oil temperature HONDA S2000 2000 1.G Owners Manual
[x] Cancel search | Manufacturer: HONDA, Model Year: 2000, Model line: S2000, Model: HONDA S2000 2000 1.GPages: 273, PDF Size: 21.58 MB
Page 42 of 273
Your car's exhaust contains carbon
monoxide gas.
You should have no
problem with carbon monoxide
entering the car in normal driving
if
you maintain your car properly.
Have the exhaust system inspected
for leaks whenever:
• The car is raised for an oil change.
• You notice a change in the sound
of
the exhaust.
• The car was in an accident that
may have damaged the underside.
Carbon monoxide gas is toxic.
Breathing it can cause
unconsciousness and even
kill
you.
Avoid any
enclosed areas or
activities that expose you to
carbon monoxide.
High levels of carbon monoxide can
collect rapidly in enclosed areas,
such as a garage. Do not run the
engine with the garage door closed.
Even with the door open, run the
engine only long enough to move the
car out of the garage.
Carbon Monoxide Hazard
With the trunk lid open, air flow can
pull exhaust gas into your vehicle's
interior and create a hazardous
condition.
If you must drive with the
trunk lid open, open
all the windows
and set the heating and cooling
system as shown below.
If you must sit in your parked car,
even
in an unconfined area, with the
engine running, adjust the heating
and cooling system as follows:
1. Push the ~ button.
2. Select the w mode.
3. Turn the fan on high speed.
4. Set the temperature control to a
comfortable setting.
Driver and Passenger Safety 39
Page 153 of 273
Service at the indicated miles x 1,000 15 30 45 60 75 90 105 120 distance or time -whichever km x 1,000 24 48 72 96 120 144 168 192 --~-~ comes first. months 12 24
36 48 60 72 84
96 Replace engine oil and oil filter Replace every 3,750 miles (6,000 km) or 6 months
Check engine oil and coolant Check oil and coolant at each fuel stop Replace air cleaner element • • r-·-. . . ·~ • • Use normal schedule except in dusty
conditions Inspect valve clearance Adjust only if noisy • Replace spark plugs • -·~-~-·-· ~~-~ f-----Inspect drive belt •
• • • Inspect idle speed I • --Replace engine coolant • • • -----Replace transmission fluid • •
• • Replace rear differential fluid • • • •
• •
• • Inspect front and rear brakes Inspect every 7,500 miles. (12,000 km) or 6 months
Replace brake fluid • -+-• Check parking brake adjustment • •
• • • • • • Replace air conditioning filter 1
" 1 •
•
• • i -~I-Lubricate al_~!lir1J:JeS, locks and latches • • • • • • • • Check tire inflation and condition Every 7,500 miles (12,000 km) Visually inspect the following items:
Tie rod ends, steering gear box, and boots Every 7,500 miles (12,000 km) or 6 months Suspension components, Drives haft boots -----r----~~ Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Cooling system hoses and connections • • • • • • • • Exhaust system", Fuel lines and connections'
1 Lights and controls, Vehicle underbody
* 1: Refer to page183 for replacement information under special driving conditions.
150 Maintenance
U.S. Owners
Follow the Severe Conditions
Maintenance Schedule if you
drive your vehicle
MAINLY
under one or more of the
following conditions:
• Driving less than 5 miles (8
km) per trip or, in freezing
temperatures, driving less
than
10 miles (16 km) per trip.
• Driving in extremely hot
[over
90° F (32° C)] conditions.
• Extensive idling or long
periods of stop-and-go driving.
• Driving in mountainous
conditions.
• Driving on muddy, dusty, or
de-iced roads.
Canadian Owners
Follow the Maintenance
Schedule for Severe Conditions.
#: See information on maintenance and
emissions warranty, last column, page 147.
Page 154 of 273
Use this schedule if your vehicle is MAINLY driven in any of the following Severe Conditions, or normally driven in Canada; otherwise use the Normal Schedule. Service at the indicated distance or time, whichever comes first. Do the items in A, B, C, D as required for each distance/time.
3,750 mi/6,000 km/6 mos Do items in A. 7,500 mi/12,000 km/- Do items in A, B. 11,250 mi/18,000 km/-
Do items in A. 15,000 mi/24,000 km/1 yr Do items in A, B, C. 18,750 mi/30,000 km/- Do items in A. 22,500 mi/36,000 km/1% yrs Do items_in_A,Jt .. ~--------· ---~~---26,250 mi/42,000 km/-Do items in A. 30,000 mi/48,000 km/2 vrs Do items in A, B, C, D. 33,750 mi/54,000 km/-
Do items in A. 37,500 mi/60,000 km/2'/z vrs
Do items in A, B. 41,250 mi/66,000 km/-
Do items in A. 45,000 mi/72,000 km/3 yrs DReplace brake fluid. DReplace coolant. Do items in A, B, C. 48,750 mi/78,000 km/- Do items in A. 52,500 mi/84,000 km/3'/z vrs Do items in A, B. 56,250 mi/90,000 km/-
Do items in A. 60,000 mi/96,000 km/4 vrs _Do items in A, B, C, D. 63,750 mi/102,000 km/-
Do items in A. 67,500 mi/108,000 km/41!2 yrs Do items in A, B. 71,250 mi/114,000 km/-
Do items in A. 75,000 mi/120,000 km/5 yrs ']Replace coolant. Do itefY!S_lll_ A,_B_,_(:, -~--~--78,750 mi/126,000 km/-
Do items in A.
Note: • Check engine oil and coolant at each fuel stop. • Check and adjust valve clearance, cold engine, if noisy.
·--~
··-
Severe Conditions:
A
B
c
Driving less than 5 mi (8 km) per trip or, in freezing
temperatures, driving less than 10 mi (16 km) per trip.
Driving in extremely hot (over 90°F/32°C) conditions.
Extensive idling or long periods of stop-and-go driving. Driving in mountainous conditions.
Drivin_gon muddy, dusty, or de-iced roads.
[]Replace enqine oil and filter. Dlnspect front and rear brakes. DC heck tire inflation and condition. Dlnspect tie rod ends, steering gear box and boots. Dlnspect suspension components. Dlnspect driveshaft boots. ORe place air cleaner element. ']Check parking brake adjustment. ']Lubricate all hinges, locks and latches. ']Replace rear differential fluid.
CONTINUED
Maintenance 151
Page 161 of 273
Engine Oil
The oil container may also display
the
API Certification seal. Make sure
it says
"For Gasoline Engines."
158 Maintenance
The SAE numbers tell you the oil's
viscosity or weight. Select the
oil for
your car according to this chart.
60
. 10 20
" ~ c" ' -c '
AnlbielltTertlperature
An oil with a viscosity of lOW-30 is
preferred for improved fuel economy
and year-round protection in your
Honda.
You may use a 5W-40 oil if
the temperature in your area goes
below oaF (
-20°C).
Synthetic Oil
You may use a synthetic motor oil if
it meets the same requirements
given for conventional motor
oil:
energy conserving, a service
classification of
SJ, and the proper
weight as shown on the chart. When
using synthetic
oil, you must follow
the
oil and filter change intervals
given
in the maintenance schedule.
Additives
Your Honda does not need any oil
additives. Purchasing additives for
the engine or transmission will not
increase your car's performance or
longevity.
It only increases the cost
of operating your car.
Page 162 of 273
Changing the Oil and Filter
Always change the oil and filter
according to the time and distance
(miles/kilometers) recommenda
tions
in the maintenance schedule.
The oil and filter collect contami
nants that can damage your engine
if
they are not removed regularly.
Changing the
oil and filter requires
special tools and access from
underneath
the car. The car should
be raised on a service station-type
hydraulic lift for this service.
Unless
you have the knowledge and proper
equipment, you should have this
maintenance done by a skilled
mechanic.
1. Run the engine until it reaches
normal operating temperature,
then shut it off.
2. Remove the engine oil fill cap.
Remove the
oil drain bolt from the
bottom of
the engine. Drain the oil
into an appropriate container.
Engine Oil
3. Remove the oil filter and let the
remaining
oil drain. A special
wrench (available from your
Honda dealer) is required to
remove the filter.
4. Install a new oil filter according to
instructions that come with it.
CONTINUED
Maintenance 159
Page 171 of 273
6-speed Manual Transmission Fluid
Check the fluid level with the
transmission at normal operating
temperature and the car sitting on
level ground. Remove the
transmission filler bolt and carefully
feel inside the bolt hole with your
finger.
The fluid level should be up
to the edge of the bolt hole.
If it is
not, add Genuine Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Reinstall
the filler bolt and tighten it securely.
168 Maintenance
If Honda MTF is not available, you
may use an
API service SG, SH or SJ
grade motor oil with a viscosity of
SAE lOW-30 or lOW-40 as a
temporary replacement. An
SG
grade is preferred, but an SH or SJ
grade may be used if SG is not
available. However, motor
oil does
not contain the proper additives and
continued use can cause stiffer
shifting. Replace as soon as
convenient.
The transmission should be drained
and refilled with new fluid according
to the time and distance recommen
dations
in the maintenance schedule.
Page 172 of 273
Check the fluid level with the
differential at normal operating
temperature and the vehicle sitting
onlevelground.Removethe
differential fluid filler bolt and
washer and carefully feel inside the
bolt hole with your finger.
The fluid
level should
be up to the edge of the
bolt hole.
If it is not, slowly add fluid
until it starts to run out of
the hole.
Use a SAE 90 viscosity hypoid gear
oil, API service classified GL5 or
GL6 only, in the differential.
Put a new washer on the filler bolt,
then reinstall the filler bolt. Tighten
it securely. Tightening torque:
33 lbf·ft (45 N·m, 4.6 kgf·m)
The differential should be drained
and refilled with new fluid according
to the time and distance
recommendations in the
maintenance schedule.
Differential Fluid
Maintenance 169
Page 185 of 273
Air Conditioning System
Your car's air conditioning is a sealed
system. Any major maintenance,
such as recharging, should
be done
by a qualified mechanic. You can do
a couple of things to
make sure the
air conditioning works efficiently.
Periodically
check the engine's
radiator and air conditioning
condenser for leaves, insects, and
dirt
stuck to the front surface. These
block the air flow and reduce cooling
efficiency.
Use a light spray from a
hose or a soft
brush to remove them.
NOTICE
The condenser and radiator fins bend
easily. Only use a low-pressure
~pray
or soft-bristle brush to clean them.
182 Maintenance
Run the air conditioning at least once
a
week during the cold weather
months. Run it for at least ten
minutes while you are driving at a
steady speed with
the engine at
normal operating temperature. This
circulates the lubricating oil con
tained in
the refrigerant.
If the air conditioning does not get as
cold
as before, have your dealer
check the system. Recharge the
system with Refrigerant HFC-134a
(R-134a). (See Specifications on page
245.)
NOTICE
Whenever you have the air conditioning
system serviced, make sure the service
facility uses a refrigerant recycling
system. This system captures the
refrigerant
for reuse. Releasing
refrigerant into the atmosphere can
damage the environment.
Page 265 of 273
Index
Brakes,ABS Certification Label ......................... 242
Vinyl ............................................ 207
Operation
.................................... 137 Chains ............................................. 191 Windows ..................................... 208
System
Indicator .................. 44, 139 Change Oil Climate Control System .................. 86
Braking System .............................. 136 Howto ......................................... 159 Clutch Fluid .................................... 171
Break-in, New Car ......................... 116 When to ....................................... 146 CO in the Exhaust ......................... 250
Brightness Control, Instruments ... 52 Changing a Flat Tire ..................... 213 Cold Weather, Starting in ............. 132
Brights, Headlights ......................... 51 Changing Engine Coolant.. ........... 163 Compact Spare Tire ....................... 212
Bulb Replacement... ....................... 192 Charging System Indicator .... 44, 227 Controls, Instruments and .............. 41
Back-up Lights ........................... 198 Check Engine Light ................ 45, 228
Covertible Top ................................. 71
Brake Lights ............................... 198 Checking
Closing the Convertible Top ...... 7 4
Headlights ..................................
195 Battery Condition ...................... 177 Convertible Top Cover. ............... 76
License Plate Lights .................. 200 Brake Fluid ................................. 170 Maintenance ................................. 77
Parking Lights ........................... 196 Clutch Fluid ................................ 171 Opening the Covertible Top ....... 71
Side Marker Lights ................... 198
Drive Belt.. .................................. 184 Coolant
Specifications .............................
245 Engine Coolant.. ......................... 120 Adding ......................................... 161
Turn Signal Lights ..................... 196 Engine Oil.. ................................. 119 Checking ..................................... 120
Bulbs, Halogen ............................... 194 Fuses ........................................... 232 Proper Solution .......................... 161
Manual Transmission Fluid ..... 168 Temperature Gauge .................... 47
c Checklist, Before Driving ............. 115 Corrosion Protection ..................... 208
Cleaner, Air .................................... 172 Crankcase Emission Control
Cables, Jump Starting With ..........
220 Cleaning .......................................... 203 System ......................................... 250
Capacities Chart. ............................ 244
Aluminum Wheels ..................... 206 Cruise Control Operation ............... 55
Carbon Monoxide Hazard .............. 39 Exterior ....................................... 204 Customer Relations
Cargo, Carrying .............................
124 Interior ........................................ 207 Information ................................. 254
CAUTION, Explanation of ............... ii Leather ........................................ 207
CD Changer. ................................... 107 Seat Belts .................................... 207
II
Page 266 of 273
Index
D In Bad Weather. ......................... 140 Malfunction Indicator
In Foreign Countries .................
249 Lamp ................................. 45, 228
DANGER, Explanation of.. ............... ii Oil Pressure Indicator ......... 44, 226
Dashboard ........................................
42 E Oil, What Kind to Use ............... 157
Daytime Running Lights ................. 52 Overheating ................................ 223
Dead Battery, What to Do ............ 220 Economy, Fuel ............................... 121 Specifications ............................. 244
Defects, Reporting
Safety ............. 258 Emergencies on the Road ............. 211 Engine Cover, Opening the .......... 118
Defrosting
the Windows ................. 91 Battery, Jump Starting .............. 220 Ethanol in Gasoline ....................... 248
Dimensions ..................................... 244 Changing
a Flat Tire .................
213 Evaporative Emission Controls .... 250
Dimming the Headlights ................ 51 Charging System Indicator ...... 227 Exhaust Fumes ................................ 39
Dipstick Checking the Fuses ................... 232 Expectant Mothers, Use of Seat
Engine Oil.. ................................. 119 Closing the Convertible Top .... 230 Belts by ......................................... 17
Directional Signals ........................... 53 Low Oil Pressure Indicator ...... 226 Exterior,
Cleaning the ................... 204
Disabled, Towing Your Car If ...... 238 Malfunction Indicator Lamp .... 228
Disc Brake
Wear Indicators ......... 136 Overheated Engine ................... 223 F
Disposal of Used Oil.. .................... 160 Emergency Brake ............................ 80
Do Not Tow a Trailer .................... 141 Emergency Flashers ....................... 79 Fabric, Cleaning ............................. 207
Doors Emission
Controls ......................... 250 Fan, Interior ...................................... 86
Locking and Unlocking ............... 62 Engine Features, Comfort and
Monitor Light.. .............................
45 Check Engine Light ............ 45, 228 Convenience
................................. 85
Power Door Locks ....................... 62 Compartment, Checking Filling the Fuel Tank ..................... 117
DOT Tire Quality Grading ........... 246
in the ....................................... 118
Downshifting, 6-speed Manual Coolant ........................................ 120
Transmission .............................. 134 Coolant Temperature Gauge ..... 4 7
Driving ............................................
129 Drive Belt. ................................... 184
Economy ..................................... 121 CONTINUED
Ill