brake HONDA INTEGRA 1998 4.G Workshop Manual

- G503 (Hatchback), G751
NOTE: Wires shown without color codes are black.
LEFT RIGHTBRAKE BRAKE
LEFT LIGHT/ RIGHT LIGHT/
REAR LEFT TAIL. REAB RIGHT TAIL-
TURN neln LIGHT TURN REAR LIGHT
SIGNAL PARKING LEFT Paqes SIGNAL PARKING RIGHT PAgCS
LIGHT LIGHT BAcK-uP 110-6 LIGHT LIGHT BACK.UP 110-6
Paqe Paoe LIGHT and Page Page LIGHT andtto*-s ttd-tz Paoe 110 110'12 110-3 110'12 Page 110 110-12
1-) 1- (-) r--r 1- 1-) f-) t--t(_r \_r \-/ r---' \-,, \-,, \.'/
LLIJ L-L.I
REARwtNDowWIPERMOTORPage 92
tl
PHOTO 108PHOTO 148
HATCHLATCHPage 114-3
t. I
lltl
cnv I
1 g c52a
HATCHOPENERSWITCHPage 134
HATCHOPENERACTUATORPage 134
HIGHMOUNTBRAKELIGHTPage 110'6
tl
tl
1 g c756
| ':::2"'
I (GS andI GS-R)
.l .rl' t- GS
: 'YF/o% :*^I a 1lz
I
IL
ALU
1
atu/
1
REO
c527PHOfO 106
HATCH KEYCYLINDERswtrcHPage 130
c530PHA|O 137
BLU
1c529
I
! cTsl
c525
POWERANTENNAMOTOR LICENSEPaoe 151 PLATEpu6rctos LIGHTS
|.--1 Page 110-12
| | l-t r-t
I | \-., \-,,
T;,. U
I iHi'$t"" I
I :3:.:ll: I
I ^ -:-"^ I
tt*l
tll
I I
'l e:3?.,,,
ltl-ll-
14-7

Ground Distributioh (cont'd)
- G503 (Sedan)
NOTE: Wkes shown without color codes are black.
LEFTIN NERBRAKELEFT LIGHT/BACK-UP TAILLIGHTLIGHT Paqes 110-7Paqe 110,1 and 110-13
r-,r ,--r\_,, r- -,
c534
L.JLIJL.J
TRAILERLIGHTINGCONNECTORPage 118
RIGHTINNERBRAKELIGHT/TAILLIGHTPages 110-7and 110-13
()
RrcHr l!-c.{r !'rqlt-
!iTfi^. iff#"" iilt[i",
b:::1,0. ii3:3 :i3::lts'
(:) (:) rllr
TRUNKLATCHswtTcHPage 114-3
tl
tl
2 Y C535
RIGHTBACK-UPLIGHTPage 110 1
/\
LEFTREARTURNSIGNALLIGHTPage 110-5
LEFTREARPARKINGLIGHTPage110-13
/\
LEFTOUTERBRAKELIGHT/TAILLIGHTPages 1'10-7and 110-13
()
'98-'99
Model
(Notuseo)
cs22
HIGHMOUNTBRAKELIGHTPage 110-7
tl
REARwrNDowDEFOGGERPage 64
ll
14-8

PGM-Fl ('98-'99 Models) (cont'd)
FUSE 2s
See PowerDistribution,
L_J__':n1:'_.:
i-T;;,;,---l HSBE'I nonr. sror : FUSE/I J roA I RELAYI I See Power I BOx
i ts Distribution, ! PHoro2t
L_J__0"n" to'n_..i
UNDER-DASH T-T------'I UNDER-FUSE/RELAY I ' FUSEs2 IHOODtuErER : BOX ! nonn.sror : FUSETr.3A Jp4oro5q I I2oA I RELAY
uauuE sERvtcEASSEMBLY aHidK- lT'! BRAKE swtrcHPHaro4T coNNEcroR ! / I closed wilh brakeP1oro 76 | {_. I pedat depressed.1 Y- -:-'Y .:rnE a \1,. DHOIO 129i 66g"; ilti5Xx+15l'""
I PHoroT6
ll^3j l;i,X|,io'"*".
i ry/,-'Em.dui6 | *";Xf-".'{'*',.."".*,'",-A*f.i.";"'"
Lt*F,--;J^,,
I i**''i
";\&**"**
| li'l|l (scs) pP8nu I
I I'illL. Service check Brake Ii control connector input switch inpul \
i: wEcpressure fiff ii psp : \
lj rslnpur s*[cninput- ii'iiror : i switch inpur : I
fi (6:) '"f'?-) %-' : : FJ:*t : iL------- t-L---J
;tx;
"-'TJ.!.
"oo,
: :[:"': l. -u-.1
i[uE,
i
*"T,!. enroLxl
' -i-----1
i
".''"]rf
_ en*err I
i fi:i
-'-- !
i 'T""t """'"'- !
ilrff:;iJ:rl *:f
See ABS, I
6lt"uo,", F:i
ffi; :i
*.1
I
i ll-i ""^,"." 'fr----1f,il0,3,,
i i ,"l,fF'%%"' i, i-[- t wrne BLU BLK f ll ; ' onN I
i"..*t-T;i;;i ffiff'rul.'l ii Ej'ir1'pi='Et'x'i
I la$ I .*^*"'-" ".*'f ""'^..-.
! i i _:f
*" :
: i-[l ffir* I iii:!:i* >+i
o"n""l
i l-' "'"1 u'* - seeGround I
i
-o-: --1i i l^_^-
'1:
i-<3:"J:qT3"'i
i Hf'.!$*
ll
J
I
lJrlffi"r"",
: l__ j
, : *"* E ;; ---="*L-l
"*fiix+*,"i
i
""[
23-6

PGM-FI ('00 Model) lcont'd)
f ---,1-------1 GAITGE SERVICE
!
""
l-t fl?i*." lfr:?"'Y"'" 33FR[",o"I

| ""^,.,^
""r,o"t" t F;J$"
i Br,ffi*
-""'Ti"::"'""
'
F fl::"",.,, !f":?sy"'" $FR["r"" i7.l S[t5',"',1flJ,:1"
,ff uo.rrn"t'o* ! PHoro-6
!-r -/ ffi ore'"*"o
(f/ffirir,r$- I """-"11-"J** 3yc431
| p$tr6l:,- i *".;f:.:f
"oou ..-.t'';;;;" "
l-.L-@---i I Iar'u+t
'""*"'l
12 f csse see ABS. I I o"o" t+-+ '-+---{ c41s
"-"lt;;;"
t;dil
-:i
"."|r-i "".*[--f:il-.
iL_1
SeeABS. I t , .l(- -l fierminals 1s-17)
3o'.,", E:i
"." lr-j o"n,nn, ! J
"o'"'ur""or.
______-.f _t-_il":______rJ"oo,'*Bi""i'""*#i;
I ,i,1|}
I MrL.
I connor
(scs)Service checkconnector input
l€2
Brakeswitch inpul
I
I
\f:----- - - - - - i | - - - - - - - - - - - : \
ii *Ecpressure Hi: ii psp i \
l: Ksinput switch'input coritiot ' I swilch input : I
f l '$' 'T,'J S' ii oll:t : iL------- ------Ji 3 Y c40e 10 lf c40s 12 l( c457 ; ; 26 y c408 :, zls ar-uar-x I o"n.,.. I ii*"I :______,: l.-l-1 'A rJ
; l-'!r-i ""^,"." o-----+t;%," i" 'f ,"#!",,
: kt-l:orr!
"""*.[",.,
| :i "Tl"r" :
I ".o".u"il-' ""n".* [ I 1-1-1wec l i rf, rsyr:sriF,.rB,]," i
i:."i:t--"# *n,,1 l-\l;tff#"'I ii IA'|5't'f3,i^'''*' i
i zt.\. [ ^ 2Yc132 [ ,' 2 Ycail :
I l.+.1 | see Grouno ':* I o"" ".. I i i ..- I :
i .-tiql i*}:11- *i
I",., ii
"'^f*il{:"{{i$l
i
i *'...#:t I
-"1 """'#*=:
ii
"'-l
pas€1+3
i
i
H** {:,]
'
$ff.':*'"ii l-=i
i
24-6

FUSE 52HOBI|, STOP20A
c216
UNDER-HOODFUSE/RELAYBOXSee PowerDistribution,page 10-9.
See Powe.Distribution,page 10-9.
WHT/GRN
C'osed withl--f uiiiipna-a depressed.
c418(Termlnals 5-7)
WHT/GFN
-l -..1113i::l, ? #:f"*".u'o?I ",
REEL
SeeHOrns
4 Y c4s1BLU/GFN II.-l----
i ll ".u o"n ! 9EcuRIJY-SYSTEM Att except,, ?--1f.^ cooL.tNEcroR usA Rs
1**9 it*'.__;il__.
t=^----- STEERTNGag I WHEEL
diiiinlor- |SET/RESUME IswrrcH i
I
(cont'd)
c431BRAKEswtTcH
I '-l--P'---e"
l L_ffi___-l3 Y c431 .9"-f------9*-t "or,-."1""L.------"0,,
i@ @ iF;5""
f-----Y (Terminals 1s-17) L--f.--------L-Jt I e/,o,o5, 1f ------4c2
o"n*",! $
'*""Tl----*irt.ouu
""'-
! seeABs. PGM-FI. 'f o [ilb'i5o'
I Brake Lghls. Automatic rr onr neo I r-r onr er-x I
. L _ _i:Tl1T:: - - - - - -- - -'-l- - - - - - - rI slr
i-#,[?=== input - input lPtroto.t
l'L------ ------J
34-1

Cruise Control (cont'd)
- How the Circuit Works
The cruise control system uses mechanical and
electrical devices to maintain the car's soeed at a
setting selected by the driver.
System Description
The cruise control unit receives command signals
from the cruise control main switch and the cruise
control SevBesume switch. With the ignition switch
in ON (ll) or START (lll), voltage is provided to the
cruise control main switch. When you push the
switch to on, power is provided to the cruise control
unit and the brake switch.
The cruise control unit receives information about
operating conditions from the brake switch, the
ignition control module (lCM), the vehicle speed
sensor (VSS), and the clutch switch (manual
transmission) or the A,/T gear positton switch
(automatic transmission). The cruise control unit
then sends signals to the cruise conirol actuator
which regulates the throttle position to maintain the
selected speed. The control unit compares the
aclual speed of the car to the selected speed. The
control unit then uses the result of that comoarison
to oDen or close the throttle.
The brake switch releases the system's control of
the throttle at the instant you press on the brakepedal. The switch sends a signal to the control unit
by removing power from the normally closed brake
input (GRY wire), and providing power at the
normally open brake input (GRNMHT wire). The
control unit responds by allowing the throttle to
close. The clutch switch or the A/T gear position
switch sends a "disengage" signal to the control unit
that also allows the throttle to close.
The cruise control system will set and automatically
maintain any speed above 25 mph (40 km/h). To set
it, make sure the main switch is on and the switch
indicator is on. Then, after reaching the desired
speed, press the set switch. This sends a "set"
signal to the cruise control unit which, in turn,
controls the cruise control actuator to maintain the
set soeed.
When you push the SET switch and the cruise
control system is on, the "cruise control" ON
indicator lights up.
34-4
You can cancel the cruise control system by
turning the main switch off. This removes power to
the control unit and erases the set sDeed from
memory. lf the system is disengaged temporarily
by the brake switch, or clutch switch, and the car's
speed is still above 25 mph, press the RESUME
switch: the car will automatically return to the
previously set speed.
For gradual acceleration without pressing the
accelerator pedal, push the RESUME switch and
hold it there. This will send an "acceleration" signal
to the control unit. When you release the switch, the
system will be reprogrammed tor the new speed. To
slow the car down, push the SET switch in and hold
it there. This sends a "deceleration" signal to the
control unit, causing the car to coast. When the
desired speed is reached, release the SET switch.
This reprograms the system for the new speed.
Reter to the Service Manual (Section 23, Electrical)
for specific tests or troubleshooting procedures.

Automatic Transmission Controls
- '98-'99 Models
-I,;;;
EACK Ue
-l'::-
FUSE 52NOFN, STOP204
UNDER-HOODFUSE/RELAYBOXSee PowerDistribution,page 10-9.
isToP s
v)Brake switch input
8c217
aa+
I Y C216ll PHaTa 24wHrcFN iSee Power ! See power
Distribution. I Distributron,page 1G8. I OuO" tO-S.
""t o:"
I(Cruise Contror 2) I C431
r rN-.t BRAKE
I | swrrcH
L q-: j ;,,?i,i?'Y,i *i,i:5"
2Ycqst "u'o '*
(Cfuise Control3t
IGFNvHT
Il'+^..6'f- - - --_- -
:f irlliin"r" r s-r zy
I
GFN wHr I 'r'oro'o
cnrwnr I t
i 8:i^i?i,i":"tZ I Cqtg Cruise C-ontrol
] fii1f,,",.,..,,
Y
SeelgnitionSystem
l---83ivBU)Battery back-up
812',
I(nE)Engine speed input (FPM)
Shitt tock Shift controlsotenoid Look_up coo.trol solenoid \VehiCle Cifcuit A,/C on valve control valve controlspeed-input control ilp"ui' ,-'H...,.,,,,..r \"&. ,j5? ,X%""r' ,"lru' rsHAr 'lgl' ,l:"u) IL _ iq - _ _ _ _ E?_ _ _ _ g'_ _ _ _ 5i _ _ _E: _ _ _ _ _ !t- _ _ _:&: _ _ _ - _tu
f
"0"
-",:: [-;"f
-
"- "T-. -T----=T--_5
"-'
*"
I p*t ^", 3rl**.,*""
-"'
il
-'-..
|
-.
|
"* *^
|
| $:'"::""
33n:Ji.'*' .
|___{ r*,," ,
f----,{ r*:,,
.ri-,-:-
ssc"ds"n'o.
"""**
|
*,"*! ""1 o"n"'* |
*f n';,, . L__J
" [--:'] ,';7..
-.: t "';%,.
-i,.!..,,, ""^"-l'-;;{t**' j:l#r-
iyi,:?n$i,:*""" ffiBB'rI"o."L*.."'.i-ii.*'ji"[!si"""' ,,_r_,"'liiif+:rm U;1f$+f,
:[ilrF""#**F.tr
39

Automatic Transmission Controls
- '00 Model
47n
24
FUSE 4AACX UE(8ADrO)
c2't7
'r,

Ir.g
l
See PowerDistribution,pag€ 1G9.
FUSE 52HOBfl, SIOP204
UNDER-HOODFUSE/BELAYBOX
c418Oerminals 15.17)
8
WHT/AIU
aa+See PowerDistfibution,page 10"8.
I
$See ABS,Brake Lights,Cruise Control
. B2t 432r--rsrbFswlIBattery back-up Btake switch input i
Shift lock Shilt conkol solenoid Lock-up control solenoid Linear solenoid \Vehicte JirCuif ly'C on valve control valve control valve eontrol Isoeed inDut control inDut !speed input control inputlvss) {rLUl tacoLl {SH B, rSH A' {LC A) (LC B) {L.s+J (LS ) Ic23 A2A At7 02 D7 Dl D3 817 8a -'c23 A28 A17 02 D7 D1 D3 817 88
T-lF$ffiT-il:
::m]'::.
1j$;$d.H-t,il: Tfl;;
ill}.-.'.-":[-{,* 'ffi; -lTl.'
i[fi;"
":ff":'[:{;,[fi::
iy:[*i xFEf"* llrTril ilfinpl -l-
"'i-f1.o"^.,,
i i--i , !r.Eli- -
L'q,j ;:i5?" *'.,
|
"ll!
i ll
I tf.f$sb
E W *$+iir [E''l
5i'i+r" "
I see venicre
-
|_
- -T ;'r'o'i;
i;*
**'""::.";
I
""
l'tr .,,,
"^::'[",,
39-4

Anti-Lock Brake System (ABS)
iTffi;---IH5BE"
tlSrqr$llilHh1,
UNOER.DASHFUSE/RELAYBOX
FUSE 16
EEiFf a ) IESYD€F...'EB 1."-9 ii1gl7sA Distribution,
Lf:je:l- JPPJ",,---------+ pags 1G6.
__li;;,
"-",['*'*-
,
ffi_-GAUGEASSEMBLY
[-4];"ffi]":+*" I if^",T*fl-;.r-ini -
i_ il*6$?jq*
.-1- N"""-l illT*ffi
o"n,n",l $
"-^*"
1
L-:L--- -'L------'
! ir'J'.f,,il'*" i
"-:i[-, -"tl
,*,***t
f=fii1ina*15.17, I*',1*,rtil Ilm
! """ i pirjli-io.6. i ^. 1 +seerndicators
-r,Llll----_.#.
ffifi'fj
LEFTFRONTWHEELSENSOR
RIGHTFBONTWHEELSENSOR
LEFTREARWHEELSENSORPHOTA 46
RIGHTREARWHEELSENSOR
44

Anti-Lock Brake System (ABS) (cont'd)
r----'t
rA?.?"" I
I relayconkol IL-:-:-J21 Y C7O4YEL/GRN II
z iL coo,
ABSCONTROLUNIT
UNDER"HOODABSFUSE/RELAYBOX
-*i[::
ABSFAIL-SAFERELAY
:F
BRN/BLK
c21110
---il'cztt
"aotrn, I
_____:$ r**,,
___:il.[ ",..
;;r
11[
;."7
:][
ra'{
_:,.,!-
;_'r[
:tt
i-l-;;.-
l-l-:--o r F"%"3,"
::t.1",.,
L6ftFrontABSSolenoid(out)
RightFrontABSSolenoid(ouU
LeftFrontABSSolenoid(ln)
LefiSearABSSolenoid(out)
FL.OUI (FL,|N) (Fn-OUI {FntN) (BL-OUT) lBL,tN) ,-it- --8, r-q-d ,
Left tront ABS Riohl lront ABS t 6ft rerr ABs t-Left tront ABS Right front ABS Left rear ABSsolenoid control solenoid control solenoid conlrol \
I
44-2