boot Hyundai H-1 (Grand Starex) 2003 Owner's Manual

PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
6-8 GASOLINE DIESEL
E VERY
Except E.C EV ERY 3,000 KM
5,000 KM EV ERY 4,000 KM (Except 2.5 CRDi)
or 3 MONTHS EV ERY 7,500 KM or 6 MONTHS (2.5 CRDi only)
MORE FREQUENTLY
MORE FREQUENTLY
EV ERY 60,000 K M or 4 8 MONTHS (Except 2.5 CRDi)
MORE FREQUENTLY
MORE FREQUENTLY
EV ERY 10,000 K M o r 6 MONTHS
MORE FREQUENTLY
EV ERY 100,000 K M
EV ERY 40,000 K M
EV ERY 45 ,000 K M
R R R R
I II
RR R
G070A06P-GAT
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
MAINTENANCE UNDER SEVERE USAGE CONDITIONS MAINTENANCE UNDER SEVERE USAGE CONDITIONS
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer to the chart below for the appropriate
maintenance intervals.
R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
ENGINE OIL AND FILTER AIR CLEANER FILTER SPARK PLUGS TIMING BELT BRAKE PADS, CALIPERS, ROTORSREAR BRAKE DRUMS/LININGSSTEERING GEAR BOX, LINKAGE & BOOTS
AIR FILTER (F o r Evaporator and Blower unit)
MANUAL TRANSMISSION OIL AUTOMATIC TRANSMISSION OIL A, B, C, F, H C, E B, H D, E, F, G C, D, G, HC, D, G, HC, D, E, FC,EA, C, D, E, F, G, H, I, J A, C, E, F, G, H, I
SEVERE DRIVING CONDITIONS
SEVERE DRIVING CONDITIONS SEVERE DRIVING CONDITIONS
SEVERE DRIVING CONDITIONS
SEVERE DRIVING CONDITIONS
A - Repeated short distance driving
B - Extensive idling
C - Driving in dusty conditions
D - Driving in areas using salt or other corrosive materials or in very cold weatherE - Driving in sandy areas
F - More than 50% driving in heavy city traffic during hot above 32°C (90°F)
G - Driving in mountainous areas
H - Towing a trailer or police car, taxi, or commercial type operation
I - Driving for patrol car, taxi, commercial car or vehicle towing
J - Driving over 170 km/h
For E.C
MAINTENANCE ITEM MAINTENANCE
OPERATION MAINTENANCE
INTERVALS DRIVING
CONDITION
Except E.C For E.C

PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
6-10 G080N01P-GAT
oo
oo
o Brake hoses and lines
Brake hoses and lines Brake hoses and lines
Brake hoses and lines
Brake hoses and lines
Visually check for proper installation, chafing, cracks, deterioration and any leakage. Replaceany deteriorated or damaged parts immedi-ately. G080O01P-GAT
oo
oo
o Brake fluid
Brake fluid Brake fluid
Brake fluid
Brake fluid
Check brake fluid level in the brake fluid reser- voir. The level should be between "MIN" and"MAX" marks on the side of the reservoir. Useonly hydraulic brake fluid conforming SAEJ1703. G080P01P-GAT
oo
oo
o Rear brake drums and linings
Rear brake drums and linings Rear brake drums and linings
Rear brake drums and linings
Rear brake drums and linings
Check for scoring, burning, leaking fluid, bro- ken parts, and excessive wear. G080Q01P-GAT
oo
oo
o Brake pads, calipers and rotors
Brake pads, calipers and rotors Brake pads, calipers and rotors
Brake pads, calipers and rotors
Brake pads, calipers and rotors
Check the pads for excessive wear, discs for run out and wear, and calipers for fluid leakage. G080R01P-GAT
oo
oo
o
Parking brake
Parking brake Parking brake
Parking brake
Parking brake
Inspect the parking brake system such as parking brake lever, cables, and so on. Fordetailed service procedures, refer to the ShopManual. G080S01P-GAT
oo
oo
o
Exhaust pipe connections,
Exhaust pipe connections, Exhaust pipe connections,
Exhaust pipe connections,
Exhaust pipe connections,
muffler and suspension bolts
muffler and suspension bolts muffler and suspension bolts
muffler and suspension bolts
muffler and suspension bolts
Check the exhaust pipe, muffler, and suspen-sion connections for looseness or damage. G080T01P-GAT
oo
oo
o
Steering gear box, linkage and boots
Steering gear box, linkage and boots Steering gear box, linkage and boots
Steering gear box, linkage and boots
Steering gear box, linkage and boots
With the vehicle stopped and engine off, check for excessive free-play in the steering wheel.Check the linkage for bends or damage. Checkthe dust boots and ball joints for deterioration,cracks, or damage. Replace any damaged parts. G080U01P-GAT
oo
oo
o Wheel bearing grease
Wheel bearing grease Wheel bearing grease
Wheel bearing grease
Wheel bearing grease
Check the wheel bearings and grease accord- ing to the maintenance schedule. For inspec-tion procedures, see Shop Manual.
G080J01P-GAT
oo
oo
o Engine coolant
Engine coolant Engine coolant
Engine coolant
Engine coolant
The coolant should be changed at those inter-
vals specified in the Vehicle Maintenance Re-quirements Section.
G080K01P-GAT oo
oo
o
Timing belt
Timing belt Timing belt
Timing belt
Timing belt
Inspect all parts related with the timing belt for
damage and deformation. Replace any dam-aged parts.
G080L01P-GAT oo
oo
o Manual transmission oil
Manual transmission oil Manual transmission oil
Manual transmission oil
Manual transmission oil
Check manual transaxle oil according to the
maintenance schedule.
NOTE:
NOTE: NOTE:
NOTE:
NOTE:
If the oil level is low, check for possible
If the oil level is low, check for possible If the oil level is low, check for possible
If the oil level is low, check for possible
If the oil level is low, check for possible leaks before adding oil. Do not overfill.
leaks before adding oil. Do not overfill. leaks before adding oil. Do not overfill.
leaks before adding oil. Do not overfill.
leaks before adding oil. Do not overfill.
G080M02P-GAT oo
oo
o
Automatic transmission fluid
Automatic transmission fluid Automatic transmission fluid
Automatic transmission fluid
Automatic transmission fluid
The fluid level should be in the "HOT" range of
the dipstick, after engine and transaxle are at normal operating temperature. Check the Auto-matic Transaxle Fluid level with the enginerunning and the transaxle in neutral, with theparking brake properly applied. Use GENUINEHYUNDAI ATF AUTOMATIC TRANSMISSIONFLUID, DIAMOND ATF DEXRON II or DIA-
MOND ATF SP I when adding or changing
fluid.