engine FORD FUSION/HYBRID 2020 Warranty Guide

It is your responsibility to make sure that all of the scheduled
maintenance is performed and that the materials used meet Ford
engineering specifications. Failure to perform scheduled maintenance as
specified in the Owner’s Manual will invalidate warranty coverage on
parts affected by the lack of maintenance. Make sure that receipts for
completed maintenance work are retained with the vehicle and
confirmation of maintenance work is always entered in yourOwner’s
Manual.
Your Ford or Lincoln dealership, or Ford or Lincoln Quality Care Service
Center, has factory-trained technicians who can perform the required
maintenance using genuine Ford parts. The dealership looks forward to
meeting your every service need to maximize your satisfaction with your
vehicle.
WHO PAYS FOR WARRANTY REPAIRS?
You will not be charged for repairs covered by any applicable warranty
during the stated coverage periods, unless specifically stated elsewhere
in this guide.
Some states have mandated alternate time coverage periods for parts of
your vehicle (e.g. seatbelts).
Some states and/or local governments may require a tax on a portion of
warranty repairs. Where applicable law allows, the tax must be paid by
you, the owner of the vehicle.
During the Bumper to Bumper Warranty period, dealers may receive
instructions to provide no-cost, service-type improvements - not
originally included in your Owner’s Manual - intended to increase your
overall satisfaction with your vehicle.
Sometimes Ford may offer a special adjustment program to pay all or
part of the cost of certain repairs beyond the terms of the applicable
warranty. Check with your dealer or call 1-800-392-3673 to learn whether
any adjustment program is applicable to your vehicle. Please have your
vehicle identification number available.
3

Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle’s Powertrain components are covered for five years or
60,000 miles, whichever occurs first. The extended coverage applies to
theEngine: all internal lubricated parts, cylinder block, cylinder heads,
electrical fuel pump, powertrain control module, engine mounts,
flywheel, injection pump, manifold (exhaust and intake), manifold bolts,
oil pan, oil pump, seals and gaskets, engine thermostat, engine
thermostat housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; single-speed gearbox (for The Focus Electric);
Front-Wheel Drive: axle shafts, front bearings seals and gaskets,
universal and constant velocity joints; Rear-Wheel Drive:axle shafts,
bearings (front and rear), center support bearing, drive axle housing
(including all internal parts), drive shaft, retainers, supports, seals and
gaskets, universal and constant velocity joints. Four-wheel/All-Wheel
Drive: axle shafts, bearings (front and rear), center support bearing,
drive shafts, final drive housing (including all internal parts),
hubs-automatic front locking (four-wheel drive), locking rings
(four-wheel drive), seals and gaskets, universal and constant velocity
joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
(3) Your vehicle’s body sheet metal panels are covered for an extended
Corrosion Coverage Period, which lasts for five years, regardless of miles
driven. The extended warranty coverage only applies if a body sheet
metal panel becomes perforated due to corrosion during normal use due
to a manufacturing defect in factory-supplied materials or factory
workmanship. If aluminum body panels have corrosion or rust damage,
and the damage is not the result of abnormal usage, vehicle accident,
customer actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles. For
damage caused by airborne material (environmental fallout) where there
11

EMISSIONS DEFECTS WARRANTY COVERAGE
During the warranty coverage period, Ford Motor Company warrants that:
•your vehicle or engine is designed, built, and equipped to meet - at
the time it is sold - the emissions regulations of the U.S.
Environmental Protection Agency (EPA).
• your vehicle or engine is free from emissions-related defects in
factory-supplied materials or workmanship, which are defects that
could prevent the vehicle or engine from conforming with applicable
EPA regulations.
•
you will not be charged for diagnosis, repair, replacement, or adjustment
of parts containing an emissions-related defect. A list of emission-related
parts can be found in What is Covered?
on pages 20-22.
The emissions defects warranty coverage period for passenger cars and
light duty trucks (applies to vehicles up to 8,500 pounds GVWR is as
follows:
• 8 years or 80,000 miles (whichever occurs first) for catalytic
converters, electronic emissions control unit, and onboard emissions
diagnostic devices, including the Battery Energy Control Module
(BECM).
• 2 years or 24,000 miles (whichever occurs first) for all other covered
parts. (NOTE: Ford’s 3-year, 36,000-mile bumper-to-bumper coverage,
as described above, surpasses this mandatory federal coverage.)
EMISSIONS PERFORMANCE WARRANTY COVERAGE
Under Emissions Performance Warranty Coverage, Ford Motor Company
will repair, replace, or adjust - with no charge for labor, diagnosis, or
parts - any emissions control device or system, if you meet all of the
following conditions:
• You have maintained and operated your vehicle according to the
instructions on proper care in the Owner’s Manual, and this booklet.
• Your vehicle fails to conform, during the warranty coverage period, to
the applicable national EPA standards as determined by an EPA
approved inspection and maintenance program.
19

•You are subject to a penalty or sanction under local, state, or federal
law because your vehicle has failed to conform to the emissions
standards. (A penalty or sanction can include being denied the right
to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
The warranty coverage period for:
Passenger cars and light duty trucks (applies to vehicles up to
8,500 pounds GVWR) as follows: -
8 years or 80,000 miles (whichever occurs first) for catalytic converters,electronic emissions control unit, and onboard emissions diagnostic
devices, including the Battery Energy Control Module (BECM).
- 2 years or 24,000 miles (whichever occurs first) for all other covered parts.
See WHAT IS COVERED below for list of covered parts.
Note that the warranty period begins on the Warranty Start Dateas
specified on page 2 of this booklet.
WHAT IS COVERED?
For your vehicle, if these parts contain an emissions-related defect, they
are covered by both the Emissions Defects Warranty and the Emissions
Performance Warranty.
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
20

•Fuel Filler Door Sensor
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
21

For full details about coverage under California requirements for
emissions control, see:
➡Defects Warranties (pages 25-29)
➡ Performance Warranty (pages 25-27)
➡ What Is Covered? (pages 28-29)
➡ What Is Not Covered? (page 29)
EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2020-model vehicle. In California, new motor vehicles must be designed,
built, and equipped to meet the State’s stringent anti-smog standards.
Ford must warrant the emission control system on your vehicle for the
periods of time listed on pages 25-29, provided there has been no abuse,
neglect, or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injection
system, the ignition system, catalytic converter, and the engine
computer. Also included may be hoses, belts, connectors, and other
emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will repair
your vehicle at no cost to you including diagnosis, parts, and labor.
MANUFACTURER’S WARRANTY COVERAGE
For Vehicles Eligible for Standard California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever first occurs):
1. If your vehicle fails a Smog Check inspection, all necessary repairs and
adjustments will be made by Ford to ensure that your vehicle passes the
inspection. This is your emission control system PERFORMANCE
WARRANTY.
2. If any emissions-related part on your vehicle is defective, the part will
be repaired or replaced by Ford. This is your short-term emission control
system DEFECTS WARRANTY.
25

WHAT IS COVERED?
The parts on the following list are covered by the Standard California
Defects Warranties and TZEV Defects Warranties.
•Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
28