brakes FORD KUGA 2011 1.G Workshop Manual

FORD KUGA 2011 1.G Workshop Manual KUGA 2011 1.G FORD FORD https://www.carmanualsonline.info/img/11/5478/w960_5478-0.png FORD KUGA 2011 1.G Workshop Manual

Page 63 of 2057

FORD KUGA 2011 1.G Workshop Manual Road/Roller Testing
Road or roller testing may be carried out for various
reasons and a procedure detailing pre-test checks,
engine starting and stopping, pre-driving checks,
on-test checks and final

Page 64 of 2057

FORD KUGA 2011 1.G Workshop Manual – that the speedometer, coolant temperaturegauge and tachometer (if equipped) register the
correct readings and operate correctly.
– that the switches and controls operate smoothly and positively,

Page 82 of 2057

FORD KUGA 2011 1.G Workshop Manual sometimes noticed in the steering wheel/column,
seats, front floor panel, front door trim panel or
front end sheet metal. It is a low frequency
vibration (around 9-15 cycles per second). It
may or may

Page 1298 of 2057

FORD KUGA 2011 1.G Workshop Manual Front Drive Halfshafts
Inspection and Verification
NOTE:New front wheel drive halfshafts should not
be installed unless disassembly and inspection
reveals unusual wear.
1. Inspect front wheel drivesha

Page 1340 of 2057

FORD KUGA 2011 1.G Workshop Manual Brake System
General EquipmentPressure/vacuum gauge set
The Ford approved diagnostic tool
The brake system operates by transferring effort
applied to the brake pedal by the driver to the
brakes at eac

Page 1341 of 2057

FORD KUGA 2011 1.G Workshop Manual narrow the cause to a specific component or condition.
Symptom Chart
Action
Possible Sources
Symptom
• INSTALL new brake shoes orbrake pads.
REFER to: Brake Pads (206-03
Front Disc Brake, Removal
an

Page 1342 of 2057

FORD KUGA 2011 1.G Workshop Manual Action
Possible Sources
Symptom
• INSTALL a new brake mastercylinder.
REFER to: Brake Master
Cylinder - 2.5L Duratec
(147kW/200PS) - VI5 (206-06
Hydraulic Brake Actuation,
Removal and Installation).

Page 1350 of 2057

FORD KUGA 2011 1.G Workshop Manual DETAILS/RESULTS/ACTIONS
TEST CONDITIONS
D2: CHECK THE BRAKE BOOSTER FOR LEAKS
1 Run the engine at approximately 1000 rpm,
release the accelerator pedal and turn the
engine off. Wait 90 seconds and app

Page 1353 of 2057

FORD KUGA 2011 1.G Workshop Manual DETAILS/RESULTS/ACTIONS
TEST CONDITIONS
F2: CHECK FOR BRAKE PEDAL BINDING
1 Check the brake pedal for free operation.
• Did the brake pedal operate freely?

zYe s INSTALL a new brake booster. TEST t

Page 1354 of 2057

FORD KUGA 2011 1.G Workshop Manual 4. Remove the vacuum hose from the brakebooster. Manifold vacuum should be available
at the brake booster end of the hose with the
engine at idle speed and the transaxle in the
NEUTRAL position. Make
Page:   1-10 11-20 21-30 31-40 40 next >