fuel FORD CONTOUR 2000 2.G Owner's Guide

223
Capacities and specifications
* Refer to Vehicle Emission Control Information (VECI) decal for spark plug and gap specifications.
** If a spark plug is removed for examination, it must be reinstalled in the same cylinder.
If a spark plug needs to be replaced, use only spark plugs with the service part number suffix
letter “FE” as shown on the engine decal.
Motorcraft parts
Component
Spark plug*
Air filter
Passenger compartment
air filter
Fuel filter
Oil filter
Battery
PCV valve
Crankcase ventilation
filter2.0 litre engine
AZFS-22F # 1+2**
AZFS-22FE# 3+4
FA-1612
FP4
FG-800A
FL-2005
BXT-40R
EV-224
FA-1621
2.5 litre engine
AWSF-32F
FA-1613
FP4
FG-800A
FL-820
BXT-40R
EV-152
—
Part number
32CCSen 17.6.99 11:31 Uhr Seite 223

Capacities and specifications
224
* Total capacity
** with automatic transaxle
Engine oil
- with filter
- without
Manual transaxle 1.9 l (2.0 qts)
Automatic transaxle
with oil cooler
Power steering
Cooling system with heating
Windshield washer fluid
Fuel tank
Braking system4.25 l (4.5 qts)
3.75 l (4.0 qts)
8.5 l (9.0 qts.)
6.6 l (7.0 qts)*
7.1 l (7.5 qts)**
Fill to MAX mark
Fill to top of reservoir
58.5 l (15.4 gallons)
Fill to MAX mark5.5 l (5.8 qts)
5.0 l (5.3 qts)
9.6 l (10.2 qts)
9.5 l (10.0 qts)*
9.7 l (10.2 qts)**
Capacities2.0 litre
engine2.5 litre
engine
32CCSen 17.6.99 11:31 Uhr Seite 224

Capacities and specifications
226Engine data
* Mechanical valve adjuster
2.0 litre
Engine2.5 litre
Engine
1988 2544
96 (125)
5500125 (170)
6250
176 (130)
4000220 (162)
4250
61506700
6375 6925
800±50
(880±50)725±50
(725±50)
1-3-4-2 1-4-2-5-3-6
1.3
Electronically controlled Idle speed
(manual transaxle)Engine
cm
3Capacity
kW (HP)
at rpm Power output
Nm (lb-ft)
at rpm Max. torque
Fuel required87 Octane
rpm Continuous engine
speed
rpm Max. intermittent
engine speed
rpm
Mixture preparation
Injection system
Firing order
mm
Spark plug gap
Ignition system
0.14 mm
0.30 mm Valve Inlet
clearances ExhaustHydraulic valve
adjusters 0.11-0.18*
0.27-0.34*
32CCSen 17.6.99 11:31 Uhr Seite 226

Customer assistance
229 GETTING ROADSIDE
ASSISTANCE
To fully assist you should you have
a vehicle concern, Ford offers a
complimentary roadside assistance
program. This program is separate
from the New Vehicle Limited
Warranty. The service is available:
• 24-hours, seven days a week
• for the Basic warranty period
(Canada) or New Vehicle Limited
Warranty period (U.S.) of three
years or 60,000 km (36,000 miles),
whichever comes first on Ford and
Mercury vehicles, and four years or
80,000 km (50,000 miles) on
Lincoln vehicles.
In the United States, you may
purchase additional roadside
assistance coverage beyond this
period through the Ford Auto Club
by contacting your Ford or Lincoln-
Mercury dealer.
• Roadside assistance will cover
• changing a flat tire
• jump-starts
• lock-out assistance
• fuel delivery
towing to the nearest Ford of
Canada or Ford Motor Company
dealership, or towing to your
selling dealership if within 56 km
(35 miles). Even non-warranty
related tows, like accidents or
getting stuck in the mud or snow,
are covered (some exclusions
apply, such as impound towing or
repossession).Using roadside assistance
Complete the roadside assistance
identification card and place it in
your wallet for quick reference. In
the United States, this card is
found in the Owner Guide portfolio
in the glove compartment in Ford
vehicles and is mailed to you if you
own a Mercury or Lincoln. In
Canada, it's found in the Roadside
Assistance book in the glove
compartment.
To receive roadside assistance in
the United States for Ford or
Mercury vehicles, call
1-800-241-3673 or if you own a
Lincoln vehicle, call
1-800-521-4140. In Canada call
1-800-665-2006.
Should you need to arrange
assistance for yourself, Ford will
reimburse a reasonable amount. To
obtain information about
reimbursement, call
1-800-241-3673 in the United
States for Ford or Mercury
vehicles; or if you own a Lincoln
vehicle, call 1-800-521-4140.
Call 1-800-665-2006 in Canada.
33CCAen 17.6.99 11:32 Uhr Seite 229

Customer assistance
236If your vehicle must be serviced
while you are traveling or living in
Central or South America, the
Caribbean, or the Middle East,
contact the nearest Ford
dealership. If the dealership cannot
help you, write or call:
FORD MOTOR COMPANY
WORLDWIDE DIRECT MARKET
OPERATIONS
1555 Fairlane Drive
Fairlane Business Park #3
Allen Park, Michigan 48101
U.S.A.
Telephone: (313) 594-4857
FAX: (313) 390-9804
If you are in another foreign
country, contact the nearest Ford
dealership. If the dealership
employees cannot help you, they
can direct you to the nearest Ford
affiliate office.
If you buy your vehicle in North
America and then relocate outside
of the U.S. or Canada, register your
vehicle identification number
(VIN) and new address with Ford
Motor Company Worldwide Direct
Market Operations. GETTING ASSISTANCE
OUTSIDE THE U.S. AND
CANADA
Before exporting your vehicle to a
foreign country, contact the
appropriate foreign embassy or
consulate. These officials can
inform you of local vehicle
registration regulations and where
to find unleaded fuel.
If you cannot find unleaded fuel or
can only get fuel with an anti-knock
index lower than is recommended
for your vehicle, contact a district
or owner relations/customer
assistance office.
The use of leaded fuel in your
vehicle without proper conversion
may damage the effectiveness of
your emission control system and
may cause engine knocking or
serious engine damage. Ford Motor
Company/Ford of Canada is not
responsible for any damage caused
by use of improper fuel.
In the United States, using leaded
fuel may also result in difficulty
importing your vehicle back into
the U.S.
33CCAen 17.6.99 11:32 Uhr Seite 236

243
Index
CPage
Cleaning your vehicle
engine compartment . . . . . . . .219
exterior lamps . . . . . . . . . . . . .220
fabric . . . . . . . . . . . . . . . . . . . .221
instrument panel . . . . . . . . . . .221
plastic exterior parts . . . . . . . .220
safety belts . . . . . . . . . . . . . . .222
wheels . . . . . . . . . . . . . . . . . . .218
wiper blades . . . . . . . . . . . . . .220
Climate control system
air conditioning . . . . . . . . . . . . .29
controlling airflow . . . . . . . . . . .26
defrosting . . . . . . . . . . . . . . . . . .38
temperature . . . . . . . . . . . . . . . .27
vents . . . . . . . . . . . . . . . . . . . . . .26
Clock . . . . . . . . . . . . . . . . . . . . . .45
Clutch
operation . . . . . . . . . . . . . . . . .127
recommended shift speeds . . .128
Cold engine starting . . . . . . . . .114
Controls
instrument panel . . . . . . . . . . . .20
power seats . . . . . . . . . . . . . . . .75
steering column . . . . . . . . . . . . .55
Customer assistance . . . . . . . . .229
D
Daytime running lights . . . . . . . .23
Defects, reporting . . . . . . . . . . .241
Defrost
rear window . . . . . . . . . . . . . . . .24
windshield . . . . . . . . . . . . . . . . .32
Dipstick, engine oil . . . . . . . . . .167
Door mounted controls . . . . . . . .64
Driving under special conditions
heavy load . . . . . . . . . . . . . . . .133
towing a trailer . . . . . . . . . . . .134
E
Electrical system
fuses . . . . . . . . . . . . . . . . . . . . .143EPage
Emergencies, roadside
fuel pump shut-off switch . . . .141
jump starting . . . . . . . . . . . . . .154
towing . . . . . . . . . . . . . . . . . . .160
Emergency brake (see Parking
brake)
Emission control system . . . . . .202
Engine
check engine warning light . . . .12
fuel pump shut-off switch . . . .141
lubricant specifications . . . . . .225
preparing to start . . . . . . . . . .111
refill capacities . . . . . . . . . . . .224
starting . . . . . . . . . . . . . . . . . . .114
Engine block heater . . . . . . . . .115
Engine coolant
checking and adding . . . . . . . .174
disposal . . . . . . . . . . . . . . . . . .178
low coolant warning light . . . . .11
refilll capacities . . . . . . . . . . . .224
specifications . . . . . . . . . . . . . .225
Engine fan . . . . . . . . . . . . . . . . .163
Engine oil
changing oil and filter . . . . . . .170
checking and adding . . . . . . . .169
dipstick . . . . . . . . . .167, 168, 169
disposal . . . . . . . . . . . . . . . . . .171
engine oil pressure
warning light . . . . . . . . . . . . . . .18
filter specifications . . . . . . . . .223
refill capacities . . . . . . . . . . . .224
specifications . . . . . . . . . . . . . .225
Exhaust fumes . . . . . . . . . .110, 202
F
Fan (see Engine fan)
Flasher, hazard . . . . . . . . . .56, 141
Flashing the lights . . . . . . . . . . . .57
Floor mats . . . . . . . . . . . . . . . . . .67
Fluid refill capacities . . . . . . . . .224
Foglamps . . . . . . . . . . . . . . .23, 208
4CInden 17.6.99 11:32 Uhr Seite 243

Index
244FPage
Fuel
calculating fuel economy . . . .201
capacity . . . . . . . . . . . . . . . . . .224
choosing the right fuel . . . . . .198
consumption . . . . . . . . . . . . . .140
fuel gauge . . . . . . . . . . . . . . . . .21
low fuel warning light . . . . . . . .15
octane rating . . . . . . . . . . . . . .199
quality . . . . . . . . . . . . . . . . . . .199
running out of fuel . . . . . . . . .202
safety information relating
to automotive fuels . . . . . . . . .196
Fuel pump shut-off switch . . . .141
Fuse panels
engine compartment . . . . . . . .144
instrument panel . . . . . . . . . . .146
Fuses
charts . . . . . . . . . . . . . . . .145, 148
checking and replacing . . . . . .143
G
Gas mileage (see Fuel)
Gauges
engine coolant temperature . . .20
fuel . . . . . . . . . . . . . . . . . . . . . . .21
odometer . . . . . . . . . . . . . . . . . .20
speedometer . . . . . . . . . . . . . . .20
trip odometer . . . . . . . . . . . . . .20
GAWR
(Gross Axle Weight Rating) . . .131
Gearshift . . . . . . . . . . . . . .123, 128
GVWR
(Gross Vehicle Weight Rating) .131
H
Hazard flashers . . . . . . . . . .56, 141
Head restraints . . . . . . . . . . . . . .74
Headlamps
aiming . . . . . . . . . . . . . . . . . . .213
bulb specifications . . . . . . . . .212
daytime running light . . . . . . . .23
flashing . . . . . . . . . . . . . . . . . . .57HPage
high beam . . . . . . . . . . . . . . . . .57
replacing bulbs . . . . . . . . . . . .206
turning on and off . . . . . . . . . . .22
warning chime . . . . . . . . . . . . . .19
High beams
indicator light . . . . . . . . . . . . . . .9
operation . . . . . . . . . . . . . . . . . .57
High-mount brakelamp . . . . . . .210
Hood
latch location . . . . . . . . . . . . . .166
release lever . . . . . . . . . . . . . .166
Horn . . . . . . . . . . . . . . . . . . . . . . .56
I
Identification Number, Vehicle
(VIN) . . . . . . . . . . . . . . . . . . . . .228
Idle, relearning . . . . . . . . . . . . .185
Idle, speed . . . . . . . . . . . . . . . . .185
Ignition
chime . . . . . . . . . . . . . . . . . . . . .19
positions on the ignition . . . . . .54
Instrument cluster . . . . . . . . . . . . .8
Instrument panel
cleaning . . . . . . . . . . . . . . . . . .221
lighting up the panel . . . . . . . . .25
Integrated child seat (see Built-in
child seat)
Intermittent wipers . . . . . . . . . . .58
Introduction . . . . . . . . . . . . . . . . . .2
J
Jack
positioning . . . . . . . . . . . . . . . .152
storage . . . . . . . . . . . . . . . . . . .151
Jump starting your vehicle
attaching cables . . . . . . . . . . . .155
disconnecting cables . . . . . . . .158
K
Keys
key in ignition warning chime .19
positions of the ignition . . . . . .54
4CInden 17.6.99 11:32 Uhr Seite 244

Index
245 LPage
Lamps
bulb replacement specification
chart . . . . . . . . . . . . . . . . . . . . .212
daytime running light system . .23
flashing the lamps . . . . . . . . . . .57
foglamps . . . . . . . . . . . . . .23, 208
hazard flashers . . . . . . . . .56, 141
headlamps . . . . . . . . . . . . . . . . .22
high beams . . . . . . . . . . . . . . . . .57
high-mounted brake lamp . . . .210
instrument panel, dimming . . .25
interior lamps . . . . . . . . . . . . . .62
reading lamps . . . . . . . . . . . . . .62
replacing bulbs . . . . . . . . . . . .206
rear lamps . . . . . . . . . . . . . . . .209
Lights, warning and indicator
air bag . . . . . . . . . . . . . . . . . . . .15
anti-lock brakes (ABS) . . . . . . .17
brake . . . . . . . . . . . . . . . . . . . . .16
charging system . . . . . . . . . . . . .9
check engine . . . . . . . . . . . . . . .12
engine oil pressure . . . . . . . . . .18
high beam . . . . . . . . . . . . . . . . . .9
low coolant . . . . . . . . . . . . . . . .11
low fuel . . . . . . . . . . . . . . . . . . .15
overdrive off . . . . . . . . . . . . . . .11
safety belt . . . . . . . . . . . . . . . . . .9
testing the warning lights . . . . .19
turn signal indicator . . . . . . . . . .8
Load limits . . . . . . . . . . . . . . . . .130
Lubricant specifications . . . . . .225
Luggage compartment . . . . . . . .66
M
Maintenance (see Servicing)
Manual transaxle
backing up (reverse) . . . . . . . .129
clutch . . . . . . . . . . . . . . . . . . . .127
fluid, capacity . . . . . . . . . . . . .224
shift speeds . . . . . . . . . . . . . . .128MPage
Mileage, calculating fuel
economy . . . . . . . . . . . . . . . . . . .201
Mirrors
side view mirrors (power) . . . .25
Motorcraft parts . . . . . . . . . . . .223
N
National Highway Traffic Safety
Administration . . . . . . . . . . . . . .241
O
Octane rating . . . . . . . . . . . . . . .199
Odometer . . . . . . . . . . . . . . . . . . .20
Oil (see Engine oil)
Oil filter . . . . . . . . . . . . . . .170, 223
On-board diagnostic
(OBD II) system . . . . . . . . . . . .205
Overdrive . . . . . . . . . . . . . . .11, 124
Overhead controls . . . . . . . . . . . .62
P
Panel dimmer control . . . . . . . . .25
Panic alarm, remote entry sytem 69
Parking brake . . . . . . . . . . . . . .118
Parts (see Motorcraft parts) . . .223
Passenger compartment
air filter (see Cabin air filter)
Passive Anti-Theft
System (PATS) . . . . . . . . . . . . . .71
Power distribution box
(see Fuses)
Power door locks . . . . . . . . . . . . .64
Power features
mirrors . . . . . . . . . . . . . . . . . . . .25
seats . . . . . . . . . . . . . . . . . . . . . .75
sunroof . . . . . . . . . . . . . . . . . . . .63
windows . . . . . . . . . . . . . . . . . . .64
Power steering
fluid, checking and adding . . .178
fluid, refill capacity . . . . . . . . .224
fluid, specification . . . . . . . . . .225
4CInden 17.6.99 11:32 Uhr Seite 245

248
Filling station information
UNLEADED FUEL ONLY
Octane 87
58.5 litres (15.4 gallons)
Use Super Premium SAE 5W-30
Motor Oil or equivalent meeting-
Ford specification WSS-M2C153-G.
Refer to Safety Compliance Certifi-
cation label on driver’s door pillar
Pull handle under the left side of
the instrument panel
Right rear of vehicle FuelFuel tank capacity
Engine oil
Tire size and pressure
Hood release location
Fuel filler location
4CInden 17.6.99 11:32 Uhr Seite 248