battery HONDA INSIGHT 2010 2.G Owner's Guide

µ
µ
If the charging system
indicator comes on brightly
when the engine is running, the 12
volt battery is not being charged.
Go to a service station or garage
where you can get technical
assistance. Immediately turn of f all electrical
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly. You will also see a ‘‘CHECK
CHARGING SYSTEM’’ message on
the multi-information display (see
page ). The charging system indicator may
also come on if the Integrated Motor
Assist (IMA) battery charge drops
below a desired level and the engine
starts to recharge the battery.
This indicator may blink af ter you
start the vehicle in the morning
when the temperature is below 20
°F ( 30°C). It will stop blinking
when the IMA battery warms up.
63
12 Volt Battery Charging System Indicator
402
—
—y

y
)"yy
2010 Insight

If the indicator comes on repeatedly,
even though it may turn of f as you
continue driving, have your vehicle
checked by your dealer as soon as
possible.
Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.
If the indicator comes on
while driving, it means one
of the engine’s emissions control
systems may have a problem. Even
though you may f eel no dif f erence in
your vehicle’s perf ormance, it can
reduce your f uel economy and cause
increased emissions. Continued
operation may cause serious damage. If your vehicle’s battery has been
disconnected or gone dead, these
codes are erased. It can take several
days of driving under various
conditions to set the codes again.
To check if they are set, turn the
ignition switch to the ON (II)
position, without starting the engine.
The malf unction indicator lamp will
come on f or 20 seconds. If it then
goes of f , the readiness codes are set.
If it blinks f ive times, the readiness
codes are not set. If possible, do not
take your vehicle f or an emissions
test until the readiness codes are set.
Refer to
for
more information (see page ).
If you have recently ref ueled your
vehicle, the indicator coming on
could be due to a loose or missing
f uel f ill cap. You will also see a
‘‘TIGHTEN FUEL CAP’’ message on
the multi-information display.
Tighten the cap until it clicks at least
once (see page ). Tightening the
cap will not turn the indicator of f
immediately; it can take several days
of normal driving.
You will also see a ‘‘CHECK
EMISSION SYSTEM’’ message on
the multi-information display. For
more information, see page .
286
89
428
Malf unction Indicator L amp
Readiness Code
Emissions T esting
T aking Care of t he Unexpect ed
403
If you keep driving with the
Malf unction Indicator Lamp on, you
can damage your vehicle’s emissions
controls and engine. Those repairs may
not be covered by your vehicle’s
warranties. This indicator may also
come on with the ‘‘D’’ indicator.
—
—y

y
)"yy
2010 Insight

The under-hood f use box is located
next to the battery. To open it, push
the tab as shown.
The under-hood f use is on the
positive terminal of the battery. To
open it, push the tabs as shown.
Fuses
406
TAB
UNDER-HOOD
TAB
(On the battery)
Next to the battery
—
—y


y
)"y

y
2010 Insight

If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pagesand , or the diagram on the
fuse box lid, which fuse or fuses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown f uses,
and check if the device works.
Turn the ignition switch to the
LOCK (0) position. Make sure the
headlights and all other
accessories are of f . Remove the cover f rom the under-
hood f use box located on the
battery (see page ).
Check each of the large f uses in
the under-hood f use box on the 12
volt battery by looking through
thetopatthewireinside.
Replacement of these f uses should
be done by your dealer.Check the smaller f uses in the
under-hood f use boxes and all the
fuses in the interior fuse box by
pulling out each one with the f use
puller provided in the interior f use
box.
1.
2.
410 411
4064.
3.
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
407
BLOWN FUSE PULLER
—
—y

y
)"y
y
2010 Insight

Î
Î Î
Î
µ
µ
µ
Î
Î
Î
No. Circuits Protected
No.
Amps.
Circuits Protected
Amps.
No. Amps. Circuits Protected
1
2Ignition Coil (EX)
Ignition Coil (IN)
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
15 A
15 A
Hatch Lock
Not Used
Condenser Fan Motor
Left Headlight High Beam
Door Lock Motor 2 (Unlock)
Door Lock Motor 1 (Unlock)
Right Headlight High Beam
DBW
IMA 2
Not Used
Heated Mirror
Front Wiper
Blower Motor
ABS/VSA Motor
Rear Defogger
Rear Defogger
Not Used
IG Main
7.5 A
30 A
10 A
15 A
15 A
10 A
15 A
10 A
10 A
30 A
30 A
30 A
30 A
40 A
50 A 1
2
3100 A
60 A
20 A Battery, Main, ACG
EPS
Horn, Stop, Hazard
1:
2:
3: U.S. LX model
U.S. models except LX model and all
Canadian models
EX models
2
3 1
2
Fuse Locations
T aking Care of t he Unexpect ed
411
UNDER-HOOD FUSE BOXESOn the battery Next to the battery
—
—y

y
)"y
y
2010 Insight

µµµ
µ
µ
Î
Î µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î Î Î
Î
Î
Specif ications
Technical Inf ormation
419
Air Conditioning
Tires Alignment Fuses 12 Volt Battery
Lights HFC-134a (R-134a)
15.8 17.6 oz (450 500 g) SP-10
12 V 60 W
Refrigerant type
Charge quantity
Lubricant oil type
12 V 55 W
Size
Pressure Toe-in
Camber
Caster Interior
Under-hood
60 psi (420 kPa , 4.2 kgf/cm
)
33 psi (230 kPa , 2.3 kgf/cm)
175/65R15 84S 3°20’
1°
0°
0.1 in (2.5 mm)
0.00 in (0.0 mm)
Capacity
12 V
12 V 35 AH/20 HR
28 AH/5 HR
12 V 21 W
T135/80D15 99M
12 V 5 W
See page
410or the fuse label
attached to the inside of the fuse
box door under the steering
column.
See page 411or the fuse box
cover.
Headlights
Front turn signal lights
Front parking lights
Front side marker lights
Side turn signal lights
(door mirror)
Rear turn signal lights
Stop/taillights
Back-up lights
Rear side marker lights
License plate lights
Spot lights
Ceiling light
Cargo area light
High-mount brake light
Glove box light
12 V 3.4 W12 V 12 V
12 V
12 V
12 V
12 V
5W
8W
8W
5W
2CP
16 W
12 V 21 W
Replacement of a light bulb should be done by your dealer. 5W
12 V
Front
Rear
Front
Rear
Front
High
Low
Front/Rear
Spare
Front/Rear
Spare
1:
2: (HB3)
(H11)
(Amber)
LED type
LED type
LED type
EX models (Amber)
1
1 1 2
2
2
—
—y

y
)"yy
2010 Insight

If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park. Increase
the engine speed to 2,000 rpm, and
hold it there until the temperature
gauge rises to at least 1/4 of the
scale (about 3 minutes).
Without touching the accelerator
pedal, let the engine idle f or 20
seconds.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F (4° and 35°C).
1.
2.
3. 4.
5.
6.
T esting of Readiness Codes
Emissions T esting
428
—
—y
y
)"yy
2010 Insight

µ
µ µ
µ
µ µ
µ µ
µ
Your new vehicle is covered by these
warranties:
covers your new vehicle, except f or
the battery, emissions control
systems, and accessories, against
def ects in materials and
workmanship.
these two
warranties cover your vehicle’s
emissions control systems. Time,
mileage, and coverage are
conditional. Please read your
warranty booklet f or exact
inf ormation. provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle. provides prorated
coverage f or a replacement battery
purchased f rom your dealer.
this warranty gives up
to 100% credit toward a replacement
battery. a seat
belt that f ails to f unction properly is
covered by a limited warranty.
Please read your warranty booklet
f or details.
covers all Honda
replacement parts against defects in
materials and workmanship. Honda accessories are covered
under this warranty. Time and
mileage limits depend on the type of
accessory and other factors. Please
read your warranty booklet f or
details. all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit. Restrictions and exclusions apply to
all these warranties. Please read the
2010 Honda warranty inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your vehicle’s original
tires are covered by their
manuf acturer. Tire warranty
inf ormation is in a separate booklet.
Please ref er to the 2010 warranty
manual that came with your vehicle.
Warranty Coverages
U.S. Owners
Canadian Owners
New Vehicle L imit ed Warrant yEmissions Cont rol Syst ems Def ect sWarrant y and EmissionsPerf ormance Warranty Replacement Muf f ler L if et ime
Limited Warranty
Replacement Bat t ery L imit ed
Warranty
Original Equipment Bat t ery L imit ed Warranty Seat Belt Limited Warranty
Replacement Part s L imit edWarranty
Accessory Limited Warranty
Rust Perf orat ion L imit ed Warrant yWarrant y and Cust omer Relat ions
433
—
—
y
y
)"yy
2010 Insight

CONT INUED
....................................
Accessories .293
ACCESSORY (Ignition Key .....................................
Position) .128
.............
Accessory Power Socket . 153
................
Active Head Restraints . 141
....................
Additives, Engine Oil . 348
.............................
Airbag (SRS) .10, 25
...
Airbags, Additional Information . 25
...
Additional Safety Precautions . 37
..........
AdvancedAirbagSystem . 30
.............................
Airbag Service .36
How the Passenger Airbag Of f ......................
Indicator Works .35
How the Side Airbag Of f ......................
Indicator Works .34
..
How the SRS Indicator Works . 34
How Your Front Airbags .........................................
Work .28
...
How Your Side Airbags Work . 32
How Your Side Curtain Airbags .........................................
Work .33
........................
SRS Components .25
..............
Air Conditioning System . 160
.......................
Air Pressure, Tires .376 ................................
Ambient Meter .72
......................................
Antif reeze .353
Anti-lock Brakes (ABS) ...............................
Indicator .64, 326
...................................
Operation .326
..............
Anti-thef t, Audio System . 253
Anti-thef t Steering Column ............................................
Lock .128
..........................................
Armrest .143
................................
Audio System .166
.......................
Auto Door Locking .107
...................
Auto Door Unlocking . 108
................................
Auto Idle Stop .321
...
Automatic Seat Belt Tensioners . 23
.............
Automatic Speed Control . 257
.
Automatic Transmission (CVT) . 311
..........................
Capacity,Fluid .418
...............
Checking Fluid Level . 356
Paddle Shif ters in the ..............................
D Position .316
Paddle Shif ters in the ...............................
S Position .319
.....
Recommended Shif t Points . 320
.......................................
Shif ting .312
Shif t Lever Position ...............................
Indicators .311 ................
Shif t Lever Positions . 313
....................
Shif t Lock Release . 315
......................
Auxiliary Input Jack .252
Battery Charging System ...........................
Indicator .63, 402
............................
Jump Starting .396
..............................
Maintenance .381
............................
Specif ications .419
..............................
Bef ore Driving .283
....................................
Belts,Seat .9,21
...........................
Beverage Holder .149
.......
Bluetooth
HandsFreeLink. 259
Brakes ...........
Anti-lock System (ABS) . 326
.............
Break-in, New Linings . 284
....................
Bulb Replacement .365
...........................................
Fluid .357
...................
Pad Wear Indicator . 325
.......................................
Parking .148
...........
System Indicator . 63,64,404
Index
A
B
INDEX
I
—
—y

y
)"yy
2010 Insight

CONT INUED
Doors...........
Auto Door Locking . 107,130
.......
Auto Door Unlocking . 108,130
............
Childproof Door Locks . 131
............
Locking and Unlocking . 130
..........
DOT Tire Quality Grading . 421
...........
Driver and Passenger Safety . 5
...........................................
Driving .301
....................................
Economy .290
..................
Dust and Pollen Filter . 370
.......
Eco Guide Feedback Monitor . 73
Ecological Drive Assist System ..........................
(ECON Assist) .304
................................
ECON Button .124
..................................
ECON Mode .124
..............................
Economy, Fuel .290
............
Emergencies on the Road . 385
.............
Battery, Jump Starting . 396
.....
Brake System Indicator . 63,404
................
Changing a Flat Tire . 387
Charging System ...........................
Indicator .63, 402
..................
Checking the Fuses . 407Low Oil Pressure
...........................
Indicator .62, 401
Malf unction Indicator ................................
Lamp .62, 403
..................
Overheated Engine . 398
.........................
Emergency Brake .148
....................
Emergency Flashers .122
...........
Emergency Hatch Opener . 137
......................
Emergency Towing .412
.......................
Emissions Controls .425
........................
Emissions Testing .428
Engine ............
Adding Engine Coolant . 353
Coolant Temperature ...................................
Indicator .67
.........................
If It Won’t Start .394
Malf unction Indicator ................................
Lamp .62, 403
.........................
Oil Lif e Display .337
........
Oil Pressure Indicator . 62,401
..............
Oil, What Kind to Use . 348
...............................
Overheating .398
............................
Specif ications .418
............................
Speed Limiter .314
.......................................
Starting .303
.
Evaporative Emissions Controls . 425...............................
Exhaust Fumes .56
Expectant Mothers, Use of Seat ........................................
Belts by .19
...................................
Fan, Interior .162
.........................................
Features .159
....................
Filling the Fuel Tank . 285
Filters .........................
Dust and Pollen .370
...............................................
Oil .350
...........
Flashers, Hazard Warning . 122
...................
Flat Tire, Changing a . 387
.....................................
Floor Mats .369
Fluids ..........
Automatic Transmission . 356
..........................................
Brake .357
..................
Windshield Washer . 355
FM Stereo Radio ...................................
Reception .246
........................
Four-way Flashers .122
............................
Front Airbags .10, 25
Index
F
E
INDEX
III
—
—y

y
)"yy
2010 Insight