cooling KIA CADENZA 2011 User Guide

Maintenance
8
7
NORMAL MAINTENANCE SCHEDULE (CONT.)
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.* 5
: Inspect for excessive valve noise and/or engine vibration and adjust if necessary. An authorized KIA dealer should perform
the operation.
* 6
: The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule
depends on fuel quality. If there are some important matters like fuel flow restriction, surging, loss of power, hard starting
problem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorized KIA dealer for
details.
Number of months or driving distance, whichever comes first
Months1224364860728496
Miles×1,0001020304050607080
Km×1,000153045607590105120
Valve clearance * 5I
Vapor hose and fuel filler capII
Fuel tank air filter (if equipped)IRIR
Vacuum hoseIIIIIIII
Fuel filter *6IRIR
Fuel lines, hoses and connectionsII
Cooling system
Inspect “Coolant level and leak” every day
At first, inspect 60,000 km (40,000 miles) or 48 months
after that, inspect every 30,000 km (20,000 miles) or 24 months
MAINTENANCE INTERVALS
MAINTENANCE ITEM

Maintenance
14
7
Air cleaner filter
A Genuine KIA air cleaner filter is recom- mended when the filter is replaced. Spark plugs
Make sure to install new spark plugs of
the correct heat range.
Valve clearance
Inspect excessive valve noise and/or
engine vibration and adjust if necessary.
An authorized KIA dealer should perform
the operation. Cooling system
Check cooling system components, such
as radiator, coolant reservoir, hoses and
connections for leakage and damage.
Replace any damaged parts. Coolant The coolant should be changed at the
intervals specified in the maintenance
schedule.
Automatic transaxle fluid
An automatic transaxle fluid should not
be checked under normal usage condi-
tions.
But in severe conditions, the fluid should
be changed at an authorized KIA dealerin accordance to the scheduled mainte-
nance at the beginning of this chapter.✽✽
NOTICE
An automatic transaxle fluid color is
basically red.
As the vehicle is driven, the automatic
transaxle fluid will begin to look darker.
It is normal condition and you should
not judge the need to replace the fluid
based upon the changed color.
CAUTION
The use of a non-specified fluid could result in transaxle malfunc- tion and failure.
Use only specified automatictransaxle fluid. (Refer to
“Recommended lubricants andcapacities” in section 8.)

Maintenance
18
7
ENGINE COOLANT
The high-pressure cooling system has a
reservoir filled with year-round antifreeze
coolant. The reservoir is filled at the fac-
tory.
Check the antifreeze protection and
coolant level at least once a year, at thebeginning of the winter season, and
before traveling to a colder climate. Checking the coolant level
WARNING
- Removing
radiator cap
Never attempt to remove the radi- ator cap while the engine is oper-
ating or hot. Doing so might leadto cooling system and engine
damage and could result in seri-
ous personal injury from escap-ing hot coolant or steam.
Turn the engine off and wait until it cools down. Use extreme care
when removing the radiator cap.
Wrap a thick towel around it, and
turn it counterclockwise slowly to
the first stop. Step back while the
pressure is released from the
cooling system. When you aresure all the pressure has been
released, press down on the cap,
using a thick towel, and continue
turning counterclockwise to
remove it.
(Continued)
(Continued)
Even if the engine is not operat-ing, do not remove the radiator cap or the drain plug while the
engine and radiator are hot. Hot
coolant and steam may still blow
out under pressure, causing seri-
ous injury.

719
Maintenance
Check the condition and connections of all cooling system hoses and heater
hoses. Replace any swollen or deterio-
rated hoses.
The coolant level should be filled
between F and L marks on the side of the
coolant reservoir when the engine iscool.
If the coolant level is low, add enough
specified coolant to provide protection
against freezing and corrosion. Bring the
level to F, but do not overfill. If frequent
additions are required, see an authorized
KIA dealer for a cooling system inspec-tion.
Recommended engine coolant
When adding coolant, use only deion-ized water or soft water for your vehicle
and never mix hard water in the
coolant filled at the factory. An improp-
er coolant mixture can result in serious
malfunction or engine damage.
The engine in your vehicle has alu- minum engine parts and must be pro-
tected by an ethylene-glycol-based
coolant to prevent corrosion and freez-ing.
DO NOT USE alcohol or methanol coolant or mix them with the specifiedcoolant.
Do not use a solution that contains more than 60% antifreeze or less than
35% antifreeze, which would reduce
the effectiveness of the solution. For mixture percentage, refer to the fol-
lowing table.
-15°C (5°F) 35 65
-25°C (-13°F) 40 60
-35°C (-31°F) 50 50
-45°C (-49°F) 60 40
Ambient
Temperature Mixture Percentage (volume)
Antifreeze Water
OVG079005L

753
Maintenance
DescriptionSymbolFuse ratingProtected component
FUSE
SPARE30A-
IGN 230A[W/O Smart Key] Ignition Switch, RLY. 3 (Start1 Relay),
[With Smart Key] RLY. 3 (Start1 Relay), RLY. 10 (IG2 Relay)
B+140AIPM (Fuse - F4/ F12/ F18/ F35, Power Connector - F27/ F28)
240AEMS Box (Fuse - F35/ F36/ F37/ F38)
30AESP Control Module, ABS Control Module
10AIPM, RLY. 11 (Wiper Relay), Front Wiper Motor
AMS10A(Not Used)
20AICM Relay Box (Head Lamp Washer Relay)
320APCM (G4KE)
STOP LP15AStop Lamp Switch
20ARLY. 7 (Front Wiper Deicer Relay)
DIAGNOSIS20AMultipurpose Check Connector
40ARLY. 4 (Cooling Fan (Low) Relay), RLY. 5 (Cooling Fan (High) Relay)

Maintenance
54
7
DescriptionSymbolFuse ratingProtected component
FUSE
IGN COIL20AIgnition Coil #1 /#2 /#3 /#4 (G4KE), Ignition Coil #1 /#2 /#3 /#4 /#5 /#6 (G6DC), Condenser (G4KE), Condenser #1 /#2 (G6DC)
SENSOR115AG4KE : Immobilizer Module, Camshaft Position Sensor #1 /#2, Crankshaft Position Sensor,
Oil Control Valve #1 /#2, Canister Purge Control Solenoid Valve
Variable Intake Manifold Valve, G6DC : Immobilizer Module, PCM, Oxygen Sensor #1 /#2 /#3 /#4
SENSOR215AG4KE : Oxygen Sensor (Up)/(Down), RLY. 5 (Cooling Fan (High) Relay)
G6DC : PCM, Oil Control Valve #1 /#2, Canister Purge Control Solenoid Valve,
Variable Intake Manifold Valve #1 /#2, RLY. 5 (Cooling Fan (High) Relay)
INJECTOR15AInjector #1/ #2/ #3/ #4 (G4KE), Injector #1/ #2/ #3/ #4/ #5/ #6 (G6DC), PCM (G6DC),
RLY. 16 (Fuel Pump Relay)
F/PUMP20ARLY. 16 (Fuel Pump Relay)
410APCM, Alternator (G6DC)
15ARLY. 13 (Burglar Alarm Horn Relay), RLY. 15 (Horn Relay)
530ARLY. 17 (Engine Control Relay)
SPARE25A-
SPARE20A-
SPARE15A-
SPARE10A-

I3
Index
Center console storage ·················································4-111
Central door lock switch················································4-16
Changing tires ··································································6-9Chains
Tire chains ·································································5-39
Checking tire inflation pressure·····································7-34
Child restraint system ····················································3-25
Child-protector rear door lock ·······································4-18
Climate control system (Automatic) ···························4-100 Air conditioning ······················································4-106
Automatic heating and air conditioning··················4-101
Manual heating and air conditioning ······················4-102
Climate control system (Manual) ··································4-91
Air conditioning ························································4-96
Climate control air filter············································4-98
Heating and air conditioning ·····································4-92
Cigarette lighter ···························································4-113
Climate control air filter ······································4-98, 7-26
Clock (Digital) ·····························································4-116
Clothes hanger ·····························································4-118
Combined instrument, see instrument cluster ···············4-43
Compact spare tire ·························································6-14
Compact spare tire replacement ····································7-38
Control switch (Outside rearview mirror) ·····················4-41
Coolant ···········································································7-18
Cooling fluid, see engine coolant ··································7-18
Crankcase emission control system ·······························7-69
Cruise control system ····················································5-28 Cup holder ···································································4-114
Cushion extension ····························································3-6
Curtain air bag ·······························································3-40
Dashboard, see instrument cluster ·································4-43
Dashboard illumination, see instrument panel
illumination ·······························································4-44
Defogging logic (Windshield) ·····································4-109 Auto defogging system ···········································4-110
Defroster (Rear window) ···············································4-90
Digital clock·································································4-106
Dimensions ······································································8-2
Displays, see instrument cluster ····································4-43
Display illumination, see instrument panel illumination··4-44
Door locks······································································4-15 Central door lock switch ···········································4-16
Child-protector rear door lock ··································4-18
Drink holders, see cup holders ····································4-114
Driver position memory system·····································4-34 Easy access function ·················································4-35
Driver's air bag·······························································3-37
Driving at night ······························································5-35
Driving in flooded areas ················································5-36
Driving in the rain··························································5-36
D