engine GMC SAVANA 1996 Owners Manual

{bong Trip/Highway Maintenance Schedule =- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(1 66 000 km) at the same intervals.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion
of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at
the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage and rear driveline center splines.
:i: *
0
0
Drive axle service:
Locking Differential
-- Drain fluid and refill at first
engine
oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential
-- Check fluid level and add
fluid
as needed at every engine oil change. If driving
in dusty areas or towing a trailer, drain fluid and
refill every
15,000 miles (35 000 km).
More frequent lubrication may be required for
heavy-duty use.
7-30
ProCarManuals.com

I
- mg Trip/Highway Maintenance Schedule -- Gasoline Engines
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Elnission Con fro1 Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
Cl Check axle fluid level and add fluid
as needed. :k*
Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. R.efer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE SERVICED BY ACTUAL MILEAGE
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components; see
An Emission Control Service.
footnote ## (or every 12 months, whichever
occurs first).
0 Check axle fluid level and add fluid
as needed.
Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required. This is a Noise Emissiou
Col7tt-ol
Servic:c. Applicclhle only to whic*les sold in
the UI7ited States.
(Continued)
7-31
ProCarManuals.com

Long TripJHighway Maintenance Schedule -- Gasoline Engines
15,000 Miles (25 000 km) (Continued)
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly. This is LZ Noise
Euzissioll
Control Service. ApplicclDle orzl~ to
vehic.1e.s sold in the United Stcrtes.
I DATE I ACTUAL MILEAGE ISERVICED BY I
22,500 Miles (37 500 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
An Et~~issior? Co11tr-d Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed.
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
7-32
ProCarManuals.com

Long TripMighwag Maintenance Schedule -- Gasoline Engines rn
30,000 Miles (50 000 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components; see
A11 Emission ColztmI Service.
footnote # (or every 12 months, whichever
occurs first).
as needed.
*:k
(or at each brake relining, whichever
occurs first).
0 Check axle fluid level and add fluid
Clean and repack the front wheel bearings
Replace fuel filter.
0 Replace air cleaner filter.
An Ernissinn Control Service. -f-
AI? Emission Control Service.
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required. This is a Noise Emission
Control Service. Applicable only to vehicles sold in
the United States.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is LI Noise
Emission Corztvol Service. Applicable
only to
vehicles sold in the United States.
7-33
ProCarManuals.com

I Long Tripmighway Maintenance Schedule -- Gasoline Engines I
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
Arz Em.issio?? Control Serviw.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs ht).
0 Check axle fluid level and add fluid
0 Rotate tires. See “Tire Inspection and
as needed. :>*
Rotation” in the Index for proper rotation
pattern and additional information. During tire rotation, check brake calipers for freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE SERVICED BY ACTUAL MILEAGE
45,000 Miles (75 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
Ail Emission Control ScJnYico.
Cl Lubricate chassis components; see
footnote
# (or every 12 months, whichever
occurs first).
0 Check axle fluid level and add fluid
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is CI Noise Emissiorl
Corltlnl Ser-\.ic.c.. Applicwhle only to I~el1iclc.s sold irl
the Urlifd Stcrtes.
as needed. :!: :!:
7-34
ProCarManuals.com

0 If your engine has a thermostatically
controlled cooling fan, inspect
all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is CI Noise
Emissim Control Service. Applicurhle OMI~ to
whicles sold ir? the United States.
DATE ACTUAL MILEAGE SERVICED BY
Change automatic transmission fluid
and filter
if the vehicle’s GVWR is over
8600 Ibs. or if the vehicle is mainly driven
under one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
I DATE I ACTUAL MILEAGE ISERVICED BY I
7-35
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines I
52,500 Miles (87 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components; see footnote ##
(or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed.
‘M
I7 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
I DATE I ACTUALMILEAGE SERVICED BY:^
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every
I2 months, whichever occurs first).
Lubricate chassis components; see
An Emissiorl Control Service.
footnote ## (or every 12 months, whichever
occurs first).
as needed.
**
(or at each brake relining, whichever
occurs first).
0 Check axle fluid level and add fluid
0 Clean and repack the front wheel bearings
0 Inspect engine accessory drive belt.
0 Replace fuel filter.
A17 Elnissiorl Co~~rol Service.
AIZ Emission Corz~ol Servicv. ?
7-36 -
ProCarManuals.com

0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
0 Vehicles With GVWR Above 8,500 lbs. Only:
Inspect shields and underhood insulation for
damage or looseness. Adjust or replace
as
required. This is a Noise Emission Control Service.
Applicable only
to vehicles sold in the United States.
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is a Noise
Emission Control Service. Applicable
only to
vehicles sold in the United States.
If your engine has a thermostatically
0 Conduct Exhaust Gas Recirculation (EGR)
system inspection as described in the
service manual.
An Emission Control Service. T
inspection. Check all fuel and vapor lines
and hoses for proper hook-up, routing and
condition. Check that the purge valve works
properly, if equipped. Replace as needed.
An Emission Control Service. T
0 Conduct evaporative control system
7
ACTUAL MILEAGE SERVICED BY:
- 7-37
ProCarManuals.com

67,500 Miles (112 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
A17 Em.issiorl Corztrol Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed. WI:
Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer
to the
appropriate
GM service manual for proper
caliper service procedures.
I DATE I ACTUAL MILEAGE ISERVTCED BY: I
75,000 Miles (125 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
Alz Ernissiorl Cmtrvl Service.
0 Lubricate chassis components; see
footnote
# (or every I2 months, whichever
occurs first).
as needed.
**
0 Check axle fluid level and add fluid
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is CI Noise Emission
Control Service.
Applicuhle nnly to \xhic:les sold in
the United Stcrtes.
7-38
ProCarManuals.com

Long TripMighway Maintenance Schedule -- Gasoline Engines
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is (1 Noise
Emission Control Service. Applicuhle only to
vehicles sold in the United Stutes.
DATE ACTUAL MILEAGE SERVICED BY
82,500 Miles (137 500 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
An Enlissiorz Control Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
Check axle fluid level and add fluid
as needed. **
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern
and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE ACTUAL MILEAGE SERVICED BY
7-39
ProCarManuals.com