GMC YUKON DENALI 2003 Owners Manual

Replace cover after servicing. Remettre le couvercle en Dlace.
B+
.- - - T- I I I SLOW I PLUG
OR I
I CUST I FEED I
,e-
IOTE: The function and FUNCTION/AMP-GAS FUNCTION/AMP-DIESEL * REMARQUE: La fonction et I'intensiti! dl
re different for gas and
mperage
of these fuses FONCTlON/INTENSlT~-ESSENCE FONCTION/INT€NSIT6-DlESEL ces fusibles sont diffhrentes pour les
iesel fueled engines. See EDU/25A
moteurs i essence et les moteurs diesel
lwners Manual for ECMRPV/ISA Voir
le Guide du proprigtaire a pour
lnctions of studs
#I and #2. FUEL HT/IM les fonctions des plots 1 et 2. ECMI/15A a EDU
5-92

*I - Gasoline Engine and Fuel Injection Rail #2.
*2 - Gasoline Engine and Fuel Injection Rail #l.
*3 - Gasoline Engine; Oxygen Sensors.
*4 - Gasoline Engine; Oxygen Sensors.
*5 - PCM Ignition
I Fuses I Usage I
I STUD #1 I
Battery-and Diesels
Only)/Dual Battery (TP2) Do
not -install fuse.
Mid Bussed Electrical Center
MBEC Power
Feed, Front Seats,
LBEC Door Modules, Door Locks,
Auxiliary Power Outlet-Rear
Cargo Area and Instrument
Panel
STUD 2 Accessory
Powerflrailer
Wirinq Brake Feed LBEC
1
~~
I RR PARK I
Right
Rear Parking and
Sidemarker LamDs
I
5-93

Fuses
RR HVAC
Usage
Rear Climate Control
AUX PWR I
Auxiliary Power
Outlet
- Console
IGN
1
PCM 1 Ignition Relay
Electronic Throttle Control,
ETC/ECM Powertrain Control Module
Electronic Brake Controller
IGN E Instrument Panel Cluster,
Air
Conditioning Relay, Turn
SignaVHazard Switch, Starter
Relav
RTD I Ride Control I
TRL B/U
~~
I Backup LampsTrailG Wiring 1
PCM B I
Powertrain Control Module,
Fuel Pumr,
I I
F/PMP I Fuel Pump (Relay)
B/U LP
I
Back-up Lamps, Automatic
Transmission Shift Lock
I
Control System
RR DEFOG
Rear Window Defoaaer
HDLP-HI
~~~ ____
HeadlampHighBeam Relay
PRIME Not Used
Fuses I Usage I
SIR Supplemental Inflatable
Restraint System
FRT PARK
DRL Front Parking Lamps,
Sidemarker Lamps
Daytime Running Lamps
(Relav)
SEO IGN
Truck Body Controller Ignition
TBC IGN1 Rear
Defog Relay
HI HDLP-LT High
Beam Headlamp-Left
LH HID Not
Used
DRL
I Davtime Runnina LamDs I
Instrument Panel
IPC/DIC Cluster/Driver Information
HI HDLP-RT
HDLP-LOW High
Beam Headlamp-Right
Headlamp Low Beam Relav
A/C COMP
I Air Conditionina Comm-essor I v
A/C COMP Air
Conditioning Compressor
Relav
5-94

Fuses
RR WPR RADIO
SEO B1
LO HDLP-LT
BTS I
CRANK
FOG LP Fog Lamps
HORN Horn Fuse
Fuses Usage
HORN Horn Relav
5-95

Capacities and Specifications
Please refer to Part D: Recommended Fluids and Lubricants on page 6-15 for more information.
All capacities are approximate.
Engine Specifications
Engine VIN Code 1 Spark Pluq GaD - I t -
VORTECTM 6000 V8 U I 0.060 inches (1.52 mm)
Capacities and Specifications
Capacities
Application Metric
English
After refill, the level must be rechecked. See Cooling System on page 5-28.
Cooling System 19.0 quarts 18.0 L
After refill, the level must be rechecked. Add enough engine oil so that the fluid is within the proper operating
range. See Engine Oil on page
5-13.
Engine Oil with Filter
Fuel Tank
5.7 L 6.0 quarts
Yukon Denali
Yukon
XL Denali
26.0 gallons
31 .O gallons
98.0 L
117.0 L
5-96

Capacities and Specifications (cont’d)
I r
Application
Air Conditioning Refrigerant R-l34a
Yukon Denali
Yukon
XL Denaii
I
Capacities ~
English
2.71 Ibs.
3.0 Ibs.
t
Metric
1.23 kg
1.36 kg
1
Wheels and Tires
5-97

Normal Maintenance Replacement Parts
Replacement part numbers listed in this section are based on the latest information available at the time of printing,
and are subject
to change. If a part listed in this manual is not the same as the part used in your vehicle when it was
built, or
if you have any questions, please contact your GM dealer.
These specifications are for information only.
If you have any questions, see the service manual.
I Part 1 Number I
Oil Filter
G F626"
Fuel Filter 41
-974*
/ PZTR5A15t
Spark Plugs cv2001
-c* PCV Valve" AI
51 8C*
Engine Air CleanedFilter P F44*
Wiper Blades (Front)
ITTA
Wiper Blade Tvpe (Front)
151 53642**
Wiper Blade Length (Front)
ITTA WiDer Blade Tvpe (Rear) 221
54396**
Wiper Blades (Rear) 22.0
inches (56.0 cm) a. I
Wiper Blade Length (Rear) 18.0 inches (45.0 cm)
*ACDelco@ Part
No.
**GM Part No.
tNGK
5-98

Section 6 Maintenance Schedule
Maintenance Schedule ...................................... 6.2
Introduction
................................................... 6.2
Your Vehicle and the Environment
.................... 6-2
Maintenance Requirements
.............................. 6.2
How This Section is Organized
......................... 6-3
Part A: Scheduled Maintenance Services
........... 6-4
Using Your Maintenance Schedule
.................... 6-4
Scheduled Maintenance
................................... 6-5
Part
B: Owner Checks and Sewices ................ 6-10
At Each Fuel Fill
.......................................... 6-10
At Least Once a Month
................................. 6-10
At Least Twice a Year
................................... 6-10
~~
At Least Once a Year ................................... 6.11
Part C: Periodic Maintenance Inspections
......... 6.14
Steering and Suspension Inspection
................ 6.14
Exhaust System Inspection
............................ 6.14
Fuel System Inspection
.................................. 6.14
Engine Cooling System Inspection
................... 6.14
Drive) Inspection
....................................... 6.14
Brake System Inspection
................................ 6.14
Part D: Recommended Fluids and Lubricants
.... 6.15
Part E: Maintenance Record
........................... 6.17
Transfer Case and Front
Axle (All-Wheel
6- 1

Maintenance Schedule
Introduction
1
IMPORTANT:
KEEP ENGINE OIL
AT THE PROPER
EVEL
AND CHANGE AS
RECOMMENDED
,. - .~
protectjon
I
Have you purchased the GM Protection Plan? The Plan
supplements your new vehicle warranties. See your
Warranty and Owner Assistance booklet or your dealer
for details.
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle in good working condition, but also helps the
environment. All recommended maintenance procedures
are important. Improper vehicle maintenance can
even affect the quality of the air we breathe. Improper
fluid levels or the wrong tire inflation can increase
the level of emissions from your vehicle. To help protect
our environment, and to keep your vehicle in good
condition, please maintain your vehicle properly.
Maintenance Requirements
Maintenance intervals, checks, inspections and
recommended fluids and lubricants as prescribed in this
manual are necessary
to keep your vehicle in good
working condition. Any damage caused by failure
to follow recommended maintenance may not be
covered by warranty.
6-2

How This Section is Organized
This maintenance schedule is divided into five parts:
“Part
A: Scheduled Maintenance Services” explains
what
to have done and how often. Some of these
services can be complex,
so unless you are technically
qualified and have the necessary equipment, you
should let your dealer’s service department or another
qualif
i service center do these jobs.
Performing maintenance work on a venicle can
be dangerous. In trying to do some jobs, you
can be seriously injured.
Do --- your own 1
If you want to get the service information, see Service
Publications Ordering Information on page
7- IO.
“Part B: Owner Checks and Services” tells you what
should
be checked and when. It also explains what
you can easily do
to help keep your vehicle in good
condition.
“Part
C: Periodic Maintenance Inspections” explains
important inspections that your dealer’s service
department or another qualified service center should
perform.
“Part
D: Recommended Fluids and Lubricants” lists
some recommended products necessary
to help
keep your vehicle properly maintained. These products,
or their equivalents, should be used whether you do
the work yourself or have it done.
maintenance work only
if you have the
required know-how and the proper tools and “Part E: Maintenance Record”
is a place for you to
equipment for the job. If you have any doubt, record
and keep track of the maintenance performed on
your vehicle. Keep your maintenance receipts. They
have a qualified technician do the work. may be needed
to qualify your vehicle for warranty 1 repairs.
6-3