Src HONDA CIVIC 1999 6.G Workshop Manual

[x] Cancel search | Manufacturer: HONDA, Model Year: 1999, Model line: CIVIC, Model: HONDA CIVIC 1999 6.G
Pages: 2189, PDF Size: 69.39 MB

Page 306 of 2189

$HONDA CIVIC 1999 6.G Workshop Manual UGIfI &AMRYo5A) 60a) A//C CIUICH -wHT/gtU c354 -BLVRED - GRN/REO f"* F*n* -*r -l I lsrc Aros^ | f*-__l I|i��il?-\.p--lII ncB lllI FIJEL PII/|P III ln*llltl nll�5-,- i II Na15 | |l arlnrl Ton l L lI$

Page 1107 of 2189

HONDA CIVIC 1999 6.G Workshop Manual t
t5.
16.
14. Assemble a 12 x 1.25 mm flange nut onto a 12 x 175
mm grade 10 flange bolt as shown.
NOTE: Wrap the tlange portion of the bolt with
vinyl tape to protect the cylinder.
12,mm FLANGE
BOLT1

t
t5.
16.
14. Assemble a 12 x 1.25 mm flange nut onto a 12 x 175
mm grade 10 flange bolt as shown.
NOTE: Wrap the tlange portion of the bolt with
vinyl tape to protect the cylinder.
12,mm FLANGE
BOLT12 mm FLANGE NUTVINYL TAPG {p/N 90i77 - SLo - 000}
Install the flange bolt into the end of the steering
rack until it bottoms in the hole, then back the
flange bolt out 'll4 turn. Hold the flange bolt, and
tighten the flange nut against the rack by hand.
Install the bearing separator on the gearbox housing
a5 snown.
FLANGE BOLT
BEARING SEPARATOR0 - 1112" I
lCommercially availablo)
STEERING RACK
CYLINDER END SEAL
Set the gearbox in a press so the gear housing point
upward, then press the cylinder end seal and steer-
ing rack out of the gearbox
NOTE: Hold the steering rack to keep it from falling
when pressed clear.
CAUTION:
. Be carsful not damage to inn6l surface ot the
cylinder housing with the flange bolt.
. Do not place your lingers under th€ ste€ring
rack.
t./
17.
12 x 175 mm Ptess
1.,
the spe-
srcle.
securely
Replace. J__--'- ,----)t'| ,-----'" ,-,-'-'| fiN ----'
| .Wl'----
I
t
-'4a
| ^--.'--4
A ooY----- \
Q) * srerhtnc nact
20. lnsert a 24" long,3E" drive extension and
cial tool into the cylinder from the gearbox
NOTE: Make sure that the special tool is
positioned on the backup ring edges'
18, Remove the 12 mm bolt and nut from the steering
rack,
19. Remove the cylinder end seal from the steering
racK.
CYLINDER HOUSING
CAUTION: Be caroful not damago to inner surfaco
of the cylinder housing with the specisl tool'
21. Set the gearbox in a press, then press out the cYlin-
der end seal and backup ring from the gearbox,
GAUTION:
. Keep the tool sttaight to avoid damaging the cylin'
der wall. Check th€ tool angls, and corr€st it if nec-
€ssary, whon rsmoving the cylinder snd seal.
. Uss a pross to removs tho cylinder end seal. Do
not try to removo ths seal by striking the tool h
will br€ak the backup ring. and the cylinder snd
s€al will lemain in tho gearbox.
BACKUP RING
CYLINDER END SEAL
CYLINDER END SEALREMOVER ATTACHMENT07NAD - SR3020A
(cont'd)
17-51
Pross

Page 1823 of 2189

HONDA CIVIC 1999 6.G Workshop Manual How To Use This Manual
Component Locations
To see where a component or connector is located on the car, look up its photo number in the
Component Location section in the back of the book. The photo wi

Page 1858 of 2189

$HONDA CIVIC 1999 6.G Workshop Manual ----" A/T -----t DRIVEN PULLEY , ^.,. ;iftTBilis".f l5Ftr,.""_ corinienixnn . Pase 232 SPEED SENSOR ; .-\.SHIELD F--.1 TDC/CKP/CYPSENSORSHIELDPage 20 ll r_:.-i 23-13 t1 23- l4 tl PRIMARY SECONDA$

Page 1864 of 2189

HONDA CIVIC 1999 6.G Workshop Manual cRutsECONTROLMAINswrTcHPage 34
tl
ll
1Y
. - - accessory
: security system :
i secun,rY ;
: SYSTEMi coNNEcroR : (oPTroN) Page |33
: . rg;3,, :, I vrfl,v 58
ili; . ----+
REARWINDOW DASH LIGHTSDEFOG

Page 1876 of 2189

HONDA CIVIC 1999 6.G Workshop Manual - Automatic Transmission (D1685)
c352
vtEw27
FUSE 42tGtao
.I ELECTRICALI LOADr DETECIOn
| (ELD) uNtrI PHOTO 9
I
UNDER.HOOOFUSE/RELAYBOX
r=-----L-_-_-_-_-_-=_-_-Tl.*1"","1#"Ei]""
li F 3,"j,[,ul
WHT/BL

Page 1999 of 2189

$HONDA CIVIC 1999 6.G Workshop Manual \ *=l\4ale-Female terminals reversedfor99-00 models TumSignalSwitch From Splice orfacing page. v icnrineo I csor " l"Pli?c-- l f "*f B""i.BfiiJrl ".^f I see Grouno ar-< pay6!,,-,v >-ra | Tt""$

Page 2001 of 2189

$HONDA CIVIC 1999 6.G Workshop Manual \ COMBINATIONLIGHTswrTcH ytEW 64 TumSignalSwltctl A2 From Splice onfacing page. v i cazs o"nttt I csor;l:J?" " lEl?,*{ GRN/FED 606UNDER-DASH IIFUSE/RELAYi BoxI I ffi **;r,-" " "J- *.. 1 t*?$