engine FORD CONTOUR 1998 2.G Manual PDF

Maintenance and care
167
BRAKE
BRAKE
TRACTION
CONTROLO/D
OFF
If you notice one or more of the
following, the emission system may
not be functioning properly; have
the vehicle serviced as soon as
possible:
•Fluid leaks.
•The charging system, engine oil
pressure or low coolant warning
lights illuminate in the
instrument cluster and remain lit.
•Strange odors.
•Engine runs for more than five
seconds after shut off or engine
misfires, surges, stalls or
backfires.
•Loss of oil pressure.Alternative design Alternative design
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 167

Maintenance and care
168
Do not park, idle or drive
your vehicle in dry grass or
other dry ground cover. The
emission system heats up the
engine compartment and exhaust
system, which can start a fire.
Important emission control
imformation
By law, anyone who manufactures,
repairs, services, leases, trades
vehicles or supervises a fleet of
vehicles is not permitted to
intentionally remove an emission
control device or prevent it from
working. Do not make any
unauthorized changes to the
vehicle or engine. Changes that
cause more unburned fuel to reach
the exhaust system can increase
the temperature of the engine or
exhaust system.
When your vehicle is serviced,
never use a metal exhaust
collector. The use of a metal
collector may melt or deform
plastic parts.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 168

Maintenance and care
169 Preparing your vehicle for
inspection/maintenance (I/M)
testing
In some localities it may be a legal
requirement to pass an I/M test of
the on-board diagnostic(OBD) II
system. If your vehicle’s powertrain
system or battery has just been
serviced, the OBD II system is reset
to a condition unready for I/M
testing. To ready the OBDII system
for I/M testing, the law specifies
that additional city and highway
driving is necessary to complete
the check of the OBDII system.
The driving mode required to reach
the ready condition consists of a
minimum of 30 minutes of city and
highway driving:
•At least 20 minutes driving in
stop and go city-type traffic with
at least four idle periods.
•At least 10 minutes of driving on
an expressway or highway.
Before completing the above
driving modes, the engine must be
warmed up and at operating
temperature. Once started, the
vehicle must not be turned off
during these modes.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 169

Maintenance and care
182Cleaning the engine
Engines are more efficient when
they are clean because grease and
dirt buildup act as insulators and
keep the engine warmer than
normal. Follow these guidelines to
clean your engine:
•Take care when using a power
washer to clean the engine. The
high pressure fluid could
penetrate the sealed parts and
cause damage.
•Do not spray with cold water, to
avoid cracking the engine block.
•Cover the alternator to prevent
water damage when cleaning the
engine.
•Never wash or rinse the engine
while it is running; water in the
running engine may cause
internal damage.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 182

Maintenance and care
184Cleaning the interior fabric
Remove dust and loose dirt with a
whisk broom or a vacuum cleaner.
Remove fresh spots immediately.
Follow the directions that come
with the cleaner.
Cleaning leather seats
(if equipped)
For routine cleaning, wipe the
surface with a soft, damp cloth. For
more thorough cleaning, wipe the
surface with a leather and vinyl
cleaner or a mild soap.
Cleaning the instrument panel
HM:
I0 20OFF LOPNL/FLR
PANEL
A/CFLOOR
DEF FLR
DEF
MAX
A/C HI/
POWERAUDIOAM/FM
SCAN
SEEK 312645ANSSIDE1-2EJECTVOLUME
000123000010 20 3040506070
80
90
100
110
120
130MPH20 406055
80120 100
140
160
180
200EF 1
/
2UNLEADED FUEL ONLY12
03x 1000
4
5
6
7
8NORMALBRAKE
CHECK
ENGINE TRACTION
CONTROLO/D
OFF
MIRRORS
Clean the instrument panel with a
damp cloth, then dry with a dry
cloth.
Any cleaner or polish that
increases the gloss of the upper
portion of the instrument panel
should be avoided. The dull finish
in this area is to help protect the
driver from undesirable windshield
reflection.
CDW VA1-19Maint en C 5/15/97 8:56 PM Page 184

Capacities and specifications
186
*Refer to Vehicle Emission Control Information (VECI) decal for spark plug and gap specifications.
**If a spark plug is removed for examination, it must be reinstalled in the same cylinder.
If a spark plug needs to be replaced, use only spark plugs with the service part number suffix
letter “FE” as shown on the engine decal.
Motorcraft parts
Component
Spark plug*
Air filter
Passenger compartment
air filter
Fuel filter
Oil filter
Battery
PCVvalve
Crankcase ventilation
filter2.0 litre engine
AZFS-22F # 1+2**
AZFS-22FE# 3+4
FA-1612
FP4
FG-800A
FL-2005
BXT-40R
EV-224
FA-1621
2.5 litre engine
AWSF-32F
FA-1613
FP4
FG-800A
FL-820
BXT-40R
EV-152
—
Part number
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 186

Capacities and specifications
187
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle2.6 l (2.7 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
61.5 l (16.2 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 187

Capacities and specifications
188
ItemFord part name
or equivalent
High performance
DOT 3 brake fluid
Premium engine
coolant
Motorcraft motor
oil 5W-30 super
premium
MERCON
®
power steering
fluid
Motorcraft
MERCON
®ATF
Ultra-clear
windshield washer
concentrate
Ford
part number
C6AZ-19542-AB
E2FZ-19549-AA
CXC-8-B*
XO-5W30-QSP
E6AZ-19582-AA
XT-2-QDX
C9AZ-19550-AA
or
C9AZ-19550-BA
Ford
specification
ESA-M6C25-A
WSE-97B44-A
American Petroleum
Institute Certification
Mark and
WSS-M2C153-G
MERCON®
MERCON®
ESR-M17P5-A Brake fluid
Engine coolant
Engine oil
Power steering
fluid
Transaxle fluid
automatic/
5-speed manual
Windshield
washer
fluid
Lubricant Specifications
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 188

Capacities and specifications
189 Engine data
* Mechanical valve adjuster
2.0 litre
Engine2.5 litre
Engine
19882544
96 (125)
5500125 (170)
6250
176 (130)
4000220 (162)
4250
61506700
63756925
800±50
(880±50)725±50
(725±50)
1-3-4-21-4-2-5-3-6
1.3
Electronically controlled Idle speed
(manual transaxle)Engine
cm
3Capacity
kW(HP)
at rpm Power output
Nm (lb-ft)
at rpm Max. torque
Fuel required87 Octane
rpm Continuous engine
speed
rpm Max. intermittent
engine speed
rpm
Mixture preparation
Injection system
Firing order
mm
Spark plug gap
Ignition system
0.14 mm
0.30 mm Valve Inlet
clearancesExhaustHydraulic valve
adjusters 0.11-0.18*
0.27-0.34*
CDW_VB1-5_Caps_en_C 5/15/97 8:58 PM Page 189

193
Index
APage
Accessory position on
the ignition . . . . . . . . . . . . . . . . . .27
Additives, engine oil . . . . . . . . .135
Air bag supplemental
restraint system
and child safety seats . . . . . . . .59
description . . . . . . . . . . . . . . . . .58
disposal . . . . . . . . . . . . . . . . . . .63
indicator light . . . . . . . . . . .10, 62
operation . . . . . . . . . . . . . . . . . .60
wearing safety belts . . . . . . . . .58
Air conditioning
(see Climate control system)
Alarm, activating panic . . . . . . . .42
Antenna, radio
(see Audio sytem) . . . . . . . . . . . .21
Anti-lock brake system (ABS) . .87
Anti-theft system (see Passive
Anti-Theft System) . . . . . . . . . . .44
Antifreeze (see Engine coolant)
Audio system . . . . . . . . . . . . . . . .21
Automatic transaxle
driving with . . . . . . . . . . . . . . . .92
fluid, adding . . . . . . . . . . . . . . .144
fluid, checking . . . . . . . . . . . . .145
fluid, refill capacities . . . . . . . .187
fluid, specification . . . . . . . . . .188
B
Backing up . . . . . . . . . . . . . . .92, 98
Battery
charging system warning light . .7
jumping a disabled battery . . .124
proper disposal, recycling . . . .148
replacement, specifications . .186
servicing . . . . . . . . . . . . . . . . . .146BPage
Brake fluid
checking and adding . . . . . . . .138
specifications . . . . . . . . . . . . . .188
Brake-shift interlock . . . . . . . . . .91
Brakelamps
(see Bulb replacement)
Brakes
anti-lock brake system (ABS) .87
brake warning light . . . . . . . . . .11
fluid, checking and adding . . .138
fluid, refill capacities . . . . . . . .187
fluid, specification . . . . . . . . . .188
parking . . . . . . . . . . . . . . . . . . . .89
Built-in child seat
folding up the seat . . . . . . . . . .73
inspection after a collision . . . .73
interlock safety feature . . . . . . .69
operation . . . . . . . . . . . . . . . . . .68
retractors . . . . . . . . . . . . . . . . . .69
Break-in period . . . . . . . . . . . . . . .2
Bulbs, replacing
foglamps . . . . . . . . . . . . . . . . .172
headlamps . . . . . . . . . . . . . . . .171
high-mounted brake lamp . . . .174
license plate lamp . . . . . . . . . .173
rear lamps . . . . . . . . . . . . . . . .173
specifications . . . . . . . . . . . . . .175
C
Cabin air filter . . . . . . . . . . . . . .150
Capacities for refilling fluids . . .187
Carbon monoxyde in exhaust . .166
Catalytic converter . . . . . . . . . .168
Chains, tires . . . . . . . . . . . . . . . .158
Changing a tire . . . . . . . . . . . . .119
Charging system warning light . . .7
CDW_Index_en_C 5/15/97 8:59 PM Page 193