air condition KIA STONIC 2018 Manual PDF

SymbolRelay NameType
A/C Blower RelayMICRO
Engine room compartment fuse panel
(U-II 1.4L/1.6L Engine (Diesel))
SymbolFuse ratingCircuit Protected
80A MDPS Unit
ALT150A Fuse - RR DEFOG, ABS1, ABS2, BLOWER
40A Rear Defogger Relay
140A ABS/ESC (Electronic Stability Control) Control
40A ABS/ESC (Electronic Stability Control) Control, Multipurpose Check Connector
40A Air Conditioner Blower Relay
10A Wiper Motor, Multifunction Switch, Wiper LO Relay
10A PM Sensor, Electronic VGT Actuator, WGT Vacuum Modulator
10A Lambda Sensor #1, #2, Rail Pressure Regulating Valve, Cooling Fan1 Relay, Cooling Fan2 Relay
15A Camshaft Position Sensor, Air Flow Sensor, Oil Control Valve, PTC1 Heater Relay
10A Head Lamp RH
10A Head Lamp LH
Maintenance
8-100

SymbolFuse ratingCircuit Protected
E420A ECM
S315AEGR Cooling Bypass Solenoid, Fuel Pressure Regulating Valve, Stop Lamp Switch, Fuel Pump Relay, A/C Blower Relay, Fuel Heat Relay
10A Back-Up Lamp Switch
40A Instrument Panel Junction Block
50A Instrument Panel Junction Block (Power Window Relay)
40A Ignition Switch, PDM Relay Box (IG2 Relay)
50A Cooling Fan1 Relay, Cooling Fan2 Relay
40A Fuel Heat Relay
30A Main Relay
10A Air Conditioner Clutch Type ECV Relay
20A Not Used
20A Head Lamp Relay
20A Head Lamp High Relay
FUEL
PUMP20A Fuel Pump Relay
15A Horn Relay, Burglar Alarm Horn Relay
E315A ECM/PCM

8-101
8
Maintenance

• If you use unauthorized electronicdevices, it may cause the vehicle to
operate abnormally, wire damage, battery discharge and fire. For your
safety, do not use unauthorized elec‐
tronic devices.
Engine exhaust gas precautions
(carbon monoxide)
• Carbon monoxide can be present with other exhaust fumes. Therefore, if
you smell exhaust fumes of any kind inside your vehicle, have it inspected
and repaired immediately. If you ever
suspect exhaust fumes are coming
into your vehicle, drive it only with all
the windows fully open. Have your vehicle checked and repaired immedi‐
ately.
WARNING
nExhaust
Engine exhaust gases contain carbonmonoxide (CO). Though colorless andodorless, it is dangerous and couldbe lethal if inhaled. Follow the in‐structions on this page to avoid COpoisoning.
• Do not operate the engine in confined or closed areas (such as garages) any
more than what is necessary to move the vehicle in or out of the area.
• When the vehicle is stopped in an open area for more than a short time
with the engine running, adjust the
ventilation system (as needed) to
draw outside air into the vehicle.
• Never sit in a parked or stopped vehi‐ cle for any extended time with the
engine running.
• When the engine stalls or fails to start, excessive attempts to restart
the engine may cause damage to the
emission control system.
Operating precautions for catalytic
converters (if equipped)
WARNING
nFire
(Continued)
(Continued)
•A hot exhaust system can igniteflammable items under your vehi‐cle. Do not park the vehicle over ornear flammable objects, such asgrass, vegetation, paper, leaves,etc.
•The exhaust system and catalyticsystem are very hot while the en‐gine is running or immediately af‐ter the engine is turned off. Keepaway from the exhaust systemand catalytic, you may get burned.Also, do not remove the heat sinkaround the exhaust system, donot seal the bottom of the vehicleor do not coat the vehicle for cor‐rosion control. It may present afire risk under certain conditions.
Your vehicle is equipped with a catalytic
converter emission control device.
Therefore, the following precautions must be observed: • Make sure to refuel your vehicle ac‐ cording to the L

• Do not misuse or abuse the engine.Examples of misuse are coasting with
the ignition off and descending steep grades in gear with the ignition off.
• Do not operate the engine at high idle speed for extended periods (5 mi‐
nutes or more).
• Do not modify or tamper with any part of the engine or emission control
system. All inspections and adjust‐ ments must be made by a professio‐
nal workshop. Kia recommends to
visit an authorized Kia dealer/service
center.
• Avoid driving with an extremely low fuel level. Running out of fuel couldcause the engine to misfire, damag‐
ing the catalytic converter.
Failure to observe these precautions
could result in damage to the catalytic converter and to your vehicle.
Additionally, such actions could void
your warranties.
Diesel particulate filter (if
equipped)
The Diesel Particulate Filter (DPF) sys‐
tem removes the soot in the exhaust gas. Unlike a disposable air filter, the DPF
system automatically burns (oxidizes)
and removes the accumulated soot ac‐ cording to the driving condition. In other
words, the active burning by engine
control system and high exhaust gas temperature caused by normal/high
driving condition burns and removes
the accumulated soot.
However, if the vehicle continues to be driven at repeated short distance or
driven at low speed for a long time, the
accumulated soot may not be auto‐ matically removed because of low ex‐
haust gas temperature. More than a
certain amount of soot deposited, the malfunction indicator light (
) illumi‐
nates.
When the malfunction indicator light
blinks, it may stop blinking by driving
the vehicle at more than 60 km/h (37 mph) or at more than second gear
with 1500 ~ 2500 engine rpm for a cer‐
tain time (for about 25 minutes).
If the malfunction indicator light (
)
continues to be blinked or the warning
massage "Check exhaust system" illu‐ minates in spite of the procedure, visit
a professional workshop and check the
DPF system. Kia recommends to visit an authorized Kia dealer/service part‐
ner. If you continue to drive with the mal‐
function indicator light blinking for a long time, the DPF system can be dam‐
aged and fuel consumption can be wor‐
sen.
CAUTION
Diesel Fuel (if equipped with DPF)It is recommended to use the regula‐ted automotive diesel fuel for dieselvehicle equipped with the DPF sys‐tem.If you use diesel fuel including highsulfur (more than 50 ppm sulfur)and unspecified additives, it cancause the DPF system to be dam‐aged and white smoke can be emit‐ted.
Lean NOx trap (if equipped)
The Lean NOx Trap (LNT) system re‐
moves the nitrogen oxide in the ex‐ haust gas. The smell can occur in the
exhaust gas depending on the quality
of the fuel and it can degrade NOx re‐ duction performance, please use the
regulated automotive diesel fuel.
Maintenance
8-136

Engine..........................................................................................9-02
Dimensions................................................................................. 9-03
Bulb wattage..............................................................................9-04
Tires and wheels....................................................................... 9-06
Weight/Volume.......................................................................... 9-11
Air conditioning system........................................................... 9-12
Recommended lubricants and capacities.............................. 9-13Recommended SAE viscosity number............................... 9-15
Vehicle identification number (VIN)........................................9-17
Vehicle certification label ........................................................ 9-18
Tire specification and pressure label..................................... 9-19
Engine number.......................................................................... 9-20
Air conditioner compressor label............................................ 9-21
Refrigerant label ...................................................................... 9-22
Declaration of conformity....................................................... 9-23
Specifications & Consumer information

9

AIR CONDITIONING SYSTEM
ITEMWeight of volumeClassification
Refrigerant 450 ± 25g R-1234yf
R-134a
Compressor lubricant 120 ± 10cc PAG 30
Please contact a professional workshop for more details.
Kia recommends to contact an authorized Kia dealer/service partner.

Specifications & Consumer information
9-12

AIR CONDITIONER COMPRESSOR LABEL
A compressor label informs you the
type of compressor your vehicle is equipped with such as model, supplier
part number, production number, re‐
frigerant (1) and refrigerant oil (2).

9-21
9
Specifications & Consumer information

A
Air baþ-supplemental restraint system Side air baþ.................................................................. 3-51
Air baþs............................................................................. 3-38
Air baþ warninþ label................................................. 3-62
Air baþ warninþ liþht.................................................. 3-42
Curtain air baþ.............................................................3-53
Driver's and passenþer's ýront air baþ.................... 3-46
SRS components and ýunctions............................... 3-43
Air cleaner........................................................................ 8-58
Air conditioner compressor label.................................. 9-21
Air conditioninþ system................................................. 9-12
Alarm system.................................................................. 4-13
Antenna............................................................................ 5-02
Anti-lock brake system (ABS)...................................... 6-34
Appearance care
Interior care...............................................................8-132
Ashtray........................................................................... 4-126Audio system
Antenna........................................................................ 5-02
Auomatic transaxle
Shiýt lock system........................................................ 6-27
Auto deýoþþinþ system............................................... 4-120
Automatic climate control system............................ 4-108 Air conditioninþ......................................................... 4-113
Automatic heatinþ and air conditioninþ............... 4-109
Manual heatinþ and air conditioninþ..................... 4-110
Automatic transaxle....................................................... 6-24
Sports mode................................................................ 6-25
B
Battery............................................................................. 8-63
Battery saver ýunction...................................................4-80
BCW (Blind-Spot Collision Warninþ) BCW (Blind-Spot Collision Warninþ) / LCA(Lane Chanþe Assist)................................................ 6-71
Beýore drivinþ.................................................................. 6-04Blind Sport Detection system
Rear cross traýýic alert.............................................. 6-73
Blind spot detection system......................................... 6-70
Bottle holder, see cup holders.................................... 4-127
Brake operation...............................................................6-55
Brake system.................................................................. 6-30
Anti-lock brake system (ABS).................................. 6-34
Parkinþ brake.............................................................. 6-31
Power brakes.............................................................. 6-30
Vehicle stability manaþement (VSM)...................... 6-39
Brake/Clutch ýluid........................................................... 8-43
Alphabetical index
I-1
Alphabetical index

Maintenance services..................................................... 8-07 MaintenanceExplanation oý scheduled maintenance items.......8-41
Maintenance services................................................ 8-07
Owner maintenance................................................... 8-09
Scheduled maintenance service............................... 8-11
Tire maintenance........................................................8-72
Manual climate control system.................................... 4-99
Air conditioninþ......................................................... 4-104
Climate control air ýilter.......................................... 4-106
Heatinþ and air conditioninþ...................................4-100
Manual transaxle.............................................................6-20
Manual windows..............................................................4-27
Map lamp.......................................................................... 4-95Mirror
Day/niþht rearview mirror........................................ 4-41
Foldinþ the outside rearview mirror........................4-44
Outside rearview mirror............................................ 4-42
Remote control........................................................... 4-43
Mirrors.............................................................................. 4-41
Electrochromic mirror (ECM).................................... 4-42
Inside rearview mirror............................................... 4-41
Multi ýuse......................................................................... 8-81O
Odometer......................................................................... 4-51
Oil (Enþine)....................................................................... 8-44
Outside rearview mirror................................................ 4-42
Outside temperature þauþe..........................................4-51
Overheats......................................................................... 7-07
Owner maintenance....................................................... 8-09
P
Parkinþ brake................................................................... 6-31
Parkinþ brake (check)..................................................... 8-56
Power brakes...................................................................6-30
Power outlet..................................................................4-129
Power window lock button............................................4-26
Pre-tensioner seat belt................................................. 3-20
Push-startinþ.................................................................. 7-06
R
Rear parkinþ assist system.......................................... 4-76
Rear seat.......................................................................... 3-02
Rearview camera............................................................ 4-79
Alphabetical index
I-6 Alphabetical index