lock FORD RANGER 1997 2.G Workshop Manual

300
*
[MC46300(R)03/96]
Removing the headlamp bulb
*
[MC46400(R)01/96]1.
Make sure that the headlamp switch is in the OFF position.
[MC46502(R)01/96]2.
Lift the hood. Remove the electrical connector behind the
headlamp by grasping the wires and pulling it rearward.
*
[MC46700(R)01/96]3.
Remove the bulb retaining ring by turning it 1/8 of a turn to
free it from the socket. Then slide the ring off the plastic
base.Keep the ring.You must use it again to hold the new
bulb in place.
*
[MC46800(R)01/96]4.
Carefully remove the bulb assembly from its socket by
gently pulling it rearward without turning.
*
[MC46900(R)03/96]
Installing the headlamp bulb
*
[MC47000(R)01/96]1.
With the flat side of the bulb's plastic base facing upward,
insert the glass end of the bulb into the socket. You may
need to turn the bulb left or right to line up the grooves in
the plastic base with the tabs in the socket. When the
grooves are aligned, push the bulb into the socket until the
plastic base contacts the rear of the socket.
*
[MC47100(R)01/96]2.
Slip the bulb retaining ring over the plastic base until it
contacts the rear of the socket. Lock the ring into the socket
by rotating it clockwise until you feel a ªstop.º
*
[MC47200(R)01/96]3.
Push the electrical connector into the rear of the plastic base
until it snaps, locking it into position.
*
[MC47300(R)01/96]4.
Turn the headlamps on and make sure that they work
properly. If the headlamp was correctly aligned before you
changed the bulb, you should not need to align it again.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

306
%*
[MC50500(R)01/96]
Cleaning the Exterior Lamps
*
[MC50510(R)01/96]
Do not use dry paper towel, chemical solvents or abrasive
cleaners to clean the lamps, as these may cause scratches or
crack the lamps.
*
[MC51000(R)01/96]
Cleaning the Engine
*
[MC51020(R)01/96]
A clean engine is more efficient because a buildup of grease and
dirt acts as an insulator, keeping the engine warmer than usual.
*
[MC51030(R)01/96]
n
Extreme care must be used if a power washer is used to
clean the engine. The high pressure fluid could penetrate
sealed parts and assemblies causing damage or malfunctions.
*
[MC51040(R)04/96]
n
In order to avoid possible cracking of the engine block or
fuel injection pump, do not spray a hot engine or injection
pump with cold water.
[MC51050(R)01/96]
n
The alternator, coils and air intake must be covered.
Covering these components will help prevent water damage.
*
[MC51060(R)01/96]
n
Never wash or rinse the engine while it is running. Water
getting into the engine may cause internal damage.
%*
[MC51500(R)03/96]
Cleaning the Seats
%*
[MC51540(R)01/96]
Fabric
*
[MC51542(R)01/96]
Remove dust and loose dirt with a whisk broom or a vacuum
cleaner. Remove fresh spots immediately. Follow the directions
that come with the cleaner.
*
[MC51544(R)01/96]
NOTE: Before using any cleaner, test it on a small, hidden
area of fabric. If the fabric's color or texture is
adversely affected by a particular cleaner, do not use
it.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

317
Customer Assistance
%*
[HS00205(R)05/96]
Roadside Assistance
*
[HS00210(R)11/95]
Ford Motor Company has set up a 24-hour, seven-day-a-week
hotline with trained operators who put you in touch with the
help you need if you experience a problem with your vehicle.
This complimentary service is provided to you throughout your
warranty period of 3 years or 36,000 miles (60,000 km),
whichever comes first. To purchase Roadside Assistance
coverages beyond this period (available through Ford Auto Club
in the United States or Ford and Lincoln-Mercury dealers in
Canada), contact your Ford or Lincoln-Mercury dealer.
Additional Roadside Assistance coverage is unavailable in
Puerto Rico and the Virgin Islands.
*
[HS00215(R)06/94]
Roadside Assistance will cover the following:
*
[HS00220(R)06/94]
n
Mount your spare if you have a flat tire.
*
[HS00225(R)06/94]
n
Jump-start your battery if it is dead.
*
[HS00230(R)06/94]
n
Unlock your vehicle if you are locked out.
*
[HS00235(R)06/94]
n
Bring you fuel if you run out.
*
[HS00240(R)06/94]
n
Tow your vehicle if you are stranded. Even non-warranty
related tows, like accidents or getting stuck in mud or snow,
are covered (some exclusions apply, such as impound towing
and repossession).
*
[HS00245(R)06/94]
How to use Roadside Assistance
*
[HS00250(R)06/94]
Your Roadside Assistance identification card can be found in the
Owner Guide portfolio in your glove compartment. Complete
the card and place it in your wallet for quick reference.
*
[HS00255(R)04/95]
To receive roadside assistance in the United States call
1-800-241-FORD (in Canada call 1-800-665-2006).
*
[HS00260(R)04/95]
Should you need to arrange for roadside assistance yourself,
Ford Motor Company will reimburse the reasonable cost. To
obtain information about reimbursement call 1-800-241-FORD (in
Canada call 1-800-665-2006).
File:14unhsr.ex
Update:Thu Mar 20 09:00:11 1997

Index
343
A
Accessory position on the ignition............. 73
Additives, engine oil.................. 257
Air bag supplemental restraint system
and child safety seats................ 133
description...................122, 127
disposal...................... 131
driver air bag..................122, 127
indicator light..................... 12
operation...................... 127
passenger air bag.................. 127
proper seating................... 123
service and information labels............ 127
tone generator.................129, 131
wearing safety belts................. 123
Air cleaner filter
location...................... 253
specifications.................... 311
Alarm, activating remote personal............. 94
Ambulance packages................... 5
Antenna, radio (see Electronic sound system)...... 27,55
Antifreeze (see Engine coolant)............. 265
Anti-lock brake system (ABS)
description..................... 155
noise........................ 157
see also Brake.................... 155
warninig light..................... 10
Anti-theft system
arming the system................... 98
description...................... 98
disarming an untriggered system............ 99
disarming a triggered system.............. 99
triggering....................... 98
Appeals (see Dispute settlement board)......... 320
Assistance (see Customer assistance)........... 317
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

344
Audio system (see Electronic sound system)........ 27
Autolamp system (see Headlamps)............ 63
Automatic transmission
fluid, adding.................... 273
fluid, checking................... 272
fluid, specification.................. 313
Axle
lubricant specifications................ 313
traction lok..................... 170
B
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies............238, 275
battery saver..................... 97
charging system warning light............. 15
disconnecting.................... 241
how to service................... 274
jumping a disabled battery.............. 237
maintenance-free.................. 274
proper disposal, recycling.............. 275
replacement, specifications.............. 311
servicing...................... 274
voltage gauge.................. 15,19
when storing your vehicle.............. 309
Brake fluid
brake warning light.................. 10
checking and adding................ 261
description..................... 261
specifications.................... 313
Brakes
adjustment..................... 155
anti-lock...................... 155
applying the brakes................. 159
brake warning light.................. 10
fluid, checking and adding.............. 261
fluid, refill capacities................ 261
fluid, specifications................. 313
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

345
Index
Brakes (continued)
front disc...................... 155
if brakes do not grip well.............. 158
master cylinder................... 261
new brake linings................... 5
noise......................155, 158
parking...................... 160
power braking................... 155
rear anti-lock.................... 155
servicing....................158, 261
stopping distances.................. 159
trailer....................... 212
when storing your vehicle.............. 309
Brake-shift interlock.................. 165
Break-in period..................... 5
Brights (high beams)................... 21
Bulbs, replacing
halogen...................... 299
headlamps..................... 299
C
Canada, customer assistance.............. 324
Canada, warranty information.............. 3
Carbon monoxide in exhaust.............. 152
Car seats for children (see Child safety seats)...... 133
Catalytic converter................... 295
Chains, tires...................... 286
Changing a tire.................... 227
Charging system gauge................. 19
Charging system warning light.............. 15
Child safety restraints
child safety belts.................. 144
child safety seats.................. 133
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

346
Child safety seats
and air bags.................... 133
attaching with tether straps............. 143
automatic locking mode (retractor)........114, 133
in front seat.................... 133
in rear outboard seat................ 133
in rear seat..................... 133
tether anchorage hardware.............. 143
Chime
headlamps on.................... 21
key in ignition.................... 21
safety belt...................... 11
Circuit breakers, see also fuses............. 218
Cleaning your vehicle
chrome and aluminum parts............. 305
engine compartment................. 306
exterior...................... 304
exterior lamps................... 306
fabric....................... 306
headlamps..................... 306
instrument panel.................. 305
interior....................... 306
interior lamps................... 307
mirrors........................ 86
plastic parts.................... 305
polishing...................... 305
rustproofing.................... 305
safety belts..................... 307
tail lamps..................... 306
upholstery and interior trim............. 306
washing...................... 304
waxing....................... 305
wheels....................... 287
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

347
Index
Climate control system.................. 64
Clock........................ 34,55
Clutch
fluid........................ 263
fluid reservoir.................261, 263
operation while driving............... 170
recommended shift speeds.............. 173
shifting the gears.................. 171
specifications.................... 313
Cold engine starting.................. 148
Combination lap and shoulder belts.........110, 112
Controls
mirrors........................ 86
power seat..................... 109
Convenience kit in cargo area.............. 229
Coolant (see Engine coolant)
checking and adding................ 265
preparing for storage................ 309
specifications.................... 313
temperature gauge.................. 22
warnings...................... 265
Cooling fan...................... 250
Crankcase emission filter................ 311
Customer Assistance Centre, Ford of Canada....... 324
D
Daytime running light system.............. 63
Defects, reporting................... 315
Defrost, windshield................. 67,70
Dipstick
automatic transmission fluid...........271, 273
engine oil..................... 258
power steering fluid................. 268
Disabled vehicle (see Towing).............. 242
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

349
Index
Engine block heater.................. 150
Engine coolant
checking and adding................ 265
checking hoses................... 267
disposal..................250, 261, 273
preparing for storage................ 309
proper solution...............250, 261, 273
recovery reservoir.................. 253
specifications.................... 313
temperature gauge.................. 22
Engine coolant temperature gauge
description...................... 22
mechanical...................... 22
Engine coolant temperature guage:electronic........ 22
Engine fan...................... 250
Engine:idle speed control................ 149
Engine oil
changing oil and oil filter............258, 260
checking and adding................ 258
dipstick...................... 258
disposal..................250, 261, 273
engine oil pressure gauge............... 20
filter, specifications................. 311
specifications..................257, 313
synthetic oil.................... 257
ªbreak-inº oils.................... 5
viscosity...................... 257
Entry system
illuminated...................... 97
remote........................ 93
Exhaust fumes..................... 152
Extended Service Plan, Ford............... 4
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

352
GAWR (Gross Axle Weight Rating)
calculating..................... 196
definition....................187, 194
driving with a heavy load.............. 187
location...................... 194
Gearshift
automatic operation................. 164
column-mounted.................. 164
floor-mounted................... 171
gearshift override.................. 165
locking the gearshift.................. 73
positions....................164, 171
shifting the gears................164, 171
shift-lock...................... 165
Gearshift:shifting the gears.............164, 171
GVWR (Gross Vehicle Weight Rating)
calculating..................... 196
definition....................187, 194
driving with a heavy load.............. 187
location...................... 194
H
Hazard flashers.................... 217
Headlamps
aiming....................... 298
checking alignment................. 298
cleaning...................... 306
daytime running lights................ 63
replacing bulbs................... 298
turning on and off.................. 61
warning chime.................... 21
High beams
indicator light.................... 21
operation....................... 61
Hitch......................... 211
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997