Ima HONDA INSIGHT 2010 2.G Service Manual

µ
µ
If the charging system
indicator comes on brightly
when the engine is running, the 12
volt battery is not being charged.
Go to a service station or garage
where you can get technical
assistance. Immediately turn of f all electrical
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly. You will also see a ‘‘CHECK
CHARGING SYSTEM’’ message on
the multi-information display (see
page ). The charging system indicator may
also come on if the Integrated Motor
Assist (IMA) battery charge drops
below a desired level and the engine
starts to recharge the battery.
This indicator may blink af ter you
start the vehicle in the morning
when the temperature is below 20
°F ( 30°C). It will stop blinking
when the IMA battery warms up.
63
12 Volt Battery Charging System Indicator
402
 —
—y

y
)"  y  y
2010 Insight

µ
µ
µ
µ
µ
Î
Î
Î
Î Î
No.No. Amps.
Circuits Protected
Amps. Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22 23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
10 A
10 A
10 A
30 A
20 A
10 A
30 A
7.5 A 10 A
20 A
10 A
15 A
15 A
30 A
15 A
15 A
10 A
7.5 A
7.5 A
Back Up
TPMS
Driver’s Power Window
Not Used
Back Up Light
SRS
T ransmission SOL
OPDS
Not Used
A/C
ABS/VSA
IMA
ACC Socket
Accessory
Daytime Running Light
Rear Wiper
Front Passenger’s Power
Window
Rear Passenger’s Side
Power Window
Rear Driver’s Side Power
Window
Fuel Pump
Washer
Meter
15 A
(7.5 A) 20 A
10 A
10 A
10 A
7.5 A
7.5 A
7.5 A 10 A
20 A
7.5 A
7.5 A 10 A
20 A
20 A
20 A
15 A
15 A
7.5 A Hazard
Stop/Horn
Not Used
LAF
Door Lock Main
Headlight Main
Small Light
Radiator Fan motor
IGPS
Right Headlight Low Beam
IG Coil
Left Headlight Low Beam
Door Lock Motor 2 (Lock)
Door Lock Motor 1 (Lock)
ABS/VSA FSR
Selectable Door Lock
IGP
Not Used
Not Used
IMA 1
MG Clutch
STS
1:U.S.models
2:EXmodels1
2 2
Fuse Locations
410
INTERIOR FUSE BOX
 —
—y

 y
)"  y 
y
2010 Insight

Î
Î Î
Î
µ
µ
µ
Î
Î
Î
No. Circuits Protected
No.
Amps.
Circuits Protected
Amps.
No. Amps. Circuits Protected
1
2Ignition Coil (EX)
Ignition Coil (IN)
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
15 A
15 A
Hatch Lock
Not Used
Condenser Fan Motor
Left Headlight High Beam
Door Lock Motor 2 (Unlock)
Door Lock Motor 1 (Unlock)
Right Headlight High Beam
DBW
IMA 2
Not Used
Heated Mirror
Front Wiper
Blower Motor
ABS/VSA Motor
Rear Defogger
Rear Defogger
Not Used
IG Main
7.5 A
30 A
10 A
15 A
15 A
10 A
15 A
10 A
10 A
30 A
30 A
30 A
30 A
40 A
50 A 1
2
3100 A
60 A
20 A Battery, Main, ACG
EPS
Horn, Stop, Hazard
1:
2:
3: U.S. LX model
U.S. models except LX model and all
Canadian models
EX models
2
3 1
2
Fuse Locations
T aking Care of t he Unexpect ed
411
UNDER-HOOD FUSE BOXESOn the battery Next to the battery
 —
—y

y
)"  y 
y
2010 Insight

The engine number is stamped into
the engine block.
The transmission number is on a
label on top of the transmission.
The IMA Motor Number is stamped
on the motor housing.
Identif ication Numbers
Technical Inf ormation
417
ENGINE NUMBER
TRANSMISSION NUMBER IMA MOTOR NUMBER
 —
—y
 y
)"  y y
2010 Insight

Quality grades can be f ound where
applicable on the tire sidewall
between tread shoulder and
maximum section width. For
example:
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades.The traction grades, f rom highest to
lowest, are AA, A, B, and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
The tires on your vehicle meet all
U.S. Federal Saf ety Requirements.
All tires are also graded f or
treadwear, traction, and temperature
perf ormance according to
Department of Transportation
(DOT) standards. The f ollowing
explains these gradings.
The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices and dif f erences in
road characteristics and climate.
Unif orm T ire Quality Grading
T readwear 200
Traction AA
Temperature A T readwear
T raction
DOT Tire Quality Grading (U.S. Vehicles)
420
 —
—y


y
)"  y y
2010 Insight

µ
Driving on a signif icantly under-
inf lated tire causes the tire to
overheat and can lead to tire failure.
Under-inf lation also reduces f uel
efficiency and tire tread life, and may
af f ect the vehicle’s handling and
stopping ability.
Please note that the TPMS is not a
substitute for proper tire
maintenance, and it is the driver’s
responsibility to maintain correct tire
pressure, even if under-inf lation has
not reached the level to trigger
illumination of the TPMS low tire
pressure telltale.TPMS malf unctions may occur f or a
variety of reasons, including the
installation of replacement or
alternate tires or wheels on the
vehicle that prevent the TPMS f rom
f unctioning properly.
Always check the TPMS malf unction
telltale af ter replacing one or more
tires or wheels on your vehicle to
ensure that the replacement or
alternate tires and wheels allow the
TPMS to continue to f unction
properly.
Your vehicle has also been equipped
with a TPMS malf unction indicator
to indicate when the system is not
operating properly. The TPMS
malf unction indicator is combined
with the low tire pressure telltale.
When the system detects a
malf unction, the telltale will f lash f or
approximately one minute and then
remain continuously illuminated.
This sequence will continue upon
subsequent vehicle start-ups as long
as the malfunction exists.
When the malf unction indicator is
illuminated, the system may not be
able to detect or signal low tire
pressure as intended.
Tire Pressure Monitoring System (TPMS) Required Federal Explanation
424
 —
—y

y
)"  y y
2010 Insight

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routes
them from the crankcase back to the intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The Clean Air Act
Crankcase Emissions Control
System
Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
Technical Inf ormation
425
 —
—y

y
)"  y  y
2010 Insight

.............................
Braking System .324
.................
Break-in, New Vehicle . 284
Brightness Control, ...............................
Instruments .121
Bulb Replacement ..........................
Back-up Lights .365
..............................
Brake Lights .365
........
Front Side Marker Lights . 364
.........
Front Turn Signal Lights . 363
.................................
Headlights .359
..........................
Parking Lights .362
..........
Rear Turn Signal Lights . 365
............................
Specif ications .419
..............................
Bulbs, Halogen .359
.........................................
Card, PC .215
.........................
Cargo Area Cover .150
..........................
Cargo Area Light .158
............................
Capacities Chart .418
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo .295
.............
CAUTION, Explanation of . iii
..................................
Ceiling Light .157
...............................
Center Pocket .155 ...................................
Center Tray .155
........................
Certif ication Label .416
............................................
Chains .379
....................
Changing a Flat Tire .387
Changing Oil ........................................
How to .350
......................................
When to .337
...
Charging System Indicator . 63,402
............
Checklist, Bef ore Driving . 302
.....................................
Child Saf ety . 38
Child Seats .............
LATCH Anchor System . 47
.............................
Lower Anchor . 47
............................
Tether Anchor . 50
................
Childproof Door Locks . 131
.............................
Climate Control .160
.........................
Clock, Setting the .254
........................
CO in the Exhaust .425
............
Cold Weather, Starting in . 303
..............................
Compact Spare .386
.................
Console Compartment . 154
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .353
....................................
Checking .289
.........................
Proper Solution .353 ...............
Temperature Indicator . 67
Crankcase Emissions Control ........................................
System .425
............
Cruise Control Operation . 256
.........................
Customer Service .432
...............
DANGER, Explanation of . iii
...................................
Dashboard .3, 60
..............
Daytime Running Lights . 120
............
Def ects, Reporting Saf ety . 434
..............
Def ogger, Rear Window . 123
..............
Def rosting the Windows . 163
....................................
Dimensions .418
.............
Dimming the Headlights . 119
Dipstick ..........
Automatic Transmission . 356
..................................
Engine Oil .288
........................
Directional Signals .118
Disc Brake Pad Wear ...................................
Indicators .325
............................
Disc Player .173, 204
.....................
Disposal of Used Oil .352
Index
C D
II
 —
—y

y
)"  y y
2010 Insight

.................................................
Fuel .284
......................
Fill Door and Cap .285
...........................................
Gauge .73
................
Octane Requirement . 284
...............................
Oxygenated .284
........................
Reserve Indicator .70
........................
Tank, Filling the .285
.....................
Fuses, Checking the .407 .............
Halogen Headlight Bulbs . 359
...........................
HandsFreeLink
. 259
..............................................
Hatch .136
......................................
Opening .136
............................
Open Indicator .68
............
Hazard Warning Flashers . 122
Headlights ........................................
Aiming .359
.........
Daytime Running Lights . 120
..................
High Beam Indicator . 69
......................
Reminder Beeper .119
........
Replacing Halogen Bulbs . 359
.................................
Turning on .119
............................
Head Restraints .139
.............................
Heated Mirrors .145
.............
High Altitude, Starting at . 303
...............
High-Low Beam Switch . 118
.......................
Hood, Opening the .287
....................................................
Horn .4
...............
Gas Mileage, Improving . 290
.........................................
Gasoline .284
...............
Fuel Reserve Indicator . 70
...........................................
Gauge .73
................
Octane Requirement . 284
........................
Tank, Filling the .285
................
Gas Station Procedures . 285
Gauges .............................
Charge/Assist .74
...............................................
Fuel .73
............
Gearshif t Lever Positions . 311
..........
Automatic Transmission . 311
......................................
Glove Box .154
...
Identif ication Number, Vehicle . 416Ignition
............................................
Keys .126
.........................................
Switch .128
............
Timing Control System . 426
IMA System Power Flow ........................................
Monitor .84
......................
Immobilizer System .127
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 62
...
Indicators, Messages (MID) . 62,89
...............
ABS (Anti-lock Brake) . 64
..............................
Auto Idle Stop .66
Brake (Parking and Brake ............................
System) .63, 404
.............................
Cruise Control .69
.................................
Cruise Main .69
................
Door/Hatch Open . 12,68
DRL (Daytime Running ....................................
Lights) .120
.
EPS (Electric Power Steering) . 68
................................
ECON Mode .71
...................................
High Beam .69
....
High Temperature (Coolant) . 67
......................
IMA Battery Level .85
.................................
IMA System .66
........
Key (Immobilizer System) . 63
Index
I H
G
IV
 —
—y
y
)"  y y
2010 Insight