wheel HONDA S2000 2000 1.G Service Manual

Changing a Flat Tire
ll.Put on the spare tire. Put the
wheel nuts back on finger-tight,
then tighten them
in a crisscross
pattern with the wheel wrench
until the wheel is firmly against
the hub.
Do not try to tighten
them
fully.
216 Taking Care of the Unexpected
12.Lower the car to the ground and
remove the jack. 13.Tighten
the wheel nuts securely in
the same crisscross pattern. Have
the wheel nut torque checked at
the nearest automotive service
facility.
Tighten
the wheel nuts to:
80 lbf.ft (1 08 N·m, 11 kgf·m)

14.Remove the tool box from the
trunk well and replace the jack,
wheel wrench and extension
in the
tool box.
15.Place the tool box into the spare
tire shelf
in the trunk. 16.Replace
the spare tire cover.
Secure it with the three clips.
Push
each clip down securely, and pivot
the ring down flat.
17.Put the flat tire in the trunk well
vertically as shown.
Changing a Flat Tire
Taking Care of the Unexpected 217

The Brake System Indicator light
comes on when you turn the ignition
ON (II). If the parking brake is not
set, it goes off after you start the
engine.
If the parking brake is set, it
goes off when you fully release the
parking brake with the engine
running. If
it comes on at any other time, it
indicates a problem with
the car's
brake system. In most cases, the
problem is a low fluid level in
the
brake fluid reservoir. Press lightly on
the brake pedal to see if it feels
normal.
If it does, check the brake
fluid level the next time you stop at a
service station (see page
170 ) . If the
fluid level is
low, take the car to your
dealer and have the brake system
inspected for leaks or worn brake
pads.
However,
if the brake pedal does not
feel normal, you should take
immediate action. Because
of the
brake system's dual-circuit design, a
problem
in one part of the system
will still give you braking at two
wheels.
You will feel the brake pedal
go down much farther before the car
begins to slow down, and you
will
have to press harder on the pedal.
The distance needed to stop will be
much longer.
Brake System Indicator
Slow down by shifting to a lower
gear, and pull to the side of the road
when it is safe. Because
of the
longer distance needed to stop, it is
hazardous to drive the car.
You
should have it towed, and repaired as
soon as possible.
If you must drive the car a short
distance in this condition, drive
slowly and cautiously.
Taking Care of the Unexpected 229

If Your Car Gets Stuck
If your car gets stuck in sand, mud,
or snow, call a towing service to pull
it out (see page
238).
236 Taking Care of the Unexpected
For very short distances, such as
freeing
the car, you can use the
detachable towing hook that mounts
on
the anchors in the front and rear
bumpers.
To use the towing hook:
1. Remove the cover from the
bumper.
2. Remove the towing hook, hook
extension and wheel wrench from
the tool box.
3. Using the wheel wrench, fasten
the extension into the bolt hole in
the anchor.

Emergency Towing
If your car needs to be towed, call a
professional towing service or,
if you
belong to one, an organization that
provides roadside assistance. Never
tow your car behind another vehicle
with just a rope or chain.
It is very
dangerous.
There are three popular types of
professional towing equipment.
238 Taking Care of the Unexpected
Flat-bed Equipment -The operator
loads your vehicle on the back of a
truck.
This is the only way your
S2000 should be transported.
When you contact the towing agency,
inform
them that you have an S2000
and that a flat-bed is required.
Wheel Lift Equipment -The tow
truck uses two pivoting arms that go
under the tires (front or rear) and lift
them off the ground. The other two
tires remain on the ground. Because
the
S2000 sits so low, the body could
come
in contact with the ground and
be damaged.
This method of
towing is unacceptable.

Specifications
Dimensions
Length
Width Height
Wheelbase Track Front
Rear
Engine
Type
Bore x Stroke
Displacement
Compression ratio
Spark plugs
244 Technical Information
162.0in(4,115mm) 68.9 in (1,750 mm)
50.6 in (1,285 mm) 94.5 in (2,400 mm)
57.9 in (1,470 mm)
59.4 in (1,510 mm)
See the certification label attached to the driver's door"amb.
Water cooled 4-stroke DOHC
VTEC 4-cylinder l=)asoline engine
3.43 x 3.31 in (87.0 x 84.0 mm)
121.8 cu-in (1,997 cm3
)
11.0 : 1 See spark plug maintenance
section page
174.
c apac1t1es
Fuel tank 13.2 US
aal (50 ll, 11.0 Imp qal)
Engine coolant
Change*'
1.72 US aal (6.51\, 1.43 Imp qal)
Total 2.01 US l=)al (7.61\, 1.67 Imp gal)
Engine oil Change*'
Including filter 5.1 US qt (4.81\, 4.2 Imp qt)
Without
filter 4.8 USgt (4.51\, 4.0 Imp qt)
Total 5.9 US qt (5.61\, 4.9 Imp qt)
Manual Chanl=)e 1.6 US_g_t (1.51\, 1.31mp qt)
transmission Total 1.7 US qt (1.61\, 1.41mp qt) fluid
Differential Chan_g_e 0.78 US qt (0.741\, 0.65 Imp qt)
oil Total 0.81 US qt (0.77 ll, 0.68 Imp at)
Windshield U.S. Cars 2.7 US qt (2.61\, 2.3 ImP at)
washer Canadian Cars 4.4 US qt (4.21\, 3.7 Imp qt)
reservoir
* 1 : Including the coolant in the reserve tank and that remaining in the
engine. Reserve tank capacity:
0.16 US gal (0.61\, 0.131mp gal)
* 2: Excluding the oil remaining in the engine.

Temperature
The temperature grades are A (the
highest),
B, and C, representing the
tire's resistance to the generation of
heat and its ability to dissipate heat
when tested under controlled
conditions on a specified indoor
laboratory test wheel. Sustained high
temperature can cause the material
of the tire to degenerate and reduce
tire life, and excessive temperature
can lead to sudden tire failure.
The
grade C corresponds to a level of
performance which all passenger car
tires must meet under the Federal
Motor Vehicle Safety Standard
No.
109. Grades B and A represent
higher levels of performance on the
laboratory test wheel than the
minimum required by
law.
DOT Tire Quality Grading (U.S. Vehicles)
Warning: The temperature grade for
this tire is established for a tire that
is properly inflated and not over­
loaded. Excessive speed, underinfla­
tion, or excessive loading either
separately or
in combination, can
cause heat build-up and possible tire
failure.
Technical Information 247

A
Accessories Installation .................................. 122
Accessory
Power Socket ................ 81
ACCESSORY (Ignition Key
Position) ........................................
61
Adding
Brake Fluid ................................. 170
Clutch Fluid ................................ 171
Engine Coolant.. ......................... 161
Engine
Oil ................................... 157
Manual Transmission Fluid ..... 168
Windshield
Washer Fluid ......... 167
Additional Information About
Your
Seat Belts ........................ 33
Lap/Shoulder Belt.. ..................... 33
Seat Belt Maintenance ................ 34
Seat Belt System Components
... 33
Additional Information About
Your SRS ...................................
37
Additional Safety Precautions .... 38
How
the Automatic Seat Belt
Tensioners Work ..................... 37
How Your Airbags Work ............ 35
How the SRS Indicator
Works ........................................ 37
SRS Components ......................... 35
Additives, Engine Oil... .................. 158
Adjustments
Mirrors ..........................................
79
Seats .............................................. 68
Airbag (SRS) ...................................... 9
Air Cleaner Element.. ....................
l72
Air Conditioning ............................... 86
Maintenance ............................... 182
Usage ............................................. 86
Air Outlets (Vents) .......................... 88
Air Pressure,
Tires ........................ 185
Alarm, Anti-theft.. .......................... 113
Alcohol in Gasoline ........................ 248
Aluminum Wheels, Cleaning ........
206-
Antifreeze ....................................... 161
Anti-lock
Brakes (ABS)
Indicator Light ..................... 45, 138
Operation .................................... 136
Anti-theft Steering Column Lock
.. 60
Anti-theft System ........................... 113
Appearance Care ...........................
203
Audio Panel. ...................................... 82
Audio System ................................... 94
Index
Automatic Car Washes ................. 204
Automatic Speed Control.. .............. 55
IB
Back-up Lamp Replacement.. ....... 198
Battery Charging System
Indicator.. .......................... 44, 227
Jump Starting ............................. 220
Maintenance ............................... 177
Specifications ............................. 245
Before Driving ............................... 115
Belts, Seat ........................................... 8
Beverage Holder ..............................
81
Body Repair .................................... 210
Brakes ............................................. 136
Anti-lock System (ABS) ............ 137
Break-in, New Linings .............. 116
Fluid ............................................
170
Light, Burned-out ...................... 198
Parking .......................................... 80
System Indicator .......................... 44
Wear Indicators, Disc ............... 136
CONTINUED

Index
Brakes,ABS Certification Label ......................... 242
Vinyl ............................................ 207
Operation
.................................... 137 Chains ............................................. 191 Windows ..................................... 208
System
Indicator .................. 44, 139 Change Oil Climate Control System .................. 86
Braking System .............................. 136 Howto ......................................... 159 Clutch Fluid .................................... 171
Break-in, New Car ......................... 116 When to ....................................... 146 CO in the Exhaust ......................... 250
Brightness Control, Instruments ... 52 Changing a Flat Tire ..................... 213 Cold Weather, Starting in ............. 132
Brights, Headlights ......................... 51 Changing Engine Coolant.. ........... 163 Compact Spare Tire ....................... 212
Bulb Replacement... ....................... 192 Charging System Indicator .... 44, 227 Controls, Instruments and .............. 41
Back-up Lights ........................... 198 Check Engine Light ................ 45, 228
Covertible Top ................................. 71
Brake Lights ............................... 198 Checking
Closing the Convertible Top ...... 7 4
Headlights ..................................
195 Battery Condition ...................... 177 Convertible Top Cover. ............... 76
License Plate Lights .................. 200 Brake Fluid ................................. 170 Maintenance ................................. 77
Parking Lights ........................... 196 Clutch Fluid ................................ 171 Opening the Covertible Top ....... 71
Side Marker Lights ................... 198
Drive Belt.. .................................. 184 Coolant
Specifications .............................
245 Engine Coolant.. ......................... 120 Adding ......................................... 161
Turn Signal Lights ..................... 196 Engine Oil.. ................................. 119 Checking ..................................... 120
Bulbs, Halogen ............................... 194 Fuses ........................................... 232 Proper Solution .......................... 161
Manual Transmission Fluid ..... 168 Temperature Gauge .................... 47
c Checklist, Before Driving ............. 115 Corrosion Protection ..................... 208
Cleaner, Air .................................... 172 Crankcase Emission Control
Cables, Jump Starting With ..........
220 Cleaning .......................................... 203 System ......................................... 250
Capacities Chart. ............................ 244
Aluminum Wheels ..................... 206 Cruise Control Operation ............... 55
Carbon Monoxide Hazard .............. 39 Exterior ....................................... 204 Customer Relations
Cargo, Carrying .............................
124 Interior ........................................ 207 Information ................................. 254
CAUTION, Explanation of ............... ii Leather ........................................ 207
CD Changer. ................................... 107 Seat Belts .................................... 207
II

Shifting
The 6-speed Manual
Transmission ..........................
133
Side Marker Lights, Bulb
Replacement in .......................... 198
Signaling
Turns ................................ 53
6-speed Manual Transmission
Checking Fluid Level ................
168
Shifting the ................................. 134
Snow Tires ...................................... 191
Solvent-type Cleaners .................... 204
Sound System ................................... 94
Spare Tire
Inflating .......................................
212
Specifications ............................. 245
Spark Plugs, Replacing ................. 17 4
Specifications Charts ..................... 244
Speed Control... ................................ 55
Speedometer .................................... 4 7
SRS, Additional Information ........... 35
Additional Safety Precautions .... 38
How the Automatic Seat Belt
Tensioners
Work ..................... 37
How the SRS Indicator
Works ........................................
37
How Your Air bags Work ............ 35
SRS Components ......................... 35
SRS Service ................................... 38
SRS Indicator Light ................... 37, 45
START (Ignition Key Position) ..... 61
Starting the Engine ........................ 131
In Cold Weather at High
Altitude ...................................
132
With a Dead Battery ................. 220
Steam Coming from Engine ......... 223
Steering Wheel
Anti-theft Column Lock ..............
60
Stereo Sound System ...................... 94
Storing Your Car ............................ 202
Stuck Car ........................................ 236
Supplemental Restraint
System
Servicing
....................................... 38
SRS Indicator .......................... 37, 45
Tensioners, Seat Belts ................ 37
T
Tachometer ...................................... 4 7
Taillights, Changing Bulbs in ....... 198
Taking Care of
the Unexpected .. 211
Technical Descriptions
Emission Control
Systems ........ 250
Index
Three Way Catalytic
Converter ................................
252
Temperature Gauge ........................ 4 7
Tensioners,
Seat Belts .................... 37
Three Way Catalytic Converter ... 251
Tire Chains ..................................... 191
Tire, How to Change a Flat .......... 213
Tires ................................................ 185
Air Pressure ............................... 185
Balancing .................................... 188
Checking Wear .......................... 188
Compact Spare Tire .................. 212
DOT Tire Quality Grading ....... 246
Inflation .......................................
185
Inspection ................................... 187
Replacing .................................... 189
Rotating ....................................... 188
Snow ............................................ 191
Specifications ............................. 245
Technical Information ..............
241
Tools, Tire Changing .................... 213
CONTINUED
VII