brake FORD FIESTA 2007 Workshop Manual

Electronic Engine Controls
DIAGNOSIS AND TESTING
I PO304 I Cylinder No. 4 misfire detected I
/ I
KS implausible signal I
MIL Code
PO303
PO31 5
PO324
1 PO335 1 Crankshaft position (CKP) sensor implausible signal I
Description
Cylinder No. 3 misfire detected
Flywheel segment adaptation at the Limit
Knock sensor (KS) communication error or implausible signal
1 PO336 1 CKP sensor missing teeth I
1 PO336 1 CKP sensor loss of synchronization I
1 PO336 1 CKP sensor no signal I
I PO340 I Camshaft position (CMP) sensor no signal I
I PO341 I CMP sensor implausible signal I
I PO351 I Ignition coil A primary malfunction I
1 PO352 1 Ignition coil B primary malfunction I
I PO420 I Catalyst system efficiency below threshold I
1 PO444 1 Evaporative mission canister purge valve open circuit I
1 PO458 1 Evaporative mission canister purge valve low voltage I
I '1 PO459 1 Evaporative mission canister purge valve high voltage I
I PO460 I Fuel tank level malfunction from instrument cluster I
-3 I VSS signal too high I
PO500
PO500
Vehicle speed sensor (VSS) signal malfunction
Vehicle speed via CAN (VS CAN) implausible signal
PO51 1
PO560
I PO603 I Powertrain control module (PCM) error NVMY or EEPROM error 1
Idle air control (IAC) valve circuit malfunction
Battery system voltage malfunction high voltage
PO562
PO571
I PO604 I PCM error RAM error I
Battery system voltage malfunction open circuit
Brake switch plausibility error
PO605 I PCM error checksum error I
I PO610 I VID block checksum not correct or not programmed I
I PO617 I Starter relay malfunction I
I PO620 I Generator circuit malfunction I
1 PO628 1 Fuel pump primary circuit low voltage I
I
7 1 Fuel pump primary circuit high voltage I
2006.0 Fiesta 1212006 G384566en
PO625
PO626
Generator low voltage
Generator high voltage
procarmanuals.com

Automatic Transmission/Transaxle .
Vehicles With: 4-Speed Automatic
Transmission
(AW81-40)
SECTION 307-01 Automatic Transmission/Transaxle
. Vehicles With: 4-Speed Automatic Transmission
(AW81-40)
VEHICLE APPLICATION:2006.0 Fiesta
CONTENTS PAGE
SPECIFICATIONS
Specifications
........................................................................\
.............................................. 307-0 1 -3
DESCRIPTION AND OPERATION
Automatic Transaxle
........................................................................\
...................................
Transmission cross-section ........................................................................\
........................
Torque converter with Torque Converter Clutch (TCC) ......................................................
Fluid pump and stator shaft ........................................................................\
........................
........................................................................\
......... Planetary gearset ......................... .:
Clutches and brakes ........................................................................\
...................................
Intermediate gear stage and differential assembly .............................................................
Main control body ........................................................................\
.......................................
Internal' gearshift mechanism ........................................................................\
.....................
Fluid circuit ........................................................................\
.................................................
........................................................................\
....................................... Identification Tags
Type plate
........................................................................\
...................................................
Transmission Ranges and Power Flow ........................................................................\
......
Transmission ratio and power flow route - 1st gear ............................................................
Transmission ratio and power flow route - 2nd gear ..........................................................
Transmission ratio and power flow route . 3rd gear ...........................................................
Transmission ratio and power flow route . 4th gear ...........................................................
Transmission ratio and power flow route . reverse gear ....................................................
Transaxle Electronic Control System ........................................................................\
..........
........................................................................\
..................................................... Overview
Transmission control unit
........................................................................\
............................
........................................................................\
.................................... Gearshift strategies
Selector lever positions
........................................................................\
..............................
Signal transmission on the CAN databus ........................................................................\
...
........................................................................\
...................................................... Sensors
........................................................................\
.................................................... Actuators
DIAGNOSIS AND TESTING
Automatic Transaxle
........................................................................\
................................... 307-01
Inspection and Verification ........................................................................\
.................... 307-01
Diagnostic Trouble Code Chart
........................................................................\
.................. 307-01
........................................................................\
...................................... Line Pressure Test 307-01
Stall Speed Test
........................................................................\
....................................... 307-01
Time Lag Test
........................................................................\
............................................. 307-01
procarmanuals.com

Automatic Tr;
Vehicles Wil
307-01 -6 Transn
~nsmission/Transaxle -
:h: 4-Speed Automatic
~ission (AW81-40) --
DESCRIPTION AND OPERATION
Item Description
I 1 I I st - 3rd gear clutch 1
1 2 14th gear brake I
1 3 1 Reverse gear clutch I
1 4 )2nd - 4th gear brake I
1 5 1 Reverse gear brake I
1 6 1 3rdl4th gear clutch I
1 7 ITorque converter 1
1 8 1 Transmission input shaft I
1 9 I Fluid pump I - --
[ 10 1 Differential assembly I
~l~put wheel, planetary gearset I
11
1 13 1 Planetary gearset I
Intermediate gear stage
vlIlstgear one-way clutch I
1 15 1 2nd gear one-way clutch I
Torque converter with Torque
Converter Clutch (TCC)
Item Description
I 1 I Torque converter housing and impeller I
1 2 1 Turbine wheel 1
1 4 1 Transmission input shaft I
FlGwith roller-type one-way clutch (
The torque converter hydraulically transmits the
output torque from the engine to the input shaft of
the transmission.
The stator increases the torque up to the clutch
point (approx. 90
% speed difference between the
impeller and the turbine wheel).
In order to increase the efficiency of the automatic
transmission, the torque converter is also equipped
with a hydraulically activated TCC
The TCC is applied with slip to ensure soft
engagement.
i
When the TCC is engaged, the torque is '..
transmitted directly from the crankshaft via the
torque converter housing to the transmission input
shaft.
2006.0 Fiesta 1212006 ~380521 en
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
Transmission
(AW81-40) 307-01 -8
DESCRIPTION AND OPERATION
Planetary
gearset
Description The following connections exist between the
/ individual components:
small sun gear - short planet gears - long planet
Long planet gear gears- annulus,
3 Small sun gear large sun gear - long planet gears - annulus.
4
5
The output always flows through the annulus.
6
2006.0 Fiesta 1212006 ~380521 en
Short planet gear
Transmission input shaft The different transmission ratios
are selected by
actuating and releasing the individual clutches and
brakes.
shaft via the corresponding clutch either onto the
A Ravigneaux planetary gearset is a two-stage
small sun gear (1st - 3rd gear) or the planet gear gearset with a shared planet gear carrier and one carrier (3rd and 4th gear) or the large sun gear annulus. (reverse gear).
Large sun gear
The drive is transmitted from the transmission input
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
Transmission
(AW81-40)
DESCRIPTION AND OPERATION
Clutches and brakes
/
Description The clutches are multi-plate clutches.
I 1 I I st - 3rd gear clutch I
1 2 14th gear brake I
1 3 1 Reverse gear clutch I
1 4 12nd - 4th gear brake I
1 6 1 3rdl4th gear clutch I
1 7 1 1st gear one-way clutch I
1 8 12nd gear one-way clutch I
The transmission is equipped with three clutches
and five brakes. The brakes
are three multi-plate brakes and two
one-way sprag clutches.
The clutches serve to transmit the torque from the
transmission input
shaft to certain components of
the planetary
gearset.
The brakes serve to hold certain components of
the planetary
gearset.
In order to achieve a given transmission ratio, it is
necessary for at least one component of the
planetary
gearset to be held while the torque is
transmitted to another component.
These combinations produce the different
transmission ratios for the individual gears.
2006.0 Fiesta 1212006 G380521 en
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: $-Speed Automatic
Transmission
(AW81-40)
DESCRIPTION AND OPERATION
Overview of operation
Item Descri~tion
I 1 I I st - 3rd gear clutch I
1 2 12nd gear one-way clutch I
1 3 12nd - 4th gear brake I
1 4 1 1st gear one-way clutch
1 5 1 Reverse gear brake I
1 6 13rd14th gear clutch
Item Description
1 8 1 Output wheel, planetary gearset
I
1 7 1 From the torque converter
1 9 ( Intermediate gear stage I
I
1 10 1 Differential assembly I
I A I Planetary gearset, rear I
11
12
I B I Planetary gearset, front I
4th gear brake
Reverse gear clutch
2006.0 Fiesta 1212006 ~380521 en
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
Transmission
(AW81-40)
DESCRIPTION AND OPERATION
i '
Intermediate gear stage and differential assembly
1 I
Component Connects
2006.0 Fiesta 1212006 G380521 en
3rdl4th gear clutch
Reverse gear clutch
2nd
- 4th gear brake
4th gear brake
Reverse gear brake
1st gear one-way clutch
2nd gear one-way clutch
* Only in selector lever position 2
** Only in selector lever position 1
Transmission input shaft to planet gear
carrier
Transmission input shaft to large sun gear
Transmission housing to large sun gear
Transmission housing to 2nd gear one-
way clutch
Transmission housing to planet gear
carrier
Transmission housing to planet gear
carrier
4th gear brake to large sun gear
X
X
X**
X X*
X X
XXX X
X
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
307-01 -1 2 Transmission (AW81-40) 307-01 -1 2 --
DESCRIPTION AND OPERATION
Item Description The output wheel of the planetary gearset drives
I 1 I Output wheel, planetary gearset
2
I I 1
The annulus of the planetary gearset is fixedly Any differences in rotational speed between the
connected to the output
wheel of the planetary two halfshafts are compensated by the differential.
gearset.
the input wheel of the intermediate gear stage.
3
4
Main control body
Output wheel, intermediate gear stage
Item Descri~tion The hydraulic lines and pressures are electronically
The output
wheel of
the intermediate gear stage [<.
drives the spur gear of the differential assembly.
Differential assembly
Input wheel, intermediate gear stage The
differential assembly transmits the torque
via
the halfshafts to the front wheels.
In addition, the manual selector slide in the main
control body provides a hydraulic emergency
running programme which
allows the vehicle to be
Manual selector lever driven in 3rd aear with the selector lever in position
.
1
Shift timing solenoid valve
5
2006.0 Fiesta 1212006 ~380521 en
regulated by a proportional solenoid valve (main
regulating valve) and four shift solenoid valves.
1 6 1 SSA shift solenoid valve
SSB
shift solenoid valve
transmission control unit-fail. -
"D", "2" or "ll'and in reverse gear with the selector
lever in position "R if key components or the
The hydraulic pressure is distributed to the The
manual selector slide is actuated by the driver
individual clutches and brakes in the main control via the selector lever, the selector lever cable, the
body. selector shaft lever and the internal gearshift
mechanism.
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
Transmission
(AW81-40)
DESCRIPTION AND OPERATION
Fluid circuit
Item Description
I 1 I Transmission control unit
1 2 1 Solenoid valves and main control body I
1 3 I Clutches and brakes I
1 4 1 Planetary gearset
1 5 1 Fluid pump I
1 6 1Oil pan I
1 7 1 Fluid cooler I
Item Description
1 8 I Torque converter I
I A I Electric actuation of the solenoid valves I
B Actuating pressure of the clutches and
1 lbrakes
I C ITo the oil pan I
I D I From the oil pan I
I E I Fluid pump pressure I
2006.0 Fiesta 121~006 ~380521 en
procarmanuals.com

Automatic Transmission/Transaxle -
Vehicles With: 4-Speed Automatic
307-01 -1 9 Transmission (AW81-40) 307-01 -1 9
DESCRIPTION AND OPERATION
1 2 I Transmission input shaft I
Item Description The planet gear carrier (6) is held by the I st gear
1 3 1 I st - 3rd gear clutch I
I 1 I From the torque converter
1 4 1 Small sun gear I
one-way clutch (5).
1 5 1 1st gear one-way clutch I
1 6 1 Planet gear carrier I
1 7 Reverse gear brake I
1 8 1Short planet gear I
1 9 1 Long planet gear I
1 0 Annulus
and output wheel of the planetary
1 1 gearset
vllntermediate gear stage I
1 12 1 Differential assembly I
N0TE:ln selector lever position "1 " the planet gear
carrier is also held by the reverse gear brake
(7)
(engine braking).
The short planet gears (8) are driven by the small
sun gear in the opposite direction of rotation to the
output from the engine.
The short planet gears drive the long planet gears
(9) in the same direction of rotation as the output
from the engine.
The long planet gears drive the ring gear (10) in
the same direction of rotation as the output from
the engine.
The annulus is fixedly connected to the output
wheel of the planetary
gearset and drives the
intermediate gear stage (1 1
) in the opposite
direction of rotation to the output from the engine.
I B I Planetary gearset, front I the output from the engine.
A
Drive is transmitted from the torque converter (1)
to the transmission input shaft (2) and via the
/ 1st-3rd gear clutch (3) to the small sun gear (4).
2006.0 Fiesta 1212006 G380528en
Planetary gearset, rear The intermediate gear stage drives
the differential
assembly (12) in the same direction of rotation as
procarmanuals.com