light FORD EXPLORER 2011 5.G Owners Manual

EMISSION CONTROL SYSTEM
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only the specified fuel listed.
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed inscheduled maintenance information
performed according to the specified schedule.
The scheduled maintenance items listed inscheduled maintenance
informationare essential to the life and performance of your vehicle
and to its emissions system.
If other than Ford, Motorcraftor Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
WARNING:Do not park, idle, or drive your vehicle in dry grass
or other dry ground cover. The emission system heats up the
engine compartment and exhaust system, which can start a fire.
Illumination of the service engine soon
indicator, charging system
warning light or the temperature warning light, fluid leaks, strange odors,
smoke or loss of engine power could indicate that the emission control
system is not working properly.
An improperly operating or damaged exhaust system may allow exhaust
to enter the vehicle. Have a damaged or improperly operating exhaust
system inspected and repaired immediately.
WARNING:Exhaust leaks may result in entry of harmful and
potentially lethal fumes into the passenger compartment.
Maintenance and Specifications
401
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

General
•Store all vehicles in a dry, ventilated place.
•Protect from sunlight, if possible.
•If vehicles are stored outside, they require regular maintenance to
protect against rust and damage.
Body
•Wash vehicle thoroughly to remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housing and underside of front fenders.
See theCleaningchapter for more information.
•Periodically wash vehicles stored in exposed locations.
•Touch-up raw or primed metal to prevent rust.
•Cover chrome and stainless steel parts with a thick coat of auto wax
to prevent discoloration. Re-wax as necessary when the vehicle is
washed. See theCleaningchapter for more information.
•Lubricate all hood, door and trunk lid hinges, and latches with a light
grade oil. See theCleaningchapter for more information.
•Cover interior trim to prevent fading.
•Keep all rubber parts free from oil and solvents.
Engine
•The engine oil and filter should be changed prior to storage, as used
engine oil contain contaminates that may cause engine damage.
•Start the engine every 15 days. Run at fast idle until it reaches normal
operating temperature.
•With your foot on the brake, shift through all the gears while the
engine is running.
Fuel system
•Fill the fuel tank with high-quality fuel until the first automatic shutoff
of the fuel pump nozzle.
Note:During extended periods of vehicle storage (30 days or more),
fuel may deteriorate due to oxidation. Add MotorcraftGas Stabilizer or
equivalent meeting Ford material specification ESE-M99C112-A to the
vehicle fuel system whenever actual or expected storage periods exceed
30 days. Follow the instructions on the additive label. The vehicle should
then be operated at idle speed to circulate the additive throughout the
fuel system.
Maintenance and Specifications
408
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

FORD CUSTOM ACCESSORIES FOR YOUR VEHICLE
A wide selection of Ford Custom Accessories are available for your
vehicle through your local Ford or Ford of Canada dealer. These quality
accessories have been specifically engineered to fulfill your automotive
needs; they are custom designed to complement the style and
aerodynamic appearance of your vehicle. In addition, each accessory is
made from high quality materials and meets or exceeds Ford’s rigorous
engineering and safety specifications. Ford Motor Company will repair or
replace any properly dealer-installed Ford Custom Accessories found to
be defective in factory-supplied materials or workmanship during the
warranty period, as well as any component damaged by the defective
accessories. The accessories will be warranted for whichever provides
you the greatest benefit:
•12 months or 12,000 miles (20,000 km) (whichever occurs first), or
•the remainder of your new vehicle limited warranty.
Contact your dealer for details and a copy of the warranty.
The following is a list of several Ford Custom Accessories. Not all
accessories are available for all models. For a complete listing of the
accessories that are available for your vehicle, please contact your dealer
or visit our online store at: www.fordaccessories.com (U.S. only).
Exterior style
•Bug shields•Deflectors
•Custom graphics*•Splash guards*
Interior style
•Ambient lighting•Floor mats
•Electrochromic compass/temperature interior mirrors
Lifestyle
•Ash cup / smoker’s package•Portable navigation*
•Trailer hitch balls•Camping tent*
•Rear seat entertainment*•Racks and carriers*
•Trailer hitch ball mounts
•Cargo organization and management
•Trailer hitch drawbars, and towing accessories
Accessories
417
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Genuine Ford parts and service
When planning your maintenance services, consider your dealership for
all your vehicle’s needs.
There are a lot of reasons why visiting your dealership for all your
service needs is a great way to help keep your vehicle running great.
Convenience
Many dealerships have extended evening and Saturday hours to make
your service visit more convenient. How’s that for quality service?
Factory-trained technicians
Service technicians participate in extensive factory-sponsored
certification training to help them become experts on the operation of
your vehicle. Ask your dealership about the training and certification
their technicians have received.
Genuine Ford and Motorcraftreplacement parts
Dealerships stock Ford and Motorcraftbranded replacement parts.
These parts meet or exceed Ford Motor Company’s specifications, and
we stand behind them. Parts installed at your dealership carry a
nationwide, 12 month/12,000 mile (20,000 km) parts and labor limited
warranty. Your dealer can give you details.
Value shopping for your vehicle’s maintenance needs
Your dealership recognizes the competitive landscape of maintenance and
light repair automotive services. With factory-trained technicians, and
one-stop service from routine maintenance like oil changes and tire
rotations to repairs like brake service, check out the value your dealers
can offer.
Scheduled Maintenance Guide
425
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Owner checks and services
Certain basic maintenance checks and inspections should be performed
by the owner or a service technician at the intervals indicated. Service
information and supporting specifications are provided in this owner’s
guide.
Any adverse condition should be brought to the attention of your dealer
or qualified service technician as soon as possible for the proper service
advice. The owner maintenance service checks are generally not covered
by warranties so you may be charged for labor, parts or fluids used.
Engine oil/coolant change intervals
Engine oilAs indicated by the message center (can be up
to one year or 10,000 miles [16,000 km])
Engine coolant,
initial change6 years or 100,000 miles (160,000 km)
(whichever comes first)
Engine coolant,
after initial changeEvery 3 years or 50,000 miles (80,000 km)
Check every month
Engine oil level
Function of all interior and exterior lights
Tires for wear and proper pressure, including spare
Windshield washer fluid level
Check every six months
Battery connections; clean if necessary
Body and door drain holes for obstructions; clean if necessary
Cooling system fluid level and coolant strength
Door weatherstrips for wear; lubricate if necessary
Hinges/latches/outside locks for proper operation; lubricate if necessary
Parking brake for proper operation
Safety belts and seat latches for wear and function
Safety warning lamps (brake, ABS, airbag, safety belt) for operation
Washer spray/wiper operation; clean or replace blades as necessary
Scheduled Maintenance Guide
426
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

EXCEPTIONS
In addition, there are several exceptions to the Normal Schedule. They
are listed below:
Normal vehicle axle maintenance
❑Rear axles and power take-off (PTO) units containing synthetic fluid and light duty trucks equipped with Ford-design axles
are lubricated for life. These fluids are not to be checked or changed unless a leak is suspected, service is required or the
axle assembly has been submerged in water. The axle and PTO fluids should be changed anytime the axle and PTO have
been submerged in water. During extended trailer tow operation above 70°F (21°C) ambient and wide open throttle for
extended periods above 45 mph (72 km/h), non-synthetic rear axle fluids should be changed every 3,000 miles
(4,800 km) or three months, whichever occurs first. The 3,000 mile (4,800 km) fluid change interval may be waived if
the axle was filled with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number F1TZ-19580-B
or equivalent. Add friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles (refer to
Maintenance product specifications and capacitiesin theMaintenance and Specificationschapter for details). The axle fluid
should be changed anytime an axle has been submerged in water.
Police/Taxi/Livery vehicle axle maintenance
❑Change rear axle fluid every 100,000 miles (160,000 km). Rear axle fluid change may be waived if the axle was filled
with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add
four ounces (118 mL) of friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles.
The axle fluid should be changed anytime the axle has been submerged in water.
California fuel filter replacement
❑If the vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this
maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful
life. Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified
intervals and to record all vehicle service.
Hot climate oil change intervals
❑If operating conditions are normal and you drive your vehicle under typical, everyday conditionsandyou are using an API
performance category oil of SL or later (for example SM, etc.) then you can follow the 7,500 mile (12,000 km) normal
service oil change intervals schedule. Vehicles operating in the Middle East, North Africa, Sub-Saharan Africa or locations with
similar climates must follow the oil change interval of 3,000 mile (4,800 km) if the owner is using oils defined by the
American Petroleum Institute (API) performance category of API SK or earlier (for example SJ, etc.).
Engine air filter & cabin air filter replacement
❑Engine air filter and cabin air filter life is dependent on exposure to dusty and dirty conditions. Vehicles operated in these
conditions will require frequent inspection and replacement of the engine air filter and cabin air filter.
Scheduled Maintenance Guide
440
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

A
Accessory delay ..........................99
Active Park Assist .....................303
Adaptive Cruise Control ...........105
AdvanceTrac ..............................277
Airbag supplemental restraint
system ........................197, 206, 208
and child safety seats ............199
description ..............197, 206, 208
disposal ....................................211
driver airbag ............199, 206, 209
indicator light .................205, 210
operation .................199, 206, 209
passenger airbag .....199, 206, 209
side airbag ...............................206
Air cleaner filter .......406–407, 410
Air conditioning ..............63, 66, 68
manual heating and air
conditioning system .................63
All Wheel Drive (AWD),
driving off road .........................316
Ambulance packages ....................7
Antifreeze
(see Engine coolant) ................385
Anti-lock brake system
(see Brakes) ......................274–275
Anti-theft system ..............154, 158
arming the system ..........154, 158
disarming a triggered
system .....................................158
Automatic transmission
driving an automatic
overdrive .................................288
fluid, adding ............................404
fluid, checking ........................404
fluid, refill capacities ..............411
fluid, specification ..................411Selectshift (SST) ....................291
Auxiliary input jack (Line in) ....60
Auxiliary power point .................96
Axle
lubricant specifications ..........411
refill capacities ........................411
B
Battery .......................................382
acid, treating emergencies .....382
jumping a disabled battery ....354
maintenance-free ....................382
replacement, specifications ...410
servicing ..................................382
Belt-Minder.............................193
Blind Spot Information
System .......................................310
Blind spot mirror ......................309
Booster seats .............................228
Brakes ........................................274
anti-lock ...........................274–275
anti-lock brake system (ABS)
warning light ...........................275
fluid, checking and adding ....404
fluid, refill capacities ..............411
fluid, specifications .................411
lubricant specifications ..........411
parking ....................................276
shift interlock ..........................287
C
Capacities for refilling fluids ....411
Car2UHome Automation
System .......................................116
Cargo net ...................................122
Cell phone use ............................10
Index
442
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

idle speed control ...................382
lubrication specifications .......411
refill capacities ........................411
service points ..........................377
Engine block heater .................273
Engine oil ..................................380
checking and adding ..............380
dipstick ....................................380
filter, specifications ........381, 410
recommendations ...................381
refill capacities ........................411
specifications ..........................411
Event data recording ....................8
Exhaust fumes ..........................272
F
Fail safe cooling ........................390
Fleet MyKey programming ......132
Floor mats .................................122
Fluid capacities .........................411
Fog lamps ....................................78
Four-Wheel Drive vehicles
driving off road .......................316
preparing to drive your
vehicle .....................................286
Fuel ............................................392
calculating fuel economy .......398
cap ...........................................394
capacity ...................................411
choosing the right fuel ...........395
detergent in fuel .....................396
filler funnel .............................396
filling your vehicle with
fuel ...........................392, 394, 398
filter, specifications ........391, 410
fuel pump shut-off ..................327
improving fuel economy ........398
octane rating ...................395, 414quality ......................................396
running out of fuel .........353, 396
safety information relating to
automotive fuels .....................392
Fuses ..................................327–328
G
Garage door opener ..................116
Gas cap (see Fuel cap) ............394
Gas mileage
(see Fuel economy) .................398
Gauges .........................................21
H
Hazard flashers .........................326
Headlamps ...................................77
aiming ........................................80
autolamp system .......................77
bulb specifications ....................85
daytime running lights .............79
flash to pass ..............................78
high beam .................................78
turning on and off ....................77
Heating
heating and air conditioning
system ...........................63, 66, 68
Hill descent mode .....................283
Hill start assist ..........................292
Hood ..........................................376
I
Ignition ...............................267, 414
Illuminated visor mirror .............94
Infant seats
(see Safety seats) .....................216
Index
444
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Inspection/maintenance (I/M)
testing ........................................403
Instrument panel
cleaning ...................................370
cluster ........................................14
lighting up panel and
interior .......................................79
Intelligent Access Key ..............131
Intelligent Access with push
button start ...............................143
J
Jack ............................................336
positioning ...............................336
storage .....................................336
Jump-starting your vehicle ......354
K
Keyless entry system
autolock ...................................139
keypad .....................................152
locking and unlocking doors ..153
programming entry code .......152
Keys ...................................130, 155
positions of the ignition .........267
L
Lamps
autolamp system .......................77
bulb replacement
specifications chart ............84–85
daytime running light ...............79
fog lamps ...................................78
headlamps .................................77
headlamps, flash to pass ..........78
instrument panel, dimming .....79
interior lamps ...........................83
LATCH anchors .........................222Liftgate ......................123–124, 145
Lights, warning and indicator ....14
anti-lock brakes (ABS) ..........275
Loading instructions .................261
Load limits .................................255
Locks
autolock ...................................139
childproof ................................142
doors ........................................138
Lubricant specifications ...........411
Luggage rack .............................128
Lug nuts ....................................352
Lumbar support, seats .....163, 165
M
Message center .....................23, 34
warning messages ...............27, 43
Mirrors ...............................100–101
automatic dimming rearview
mirror ......................................100
fold away .................................102
heated ......................................101
programmable memory ..........145
side view mirrors (power) .....101
signal .......................................102
Moon roof ..................................114
Motorcraftparts ..............374, 410
MyFord Connect™ system ........62
MyFord Touch™ system ............62
MyFord™ system ..................51, 62
MyKey ........................................132
O
Octane rating ............................395
Oil (see Engine oil) ..................380
Index
445
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Overdrive ...................................288
P
Parental MyKey
programming .............................132
Park Assist ................................303
Parking brake ............................276
Parts
(see Motorcraftparts) ...........410
Passenger Occupant
Classification Sensor .................182
Pedals (see Power adjustable
foot pedals) ...............................103
Power adjustable foot pedals ...103
Power distribution box
(see Fuses) ...............................332
Power door locks ......................138
Power liftgate ............................124
Power mirrors ...........................101
Power point .................................96
Power steering ..........................284
fluid, refill capacity ................411
fluid, specifications .................411
Power Windows ...........................98
Preparing to drive your
vehicle ........................................286
Push button start system .........270
R
Rear-view camera system .........296
Rear window defroster ...............75
Recommendations for
attaching safety restraints for
children ......................................214Relays ........................................327
Remote entry system .......142–143
illuminated entry ............148–149
locking/unlocking doors .........144
opening the trunk ...................145
Remote start ...........................149
replacement/additional
transmitters .............................148
replacing the batteries ...........147
Remote start .............................149
Remote start climate
operation .....................................75
Reverse sensing system ...........294
Roadside assistance ..................325
Roof rack ...................................128
S
Safety belts (see Safety
restraints) ..........184–186, 191–192
Safety Canopy ...................206, 208
Safety defects, reporting ..........366
Safety restraints 184–186, 191–192
Belt-Minder...........................193
extension assembly ................191
for adults .................185–186, 191
for children .............................211
inflatable safety belt ...............189
Occupant Classification
Sensor ......................................182
warning light and chime ........192
Safety restraints - LATCH
anchors ......................................222
Safety seats for children ..........216
Safety Compliance
Certification Label ....................414
Satellite Radio Information ........57
Index
446
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)