air filter KIA RIO 2022 User Guide
[x] Cancel search | Manufacturer: KIA, Model Year: 2022, Model line: RIO, Model: KIA RIO 2022Pages: 528, PDF Size: 11.8 MB
Page 403 of 528

Maintenance
16
7
Vacuum crankcase ventilation
hoses
Inspect the surface of hoses for evi-
dence of heat and/or mechanical
damage. Hard and brittle rubber,
cracking, tears, cuts, abrasions, and
excessive swelling indicate deterio-
ration. Particular attention should be
paid to examine those hose surfaces
nearest to high heat sources, such
as the exhaust manifold.
Inspect the hose routing to assure
that the hoses do not come in con-
tact with any heat source, sharp
edges or moving component which
might cause heat damage or
mechanical wear. Inspect all hose
connections, such as clamps and
couplings, to make sure they are
secure, and that no leaks are pres-
ent. Hoses should be replaced
immediately if there is any evidence
of deterioration or damage.
Air cleaner filter
A Genuine Kia air cleaner filter is rec-
ommended when the filter is replaced.
Spark plugs
Make sure to install new spark plugs
of the correct heat range.
When assembling parts, be sure to
wipe the inside and outside of the
boot bottom of the ignition coil and
the insulator of the spark plug with a
soft cloth to prevent contamination of
the spark plug insulator.
Valve clearance (if equipped)
Inspect excessive valve noise and/or
engine vibration and adjust if neces-
sary. An authorized Kia dealer
should perform the operation.
Cooling system
Check the cooling system compo-
nents, such as the radiator, coolant
reservoir, hoses and connections for
leakage and damage. Replace any
damaged parts.
Coolant
The coolant should be changed at
the intervals specified in the mainte-
nance schedule.
Intelligent Variable
Transmission (IVT) fluid
The Intelligent Variable Transmission
(IVT) fluid should not be checked
under normal usage conditions.
But in severe conditions, the fluid
should be changed at an authorized
Kia dealer in accordance to the
scheduled maintenance at the begin-
ning of this chapter.
(Refer to “Maintenance Under Severe
Usage Conditions” this chapter.)
SC PE USA 7.qxp 9/9/2021 6:26 PM Page 16
Page 418 of 528

731
Maintenance
AIR CLEANER
Filter replacement
It must be replaced when necessary,
and should not be washed.
You can clean the filter when inspect-
ing the air cleaner compartment.
Clean the filter by using compressed
air.1. Loosen the air cleaner cover
attaching clips and open the cover. 2. Wipe the inside of the air cleaner.
3. Replace the air cleaner filter.
4. Lock the cover with the cover
attaching clips.
OYB076018
OYB076020OYB076021
SC PE USA 7.qxp 9/9/2021 6:27 PM Page 31
Page 419 of 528

Maintenance
32
7
Replace the filter according to the
Maintenance Schedule.
If the vehicle is operated in extreme-
ly dusty or sandy areas, replace theelement more often than the usualrecommended intervals. (Refer to“Maintenance under severe usageconditions” in this chapter.)
CAUTION - Air filter
maintenance
Do not drive with the air clean- er removed; this will result inexcessive engine wear.
When removing the air cleaner filter, be careful that dust ordirt does not enter the airintake, or damage may result.
Use a Kia genuine part. Use of a non-genuine part coulddamage the air flow sensor.
SC PE USA 7.qxp 9/9/2021 6:27 PM Page 32
Page 420 of 528

733
Maintenance
CLIMATE CONTROL AIR FILTER
Filter inspection
The climate control air filter should
be replaced according to the
Maintenance Schedule. If the vehicle
is operated in severely air-polluted
cities or on dusty rough roads for a
long period, it should be inspected
more frequently and replaced earlier.
When you replace the climate control
air filter, replace it performing the fol-
lowing procedure, and be careful to
avoid damaging other components.1. Open the glove box and removethe stoppers on both sides. 2. With the glove box open, pull the
support strap (1).
OYB076023OYB076022
SC PE USA 7.qxp 9/9/2021 6:27 PM Page 33
Page 421 of 528

Maintenance
34
7
3. Remove the climate control air fil-
ter cover while pressing the lock
on both sides of the cover. 4. Replace the climate control air fil-
ter.
5. Reassemble in the reverse order of disassembly.
When replacing the climate control
air filter, install it properly. Otherwise,
the system may produce noise, and
the effectiveness of the filter may be
reduced.
OSC076007OQL075021
SC PE USA 7.qxp 9/9/2021 6:27 PM Page 34
Page 498 of 528

7111
Maintenance
EMISSION CONTROL SYSTEM
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty
information contained in the
Warranty & Consumer Information
manual in your vehicle.
Your vehicle is equipped with an
emission control system to meet all
applicable emission regulations.
There are three emission control
systems, as follows.
(1) Crankcase emission control sys-tem
(2) Evaporative emission control sys- tem
(3) Exhaust emission control system
In order to assure the proper function
of the emission control systems, it is
recommended that you have your
vehicle inspected and maintained by
an authorized Kia dealer in accor-
dance with the maintenance sched-
ule in this manual. Caution for the Inspection and
Maintenance Test (With Electronic
Stability Control (ESC) system)
To prevent the vehicle from mis-
firing during dynamometer test-
ing, turn the Electronic Stability
Control (ESC) system off by
pressing the ESC switch.
After dynamometer testing is completed, turn the ESC system
back on by pressing the ESC
switch again.1. Crankcase emission control system
The positive crankcase ventilation
system is employed to prevent air
pollution caused by blow-by gases
being emitted from the crankcase.
This system supplies fresh filtered air
to the crankcase through the air
intake hose. Inside the crankcase,
the fresh air mixes with blow-by
gases, which then pass through the
PCV valve into the induction system.
2. Evaporative emission con-trol (including ORVR:
Onboard Refueling Vapor
Recovery)
system
The Evaporative Emission Control
System is designed to prevent fuel
vapors from escaping into the atmos-
phere.
(The ORVR system is designed to
allow the vapors from the fuel tank to
be loaded into a canister while refu-
eling at the gas station, preventing
the escape of fuel vapors into the
atmosphere.)
SC PE USA 7.qxp 9/9/2021 6:31 PM Page 111
Page 518 of 528

Index
2I
Air bag - advanced supplemental restraint system ........3-34Adding equipment to or modifying your air bag-equipped vehicle ......................................................3-62
Air bag warning label ................................................3-62
Air bag warning light ..................................................3-38
Curtain air bag ............................................................3-54
Driver's and passenger's front air bag ........................3-49
How does the air bag system operate ........................3-35
Inflation and non-inflation conditions of the air bag..3-56
Occupant detection system ........................................3-41
Side air bag ................................................................3-52
SRS Care ....................................................................3-61\
SRS components and functions ..................................3-38
Air cleaner ....................................................................7-31\
Filter replacement ......................................................7-31
Air conditioning system ..................................................8-6
Appearance care ..........................................................7-102 Exterior care ..............................................................7-102
Interior care ..............................................................7-108
Automatic climate control system ..............................4-122 Activate upon washer fluid use ..............................4-134
Air Conditioning refrigerant label ............................4-133
Automatic heating and air conditioning ..................4-123
Checking the amount of air conditioner refrigerant and compressor lubricant ..............................................4-132
Climate control air filter ..........................................4-131 Manual heating and air conditioning ........................4-124
System operation ......................................................4-129
Battery........................................................................\
....7-39 For best battery service ..............................................7-39
Recharging the battery ................................................7-40
Reset items ..................................................................7-41
Before driving ..................................................................5-5 Before entering vehicle ................................................5-5
Before starting ............................................................5-5
Necessary inspections ................................................5-5
Blind-Spot Collision Warning (BCW) ..........................5-65 Blind-Spot Collision Warning malfunction andlimitations ................................................................5-70
Blind-Spot Collision Warning operation ....................5-69
Blind-Spot Collision Warning settings ......................5-67
Detecting sensor ..........................................................5-66
Brake fluid ....................................................................7-27\
Checking the brake fluid level ....................................7-27
Brake system..................................................................5-25 Anti-lock Brake System (ABS) ..................................5-30
Electronic Stability Control (ESC) ............................5-31
Good braking practices ..............................................5-38
Hill-start Assist Control (HAC) ..................................5-35
Parking brake ..............................................................5-27
Power brakes ............................................................5-25
A
B
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 2
Page 519 of 528

I3
Index
Vehicle Stability Management (VSM)........................5-36
Bulb wattage ....................................................................8-3
California perchlorate notice ......................................7-114
Checking fluid levels ....................................................7-20
Child Restraint System (CRS) ......................................3-27 Using a child restraint system ....................................3-28
Climate control air filter ................................................7-33 Filter inspection ..........................................................7-33
Consumer assistance (U.S. only) ..................................8-11
Cruise Control (CC) ......................................................5-84 Accelerating temporarily ............................................5-86
Cruise Control operation ............................................5-84
Decreasing set speed ..................................................5-85
Increasing set speed ....................................................5-85
Resuming Cruise Control ..........................................5-87
Temporarily pausing Cruise Control ..........................5-86
Turning off Cruise Control ........................................5-87
Declaration of Conformity ..........................................4-154 FCC ....................................................................\
......4-154
Declaration of conformity ..........................................5-102 The radio frequency components (Rear Corner Radar)complies ..................................................................5-102 Defroster ......................................................................4-\
109
Rear window defroster ..............................................4-109
Dimensions ......................................................................8-\
2
Door locks......................................................................4-\
18 Auto door lock/unlock feature ....................................4-21
Child-protector rear door lock ....................................4-22
Impact sensing door unlock system ............................4-21
Operating door locks from inside the vehicle ............4-19
Operating door locks from outside the vehicle ........4-18
Rear Occupant Alert (ROA) system ..........................4-22
Speed sensing door lock system ................................4-21
Driver Attention Warning (DAW) ................................5-75 Basic function ............................................................5-75
Detecting sensor ..........................................................5-75
Driver Attention Warning malfunction and limitations ................................................................5-81
Driver Attention Warning operation ..........................5-78
Driver Attention Warning settings ..............................5-76
Leading Vehicle Departure Alert ................................5-75
Economical operation ..................................................5-103
Electrical Equipment (U.S. only) ..................................8-14
Emergency starting ..........................................................6-5 Jump starting ................................................................6-5
Push-starting ................................................................6-6
C
D
E
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 3
Page 523 of 528

I7
Index
Light bulb position (Front) ........................................7-74
Light bulb position (Rear) (4 Door) ..........................7-76
Light bulb position (Rear) (5 Door) ..........................7-75
Light bulb position (Side) ..........................................7-77
Map lamp bulb replacement ......................................7-98
Position lamp + DRL (LED type) bulb replacement..7-84
Position lamp bulb replacement (Headlamp Type A)..7-81
Rear turn signal lamp bulb replacement (for 4 door) ..7-93
Rear turn signal lamp bulb replacement (for 5 door) ..7-86
Room lamp bulb replacement ..................................7-100
Side marker (front) (Bulb type) bulb replacement (Headlamp Type A) ..................................................7-82
Side marker (front) (LED type) bulb replacement (Headlamp Type B, C) ..............................................7-84
Side marker (rear) (Bulb type) bulb replacement (Rear combination lamp Type A) (for 5 door) ........7-90
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) (for 4 door) ........7-97
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) (for 5 door) ........7-91
Side repeater lamp (bulb type) bulb replacement ......7-85
Side repeater lamp (LED type) bulb replacement ......7-85
Static bending light replacement (Headlamp Type B, C) ............................................7-82
Stop and tail lamp (LED type) bulb replacement (for 4 door)................................................................7-96
Stop and tail lamp (LED type) bulb replacement (for 5 door)................................................................7-91 Stop and tail lamp / Side marker (Bulb type)
replacement (for 4 door) ..........................................7-94
Stop and tail lamp bulb replacement (for 5 door) ......7-88
Tail lamp (Bulb type) bulb replacement (for 4 door) ..7-95
Tail lamp (inside) bulb replacement (for 5 door) ......7-89
Trunk lamp bulb replacement (for 4 door) ................7-98
Vanity mirror lamp bulb replacement ........................7-99
Lighting........................................................................\
..4-92 Battery saver function ................................................4-92
Front fog light ............................................................4-98
Headlight escort function ............................................4-92
Headlight welcome function ......................................4-92
High Beam Assist (HBA) ..........................................4-96
High beam operation ..................................................4-95
Lighting control ..........................................................4-93
Turn signals and lane change signals ........................4-97
Maintenance services ......................................................7-5 Owner maintenance precautions ..................................7-6
Owner’s responsibility ..................................................7-5
Manual climate control system ....................................4-110 Activate upon Washer Fluid Use ............................4-121
Air Conditioning refrigerant label ............................4-120
Checking the amount of air conditioner refrigerant and compressor lubricant ........................................4-119
Climate control air filter ..........................................4-118
M
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 7