engine HONDA CR-Z 2012 1.G Owners Manual

314
Information
Identification Numbers
Vehicle Identification Number (VIN)
Your vehicle has a 17-digit vehicle identification number (VIN) used to register your
vehicle for warranty purposes, and for licensing and insuring your vehicle. See the
image below for the VIN locations.
Engine Number and Transmission Number
See the image below for the locations of your vehicle's engine number and transmission number.
Vehicle Identification Number
Engine Number
Certification Label/
Vehicle Identification Number
Manual Transmission
Number
Automatic Transmission
(CVT) Number IMA Motor Number
Vehicle Identification Number

317
Continued
Information
Emissions Testing
Testing of Readiness Codes
Your vehicle uses “readiness codes,” as part of its onboard self diagnostic system.
Some states refer to these codes during testing to see if your vehicle's emissions
components are working properly.
The codes may not be read if you go through the testing just after the battery has
gone dead or been disconnected.
To check if they are set, turn the ignition switch to ON
(w
, without starting the
engine. The malfunction indicator lamp will come on for several seconds. If it then
goes off, the readiness codes are set. If it blinks five times, the readiness codes are not set.
If you are required to have your vehicle tested before the readiness codes are ready,
prepare the vehicle for retesting by doing the following:
1. Fill the gas tank to approximately 3/4 full.
2. Park the vehicle and leave the engine off for 6 hours or more.
3. Make sure the ambient temperature is between 40 °F and 95 °F (4 °C and 35 °C).
4. Start the engine without touching the accelerator pedal, and let it idle for 20 seconds.
5. Keep the vehicle in
(P (automatic transmission) or (N (manual transmission).
Increase the engine speed to 2,000 rpm, and hold it there for about 3 minutes.
6. Let the engine idle with your foot off the accelerator for 20 seconds.
1Testing of Readiness Codes
The readiness codes are erased when the 12 volt
battery is disconnected, and set again only after
several days of driving under a variety of conditions.
If a testing facility dete rmines that the readiness
codes are not set, you may be requested to return at
a later date to complete the test.
If the testing faci lity determines the readiness codes
are still not set, see a dealer.

318
uuEmissions TestinguTesting of Readiness Codes
Information
7.Select a nearby, lightly traveled major highway where you can maintain a speed
of 50 to 60 mph (80 to 97 km/h) for at least 20 minutes. Drive on the highway in
(D (automatic) or 5th (manual). Do not use cruise control. When traffic allows,
drive for 90 seconds without moving the accelerator pedal. (Vehicle speed may
vary slightly; this is okay.) If you cannot do this for a continuous 90 seconds
because of traffic conditions, drive for at least 30 seconds, then repeat it two
more times (for a total of 90 seconds).
8. Drive in city/suburban traffic for at least 10 minutes. When traffic conditions
allow, let the vehicle coast for several seconds without using the accelerator pedal
or the brake pedal.
9. Park the vehicle and leave the engine off for 30 minutes.

321
Information
Authorized Manuals
■Service Express
For electronic copies of service publication s, you can purchase a subscription to
Service Express. Visit techinfo.honda.com for pricing and options.
■ U.S. Owners
The publications listed below can be pu rchased from Helm Incorporated. You can
order a manual by phone at (800) 782-4356 (credi t card orders only), or online at
www.helminc.com .
Make an inquiry to Helm Inc. at (800) 782-4356 if you are interested in ordering
other models' or other years' manuals.
Publication
Form NumberForm Description
61SZT012012 Honda CR-Z Service Manual
61SZT302012 Honda CR-Z Body Repair Manual
31SZT6102012 Honda CR-Z Owner’s Manual
31SZT8102012 Honda CR-Z Navigation System Owner’s Manual
31SZTM102012 Honda CR-Z Service History
31SZTQ102012 Honda CR-Z Technology Reference Guide
HON-ROrder Form for Previous Years-
Indicate Year and Model Desired
1Authorized Manuals Service Manual: Covers maintenance and recommended procedures
for repair to engine and chassis components. It is
written for the journeyman technician, but it is simple
enough for most mechanically inclined owners to understand.
Body Repair Manual:
Describes the procedures involved in the replacement
of damaged body parts.

Index
323
Index
Index
Numbers
7-Speed Manual Shift Mode................... 205
A
ABS (Anti-lock Brake System) .................. 222
Accessories and Modifications ................ 236
Accessory Power Socket ........................... 127
Active Head Restraints ............................. 123
Additives
Coolant .................................................. 252
Engine Oil ............................................... 249
Washer ................................................... 257
Additives, Engine Oil ............................... 247
Adjusting
Head Restraints ....................................... 121
Headlights .............................................. 258
Mirrors.................................................... 118
Seats....................................................... 119
Steering Wheel ....................................... 117
Air Conditioning System
(Climate Control System) ....................... 132
Changing the Mode................................ 132 Defrosting the Windscreen and
Windows .............................................. 133
Dust and Pollen Filter .............................. 280
Recirculation/Fresh Air Mode................... 132
Sensors ................................................... 134
Using Automatic Climate Control............ 132
Air Pressure ...................................... 269, 313
Airbags ....................................................... 41 Advanced Airbags ..................................... 47
After a Collision ......................................... 45
Airbag Care ............................................... 55
Event Data Recorders ................................. 26
Front Airbags (SRS) .................................... 44
Indicator ........................................ 52, 70, 74
Passenger Airbag Off Indicator .................. 53
Sensors ...................................................... 47
Side Airbag Cutoff System ......................... 50
Side Airbag Off Indicator ........................... 50
Side Airbags .............................................. 48
Side Curtain Airbags .................................. 51
AM/FM Audio ................................... 143, 154
Anti-lock Brake System (ABS) .................. 222
Indicator .................................................... 70
ASST Indicator ............................................. 82
Audio Remote Controls .............................. 19
Audio System ............................................ 136
Adjusting the Sound ................................ 142
Auxiliary Input Jack .................................. 138
Error Messages ........................................ 167
General Information ................................ 169
MP3/WMA/AAC ...................................... 149
PC Card ................................................... 172
Radio Data System (RDS) ......................... 144
Reactivating ............................................. 139
Recommended CDs ................................. 169
Recommended Drives .............................. 171
Security Code .......................................... 139
Theft Protection ....................................... 139
USB Adapter Cable .................................. 137 USB Flash Drives ...................................... 171
with Navigation System ........................... 151
without Navigation System ...................... 141
Authorized Manuals ................................ 321
Auto Door Locking/Unlocking ................. 103
Customize ................................................. 90
Auto Idle Stop .......................................... 225
Auto Idle Stop Indicator ............................ 76
Automatic Lighting .................................. 111
Automatic Transmission (CVT) ................. 202
Creeping ................................................. 202
Fluid ........................................................ 254
Kickdown ................................................ 202
Operating the Shift Lever......................... 204
Shift Lever Does Not Move ...................... 296
Shifting ................................................... 203
Auxiliary Input Jack .................................. 138
Average Fuel Economy .............................. 88
Average Fuel Economy Records ................ 88
Average Speed ........................................... 85
B
Back-Up Light ........................................... 263
Battery ...................................................... 278
Charging System Indicator................. 69, 300
Jump Starting .......................................... 294 Maintenance }
(Checking the 12 Volt Battery) ............... 278
Maintenance (Replacing) ......................... 279
Battery Charge in Progress (CHRG) ........... 82

324
Index
Belts (Seat).................................................. 34
Beverage Holders ...................................... 126
Bluetooth ® HandsFreeLink ®............... 88, 173
Booster Seats (For Children) ....................... 63
Brake System ............................................. 220
Anti-lock Brake System (ABS) ................... 222
Brake Assist System ................................. 223
Brake System Indicator............................. 302
Fluid ........................................................ 256
Foot Brake ............................................... 221
Indicator .................................................. 302
Parking Brake .......................................... 220
Brightness Control (In strument Panel).... 115
Bulb Replacement ..................................... 258
Back-Up Lights......................................... 263
Brake/Taillight .......................................... 264
Bulb Specifications ................................... 312
Fog Lights ................................................ 260 Front Turn Signal/Parking/Side Marker Light ...................................................... 262
Headlights ............................................... 258
High-Mount Brake Light .......................... 265
Rear License Plate Light............................ 265
Side Turn Signal/Emergency Indicator Light .....
262 C
Carbon Monoxide Gas
............................... 64
Carrying Cargo ................................. 193, 195
CD Player ........................... 145, 156, 158, 162
Certification Label .................................... 314
Changing Bulbs ........................................ 258
Charging System Indicator ................. 69, 300
Child Safety ................................................. 56
Child Seat .................................................... 56
Booster Seats ............................................ 63
Child Seat for Infants................................. 58
Child Seat for Small Children ..................... 59
Installing a Child Seat ................................ 60
Larger Children ......................................... 62
Selecting a Child Seat ................................ 59
Using a Tether ........................................... 61
CHRG Indicator ........................................... 82
Cleaning the Exterior ............................... 283
Cleaning the Interior ................................ 281
Climate Control System ............................ 132
Changing the Mode ................................ 132
Defrosting the Windscreen and
Windows ............................................... 133
Dust and Pollen Filter............................... 280
Recirculation/Fresh Air Mode ................... 132
Sensors ................................................... 134
Using Automatic Climate Control ............ 132
Compact Spare Tire .......................... 287, 313
Controls ....................................................... 97
Coolant (Engine) ...................................... 252
Adding to the Radiator ............................ 253 Adding to the Reserve Tank .................... 252
High Temperature Indicator ...................... 73
Low Temperature Indicator ....................... 74
Overheating ............................................ 297
Creep Aid System ..................................... 200
Creeping ................................................... 202
Cruise Control .......................................... 212
Indicator ................................................... 76
Cup Holders .............................................. 126
Customer Service Information ................ 322
Customized Features ................................. 90
D
Daytime Running Lights .......................... 112
Dead Battery ............................................ 294
Defrosting the Windshield and Windows ................................................. 133
Devices that Emit Radio Waves ............... 315
Dimming Headlights .............................................. 110
Rearview Mirror ...................................... 118
Dipstick (Engine Oil) ................................ 248
Directional Signals (Turn Signal) ............. 110
Door Mirrors ............................................. 118
Doors .......................................................... 99
Auto Door Locking.................................. 103
Auto Door Unlocking .............................. 103
Door Open Indicator ................................. 72
Door/Hatch Open Indicator ....................... 33
Keys.......................................................... 99

325
Index
Locking/Unlocking the Doors from the Inside...................................... 102
Locking/Unlocking the Doors from the Outside................................... 100
Lockout Prevention System ..................... 101
DOT Tire Quality Grading ........................ 272
Driving ...................................................... 191
Automatic Transmission (CVT)................. 202
Braking ................................................... 220
Cruise Control ........................................ 212
Shifting Gear .......................................... 203
Starting the Engine ................................. 198
Dust and Pollen Filter .............................. 280
E
Eco Assist System .......................................... 8
Eco Drive Bar .......................................... 9, 87
Eco Guide ............................................... 9, 86
Eco Score ................................................ 9, 86
ECON Mode Indicator ................................ 77
Elapsed Time .............................................. 85
Electric Motor Assist Indicator (ASST) ....... 82
Electric Power Steering System (EPS)
Indicator ........................................... 72, 302
Electronic Stability Control (ESC) ............ 215
Emergency ................................................ 308
Emissions Testing (Readiness Codes) ...... 317
Engine ....................................................... 314
Coolant .................................................. 252
Jump Starting ......................................... 294 Oil ........................................................... 247
Starting ................................................... 198
Switch Buzzer .......................................... 109
Engine Coolant ......................................... 252
Adding to the Radiator ............................ 253
Adding to the Reserve Tank ..................... 252
High Temperature Indicator ....................... 73
Low Temperature Indicator ........................ 74
Overheating ............................................ 297
Engine Oil ................................................. 247
Adding .................................................... 249
Checking ................................................. 248
Displaying Oil Life .................................... 241
Low Oil Pressure Indicator .................. 68, 299
Recommended Engine Oil ........................ 247
Engine Oil Life ............................................ 88
EPS
(Electric Power Steering System) ..... 72, 302
Exhaust Gas Hazard (Carbon Monoxide) .. 64
Exterior Care (Cleaning) ........................... 283
Exterior Mirrors ........................................ 118
F Features ..................................................... 135
Filters ......................................................... 280
Dust and Pollen ....................................... 280
Oil ........................................................... 250
Flat Tire ..................................................... 287
Floor Mats ................................................. 282 Fluid
Clutch ..................................................... 256
Manual Transmission ....................... 254, 255
Fluids
Brake ...................................................... 256
Engine Coolant ....................................... 252
Windshield Washer ................................. 257
Foot Brake ................................................ 221
Front Airbags (SRS) ..................................... 44
Front Wiper/Washer ................................. 113
Fuel ...................................................... 21, 232
Economy ................................................. 235
Gauge ....................................................... 81
Instant Fuel Economy Gauge ..................... 81
Low Fuel Indicator ..................................... 70
Range ....................................................... 85
Recommendation .................................... 232
Refueling................................................. 232
Fuel Economy ........................................... 235
Fuel Fill Cap ........................................ 21, 234
Message.................................................. 301
Fuel Fill Door ...................................... 21, 233
Fuses .......................................................... 304
Inspecting and Changing......................... 307
Locations......................................... 304, 305

326
Index
G Gasoline (Fuel)Economy ................................................. 235
Gauge ....................................................... 81
Information ............................................. 232
Instant Fuel Economy ................................. 81
Low Fuel Indicator ..................................... 70
Refueling ................................................. 232
Gauges ......................................................... 81
Gear Shift Lever Positions Automatic Transmissi on (CVT) ................. 203
Glass (care) ................................................ 283
Glove Box .................................................. 125
H
Halogen Bulbs ........................................... 258
Handling the Unexpected ........................ 285
HandsFreeLink ® (HFL) ............................... 173
HFL Buttons ............................................. 173
HFL Menus .............................................. 175
HFL Status Display.................................... 174
Phone Setup ............................................ 177
Hatch ......................................................... 104
Door/Hatch Open Indicator ........................ 33
Unable to Open ....................................... 310
Hazard Warning Button ............................... 2
Head Restraints ......................................... 121
Headlights ................................................. 111
Aiming .................................................... 258
Automatic Operation ............................... 111 Dimming ......................................... 110, 112
Operating........................................ 110, 112
Heaters (Seat) ........................................... 131
HFL (HandsFreeLink ®)............................... 173
High Temperature Indicator ...................... 73
High-Beam Indicator .................................. 74
Hill Start Assist System ............................. 200
Honda IMA System ..................................... 10
I Identification Numbers ............................ 314
Engine and Transmission ......................... 314
Vehicle Identification ............................... 314
Ignition Switch ......................................... 109
Illumination Control ................................. 115
Knob ....................................................... 115
IMA Battery Charge Level Indicator .......... 82
IMA System Indicator ................................. 73
Immobilizer System .................................. 105
Indicator.................................................... 76
Indicators .................................................... 68
ABS (Anti-lock Brake System)..................... 70
Auto Idle Stop ........................................... 76
Charging System ............................... 69, 300
CRUISE CONTROL ............................. 76, 213
CRUISE MAIN .................................... 76, 212
Door Open ................................................ 33
ECON Mode .............................................. 77
EPS (Electric Power Steering System) .. 72, 302
Fog Light ................................................... 75 High Temperature ..................................... 73
High-Beam................................................ 74
IMA System .............................................. 73
Immobilizer System ................................... 76
Lights On .................................................. 75
Low Fuel ................................................... 70
Low Oil Pressure ............................... 68, 299
Low Temperature...................................... 74
Low Tire Pressure/TPMS .................... 72, 217
Malfunction Indicator Lamp .............. 69, 301
Parking Brake and Brake System ....... 68, 302
Seat Belt Reminder.............................. 35, 70
Security System Alarm............................... 76
Shift Up .................................................... 77
Side Airbag Off ................................... 54, 74
Supplemental Restraint System ........... 52, 71
System Message ....................................... 73
Transmission ............................................. 69
Turn Signal ............................................... 75
VSA
® (Vehicle Stability Assist)
System ............................................ 71, 215
VSA ® OFF .......................................... 71, 216
Information .............................................. 311
Instant Fuel Economy Gauge .................... 81
Instrument Panel ........................................ 67
Brightness Control .................................. 115
Interior Lights ........................................... 124
Interior Rearview Mirror ......................... 118

328
Index
O Odometer.................................................... 84
Oil (Engine) ............................................... 247
Adding .................................................... 249
Checking ................................................. 248
Displaying Oil Life .................................... 241
Low Oil Pressure Indicator .................. 68, 299
Recommended Engine Oil ........................ 247
Viscosity .................................................. 247
Opening/Closing Hatch ...................................................... 104
Hood ....................................................... 246
Power Windows ...................................... 107
Outside Temperature ................................. 85
Overheating .............................................. 297
P
Panic Mode ............................................... 106
Parking ...................................................... 224
Parking Brake ............................................ 220
Parking Brake and Brake System Indicator ............................................ 68, 302
Passenger Airbag Off Indicator ................. 53
Passing Indicators ..................................... 110
Power Door Mirror ................................... 118
Power Flow Monitor ................................... 89
Power Windows ........................................ 107
Precautions While Driving ........................ 201
Rain ......................................................... 201
Pregnant Women ....................................... 39 Puncture (Tire)
.......................................... 287
R
Radiator .................................................... 253
Radio (AM/FM) ................................. 143, 154
Radio Data System (RDS) ......................... 144
Range .......................................................... 85
Readiness Code (Emissions Testing) ........ 317
Rear Defogger/Heated Door Mirror
Button ..................................................... 116
Rear Luggage Console ............................. 128
Rear Side Marker Light ............................ 263
Rear Turn Signal Light ............................. 263
Rearview Mirror ....................................... 118
Refueling .................................................. 232
Fuel Gauge................................................ 81
Gasoline .......................................... 232, 312
Low Fuel Indicator ..................................... 70
Regulations ............................... 218, 271, 315
Remote Transmitter ................................. 100
Replacement Battery .................................................... 278
Bulbs ....................................................... 258
Fuses ............................................... 304, 305
Tires ........................................................ 275
Wiper Blade Rubber ........................ 266, 268
Reporting Safety Defects ......................... 316
Resetting a Trip Meter ............................... 84 S Safe Driving
................................................ 29
Safety Check ............................................... 33
Safety Labels .............................................. 65
Safety Message .......................................... 27
Seat ........................................................... 119
Adjusting ................................................ 119
Seat Heaters ........................................... 131
Seat Belts .................................................... 34
Automatic Seat Belt Tensioners ................. 36
Checking .................................................. 40
Fastening .................................................. 37
Installing a Child Seat................................ 60
Pregnant Women...................................... 39
Reminder .................................................. 35
Warning Indicator ............................... 35, 70
Seat Heaters ............................................. 131
Security System Immobilizer System Indicator ..................... 76
Security System Alarm Indicator ................ 76
SEL/RESET Button ....................................... 90
Selecting a Child Seat ................................ 59
Selector Knob (Audio) ............................. 141
Setting the Clock ........................................ 98
Shift Lever .......................................... 20, 203
Operation ......................................... 20, 204
Releasing ................................................ 296
Won’t Move ........................................... 296
Shift Lever Position Indicator .................. 204
Shifting ..................................................... 203
Side Airbags ............................................... 48

329
Index
Cutoff System ........................................... 50
Off Indicator ............................................. 50
Side Curtain Airbags .................................. 51
Snow Tires ................................................ 277
Spare Tire ......................................... 287, 313
Spark Plugs ............................................... 312
Specifications ........................................... 312
Specified Fuel ................................... 232, 312
Speedometer .............................................. 81
SRS Airbags (Airbags) ................................ 41
Starting the Engine .................................. 198
Does Not Start ........................................ 293
Engine Switch Buzzer .............................. 109
Jump Starting ......................................... 294
Steering Wheel ........................................ 117
Adjusting ................................................ 117
Stopping ................................................... 224
Supplemental Restraint System (SRS) ....... 44
Switches
(Around the Steering Wheel) ........ 2, 3, 109
System Message Indicator ......................... 73T
Tachometer
................................................. 81
Temperature High Temperature Indicator ....................... 73
Low Temperature Indicator ........................ 74
Temperature Sensor ................................. 134
Time (Setting) ............................................. 98
Tire Pressure Monitoring System
(TPMS) ..................................................... 217
Indicator ............................................ 72, 303
Tires ........................................................... 269
Air Pressure ..................................... 270, 313
Checking and Maintaining ....................... 269
Compact Spare Tire ......................... 287, 313
Inspection ................................................ 269
Labeling .................................................. 270
Puncture (Flat Tire) ................................... 287
Regulations ............................................. 272
Rotation .................................................. 276
Tire Chains .............................................. 277
Wear Indicators ....................................... 274
Winter ..................................................... 277
Tonneau Cover ......................................... 129
Tools .......................................................... 286
Towing a Trailer ....................................... 197
Towing Hook ............................................ 309
Towing Your Vehicle ................................ 197
Emergency .............................................. 308
TPMS (Tire Pressure Monitoring System) ......... 217
Indicator ............................................ 72, 303 Transmission
............................................. 203
Automatic ............................................... 203
Fluid ........................................................ 254
Number................................................... 314
Shift Lever Position Indicator.................... 204
Trip Meter ................................................... 84
Troubleshooting ....................................... 285
Blown Fuse...................................... 304, 305
Brake Pedal Vibrates .................................. 25
Buzzer Sounds When Opening Door.......... 25
Emergency Towing .................................. 308
Engine Does Not Start ............................. 293
Noise When Braking .................................. 25
Overheating ............................................ 297
Puncture/Flat Tire .................................... 287
Regular Gasoline ............................. 232, 312
Shift Lever Won’t Move ........................... 296
Unable to Open the Hatch....................... 310
Warning Indicators .................................... 68
Turn Signals .............................................. 110
Indicators (Instrument Panel) ..................... 75
U
Unlocking the Doors ................................ 100
USB Adapter Cable ................................... 137
USB Flash Drive ................................. 165, 171