engine HONDA PILOT 2006 1.G Manual PDF

The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any
combustible materials that come
near it. Park your vehicle away from
high grass, dry leaves, or other
f lammables.A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your vehicle’s three way
catalytic converter.
Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective. Keep the engine tuned-up.
Have your vehicle diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Three Way Catalytic Converter
T echnical Inf ormation
295
THREE WAY CATALYTIC CONVERTER
THREE WAY CATALYTIC
CONVERTERS

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.Make sure the gas tank is nearly,
but not completely f ull (around
3/4).
Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park. Increase
the engine speed to 2,000 rpm, and
hold it there until the temperature
gauge rises to at least 1/4 of the
scale (about 3 minutes).
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D. Do not use the cruise control.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F.
T esting of Readiness Codes
State Emissions T esting
296

µµ
µ
(


%
)
$
%

.
"

#
) This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the service manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
This manual describes the procedures involved in the
replacement of damaged body parts. Body Repair Manual: Electrical T roubleshooting Manual: Service Manual:
Authorized Manuals
304
NOTE: Dealers and companies, pl
ease provide dealer or company name,
and the name of the person to whose attention the shipment should be
sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA
Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These publications cannot be returned for credit wit
hout receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

CONT INUED
............................
Capacities Chart .288
.............
Carbon Monoxide Hazard . 57
.............................
Carrying Cargo .193
..............
CAUTION, Explanation of . ii
..........................
CD Changer .131, 134
.......................................
CD Player .130
...
Accessories and Modif ications . 191
ACCESSORY (Ignition Key .......................................
Position) .81
............
Accessory Power Sockets . 101
...........................
AC Power Outlet .102
....................
Additives, Engine Oil . 239
...............
AdvancedAirbagSystem . 30
.............................
Airbag (SRS) .11, 25
..........
Airbag System Components . 25
..............
Air Conditioning System . 106
.....................
Rear A/C Control .113
.......................
Air Pressure, Tires .258
......................................
Antif reeze .242
...............
Anti-lock Brakes (ABS) . 209
...............................
Indicator .63, 210
...................................
Operation .209
..............
Anti-thef t, Audio System . 139
.
Anti-thef t Steering Column Lock . 81
................................
Audio System .115
...
Automatic Seat Belt Tensioners . 23
...
Automatic Lighting Off Feature . 76
.............
Automatic Speed Control . 175
..............
Automatic Transmission . 200
..........................
Capacity, Fluid .288 ...............
Checking Fluid Level . 244
.......................................
Shif ting .200
.
Shif t Lever Position Indicator . 200
................
Shif t Lever Positions . 201
....................
Shif t Lock Release . 203
Battery Charging System ...........................
Indicator .62, 276
............................
Jump Starting .272
..............................
Maintenance .262
............................
Specif ications .289
..............................
Bef ore Driving .185
..................................
Belts, Seat .10, 21
...........................
Beverage Holders .99
..................................
Booster Seats .54
Brakes ...........
Anti-lock System (ABS) . 209
.............
Break-in, New Linings . 186
....................
Bulb Replacement .252
...........................................
Fluid .246
.........................................
Parking .97
.................
System Indicator . 63,278
........................
Wear Indicators .209 .............................
Braking System .208
.................
Break-in, New Vehicle . 186
..
Brightness Control, Instruments . 76
........................
Brights, Headlights .75
Bulb Replacement ..........................
Back-up Lights .252
.....................
Brake Lights .252, 253
................
Front Parking Lights . 249
........
Front Side Marker Lights . 249
.................................
Headlights .248
........
High-mount Brake Lights . 253
.................................
Rear Bulbs .252
............................
Specif ications .289
.............
Turn Signal Light . 249,252
..............................
Bulbs, Halogen .248
Index
A
B
C
INDEX
I

........................
Certif ication Label .286
............................................
Chains .261
....................
Changing a Flat Tire .267
Change Oil ........................................
How to .240
......................................
When to .229
...
Charging System Indicator . 62,276
............
Checklist, Bef ore Driving . 198
..................
Childproof Door Locks . 83
Child Seats .........................................
LATCH .47
..........
Tether Anchorage Points . 51
...............
Climate Control System . 112
.........................
Clock, Setting the .140
.....................
Code, Audio System .139
........................
CO in the Exhaust .293
............
Cold Weather, Starting in . 199
......................
Compact Spare Tire .266
...................
Console Compartment . 99
.................
Consumer Inf ormation . 300
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .242
....................................
Checking .189
.........................
Proper Solution .242
...................
Temperature Gauge . 71...................
Conversation Mirror .100
Crankcase Emissions Control ........................................
System .293
............
Cruise Control Operation . 175
....
Customer Service Inf ormation . 300
................
DANGER, Explanation of . ii
...................................
Dashboard .4, 60
................
Daytime Running Lights . 76
Daytime Running Lights .......................................
Indicator .67
.................................
Dead Battery .272
............
Def ects, Reporting Saf ety . 302
................
Def ogger, Rear Window . 77
......
Def rosting the Windows . 108,110
....................................
Dimensions .288
...............
Dimming the Headlights . 75
Dipstick ..........
Automatic Transmission . 244
..................................
Engine Oil .189
....................
Directional Signals . 66,75
........
Disc Brake Wear Indicators . 210
.....................
Disposal of Used Oil .241 Doors
..............
Locking and Unlocking . 82
..........
DOT Tire Quality Grading . 290
...........
Driver and Passenger Safety . 7
...........................................
Driving .197
....................................
Economy .190
...................................
DVD Player .142
........
DVD Player Error Message . 171
..............................
Economy, Fuel .190
............
Emergencies on the Road . 265
.............
Battery, Jump Starting . 272
...........
Brake System Indicator . 278
................
Changing a Flat Tire . 267
.....
Charging System Indicator . 276
..................
Checking the Fuses . 279
.....
Low Oil Pressure Indicator . 276
...
Malf unction Indicator Lamp . 277
..................
Overheated Engine . 274
...........................
Emergency Brake .97
......................
Emergency Flashers .77
.......................
Emissions Controls .293
.............
Emissions Testing, State . 296
Index
D
E
II
Emergency Towing .......................278

CONT INUED
Engine....
Coolant Temperature Gauge . 71
Malf unction Indicator ................................
Lamp .62, 277
........
Oil Pressure Indicator . 62,276
..............
Oil, What Kind to Use . 239
...............................
Overheating .274
............................
Specif ications .289
............................
Speed Limiter .202
.......................................
Starting .199
.
Evaporative Emissions Controls . 293
...............................
Exhaust Fumes .57
Exhaust Gas Recirculation ........................................
System .294
Expectant Mothers, Use of Seat ........................................
Belts by .19
...............
Gas Mileage, Improving . 190
.........................................
Gasoline .186
...............
Fuel Reserve Indicator . 67
...........................................
Gauge .70
................
Octane Requirement . 186
........................
Tank, Filling the .187
................
Gas Station Procedures . 187Gauges
...
Engine Coolant Temperature . 71
...............................................
Fuel .70
GAWR (Gross Axle Weight .......................................
Rating) .214
GCWR (Gross Combined Weight .......................................
Rating) .214
............
Gearshif t Lever Positions . 200
........................................
Glove Box .99
GVWR (Gross Vehicle Weight .......................................
Rating) .214
.............
Halogen Headlight Bulbs . 248
.................
Hazard Warning Button . 77
...................................
Fan, Interior .106
.........................................
Features .105
....................
Filling the Fuel Tank . 187
Filters ...............................................
Oil .240
.............
Flashers, Hazard Warning . 77
...................
Flat Tire, Changing a . 267Fluids
..........
Automatic Transmission . 244
..........................................
Brake .246
..........................
Power Steering .247
................
Windshield Washers . 243
...................
Folding the Third Seat . 89
..........................
Four-way Flashers .77
.................................................
Fuel .186
...............................
Cap Message .72
......................
Fill Door and Cap .187
...........................................
Gauge .70
................
Octane Requirement . 186
........................
Reserve Indicator .67
........................
Tank, Filling the .187
.....................
Fuses, Checking the .279
Index
F GH
INDEX
III

CONT INUED
..................................
Maintenance .227
Owner’s Maintenance ...................................
Checks .234
.................................
Record .236-237
................................
Minder .229-235
.........................
Minder Indicator .69
..........................................
Saf ety .228
.
Malf unction Indicator Lamp . 62,277
..............
Manual Seat Adjustments . 88
...............................
Meters, Gauges .70
.................................
Modif ications .192
.........................................
Moonroof .96
.................................
Lower Anchor .47
...
Lubricant Specif ications Chart . 288
.........................................
Luggage .193
...................
Neutral Gear Position . 201
..................
New Vehicle Break-in . 186
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 286 ...
Octane Requirement, Gasoline . 186
.........................................
Odometer .70
...............................
Odometer, Trip .70
....................
Of f -Highway Driving . 223
...................
Of f -Road Precautions . 223
Oil ........................
Change, How to .240
......................
Change, When to .229
......................
Checking Engine .189
..............
Pressure Indicator . 62,276
Selecting Proper Viscosity ......................................
Chart .239
...........
ON (Ignition Key Position) . 81
Onboard Ref ueling Vapor ....................................
Recovery .293
..............................
Outside Mirrors .93
....................
Overheating, Engine .274
....
Owner’s Maintenance Checks . 234
..............
Panel Brightness Control . 76
........................
Park Gear Position .201
...........................................
Parking .207 .................................
Parking Brake .97
Parking Brake and Brake System ...............................
Indicator .63, 278
.................................
Parking Lights .75
..
Parking Over Things that Burn . 295
..........................
Playing the Radio .117
................................
Playing a Disc .130
....
Playing the Disc Changer . 131,134
.............................
PGM-FI System .294
................
Power Seat Adjustments . 87
.................
Power Socket Locations . 98
..............................
Power Windows .94
.........
Pregnancy, Using Seat Belts . 19
.........
Protecting Adults and Teens . 12
...
Additional Safety Precautions . 20
.....
Advice f or Pregnant Women . 19
........................
Protecting Children .38
...........................
Protecting Inf ants .43
...........
Protecting Larger Children . 53
.............
Protecting Small Children . 44
Index
INDEXP
M
N O
V

...................
Radiator Overheating . 274
.............
Radio/CD Sound System . 115
...........................
Readiness Codes .296
...............................
Rear A/C Unit .113
............
Rear Audio Control Panel . 147
........
Rear Entertainment System . 142
..
Rear Lights, Bulb Replacement . 252
.
Rear View Camera and Monitor . 184
............................
Rear View Mirror .92
.................
Rear Window Def ogger . 77
.
Rear Window Wiper and Washer . 74
..........
Reclining the Seat Backs . 87-90
.............................
Reminder Lights .61
...............
Remoto Audio Controls . 138
.................
Remote Control (RES) . 169
.......................
Remote Transmitter .83
Replacement Inf ormation ................
Engine Oil and Filter . 240
.................................
Floor Mats .254
..........................................
Fuses .279
................................
Light Bulbs .248
........................................
Minder .235
................................
Timing Belt .245
...........................................
Tires .259 .............................
Wiper Blades .255
Replacing Seat Belts Af ter a ............................................
Crash .23
...
Reserve Tank, Engine Coolant . 189
...............................
Restraint, Child .38
..................
Reverse Gear Position . 201
................................
Rotation, Tire .259
......................................
Saf ety Belts .10
............
Safety Defects, Reporting . 302
.................................
Saf ety Features .9
.........................................
Airbags .11
.....................................
Seat Belts .10
.............
Saf ety Labels, Location of . 58
...............................
Saf ety Messages .ii
.........................................
Seat Belts .10
...............
Additional Information . 21
Automatic Seat Belt ...............................
Tensioners .23
.....................................
Cleaning .254
......................
Lap/Shoulder Belt .22
................................
Maintenance .23
Reminder Light and ................................
Beeper .21, 62 ...................
System Components . 25
...............
Use During Pregnancy . 19
...
Wearing a Lap/Shoulder Belt . 15
....................................
Seat Heaters .86
.................................................
Seats .87
............
Folding the Second Seat . 89
...............
Folding the Third Seat . 90
..........................
Head Restraints .91
.........
Reclining the Second Seat . 89
............
Reclining the Third Seat . 90
.......................
Third Seat Access .89
...................
Seats, Adjusting the . 87-90
............................
Security System .174
...............................
Serial Number .286
...........................
Service Intervals .229
.............................
Service Manual .303
.........
Service Station Procedures . 187
..........................
Setting the Clock .140
Shif ting the Automatic .............................
Transmission .200
.....
Shif t Lever Position Indicator . 200
........................
Shif t Lock Release .203
Side Marker Lights, Bulb .........................
Replacement in .249
..............................
Side Airbags .11, 31
..........................
Of f Indicator .34, 63
Index
R
S
VI

CONT INUED
...............................
Signaling Turns .75
.....................................
Snow Tires .260
................................
Sound System .115
Spare Tire ......................................
Inf lating .266
............................
Specif ications .289
....................
Specif ications Charts . 288
................................
Speed Control .175
..........
SRS, Additional Inf ormation . 25
...
Additional Safety Precautions . 37
.............................
Airbag Service .36
How the Side Airbag Of f ........................
Indicator Work .34
..
How the SRS Indicator Works . 33
How Your Front Airbags .........................................
Work .28
...
How Your Side Airbags Work . 31
........................
SRS Components .25
.............................
SRS Indicator .33 ,63
....
START (Ignition Key Position) . 81
.......................
Starting the Engine .199
In Cold Weather at High ..................................
Altitude .199
................
With a Dead Battery . 272
..............
State Emissions Testing . 296
........
Steam Coming f rom Engine . 274Steering Wheel
..................................
Adjustment .78
.............
Anti-theft Column Lock . 81
...............................
Buttons .138, 175
...................
Stereo Sound System . 115
....................
Storing Your Vehicle .263
........................
Sunglasses Holder .100
........................................
Sun Visor .101
Supplemental Restraint System ......................................
Servicing .36
.........................
SRS Indicator .33 ,63
...................
System Components . 25
..................................
Synthetic Oil .240
......
Taillights, Changing Bulbs in . 252
.
Taking Care of the Unexpected . 265
Technical Descriptions ......
DOT Tire Quality Grading . 290
.....
Emissions Control Systems . 293
..........
State Emissions Testing . 296
Three Way Catalytic ...............................
Converter .295
.......................
Temperature Gauge .71
........
Temperature, Inside Sensor . 114....................
Temperature, Outside . 71
...................
Tensioners, Seat Belts . 23
........
Testing of Readiness Codes . 296
..............
Tether Anchorage Points . 51
............................
Thef t Protection .139
..
Three Way Catalytic Converter . 295
..........................
Time, Setting the .140
..................
Tilt the Steering Wheel . 78
....................................
Timing Belt .245
....................................
Tire Chains .261
.........
Tire, How to Change a Flat . 267
Tire Pressure Monitoring ........................
System (TPMS) .205
Index
INDEX
T
VII

Service Inf ormation Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:Power Steering Fluid:
Rear Differential Fluid: Brake Fluid:Tire Pressure (measured cold):
Automatic Transmission Fluid: 32 psi (220 kPa , 2.2 kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm
)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ). Compact Spare Tire: Front/Rear:
Honda VTM-4 Differential Fluid
(see page ).
API Premium grade 5W-20
detergent oil (see page ).
Oil change capacity (including
filter):
4.5 US qt (4.3
)
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page ).
Unleaded gasoline, pump octane
number of 87 or higher.
239
244 247
246
245
20.34 US gal (77.0)