reset GMC SIERRA DENALI 2003 Owner's Manual

Coolant Surge Tank Pressure Cap
The coolant surge tank
pressure cap must be fully
installed on the coolant
surge tank.
Nofice: Your pressure cap is a pressure-type cap
and must be tightly installed to prevent coolant loss
and possible engine damage from overheating. See “Capacities and Specifications” for more
information.
Engine Overheating
You will find a coolant temperature gage on your
vehicle’s instrument panel. See
Engine Coolant
Temperature Gage
on page 3-36. In addition, you will
find a LOW COOLANT, ENGINE OVERHEATED and a
REDUCED ENGINE POWER message in the DIC on
the instrument panel. See
Driver lnformation Center
(DIC)
on page 3-43.
Overheated Engine Protection
Operating Mode
If an overheated engine condition exists and the
REDUCED ENGINE POWER message is displayed, an
overheat protection mode which alternates firing groups
of cylinders helps prevent engine damage. In this mode,
you will notice a
loss in power and engine performance.
This operating mode allows your vehicle to be driven to
a
safe place in an emergency. Driving extended miles (km)
and/or towing a trailer in the overheat protection mode
should be avoided.
Nofice: After driving in the overheated engine
protection operating mode, to avoid engine damage,
allow the engine to cool before attempting any repair.
The engine oil will be severely degraded. Repair the
cause of coolant
loss, change the oil and reset the oil
life system. See “Engine
Oil” in the Index.
5-27

Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory to give you the longest tire life
and best overall performance.
Scheduled wheel alignment and wheel balancing are
not needed. However,
if you notice unusual tire wear or
your vehicle pulling one way or the other, the alignment
may need to be reset.
If you notice your vehicle
vibrating when driving on a smooth road, your wheels
may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted
or corroded.
If wheel nuts keep coming loose, the
wheel, wheel bolts and wheel nuts should be replaced.
If the wheel leaks air, replace it (except some
aluminum wheels, which can sometimes be repaired).
See your dealer
if any of these conditions exist.
Your dealer will know the kind of wheel you need.
Each new wheel should have the same load-carrying
capacity, diameter, width, offset and be mounted
the same way as the one it replaces.
If you need to replace any
of your wheels, wheel bolts
or wheel nuts, replace them only with new
GM
original equipment parts. This way, you will be sure to
have the right wheel, wheel bolts and wheel nuts
for your vehicle. Usin,
__ __ wrong replacement wheels,
whc
bolts or wheel nuts on your vehicle can be
dangerous.
It could affect the braking and
handling
of your vehicle, make your tires lose
air and make you
lose control. You could have
a collision
in which you or others could be
injured. Always use the correct wheel, wheel
bolts and wheel nuts
for replacement.
Notice: The wrong wheel can also cause problems
with bearing life, brake cooling, speedometer or
odometer calibration, headlamp aim, bumper height,
vehicle ground clearance and tire clearance to the
body and chassis.
See
Changing a Flat Tire on page 5-69 for more
information.
5-67

Scheduled Maintenance
The services shown in this schedule up to 100,000 miles
(1 66 000 km) should be repeated after 100,000 miles
(1 66 000 km) at the same intervals for the life of
this vehicle. The services shown at
150,000 miles
(240
000 km) and 200,000 miles (332 000 km) should
be repeated at the same intervals after 150,000 miles
(240
000 km) and 200,000 miles (332 000 km) for the life
of this vehicle.
See
Part B: Owner Checks and Services on page 6-10
and Part C: Periodic Maintenance Inspections on
page
6- 14.
Footnotes
t The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle
's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
+ A good time to check your brakes is during tire
rotation. See Brake System Inspection on page
6-15.
Engine Oil and Chassis Lubrication
Scheduled Maintenance
Change engine oil and filter as indicated by the GM
Oil Life SystemTM (or every 12 months, whichever
occurs first). Reset the system.
Your vehicle has a computer system that lets you know
when to change the engine oil and filter. This is
based on engine revolutions and engine temperature,
and not on mileage. Based on driving conditions,
the mileage at which an oil change will be indicated can
vary considerably. For the oil life system to work
properly, you must reset the system every time the oil is
changed.
When the system has calculated that oil life has been
diminished, it will indicate that an oil change
is
necessary. A CHANGE ENGINE OIL message will
come on. Change your oil as soon as possible within
the next two times you stop for fuel. It is possible that,
it
you are driving under the best conditions, the oil life
system may not indicate that an
oil change is necessary
for over a year. However, your engine
oil and filter
must be changed at least once a year and at this time
the system must be reset. It
is also important to
check your oil regularly and keep
it at the proper level.
6-5

If the system is ever reset accidentally, you must
change your oil at
3,000 miles (5 000 km) since your
last oil change. Remember to reset the oil life system
whenever the oil is changed. See
Engine Oil on
page 5-73
for information on resetting the system.
An Emission Control Service.
Lubricate chassis components with each engine oil
and filter change.
Lubricate the front suspension, ball joints, steering
linkage, transmission shift linkage, transfer case shift
linkage and parking brake cable guides. Ball joints
should not be lubricated unless their temperature is
10°F (-12°C) or higher or they could be damaged.
After the services are performed, record the date,
odometer reading and who performed the service on the
maintenance record pages in Part
E of this schedule.
7,500 Miles (12 500 km)
0 Check readfront axle fluid level and add fluid as
needed. Check constant velocity joints and axle seals
for leaking.
page 5-62 for proper rotation pattern and additional
information.
(See footnote +.)
0 Rotate tires. See Tire Inspection and Rotation on
15,000 Miles (25 000 km)
0 Inspect engine air cleaner filter if you are driving in
dusty conditions. Replace filter
if necessary. An
Emission Control Service. (See footnote
t.)
0 Check readfront axle fluid level and add fluid as
needed. Check constant velocity joints and axle seals
for leaking.
0 Rotate tires. See Tire Inspection and Rotation on
page 5-62
for proper rotation pattern and additional
information.
(See footnote +.)
6-6

M
Maintenance. Normal Replacement Parts .......... 5-1 05
Maintenance Schedule
At Each Fuel Fi!!
......................................... 6-10
At Least Once a Month ................................ 6-10
At Least Once a Year
.................................. 6-1 1
At Least Twice a Year .................................. 6-1 1
Brake System Inspection
.............................. 6-15
Engine Cooling System Inspection
................. 6-14
Exhaust System Inspection
........................... 6-1 4
How This Section is Organized
....................... 6-3
Introduction
.................................................. 6-2
Maintenance Requirements
............................. 6-2
Part
A - Scheduled Maintenance Services ......... 6-4
Part
B - Owner Checks and Services ............. 6-10
Part C
- Periodic Maintenance Inspections ...... 6-1 4
Part D
- Recommended Fluids and
Lubricants
............................................... 6-1 6
Part E
- Maintenance Record ........................ 6-1 8
Scheduled Maintenance
................................. 6-5
Steering and Suspension Inspection
............... 6-14
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
..................... 4-59
Fuel
System Inspection
................................ 6-14
Using Your
................................................... 6-4
Making Turns
................................................. 4-57
Malfunction Indicator Light
................................ 3-38
Matching Transmitter(s) to Your Vehicle
............... 2-5
Memory Seat ................................................. 2-42
..... 3-53
Message
DIC Warnings and Messages ...............
Mexico. Central America and Caribbean
Islands/Countries (Except Puerto Rico
and
U.S. Virgin Islands) ................................. 7-4
Mirrors Automatic Dimming Rearview with Onstar@,
Compass and Temperature Display
............. 2-28
Outside Automatic Dimming Mirror
................. 2-31
Outside Convex Mirror
................................. 2-32
Outside Curb View Assist Mirrors
................... 2-32
Outside Heated Mirrors
............... ......... 2-32
Outside Power Foldaway Mirrors
.................... 2-31
Outside Power Mirrors
.................................. 2-31
MyGMLink.com
................................................ 7-3
New Vehicle Break-In
.........................
Normal Maintenance Replacement Parts ....
..... 2-15
.... 5-105
Odometer ...................................................... 3-26
Off-Road Recovery
.......................................... 4-13
Oil Engine
....................................................... 5-13
Pressure Gage
............................................ 3-40
OIL LIFE RESET
............................................ 3-54
9

Removing the Flat Tire and Installing
the Spare Tire
............................................. 5-77
Replacement Bulbs
......................................... 5-59
Replacing Brake System Parts
.......................... 5-42
Replacing Restraint System Parts
After a Crash
.............................................. 1-73
Reporting Safety Defects
Canadian Government
................................... 7-9
General Motors
............................................. 7-9
United States Government
.............................. 7-9
Resetting Defaults
........................................... 2-38
Restraint System Check
................................... 6-1 1
Removing
the Spare Tire and Tools
................... 5-70
Reprogramming a Single HomeLink@ Button
....... 2-38
Checking Your Restraint Systems
................... 1-73
Replacing Restraint System Parts After
a
Crash ..................................................... 1 -73
Checking
.................................................... 1-73
Replacing Parts
........................................... 1-73
Retained Accessory Power (RAP)
...................... 2-1 6
Right Front Passenger Position, Safety Belts
...... 1-22
Right Front Passenger Position
Top Strap Anchor
........................................ 1-41
Roadside
Assistance Program
....................................... 7-5
Running Your Engine While You Are Parked
....... 2-27
Restraint
Systems
Restraints, Head
............................................... 1-6
RFA# BATTERY LOW
..................................... 3-60
Rocking Your Vehicle To Get It Out
................... 4-43
S
Safety Belt
Safety Belts Reminder
Light
........................................ 3-26
Care of
.................................................. 5-88
Center Passenger Position
............................ 1-22
Driver Position
............................................ 1-13
How to Wear Safety Belts Properly
................ 1-13
Questions and Answers About Safety Belts
..... 1-12
Rear Safety Belt Comfort Guides for
Children and Small Adults
......................... 1-27
Rear Seat Passengers
................................. 1-24
Right Front Passenger Position
...................... 1-22
Safety Belts Are for Everyone
......................... 1-8
Safety Warnings and Symbols
.............................. iii
Safety Belt Extender .................................... 1-29
Safety Belt Use During Pregnancy
................. 1-21
Safety Chains
................................................. 4-56
Scheduled Maintenance
.................................. 6-5
Seats
Head Restraints
....................... , ................. 1-6
Heated Seats
............................................... 1-3
Memory
..................................................... 2-42
Power Lumbar
.............................................. 1-3
Power Seats
................................................. 1-2
Rear Seat Operation
...................................... 1-7
Reclining Seatbacks
...................................... 1-4
Secondary Latch System
................................. 5-74
12

Securing a Child Restraint
Center Rear Seat Position
............................ 1-48
Designed for the LATCH System
................... 1-46
Rear Outside Seat Position
........................... 1-46
Select Button
................................................. 3-53
Service
........................................................... 5-3
Vehicle
..................................................... 5-4
Doing Your Own Work
................................... 5-4
Engine Soon Light
....................................... 3-38
Publications Ordering Information
................... 7-10
Right Front Seat
Position
.............................. 1-50
Adding Equipment to the Outside
of Your
SERVICE
4 WHEEL STEER ............................. 3-58
SERVICE 4WD
............................................... 3-56
SERVICE AIR SUSPENSION
........................... 3-56
SERVICE AIRBAG
.......................................... 3-55
SERVICE BRAKE BOOSTER
........................... 3-55
SERVICE BRAKE SYSTEM
............................. 3-55
Service Bulletins
............................................. 7-1 0
Service Manuals ............................................. 7-10
Setting the Time
............................................. 3-61
Sheet Metal Damage
.................................... 5-91
Shifting Into Park (P)
.................................... 2-23
Setting Preset PTYs (RDS Only)
....................... 3-67
Setting Preset Stations
.................................... 3-65
Setting the Tone (Bassnreble)
.......................... 3-66
Shifting Out of Park (P)
................................... 2-25 Skidding
........................................................ 4-1 5
Some Other Rainy Weather Tips ....................... 4-32
Spare Tire
..................................................... 5-85
Spare Tire Check
............................................ 6-11
Specifications. Capacities
............................... 5-1 04
Speedometer .................................................. 3-26
Starter Switch Check
....................................... 6-12
Starting Your Engine
....................................... 2-16
Steering
.......................................................... 4-9
Steering and Suspension Inspection
.................. 6-14
Steering in Emergencies
.................................... 4-9
Steering Tips
................................................... 4-9
Center Console Storage Area
.... ............ 2-39
Cupholder(s)
............................................... 2-39
Glove Box
.................................................. 2-39
Steering
Wheel Controls, Audio
......................... 3-81
Storage Areas
Storing a Flat or Spare Tire and
Tools ............... 5-83
Stuck in Sand, Mud, Ice or Snow
...................... 4-42
Sun Visors
..................................................... 2-12
Swing-Out Windows
........................................ 2-11
Tachometer
................................................ 3-26
Tailgate
........................................................... 2-8
Tailgate Removal
.............................................. 2-9
13