engine coolant JAGUAR XJ 2004 X350 / 3.G Owners Manual
[x] Cancel search | Manufacturer: JAGUAR, Model Year: 2004, Model line: XJ, Model: JAGUAR XJ 2004 X350 / 3.GPages: 227, PDF Size: 4.22 MB
Page 13 of 227
Owner Information 1 - 9
Protect the Environment
We must all play our part in protecting
the environment. Correct vehicle usage
and disposal of waste cleaning and
lubrication materials are significant steps
towards this aim.
Avoid using high engine speeds. You will
then protect your engine, reduce fuel
consumption, lower the engine noise
level and help towards reducing the
environmental burden.
Dispose of batteries, tyres, engine, brake
and coolant fluids at your local
authorised waste disposal facilities.
Window Tinting
!WARNING:
Do not have your vehicle windows
tinted with a metal oxide tinting (for
maximum heat reduction from sun
load).
Metal oxide tinting prevents the
reception of the Global Positioning
Satellite (GPS) signals by the antenna
causing the navigation system to stop
functioning.
Metal oxide tinting also prevents the
reception of the Remote Keyless Entry
(RKE) signals by the antenna, causing
reduced operation of the arming/
disarming/locking/unlocking system of the
vehicle.
A non-metal tinting should be used if you
require window tinting and if in doubt,
contact your Jaguar Retailer for advice.
Window marking
It is a worthwhile precaution to have the
vehicle registration number etched into
each window glass by a Jaguar Retailer.
Mobile/Portable
Telephones
!WARNING:
Using a mobile/portable telephone
without an exterior antenna is not
recommended when driving as the
electro-magnetic fields produced can
cause malfunctions with the vehicle
electronic systems.
Check the laws and regulations on the
use of cellular telephones in the areas
where you drive. Always obey them. Also,
give full attention to driving.
Use hands-free operation (if fitted) and
pull off the road and park before making
or answering a call, if driving conditions
so require.
Page 75 of 227
4-4 On the Road
Engine Temperature (E)
Drive at moderate road and engine
speeds until normal operating
temperature is reached. This is indicated
when the pointer is between the
blue (cold) segment and the red (hot)
segment.
The engine operating temperature will
vary with changes in weather and engine
load. The engine temperature may rise in
some circumstances, such as:
• Idling for long periods in slow moving traffic.
• Driving up a long hill in hot weather.
• Driving slowly or stopping after driving at high speed.
• Towing a trailer or caravan.!WARNING:
1. The radiator cooling fans may continue to run after the ignition
has been switched off but will
automatically switch off when the
engine has cooled sufficiently.
2. It is unsafe to run the engine in an overheated condition.
3. Do not remove the coolant reservoir filler cap while the
engine is hot. If it is essential, then
protect your hands against
escaping steam. SLOWLY turn the
cap anti-clockwise to allow the
steam pressure to escape
completely before removing the
cap. Should the pointer move into the red
segment (
H) of the coolant gauge, stop
the vehicle as soon as it is safely possible,
turn off the engine and open the hood to
allow the engine to cool.
Page 87 of 227
4-16 On the Road
Messages
The table on this and the following pages lists all messages and warning lights and explains their meaning.
Message Warning
Light Priority
Indicator Meaning
LOW BRAKE FLUID Brake Red Displayed when the brake fluid level is low. Complete loss of braking may occur.
!WARNING:
DO NOT drive the vehicle until the fault is rectified. Consult a Jaguar
Retailer immediately.
ENGINE
COOLANT LOW None Red Displayed when the coolant level in
the reservoir is too low or is empty.
Check temperature gauge often. The coolant reservoir should be topped up at the
earliest opportunity and any leaks repaired.
CATS SYSTEM FAULT None Amber Displayed when a fault is detected in the adaptive damping (CATS) system (only those vehicles fitted with adaptive damping suspension). Report the fault to a
Jaguar Retailer at the earliest opportunity.
RESTRICTED
PERFORMANCE None Red This will be displayed when the vehicl
e has possible loss of power or driveability.
Report the fault to a Jaguar Retailer.
ENGINE SYSTEMS FAULT Malfunction
Indicator lamp Red Displayed when the engine has defaulted to ‘limp-home’ mode.
Report the fault to a Jaguar Retailer at the earliest opportunity.
Page 131 of 227
4-60 On the Road
Use of Headlamps In Daylight
When visibility is poor the headlamps
with dipped beam setting should be
switched on so that the vehicle may be
seen more easily by other road users.
The instrument illumination dimmer
control adjusts the brightness of the panel
lighting.
Engine Oil Consumption
A certain amount of oil consumption is
normal. The rate of consumption will
depend on the following:
• The quality and viscosity of the oil.
• The amount of oxidation and dilution of the oil.
• Climatic conditions.
• The speed at which the engine is being operated.
• Road conditions.
Drivers should expect above normal
consumption when the engine is new,
and after running-in if high speeds are
sustained.
Winter Driving
Freeing a frozen door lock
Caution: Do not ap ply a proprietary
lock de-icer through the keyhole.
Should the lock beco me frozen, warm the
end of the key before use.
Windscreen wiper blades
Before driving away, clear any ice from
the windscreen and check that the wiper
blades are free. Switching on the heated
screen will accelerate this process.
The heated wiper park, if fitted, will come
on automatically.
Frost precautions
The correct concentration of coolant
must be maintained at all times when
‘topping up’ or ‘refilling’ the cooling
system.
Parking the Vehicle
When leaving the vehicle, remember the
following:
• Whenever the vehicle is being parked, apply the parkbrake and move the
gear selector to Park ‘P’.
• Do not leave children or pets in the vehicle unattended.
• Do not leave luggage or valuables on view. Always take your valuables with
you or lock them in the luggage
compartment.
• Remove the ignition key and spare keys, even when the vehicle is in your
garage.
• When the vehicle is unoccupied, close
all windows and lock all doors
securely.
• Park the vehicle where it can be seen. At night, park in a well-lit area.
• Ensure that the keys and the key transmitters are removed from the
vehicle before locking the doors,
and that all doors, the luggage
compartment and the hood are
closed.
Page 184 of 227
Maintenance
Regular Checks . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 3
Hood Release . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 4
Checking and Top Up . . . . . . . . . . . . . . . . . . . . . 7 - 6
Check Engine Oil Level . . . . . . . . . . . . . . . . . . . . 7 - 6
Check Power Steering Fluid Level . . . . . . . . . . . . 7 - 8
Check Brake Fluid Reservoir . . . . . . . . . . . . . . . . 7 - 9
Check Windscreen/Headlight Washer Reservoir. . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 10
Check Coolant Level . . . . . . . . . . . . . . . . . . . . . 7 - 11
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 12
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 13
Battery Warning Signs. . . . . . . . . . . . . . . . . . . . 7 - 14
Check/Top Up Battery Electrolyte . . . . . . . . . . . 7 - 15
Windscreen Wipers . . . . . . . . . . . . . . . . . . . . . 7 - 17
Tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 18
Tyre Pressures . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 18
Vehicle Care . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 22
Interior Care . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 22
Exterior Care . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 23
Electrical Accessories . . . . . . . . . . . . . . . . . . . . 7 - 25
Page 186 of 227
Maintenance 7 - 3
7 Maintenance
Regular Checks
In the interests of safety and reliability,
it is advisable to carry out the following
checks at the recommended intervals,
and always before starting on a long
journey.
Daily
Check that there is sufficient fuel for the
journey intended, particularly at night
and before joining motorways.
Weekly
Tyres– Check the tyres, including the
spare, for condition and pressure.
Tyre pressures are explained on page 8 - 8
and shown on a label inside the fuel filler
flap.
Lights – Check that all exterior lights and
direction indicators function correctly
and that the lenses are clean.
Engine oil – With the vehicle standing
on level ground, check the oil level and
top up if necessary with oil of the correct
grade.
Engine coolant – With the engine cold,
check the level of the coolant in the
coolant reservoir header tank. Any loss of
fluid must be checked by a Jaguar
Retailer. Brake fluid
– Check the level of the fluid
in the brake fluid reservoir. Top up if
necessary with new, unused Jaguar
approved brake fluid.
The reservoir is initially nearly full,
but the level will drop as the brake pads
wear. If the level appears unusually low,
location of the fluid leakage must be
checked by a Jaguar Retailer.
Power steering fluid – With the engine
cold, check the level of the fluid in the
power steering fluid reservoir. Top up if
necessary with fluid of the correct
specification. Any loss of fluid should be
checked by a Jaguar Retailer.
Windscreen washer fluid – Top up
with windscreen washer fluid and clean
soft water. Check the operation of the
washers. It is recommended that you
use Jaguar Windscreen Washer Fluid to
keep the glass clean and also to prevent
the fluid from freezing during cold
weather.
Monthly
Wiper blades – Check the quality of the
wipe. If smearing or juddering is evident,
clean the windscreen and wiper blades.
Used Engine Oil
!WARNING:
Prolonged and repeated contact may
cause serious skin disorders,
including dermatitis and cancer.
Always use a hand cream to protect the
skin from oil contamination.
Avoid contact with the skin as far as
possible and wash thoroughly after any
contact. Keep oils out of reach of
children.
PROTECT THE ENVIRONMENT: It is
illegal to pollute drai ns, watercourses and
soil. Use authorised waste collection
facilities, including civic amenity sites and
garages providing fa cilities for the
disposal of used oi l, oil filters and
batteries. If in doubt, contact your Local
Authority for advice on disposal.
Page 188 of 227
Maintenance 7 - 5
Reservoir and Dipstick Locations V8 Engine
1.Engine oil filler
2. Brake reservoir (concealed by cover)
3. Power steering reservoir 4.
Engine oil dipstick
5. Coolant reservoir
6. Windscreen wash reservoir
Page 194 of 227
Maintenance 7 - 11
Check Coolant Level
Refer to page 7 - 5 for coolant header tank
location.
The coolant level MAX and MIN
indicators are located inside the reservoir
and are only visible when looking into the
filler neck with the cap removed. Check
the level only when the engine is cold.
The coolant level shou ld be between the
MAX and MIN indicators. If persistent
coolant loss is noticed, have a Jaguar
Retailer investigate the cause
immediately.
!WARNING:
Do not remove the coolant header
tank filler/pressure cap while the
engine is hot. If the cap must be
removed, protect the hands against
escaping steam and slowly turn the
cap anti-clockwise until the steam
starts to escape. Leave the cap in this
position until the pressure is
released, and then remove the cap.
Topping up
!WARNING:
Do not allow anti-freeze to make
contact with skin or eyes. If this
happens, rinse the affected area
immediately with plenty of water.
Caution: Anti-freeze will damage
paintwork. Avoid spillage.
Top up with a mixture of 50% water and
50% anti-freeze until the coolant is
between the MAX and MIN indicators
inside the header tank. Use anti-freeze to
specification WSS M97B44, coloured
orange, Extended Life Coolant.
Refit the filler cap and hand-tighten
securely until the ratchet operates. Engine anti-freeze
When used at the correct concentration,
anti-freeze not only protects the engine
from frost damage in winter, it also
provides all year round protection against
internal corrosion.
The cooling system should always be
topped up or refilled with the specified
anti-freeze at the correct concentration.
This 50/50% mixture gives frost
protection for temperatures down to
–40°F (–40°C).
Do not mix any other anti-freeze with
that specified; inferior quality anti-freeze
may be ineffective in maintaining
adequate frost and corrosion protection
to the cooling system.
The coolant solution
may remain in the
cooling system for five years or
156,000 miles (250,000 km) after which
the system should be drained, flushed
and refilled.
Engine block heater
For further information consult your
Jaguar Retailer.
Caution: The fitting of an engine
block heater does not eliminate the
need for anti-freeze under freezing
conditions.
Page 220 of 227
Index
Adaptive cruise control . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 51
Air conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Alarms and audible signals . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
– audible signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
– error signal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 16
– full alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
Alloy wheels – care of . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Anti-freeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
Anti-lock braking system (ABS) . . . . . . . . . . . . . . . . . . . . 4 - 47
Audible warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 10
Automatic car wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 23
Automatic climate control . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Automatic transmission . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 43
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 13
– back-up sounder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
– charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 15
– electrolyte level – check/top up . . . . . . . . . . . . . . . . . . 7 - 15
– lead connection/disconnection . . . . . . . . . . . . . . . . . . 7 - 16
– reconnection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
Brake fluid level check . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 47
Brightwork – polishing . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24 Bulb renewal
– front direction indicator . . . . . . . . . . . . . . . . . . . . . . . 6 - 15
– front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– front parking (side) light . . . . . . . . . . . . . . . . . . . . . . . . 6 - 16
– headlight – dipped beam . . . . . . . . . . . . . . . . . . . . . . . 6 - 15
– headlight – main beam . . . . . . . . . . . . . . . . . . . . . . . . 6 - 16
– number plate light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– rear light assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 19
– side marker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 18
– side repeater indicator . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– top access cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 14
C
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 12
Carpets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 22
Catalytic converters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 68
Checks and top up
– brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
– engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 6
– power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 8
– washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 10
Child restraint tether anchorages . . . . . . . . . . . . . . . . . . 3 - 29
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 23
– door locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 14
Chromework – polishing . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Climate control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Clock adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 32
Coolant level – check/top up . . . . . . . . . . . . . . . . . . . . . . 7 - 11
Cruise (speed) control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 49
Page 221 of 227
Index
Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 25
Direction indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 26
Door window operation . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 29
Dynamic stability control (DSC) . . . . . . . . . . . . . . . . . . . . 4 - 46
E
Earth points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 25
Electrical accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 25
Electronic road toll systems . . . . . . . . . . . . . . . . . . . . . . . . 3 - 9
Emergency brake assist . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 48
Emergency starting
– using jump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 4
Engine
– anti-freeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– block heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– coolant level check . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– oil level check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 6
– temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4
Entry/exit mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 7
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 23
Exterior lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 23
FFire extinguisher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 20
First aid kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 61
Floor mat retention . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 - 10
Foreign travel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 61
Front and rear park distance control . . . . . . . . . . . . . . . . 4 - 36
Fuel and refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 63
– catalytic converters . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 68
– filler flap manual release . . . . . . . . . . . . . . . . . . . . . . . 4 - 66
– fuel economy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 65
– level gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 3
– requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 64
– tank capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 65
– tank filling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 63
– unleaded fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 66
Fuses and fuse boxes
– cabin fuse box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 26
– checking and renewing a blown fuse . . . . . . . . . . . . . . 6 - 21
– engine compartment fuse box . . . . . . . . . . . . . . . . . . . 6 - 24
– fuse box locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 22
– fuse positions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 23
– trunk fuse box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 29
G