service HONDA INSIGHT 2004 1.G Owner's Manual

If your vehicle gets stuck in sand,
mud, or snow, call a towing service
to pull it out (see page ).For very short distances, such as
f reeing the vehicle, you can use the
detachable towing hook that mounts
on the anchor in the f ront bumper.
To use the towing hook:Remove the towing hook and
wheel wrench f rom the tool box. Remove the cover f rom the
bumper with the end of the
extension.
Screw the towing hook into the
hole and tighten it securely by
hand.
1. 2.
3.
181
If Your Vehicle Gets Stuck
Emergency T owing
T aking Care of t he Unexpect ed182

µ
The tires on your vehicle meet all
U.S. Federal Saf ety Requirements.
All tires are also graded f or
treadwear, traction, and temperature
perf ormance according to
Department of Transportation
(DOT) standards. The f ollowing
explains these gradings.
Quality grades can be f ound where
applicable on the tire sidewall
between the tread shoulder and the
maximum section width. For
example:
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades. The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices, and dif f erences in
road characteristics and climate.
The traction grades, f rom highest to
lowest, are AA, A, B, and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
DOT T ire Quality Grading (U.S. Vehicles)
T echnical Inf ormation
Unif orm T ire Quality Grading
T readwear 200
Traction AA
Temperature A Treadwear
Traction AA, A, B, C
194

Customer Service................................
Inf ormation .202
....................
Warranty Coverages .203
Reporting Saf ety Def ects ..........................
(U.S. Vehicles) .204
.....................
Authorized Manuals .205
Warranty and Customer Relations
Warrant y and Cust omer Relat ions201

Honda dealership personnel are
trained prof essionals. They should
be able to answer all your questions.
If you encounter a problem that your
dealership does not solve to your
satisf action, please discuss it with
the dealership’s management. The
Service Manager or General
Manager can help. Almost all
problems are solved in this way.
If you are dissatisf ied with the
decision made by the dealership’s
management, contact your Honda
Customer Service Office.U.S. Owners:
Canadian Owners:
In Puerto Rico and the U.S. Virgin
Islands:
Vortex Motor Corp.
Bella International
P.O. Box 190816
San Juan, Puerto Rico 00919-0816
(787) 620-7020
Vehicle Identif ication Number
(see page )
Name and address of the dealer
who services your vehicle
Date of purchase
Mileage on your vehicle
Your name, address, and tele-
phone number
A detailed description of the
problem
Name of the dealer who sold the
vehicle to you
When you call or write, please give
us this inf ormation:
190
Cust omer Service Inf ormat ion
Warrant y and Cust omer Relat ions202
American Honda Motor Co., Inc.
Automobile Customer Service
Mail Stop 500-2N-7A
1919 Torrance Boulevard
Torrance, California 90501-2746
Tel: (800) 999-1009
Honda Canada Inc.
715 Milner Avenue
Toronto, ON
M1B 2K8
Tel: 1-888-9-HONDA-9
Fax: Toll-free 1-877-939-0909 Toron to (416) 287-4776
CUSTOMER RELATIONS
RELATIONS AVEC LA CLIENTÈLE

ÎÎ
Î
µ
Î




$
#
Valid only f or sales within the U.S. Canadian owners shouldcontact their authorized Honda dealer.
T he publications shown below can be purchased f rom Helm
Incorporated. You can order in any of three ways:
Detach and mail the order f orm on the right half of this page
Call Helm Inc. at 1-800-782-4356
Go online at
If you are interested in other years or models, contact Helm Inc.
at 1-800-782-4356
(credit card orders only)
Authorized Manuals
Purchasing Factory Authorized Manuals
(U.S. only)
205
Publication
Form Number 61S3Y05
61S3Y05EL 61S3Y30
31S3Y650
31S3YQ10 HON-R Form Description
2000-04 Honda Insight Service Manual
2000-04 Honda Insight
Electrical Troubleshooting Manual 2000-04 Honda InsightBody Repair Manual2004 Honda Insight Owner’s Manual
2004 Honda Insight Quick Start Guide
Order Form for Previous Years-
Indicate Year and Model Desired Price
Each
$70.00
$50.00
$44.00
$34.00
$12.00
FREE (NOTE: For Credit Card Holder Orders Only)
MINIMUM CREDIT CARD PURCHASE $10.00
ORDER TOLL FREE: 1-800-782-4356
OR
PUBLICATION NUMBER VEHICLE MODEL
Name Year Qty
Price
Each Total
Price
GRAND TOTAL HANDLING CHARGE Mich. Purchases
Add 6% Sales Tax TOTAL MATERIAL
$6.95Prices are subject to change without notice and without incurring
obligation. Monday-Friday 8:00 A.M. 6:00 P.M. EST
By completing this form you can order the materials desired. You can
pay by check or money order, or charge to your credit card. Mail to
Helm Incorporated at the address shown on the back of the order form.
Prices are subject to change without
notice and without incurring obligation.
Orders are mailed within 10 days. Please
allow adequate time for delivery.
www. helminc. com

µµ
µ
(


%
)
$
%

.
"

#
) This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
This manual describes the procedures involved in the
replacement of damaged body parts.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
206
NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA
Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

Î
.................................
Chains, Tires .159
....................
Charge/Assist Gauge .51
Changing Oil ........................................
How to .134
......................................
When to .127
....................
Changing a Flat Tire .165
...
Charging System Indicator . 42,178
............
Checklist, Bef ore Driving . 106
.....................................
Child Saf ety .23
..................................
Booster Seats .33
.......................................
Child Seats .28
.........
Important Saf ety Reminders . 26
..............................................
Inf ants .24
................................
Large Children .32
..........................
Risks with Airbags .24
.................................
Small Children .27
.............................................
Tethers .31
.............
Where Should a Child Sit? . 23
Child Seats ..........
Tether Anchorage Points . 31
.................................................
Clock .89
...................................
Clutch Fluid .143
........................
CO in the Exhaust .197
............
Cold Weather, Starting in . 107
......................
Compact Spare Tire .164
...............
Consumer Inf ormation . 202.............
Controls, Instruments and . 39
Coolant ........................................
Adding .137
......................................
Checking .96
.........................
Proper Solution .137
...................
Temperature Gauge . 47
Crankcase Emissions Control ........................................
System .197
.....................................
Cup Holders .69
.....................
Current Fuel Mileage .48
.............
Customer Service Of f ice . 202
................................
Economy, Fuel .97
..................................
Emergencies .163
.............
Battery, Jump Starting . 173
...........
Brake System Indicator . 180
................
Changing a Flat Tire . 165
.....
Charging System Indicator . 178
..................
Checking the Fuses . 184
.............
Hazard Warning Button . 55
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 40
................
Daytime Running Lights . 54
Daytime Running Lights .......................................
Indicator .44
.................................
Dead Battery .173
............
Def ects, Reporting Saf ety . 204
..........................
Def og and Def rost .75
................
Def ogger, Rear Window . 56
................
Def rosting the Windows . 75
....................................
Dimensions .192
...............
Dimming the Headlights . 54Dipstick
....................................
Engine Oil .95
..........................
Directional Signals .54
........
Disc Brake Wear Indicators . 119
.....................
Disposal of Used Oil .136
..................
Display Change Button . 47
Doors ..............
Locking and Unlocking . 60
..........
DOT Tire Quality Grading . 194
Downshif ting, 5-speed Manual
.............................
Transmission .108
...........
Driver and Passenger Safety . 5
...........................................
Driving .105
......................................
Economy .97
..................
Dust and Pollen Filter . 150
Index
D
E
II

Î
Î...................
Radiator Overheating . 175
...........................
Readiness Codes .200
...............
Radio/CD Sound System . 78
..
Rear Lights, Bulb Replacement . 147
............................
Rear View Mirror .66
.................
Rear Window Def ogger . 56
....................
Rear Window Washer .53
.......................
Rear Window Wiper .53
...............
Reclining the Seat Backs . 64
Replacement Inf ormation ................
Engine Oil and Filter . 134
..........................................
Fuses .184
................................
Light Bulbs .144
....................................
Schedule .127
...........................................
Tires .157
.............................
Wiper Blades .151
Replacing Seat Belts Af ter a ............................................
Crash .18
Reserve Tank, Engine .................................
Coolant .96, 137
...............................
Restraint, Child .23
................................
Roof Antenna .150
................................
Rotation, Tire .157 ..................................
Saf ety Belts .8, 17
.........
Safety Defects, Reporting . 204
.................................
Saf ety Features .7
...........................................
Airbags .9
.......................................
Seat Belts .8
.............
Saf ety Labels, Location of . 37
...............................
Saf ety Messages .ii
.....................................
Seat Belts .8, 17
...............
Additional Information . 17
.....................................
Cleaning .149
......................
Lap/Shoulder Belt .17
................................
Maintenance .18
Reminder Indicator and ................................
Beeper .17, 42
...................
System Components . 17
...............
Use During Pregnancy . 15
...
Wearing a Lap/Shoulder Belt . 13
........................
Seats, Adjusting the .64
...............................
Serial Number .190
...........................
Service Intervals .127
...........................
Service Manual .205
...........
Service Station Procedures . 93
............................
Setting the Clock .89
...
Shif t Lever Position Indicators . 111........................
Shif t Lock Release .115
...............................
Signaling Turns .54
.....................................
Snow Tires .159
..................................
Sound System .78
Spare Tire ......................................
Inf lating .164
............................
Specif ications .193
....................
Specif ications Charts . 192
..........
SRS, Additional Inf ormation . 19
...
Additional Safety Precautions . 22
How the SRS Indicator .......................................
Works .21
...........
How Your Airbags Work . 19
........................
SRS Components .19
..................................
SRS Service .22
.............................
SRS Indicator .21 ,42
....
START (Ignition Key Position) . 59
.......................
Starting the Engine .107
In Cold Weather at High ..................................
Altitude .107
................
With a Dead Battery . 173
..............
State Emissions Testing . 200
........
Steam Coming f rom Engine . 175
Steering Wheel .............
Anti-theft Column Lock . 59
.....................
Stereo Sound System .78
Index
RS
VI

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:Automatic Transmission Fluid
(CVT):
5-speed Manual Transmission
Fluid:Brake Fluid:
Tire Pressure (measured cold):
10.6
US gal (40
)
2.6 US qt ( 2.5
)
1.6US qt ( 1.5
)
5.8
US qt ( 5.5
)
Unleaded gasoline, pump octane
number of
86or higher.
API Premium grade 0W-20
detergent oil (see page ).
Oil change capacity (including
filter): Use Honda ATF-Z1
(Automatic
Transmission Fluid) only.
Capacity:
Honda Manual Transmission
Fluid preferred, or an SAE 10W-30
or 10W-40 motor oil as a
temporary replacement (see page ).
Capacity (including differential): Honda Heavy Duty Brake Fluid
DOT
3preferred, or a DOT 3or
DOT 4brake fluid as a temporary
replacement (see page ).
Front:
Rear:
Spare Tire: 38 psi (260 kPa)
35 psi (240 kPa)
60 psi (420 kPa)
141
133 142