maintenance FORD MONDEO 2006 2.G User Guide

Downloaded from www.Manualslib.com manuals search engine Engine oil filler cap
To open, turn anti-clockwise and pullup. Do not open the cap while theengine is running.
To close, turn the cap clockwise untilit clicks.
Engine oil change
Use Ford/Motorcraft Formula ESAE 5W-30 engine oil. Alternativeengine oils with the viscosity SAE5W-30 meeting the requirementsof Ford SpecificationWSS-M2C913-B may also beused.
Engine oil top-up
If you are unable to find an oil thatmeets any of these specifications,you must use an oil of the viscositySAE 5W-30, SAE 10W-40 or SAE5W-40, according to outsidetemperatures, meeting therequirements of either ACEA A1/B1or ACEA A3/B3 specifications. Useof these oils may result in longercranking periods, reduced engineperformance, reduced fuel economy,and increased emission levels.
ENGINE COOLANT
CHECK
151
MaintenanceE73413 E73415

Downloaded from www.Manualslib.com manuals search engine WARNING
To avoid scalding, never removethe cap from the coolantreservoir when the engine is hot. Donot restart the engine until theproblem has been eliminated.
The coolant level is visible throughthe translucent reservoir. The coolantlevel should be between the MINand the MAX mark when the engineis cold. Hot coolant expands andmay, therefore, extend beyond theMAX mark.
WARNING
Take great care when addingcoolant. Avoid spillage on anypart of the engine.
The coolant should be added whenthe engine is cold. If coolant has tobe added when the engine is hot, firstwait 10 minutes for the engine tocool. Unscrew the cap slowly. Anypressure will escape while you areturning the cap. Fully remove the cap.
WARNING
Do not allow this fluid to makecontact with the skin or eyes. Ifthis should happen rinse the affectedareas immediately with plenty ofwater and contact your doctor.
When the vehicle is new, the coolingsystem is filled with coolant whichoffers anti−freeze protection downto approximately –25 ºC.
Add coolant that meets the FordSpecification.
AUTOMATIC
TRANSMISSION FLUID
CHECK
Your dealer checks the fluid level inthe automatic transmission whencarrying out routine maintenancework on your vehicle.
BRAKE AND CLUTCH
FLUID CHECK
WARNING
Do not allow this fluid to makecontact with the skin or eyes. Ifthis should happen rinse the affectedareas immediately with plenty ofwater and contact your doctor.
Brake and clutch fluid systems aresupplied from the same reservoir.
The level of the fluid must bebetween the MIN and MAX markson the side of the reservoir.
152
MaintenanceE73414

Downloaded from www.Manualslib.com manuals search engine POWER STEERING FLUID
CHECK
The fluid level should come up to theMAX mark when the engine is cold.
If it drops below the MIN mark, topup with the specified fluid.
WASHER FLUID CHECK
Front and rear washer systems aresupplied from the same reservoir.The reservoir is located behind theright-hand headlamp.
Replace the cap securely aftertopping up.
Washer jets
To ensure the system functionsproperly, keep the washer jets freeof snow and ice.
Switching on the heated windscreendefrosts both the windscreen andthe front washer jets.
153
MaintenanceE73416 E73422

Downloaded from www.Manualslib.com manuals search engine TECHNICAL SPECIFICATIONS
Vehicle fluids
SpecificationRecommended fluidPart
WSS-M2C204-AFord Power Steering FluidPower assisted steering
WSS-M97B44-DMotorcraft SuperPlusAntifreezeCoolant
Capacities
Vehicles with a petrol engine
Capacities
Capacity inlitres (gallons)ItemVariant
Max-markPower assisted steering fluidAll
58.5 litresFuel tankAll
4.3 litresEngine oil - with filter1.8 l Duratec-HE
3.9 litresEngine oil - without filter1.8 l Duratec-HE
8.3 litresCooling system including heating1.8 l Duratec-HE
6.6 litresWindscreen washer system - withheadlamp washer1.8 l Duratec-HE
2.6 litresWindscreen washer system -without headlamp washer1.8 l Duratec-HE
4.3 litresEngine oil - with filter1.8 l Duratec-SCi
3.9 litresEngine oil - without filter1.8 l Duratec-SCi
8.3 litresCooling system including heating1.8 l Duratec-SCi
5.0 litresWindscreen washer system - withheadlamp washer1.8 l Duratec-SCi
2.5 litresWindscreen washer system -without headlamp washer1.8 l Duratec-SCi
4.3 litresEngine oil - with filter2.0 l Duratec-HE
3.9 litresEngine oil - without filter2.0 l Duratec-HE
8.1 litresCooling system including heating2.0 l Duratec-HE
6.5 litresWindscreen washer system - withheadlamp washer2.0 l Duratec-HE
154
Maintenance

Downloaded from www.Manualslib.com manuals search engine Capacity inlitres (gallons)ItemVariant
2.6 litresWindscreen washer system -without headlamp washer2.0 l Duratec-HE
5.7 litresEngine oil - with filter2.5 l Duratec-VE
5.2 litresEngine oil - without filter2.5 l Duratec-VE
9.5 litresCooling system including heating2.5 l Duratec-VE
6.5 litresWindscreen washer system - withheadlamp washer2.5 l Duratec-VE
2.6 litresWindscreen washer system -without headlamp washer2.5 l Duratec-VE
5.7 litresEngine oil - with filter3.0 l Duratec-VE/ST
5.2 litresEngine oil - without filter3.0 l Duratec-VE/ST
9.5 litresCooling system including heating3.0 l Duratec-VE/ST
6.5 litresWindscreen washer system - withheadlamp washer3.0 l Duratec-VE/ST
2.6 litresWindscreen washer system -without headlamp washer3.0 l Duratec-VE/ST
Vehicles with a diesel engine
Capacities
Capacity in litres(gallons)ItemVariant
Max-markPower assisted steering fluidAll
58.5 litresFuel tankAll
6.0 litresEngine oil - with filterAll
5.8 litresEngine oil - without filterAll
10.6 litresCooling system including heating - withauxiliary heaterAll
10.4 litresCooling system including heating - withoutauxiliary heaterAll
6.5 litresWindscreen washer system - withheadlamp washerAll
2.6 litresWindscreen washer system - withoutheadlamp washerAll
155
Maintenance

Downloaded from www.Manualslib.com manuals search engine BATTERY CARE
The battery requires very littlemaintenance. The fluid level ischecked regularly during the routineservice inspections.
USING BOOSTER
CABLES
Connect batteries with only the samenominal voltage (12 volts). Usebooster cables with insulated clampsand adequate size cable. Do notdisconnect the battery from thevehicle’s electrical system.
To connect the boostercables
Flat batteryA
Booster batteryB
•Position the vehicles so that theydo not touch one another.
•Switch off the engine and anyelectrical equipment.
158
Vehicle batteryE73405

Downloaded from www.Manualslib.com manuals search engine Changing a bulb..............................57Approach lamps..................................60Central brake lamp (4-door)..............63Central brake lamp (5-door andEstate)...............................................63Fog lamps (ST variants).......................61Fog lamps (vehicles with sportbumpers)...........................................60Footwell lamp.......................................65Front interior lamp...............................64Glove compartment lamp..................65Headlamps, side lamps, directionindicators...........................................58Luggage compartment lamp............65Number plate lamp.............................64Reading lamps.....................................65Rear interior lamp................................64Rear lamps (4-door and 5-door).......61Rear lamps (Estate)............................62Side repeater indicator.......................60Sun visor lamps....................................65
Changing a fuse.............................137Changing a road wheel................160Fitting a wheel.....................................165Jacking points.....................................161Removing a wheel.............................163Spare wheel........................................160Stowing the wheel.............................165Vehicle jack..........................................161
Changing the remote controlbattery............................................33Changing the wiper blades...........52Checking the wiper blades............51Child safety locks............................24Child safety.......................................18Child seat positioning......................19Child seats........................................18Child restraints for different massgroups................................................19
Cigar lighter......................................97
Cleaning the exterior....................156Body paintwork preservation...........156Cleaning the headlamps...................156Cleaning the rear window................156
Cleaning the interior......................156Seat belts............................................156
Climate control................................80Principle of operation..........................80
Clock.................................................97Coded keys......................................41Coding erasure....................................42Key coding............................................41
Convenience features....................97Cruise control.................................124Principle of operation........................124
Cup holders.....................................99
D
Detachable tow ball......................130Installing the tow ball..........................131Maintenance.......................................132Removing the tow ball......................130
Direction indicators.........................56Disarming the alarm........................44Vehicles with 3.0 l Duratec-VE/-ST or2.5 l Duratec-VE engine..................45
Disarming the engineimmobiliser.....................................43Driving hints....................................133
E
Electric exterior mirrors..................70Electric folding mirrors.........................70Mirror tilting positions..........................70
Electric seats....................................912-way electric seat...............................918-way electric seat...............................91
188
Index

Downloaded from www.Manualslib.com manuals search engine Head restraints................................92Front head restraints...........................92Rear head restraints............................92
Headlamp levelling..........................55Headlamp washers.........................51Heated seats...................................95Recommended settings....................95
Heated windows and mirrors.......86Heated exterior mirrors......................86Heated windows.................................86
Hints on driving with ABS..............118Horn..................................................46
I
Ignition switch................................100Ignition switch positions....................100
Information displays........................78Inspecting safety systemcomponents................................135Seat belts............................................135
Instrument lighting dimmer............97Instruments......................................72Interior lamps...................................57Reading lamps.....................................57
Interior mirror...................................70Auto-dimming mirror............................71
Introduction........................................5
K
Keys and remote controls.............32
L
Lighting control................................53Autolamps.............................................53Headlamp flasher................................54Main/dipped beam..............................53Parking lamps.......................................53
Lighting.............................................53
Load carrying.................................126General information...........................126
Locking and unlocking...................35Central and double locking................36Doors.....................................................35Tailgate..................................................35
Locks................................................35Luggage covers.............................1275-door..................................................127Estate...................................................127
M
Maintenance..................................144General information...........................144Technical specifications....................154
Manual climate control....................81Air distribution control..........................81Blower....................................................81Permanent comfort settings.............83Rapid cooling of the vehicleinterior................................................83Rapid heating of the vehicleinterior................................................83Rapid windowdefrosting/demisting.......................82Recirculated air....................................82Switching the air conditioning on andoff.......................................................82Switching the climate control systemon and off..........................................82Temperature control............................81
Manual seats...................................90Adjusting the angle of theseatback............................................91Adjusting the lumbar support.............91Moving the seats forwards orbackwards........................................90
190
Index