Control HONDA CR-V 2002 RD4-RD7 / 2.G Manual PDF

Thediagramsinthissectiongive
you the dimensions and capacities of
your Honda, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 340
................................
Specif ications .342
DOT Tire Quality Grading ......................
(U.S. Vehicles) .344
Unif orm Tire Quality ..................................
Grading .344
.................................
Treadwear .344
......................................
Traction .344
.............................
Temperature .345
.........................
Oxygenated Fuels .346
......
Driving in Foreign Countries . 347.......................
Emissions Controls .348
.....................
The Clean Air Act .348
Crankcase Emissions Control ....................................
System .348
Evaporative Emissions Control ....................................
System .348
Onboard Ref ueling Vapor ................................
Recovery .348
...
Exhaust Emissions Controls . 349
....................
PGM-FI System .349
Ignition Timing Control ................................
System .349
Three Way Catalytic ...........................
Converter .349
....................
Replacement Parts . 349
..
Three Way Catalytic Converter . 350
..............
State Emissions Testing . 351
T echnical Inf ormat ion
T echnical Inf ormation339

µ
The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices and dif f erences in
road characteristics and climate. The traction grades, f rom highest to
lowest, are AA, A, B, and C. These
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
The tires on your vehicle meet all
U.S. Federal Saf ety Requirements.
All tires are also graded f or
treadwear, traction, and temperature
perf ormance according to
Department of Transportation
(DOT) standards. The f ollowing
explains these gradings.
Quality grades can be f ound where
applicable on the tire sidewall
between the tread shoulder and the
maximum section width. For
example:
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades. Treadwear
Traction AA, A, B, C
T readwear 200
Traction AA
Temperature A
Unif orm T ire Quality Grading
DOT T ire Quality Grading (U.S. Vehicles)
T echnical Inf ormation344

µWarning: The temperature grade f or
this tire is established f or a tire that
is properly inf lated and not over-
loaded. Excessive speed, underinf la-
tion, or excessive loading, either
separately or in combination, can
cause heat buildup and possible tire
f ailure.
The temperature grades are A (the
highest), B, and C, representing the
tire’s resistance to the generation of
heat and its ability to dissipate heat
when tested under controlled
conditions on a specif ied indoor
laboratory test wheel. Sustained high
temperature can cause the material
of the tire to degenerate and reduce
tire life, and excessive temperature
can lead to sudden tire f ailure. The
grade C corresponds to a level of
perf ormance which all passenger car
tires must meet under the Federal
Motor Vehicle Saf ety Standard No.
109. Grades B and A represent
higher levels of perf ormance on the
laboratory test wheel than the
minimum required by law. Temperature A,B,C
DOT T ire Quality Grading (U.S. Vehicles)
T echnical Inf ormation345

If you are planning to take your
Honda outside the U.S. or Canada,
contact the tourist bureaus in the
areas you will be traveling in to f ind
out about the availability of unleaded
gasoline with the proper octane
rating.
If unleaded gasoline is not available,
be aware that using leaded gasoline
in your Honda will af f ect perf or-
mance and fuel mileage, and damage
its emissions controls. It will no
longer comply with U.S. and
Canadian emissions regulations, and
will be illegal to operate in North
America. To bring your vehicle back
into compliance will require the re-
placement of several components,
such as the oxygen sensors and the
three way catalytic converter. These
replacements are not covered under
warranty.
Driving in Foreign Countries
T echnical Inf ormation347

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
In Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
Your vehicle has a Positive
Crankcase Ventilation System. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The Positive Crank-
case Ventilation valve routes them from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
238
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
T echnical Inf ormation348

The exhaust emissions controls
include three systems: PGM-FI,
Ignition Timing Control and Three
Way Catalytic Converter. These
three systems work together to
control the engine’s combustion and
minimize the amount of HC, CO, and
NOx that comes out the tailpipe. The
exhaust emissions control systems
are separate from the crankcase and
evaporative emissions control
systems.The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more inf orma-
tion. The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
genuine Honda replacement parts or
their equivalent f or repairs. Using
lower quality parts may increase the
emissions f rom your vehicle.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), dinitrogen
(N ), and water vapor. The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
or the Powertrain Control Module
(PCM) uses various sensors to
determine how much air is going
into the engine. It then controls how
much f uel to inject under all operat-
ing conditions.
2
2
Replacement Parts
Exhaust Emissions ControlsPGM-FI Syst em
Ignit ion T iming Cont rol Syst emThree Way Catalytic Converter
Emissions Cont rols
T echnical Inf ormation349

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Honda dealer.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 5th (M/T). Do not use
thecruisecontrol.Whentraffic
allows, drive f or 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
St at e Emissions T est ing
T echnical Inf ormation352

µµ
µ µ
µ µ
µµ
µ a seat
belt that f ails to f unction properly is
covered f or the usef ul lif e of the
vehicle.
provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle.
covers your new vehicle, except f or
the battery, emissions control
systems and accessories, against
def ects in materials and
workmanship. Your new Honda is covered by these
warranties:
provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
this warranty gives up
to 100 percent credit toward a
replacement battery. these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation.
covers all genuine
Honda replacement parts against
defects in materials and workman-
ship. Genuine Honda Accessories are
covered under this warranty. Time
and mileage limits depend on the
type of accessory and other f actors.
Please read your warranty manual
f or details. all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit.
Restrictions and exclusions apply to
all these warranties. Please read the
2002 Honda Warranty Inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty inf or-
mation is in a separate booklet.
Please ref er to the 2002 Warranty
Manual that came with your vehicle.Seat Belt Limited Warranty
Replacement Muf f ler L if et imeLimited Warranty
New Vehicle L imit ed Warrant y Replacement Bat t ery L imit ed
Warranty
Original Equipment Bat t ery L imit ed Warranty
Emissions Cont rol Syst ems Def ect s
Warrant y and EmissionsPerf ormance Warranty
Replacement Part s L imit edWarranty
Accessory Limited Warranty
Rust Perf orat ion L imit ed Warrant yU.S. Owners
Canadian Owners
Warranty Coverages
Warrant y and Cust omer Relat ions355

CONT INUED
...
Accessories and Modif ications . 191
................................
Accessories .191
.
Additional Safety Precautions . 192
............................
Modif ications .192
ACCESSORY (Ignition Key .......................................
Position) .87
............
Accessory Power Sockets . 122
....................
Additives, Engine Oil . 248
.............................
Airbag (SRS) .10, 54
.....................
Air Cleaner Element .265
..............
Air Conditioning System . 128
..............................
Maintenance .274
.........................................
Usage .128
.......................
Air Outlets (Vents) .130
.......................
Air Pressure, Tires .278
..................
High Speed Driving . 279
.........................
Normal Driving .279
.......................
Alcohol in Gasoline .346
......................................
Antif reeze .251
Anti-lock Brakes (ABS) ...............................
Indicator .68, 214
...................................
Operation .212
..............
Anti-thef t, Audio System . 178Anti-thef t Steering Column
..............................................
Lock .87
..........................
Appearance Care .297
................................
Audio System .137
...
Automatic Seat Belt Tensioners . 52
.............
Automatic Speed Control . 179
..............
Automatic Transmission . 204
..........................
Capacity,Fluid .342
...............
Checking Fluid Level . 260
.......................................
Shif ting .205
.
Shif t Lever Position Indicator . 204
................
Shif t Lever Positions . 205
....................
Shif t Lock Release . 209
Battery Charging System ...........................
Indicator .66, 326
............................
Jump Starting .320
..............................
Maintenance .269
............................
Specif ications .343
..............................
Bef ore Driving .183
....................................
Belts,Seat .8,50
.........................
Beverage Holders .116
.................................
Body Repairs .305 Brakes
...........
Anti-lock System (ABS) . 212
.............
Break-in, New Linings . 184
....................
Bulb Replacement .290
...........................................
Fluid .263
.........................................
Parking .82
.................
System Indicator . 66,329
........................
Wear Indicators .211
.............................
Braking System .211
.................
Break-in, New Vehicle . 184
..
Brightness Control, Instruments . 77
........................
Brights, Headlights .76
.................................
Built-in Table .117
Bulb Replacement ..........................
Back-up Lights .290
..............................
Brake Lights .290
......................
Cargo Area Light .293
..............................
Ceiling Light .293
................
Front Parking Lights . 289
........
Front Side Marker Lights . 288
.................................
Headlights .287
.........
High-mount Brake Light . 292
...........................
Interior Lights .293
...................
License Plate Light . 291
Index
A
B
I

ÎBulb Replacement.........
Rear Side Marker Lights . 290
............................
Specif ications .343
...................................
Spotlights .293
....................
Turn Signal Lights . 288
..............................
Bulbs, Halogen .287
................
DANGER, Explanation of . ii
.......................................
Dashboard .64
................
Daytime Running Lights . 77
............
Def ects, Reporting Saf ety . 356
........................
Def og and Def rost .134
................
Def ogger, Rear Window . 81
..............
Def rosting the Windows . 134
.......................
Detachable Anchor .108
....................................
Dimensions .342
...............
Dimming the Headlights . 76
............................
Capacities Chart .342
.............
Carbon Monoxide Hazard . 60
..........................
Cargo Area Light .125
.................................
Cargo Hooks .195
.............................
Carrying Cargo .193
Cassette Player ............................................
Care .168
...........................
Operation .151, 164
..............
CAUTION, Explanation of . ii
..........................
CD Changer .149, 169
.......................................
CD Player .146
...............................
Center Pocket .119
..................................
Center Table .115
........................
Certif ication Label .340
............................................
Chains .284
....................
Changing a Flat Tire .308
............
Changing Engine Coolant . 253.................................
Changing Oil .249
........................................
How to .249
......................................
When to .238
...
Charging System Indicator . 66,326
............
Checklist, Bef ore Driving . 199
.....................................
Child Saf ety .24
.......................................
Child Seats .29
......
LATCH Anchorage System . 48
...........................
Lower Anchors .48
............
Tether Anchorage Point . 46
..................
Childproof Door Locks . 93
....................
Cleaner Element, Air . 265
Cleaning ....................
Aluminum Wheels .299
...................................
Carpeting .301
......................................
Exterior .298
.........................................
Fabric .302
.......................................
Interior .301
.......................................
Leather .302
...................................
Seat Belts .302
...........................................
Vinyl .302
....................................
Windows .303
.................
Clock, Setting the . 144,162
...................................
Clutch Fluid .264
........................
CO in the Exhaust .348
............
Cold Weather, Starting in . 201...............
Consumer Inf ormation . 354
.............
Controls, Instruments and . 63
Coolant ........................................
Adding .251
....................................
Checking .189
.........................
Proper Solution .251
...................................
Replacing .253
...................
Temperature Gauge . 74
....................
Corrosion Protection .304
Crankcase Emissions Control ........................................
System .348
............
Cruise Control Operation . 179
..........
Customer Relations Of f ice . 354
Index
C
D
II