cloth, then dry with a dry
cloth.
Any cleaner or polish that
increases the gloss of the upper
portion of the instrument panel
should be avoided. The dull finish
in this area is to help protect the
driver from undesirable windshield
reflection.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 184

Capacities and specifications
186
*Refer to Vehicle Emission Control Information (VECI) decal for spark plug and gap specifications.
**If a spark plug is removed for examination, it must be reinstalled in the same cylinder.
If a spark plug needs to be replaced, use only spark plugs with the service part number suffix
letter “FE” as shown on the engine decal.
Motorcraft parts
Component
Spark plug*
Air filter
Passenger compartment
air filter
Fuel filter
Oil filter
Battery
PCVvalve
Crankcase ventilation
filter2.0 litre engine
AZFS-22F # 1+2**
AZFS-22FE# 3+4
FA-1612
FP4
FG-800A
FL-2005
BXT-40R
EV-224
FA-1621
2.5 litre engine
AWSF-32F
FA-1613
FP4
FG-800A
FL-820
BXT-40R
EV-152
—
Part number
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 186

Capacities and specifications
187
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle2.6 l (2.7 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
61.5 l (16.2 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 187

Capacities and specifications
189 Engine data
* Mechanical valve adjuster
2.0 litre
Engine2.5 litre
Engine
19882544
96 (125)
5500125 (170)
6250
176 (130)
4000220 (162)
4250
61506700
63756925
800±50
(880±50)725±50
(725±50)
1-3-4-21-4-2-5-3-6
1.3
Electronically controlled Idle speed
(manual transaxle)Engine
cm
3Capacity
kW(HP)
at rpm Power output
Nm (lb-ft)
at rpm Max. torque
Fuel required87 Octane
rpm Continuous engine
speed
rpm Max. intermittent
engine speed
rpm
Mixture preparation
Injection system
Firing order
mm
Spark plug gap
Ignition system
0.14 mm
0.30 mm Valve Inlet
clearancesExhaustHydraulic valve
adjusters 0.11-0.18*
0.27-0.34*
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 189

CPage
Child safety restraints
built-in child seat . . . . . . . . . . .68
child safety seats . . . . . . . . . . . .74
children and safety belts . . .64, 66
Child safety seats
and air bags . . . . . . . . . . . . . . . .59
attaching with tether straps . . .77
automatic locking mode . . . . . .52
Childproof safety locks . . . . . . . .38
Chimes . . . . . . . . . . . . . . . . . . . . .13
Circuit breakers . . . . . . . . . . . . .112
Cleaning your vehicle
engine compartment . . . . . . . .182
exterior lamps . . . . . . . . . . . . .183
fabric . . . . . . . . . . . . . . . . . . . .184
instrument panel . . . . . . . . . . .184
plastic exterior parts . . . . . . . .183
safety belts . . . . . . . . . . . . . . .185
wheels . . . . . . . . . . . . . . . . . . .181
wiper blades . . . . . . . . . . . . . .183
Climate control system
air conditioning . . . . . . . . . . . . .24
controlling airflow . . . . . . . . . . .23
defrosting . . . . . . . . . . . . . . . . . .26
temperature . . . . . . . . . . . . . . . .23
vents . . . . . . . . . . . . . . . . . . . . . .22
Clock . . . . . . . . . . . . . . . . . . . . . .21
Clutch
operation . . . . . . . . . . . . . . . . . .96
recommended shift speeds . . . .97
Cold engine starting . . . . . . . . . .85
Controls
instrument panel . . . . . . . . . . . .17
mirrors . . . . . . . . . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .48
steering column . . . . . . . . . . . . .27DPage
Daytime running lights . . . . . . . .18
Defects, reporting . . . . . . . . . . .192
Defrost
rear window . . . . . . . . . . . . . . . .19
windshield . . . . . . . . . . . . . . . . .26
Dipstick, engine oil . . . . . . . . . .133
Door mounted controls . . . . . . . .37
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .102
towing a trailer . . . . . . . . . . . .103
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .112
Emergencies, roadside
fuel pump shut-off switch . . . .110
jump starting . . . . . . . . . . . . . .124
towing . . . . . . . . . . . . . . . . . . .127
Emergency brake (see Parking
brake)
Emission control system . . . . . .166
Engine
check engine warning light . . . . .9
fuel pump shut-off switch . . . .110
lubricant specifications . . . . . .188
preparing to start . . . . . . . . . . .82
refill capacities . . . . . . . . . . . .187
starting . . . . . . . . . . . . . . . . . . . .85
Engine block heater . . . . . . . . . .86
Engine coolant
checking and adding . . . . . . . .139
disposal . . . . . . . . . . . . . . . . . .141
low coolant warning light . . . . . .8
refilll capacities . . . . . . . . . . . .187
specifications . . . . . . . . . . . . . .188
Engine fan . . . . . . . . . . . . . . . . .129
Index
194
CDW_Index_en_C 5/15/97 8:59 PM Page 194

Index
195 EPage
Engine oil
changing oil and filter . . . . . . .136
checking and adding . . . . . . . .135
dipstick . . . . . . . . . . . . . . . . . .133
disposal . . . . . . . . . . . . . . . . . .137
engine oil pressure
warning light . . . . . . . . . . . . . . .11
filter specifications . . . . . . . . .186
refill capacities . . . . . . . . . . . .187
specifications . . . . . . . . . . . . . .188
Exhaust fumes . . . . . . . . . . .81, 166
F
Fan (see Engine fan)
Flasher, hazard . . . . . . . . . .29, 110
Flashing the lights . . . . . . . . . . . .30
Floor mats . . . . . . . . . . . . . . . . . .40
Fluid refill capacities . . . . . . . . .187
Foglamps . . . . . . . . . . . . . . .18, 172
Fuel
calculating fuel economy . . . .165
capacity . . . . . . . . . . . . . . . . . .187
choosing the right fuel . . . . . .162
consumption . . . . . . . . . . . . . .109
fuel gauge . . . . . . . . . . . . . . . . .16
low fuel warning light . . . . . . . . .9
octane rating . . . . . . . . . . . . . .163
quality . . . . . . . . . . . . . . . . . . .164
running out of fuel . . . . . . . . .166
safety information relating
to automotive fuels . . . . . . . . .160
Fuel pump shut-off switch . . . .110
Fuse panels
engine compartment . . . . . . . .113
instrument panel . . . . . . . . . . .115FPage
Fuses
charts . . . . . . . . . . . . . . . .114, 117
checking and replacing . . . . . .112
G
Gas mileage (see Fuel economy)
Gauges
engine coolant temperature . . .15
fuel . . . . . . . . . . . . . . . . . . . . . . .16
odometer . . . . . . . . . . . . . . . . . .15
speedometer . . . . . . . . . . . . . . .15
trip odometer . . . . . . . . . . . . . .15
GAWR
(Gross Axle Weight Rating) . . .100
Gearshift . . . . . . . . . . . . . . . .90, 96
GVWR
(Gross Vehicle Weight Rating) .100
H
Hazard flashers . . . . . . . . . .29, 110
Head restraints . . . . . . . . . . . . . .47
Headlamps
aiming . . . . . . . . . . . . . . . . . . .176
bulb specifications . . . . . . . . .175
daytime running light . . . . . . . .18
flashing . . . . . . . . . . . . . . . . . . .30
high beam . . . . . . . . . . . . . . . . .30
replacing bulbs . . . . . . . . . . . .171
turning on and off . . . . . . . . . . .17
warning chime . . . . . . . . . . . . . .13
High beams
indicator light . . . . . . . . . . . . . . .7
operation . . . . . . . . . . . . . . . . . .30
CDW_Index_en_C 5/15/97 8:59 PM Page 195

HPage
High-mount brakelamp . . . . . . .174
Hood
latch location . . . . . . . . . . . . . .132
release lever . . . . . . . . . . . . . .132
Horn . . . . . . . . . . . . . . . . . . . . . . .29
I
Identification Number, Vehicle
(VIN) . . . . . . . . . . . . . . . . . . . . .191
Idle, relearning . . . . . . . . . . . . .149
Idle, speed . . . . . . . . . . . . .149, 189
Ignition
chime . . . . . . . . . . . . . . . . . . . . .13
positions on the ignition . . . . . .27
Instrument cluster . . . . . . . . . . . . .6
Instrument panel
cleaning . . . . . . . . . . . . . . . . . .184
lighting up the panel . . . . . . . . .19
Integrated child seat (see Built-in
child seat)
Intermittent wipers . . . . . . . . . . .31
Introduction . . . . . . . . . . . . . . . . . .2
J
Jack
positioning . . . . . . . . . . . . . . . .122
storage . . . . . . . . . . . . . . . . . . .121
Jump starting your vehicle
attaching cables . . . . . . . . . . . .125
disconnecting cables . . . . . . . .126
K
Keys
key in ignition warning chime .13
positions of the ignition . . . . . .27
Index
196LPage
Lamps
bulb replacement specification
chart . . . . . . . . . . . . . . . . . . . . .175
daytime running light system . .18
flashing the lamps . . . . . . . . . . .30
foglamps . . . . . . . . . . . . . .18, 172
hazard flashers . . . . . . . . .29, 110
headlamps . . . . . . . . . . . . . . . . .17
high beams . . . . . . . . . . . . . . . . .30
high-mounted brake lamp . . . .174
instrument panel, dimming . . .19
interior lamps . . . . . . . . . . . . . .36
reading lamps . . . . . . . . . . . . . .36
replacing bulbs . . . . . . . . . . . .170
rear lamps . . . . . . . . . . . . . . . .173
Lights, warning and indicator
air bag . . . . . . . . . . . . . . . . . . . .10
anti-lock brakes (ABS) . . . . . . .11
brake . . . . . . . . . . . . . . . . . . . . .11
charging system . . . . . . . . . . . . .7
check engine . . . . . . . . . . . . . . . .9
engine oil pressure . . . . . . . . . .11
high beam . . . . . . . . . . . . . . . . . .7
low coolant . . . . . . . . . . . . . . . . .8
low fuel . . . . . . . . . . . . . . . . . . . .9
overdrive off . . . . . . . . . . . . . . . .9
safety belt . . . . . . . . . . . . . . . . . .7
testing the warning lights . . . . .12
turn signal indicator . . . . . . . . . .6
Load limits . . . . . . . . . . . . . . . . .100
Lubricant specifications . . . . . .188
Luggage compartment . . . . . . . .39
CDW_Index_en_C 5/15/97 8:59 PM Page 196