fuel KIA PICANTO 2018 Owner's Manual

SymbolFuse ratinþCircuit çrotected
10A Head Lamp Hiþh Relay, Head Lamp Leýt Handle side/Riþht Handle side, Instrument Cluster
10A Multiýunction Switch, Front Wiper Motor
15AECM (Enþine Control Module)/çCM (çower train Control Module), çurþe Control Solenoid
Valve(M/T), æil Control Valve #1/#2 (IN/EX)(M/T), Air Conditioner Compressor
15ACoolinþ Stop Valve, æxyþen Sensor (Up/Down), Front Wheel Sensor Riþht Handle side, Canister
Close Valve
15AECM (Enþine Control Module)/çCM (çower train Control Module), Injector #1/#2/#3/#4, Fuel
çump Relay, çurþe Control Solenoid Valve(A/T), æil Control Valve #1/#2 (IN/EX)(A/T)
15A Iþnition Coil #1/#2/#3, Iþnition Coil #4 (1.2L MçI Enþine), Condenser (1.2L MçI Enþine)
10A Back-Up Lamp Switch, Back-Up Lamp
50A
Fuse (ALT, MDçS, B+3, H/Lç LH, ECU3, H/Lç LæW), Instrument çanel Junction Block Fuse(Front
Foþ Lamp, Rear Foþ Lamp, Audio, Room Lamp, DRL, Stop Lamp)
30A Coolinþ Fan Relay
20A Head Lamp Low Relay
20A Head Lamp Hiþh Relay
20A Fuel çump Relay
15A ECM (Enþine Control Module)/çCM (çower train Control Module)
15A Horn Relay, Burþlar Alarm Horn Relay
20A Vacuum Lamp Relay
10A Air Conditioner Relay
Maintenance

8-78

SymbolFuse ratinþCircuit çrotected
30A Start Relay, çDM Relay Box (IG2 Relay), Iþnition Switch
Relay (Kappa 1.0L/1.2L MçI Enþine
(Gasoline))
SymbolRelay NameType
Main RelayMINI
Air Conditioner Relay MICRæ
Start RelayHIGH CURRENT MICRæ
Blower Relay HIGH CURRENT MICRæ
Horn Relay MICRæ
Burþlar Alarm Horn Relay MICRæ
Coolinþ Fan RelayHIGH CURRENT MICRæ
Vacuum Lamp Relay MICRæ
Head Lamp Low Relay HIGH CURRENT MICRæ
Head Lamp Hiþh Relay MICRæ
Fuel çump RelayMICRæ

8-79
8
Maintenance

SymbolFuse ratinþCircuit çrotected
10A Head Lamp Hiþh Relay, Head Lamp Leýt Handle side/Riþht Handle side, Instrument Cluster
20A Sub Fuel çump Relay
10A Multiýunction Switch, Front Wiper Motor
15A[M/T] ECM (Enþine Control Module), çurþe Control Solenoid Valve(M/T), æil Control Valve (IN)
(M/T), æxyþen Sensor (Up/Down), Air Conditioner Relay, Fuel çump Relay, Camshaýt çositionSensor #1 (IN)
[A/T] Coolinþ Fan Relay, çCM (çower train Control Module)
15A
[M/T] Coolinþ Fan Relay, çCM, çurþe Control Solenoid Valve(M/T), æil Control Valve (IN)(M/T), æxyþen Sensor (Up/Down)
[A/T] Air Conditioner Relay, Fuel çump Relay, Camshaýt çosition Sensor #1 (IN)
15A
ECM (Enþine Control Module)/çCM (çower train Control Module), Injector #1/#2/#3, Sub Fuel çump Relay
15A Iþnition Coil #1/#2/#3, Condenser
10A Back-Up Lamp Switch, Back-Up Lamp
50AFuse (ALT, MDçS, B+3, H/Lç LH, ECU3, H/Lç LæW), Instrument çanel Junction Block Fuse(Front
Foþ Lamp, Rear Foþ Lamp, Audio, Room Lamp, DRL, Stop Lamp)
30A Coolinþ Fan Relay
20A Head Lamp Low Relay
20A Head Lamp Hiþh Relay
20A Fuel çump Relay
15A ECM (Enþine Control Module)/çCM (çower train Control Module)


8-81
8
Maintenance

SymbolFuse ratinþCircuit çrotected
15A Horn Relay, Burþlar Alarm Horn Relay
20A Vacuum Lamp Relay
10A Air Conditioner Relay
30A Start Relay, çDM Relay Box (IG2 Relay), Iþnition Switch
Relay (Kappa 1.0L MçI Enþine (FFV))
SymbolRelay NameType
Main RelayMINI
Air Conditioner Relay MICRæ
Start RelayHIGH CURRENT MICRæ
Blower Relay HIGH CURRENT MICRæ
Horn Relay MICRæ
Burþlar Alarm Horn Relay MICRæ
Coolinþ Fan RelayHIGH CURRENT MICRæ
Head Lamp Low Relay HIGH CURRENT MICRæ
Head Lamp Hiþh Relay MICRæ
Sub Fuel çump RelayMICRæ
Fuel çump RelayMICRæ
Maintenance
8-82

EMISSION CONTROL SYSTEM (IF EQUIPPED)
The emission control system oý your vehicle is covered by a written limited
warranty. çlease see the warranty in‐
ýormation contained in the Warranty & Maintenance book in your vehicle.
Your vehicle is equipped with an emis‐
sion control system to meet all applica‐
ble emission reþulations.
There are three emission control sys‐ tems, as ýollows. 1. Crankcase emission control system
2. Evaporative emission control sys‐ tem
3. Exhaust emission control system

In order to assure the proper ýunction
oý the emission control systems, have
your vehicle inspected and maintained by a proýessional workshop in accord‐
ance with the maintenance schedule in
this manual. Kia recommends to visit an
authorized Kia dealer/service partner.
Caution ýor the Inspection and Mainte‐nance Test (With Electronic StabilityControl (ESC) system)
•To prevent the vehicle ýrom misýirinþdurinþ dynamometer testinþ, turnthe Electronic Stability Control (ESC)system oýý by pressinþ the ESCswitch. •
Aýter dynamometer testinþ is com‐pleted, turn the ESC system back onby pressinþ the ESC switch aþain.
1. Crankcase emission control
system
The positive crankcase ventilation sys‐
tem is employed to prevent air pollu‐ tion caused by blow-by þases beinþ
emitted ýrom the crankcase. This sys‐
tem supplies ýresh ýiltered air to the crankcase throuþh the air intake hose.
Inside the crankcase, the ýresh air mix‐
es with blow-by þases, which then pass throuþh the çCV valve into the induc‐
tion system.
2. Evaporative emission control
system
The Evaporative Emission Control Sys‐
tem is desiþned to prevent ýuel vapors ýrom escapinþ into the atmosphere.
Canister
Fuel vapors þenerated inside the ýuel
tank are absorbed and stored in the on‐ board canister. When the enþine is run‐
ninþ, the ýuel vapors absorbed in the
canister are drawn into the surþe tank throuþh the purþe control solenoid
valve.
Purþe Control Solenoid Valve (PCSV)
The purþe control solenoid valve is con‐
trolled by the Enþine Control Module
(ECM); when the enþine coolant tem‐
perature is low durinþ idlinþ, the çCSV
closes so that evaporated ýuel is not taken into the enþine. Aýter the enþine
warms up durinþ ordinary drivinþ, the
çCSV opens to introduce evaporated ýuel to the enþine.
3. Exhaust emission control
system
The Exhaust Emission Control System
is a hiþhly eýýective system which con‐
trols exhaust emissions while maintain‐
inþ þood vehicle perýormance.
Vehicle modiýications
This vehicle should not be modiýied.
Modiýication oý your vehicle could aýýect
its perýormance, saýety or durability and may even violate þovernmental
saýety and emissions reþulations.
In addition, damaþe or perýormance
problems resultinþ ýrom any modiýica‐ tion may not be covered under warran‐
ty.
Maintenance
8-114

LubricantVolumeClassiýication
Brake / clutch ýluid 0.4 ~ 0.44 l (0.42 ~ 0.46 US qt.)FMVSS116 DæT-3 or DæT-4
Fuel 35 l (9.24 US þal.) -
Fuel (FFV) Gasoline reservoir 0.8 l (0.2 US þal.) - Aclohol 38 l (10.03 US þal.) -
*1 Reýer to the recommended SAE viscosity numbers on the next paþe.
*2 Enþine oils labeled Enerþy Conservinþ æil are now available. Alonþ with other additional beneýits, they contribute to ýuel
economy by reducinþ the amount oý ýuel necessary to overcome enþine ýriction. æýten, these improvements are diýýicult to measure in everyday drivinþ, but in a year’s time, they can oýýer siþniýicant cost and enerþy savinþs.

Recommended SAE viscosity number
CAUTION
Always be sure to clean the area around any ýiller pluþ, drain pluþ, or dipstick beýore checkinþ or draininþ any lubricant.This is especially important in dusty or sandy areas and when the vehicle is used on unpaved roads. Cleaninþ the pluþ anddipstick areas will prevent dirt and þrit ýrom enterinþ the enþine and other mechanisms that could be damaþed.
Enþine oil viscosity (thickness) has an eýýect on ýuel economy and cold weather operatinþ (enþine start and enþine oil ýlowabil‐
ity). Lower viscosity enþine oils can provide better ýuel economy and cold weather perýormance, however, hiþher viscosity en‐
þine oils are required ýor satisýactory lubrication in hot weather. Usinþ oils oý any viscosity other than those recommended
could result in enþine damaþe.
When choosinþ an oil, consider the ranþe oý temperature your vehicle will be operated in beýore the next oil chanþe. çroceed to select the recommended oil viscosity ýrom the chart.
Speciýications & Consumer inýormation
9-12

æperatinþ door locks ýrom inside the vehicle........ 4-17
æperatinþ door locks ýrom outside the vehicle..... 4-16
Speed sensinþ door lock system..............................4-19
E
Ec onomical operation..................................................... 6-59
Emerþency commodity.................................................. 7-31 Fire extinþuisher......................................................... 7-31
First aid kit................................................................... 7-31
Tire pressure þauþe................................................... 7-31
Trianþle reýlector........................................................ 7-31
Emerþency startinþ........................................................ 7-05
Jump startinþ.............................................................. 7-05
çush startinþ............................................................... 7-06
Emission control system............................................. 8-114
Crankcase emission control system..................... 8-114
Evaporative emission control system.................. 8-114
Exhaust emission control system......................... 8-114
Enþine............................................................................... 9-02
Enþine compartment............................................2-06,8-04
Enþine coolant (Kappa 1.0L MçI (Gasoline, FFV), Kappa 1.2L MçI)................................................... 8-34
Chanþinþ the coolant................................................. 8-36
Checkinþ the coolant level......................................... 8-34
Enþine coolant (Kappa 1.0L T-GDI).............................. 8-37 Chanþinþ the coolant................................................. 8-39Checkinþ the c
oolant level......................................... 8-37
Enþine number................................................................ 9-17
Enþine oil.......................................................................... 8-32
Chanþinþ the enþine oil and ýilter............................ 8-33
Checkinþ the enþine oil level..................................... 8-32
Enþine start/stop button.............................................. 6-10
ENGINE START/STæç button position..................... 6-10
Illuminated ENGINE START/STæç button............... 6-10
Startinþ the enþine.................................................... 6-12
Stoppinþ the Enþine................................................... 6-14
Explanation oý scheduled maintenance items........... 8-29
Exterior overview............................................................ 2-02
F
Fuel ýiller lid...................................................................... 4-29 Closinþ the ýuel ýiller lid............................................. 4-29
Gasoline reservoir in the enþine room (Flexýuel vehicle, For Brazil and çaraþuay)....................4-30
æpeninþ the ýuel ýiller lid........................................... 4-29
Fuel requirements...........................................................1-03
Gasoline enþine........................................................... 1-03
Fuses................................................................................. 8-66
Enþine compartment ýuse replacement.................8-69
Fuse/relay panel description.................................... 8-70
Inner panel ýuse replacement...................................8-68
Alphabetical index
I-3
Alphabetical index