washer fluid Lancia Delta 2008 Owner handbook (in English)

CARE AND MAINTENANCE199
5
SCHEDULED SERVICING PLAN
Petrol versions
Thousands of kilometres
Check tyre condition/wear and adjust pressure if required
Check lighting system operation (headlights, direction indicators, hazard lights,
passenger compartment lights, boot lights, instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads and
brake pad wear indication
Check rear disc brake pad condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of bonnet and boot locks and
linkage cleanness and lubrication;
Check and top up, if required, fluid levels (engine coolant, brake/hydraulic
clutch fluid, windscreen washer fluid, battery fluid, etc)
Check the handbrake lever stroke and adjust it, if necessary
visually inspect the condition of the accessory drive belt
Visually inspect the condition of the toothed timing drive belt30 60 90 120 150 180
    
    
    
    
    
    
    
    
    
    



CARE AND MAINTENANCE201
5
Diesel versions
Thousands of kilometres
Check tyre condition/wear and adjust pressure if required
Check lighting system operation (headlights, direction indicators, hazard lights,
passenger compartment lights, boot lights, instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads and
brake pad wear indication
Check rear disc brake pad seal condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of bonnet and boot locks and
linkage cleanness and lubrication
Check and top up, if required, fluid levels
(engine coolant, brake/hydraulic clutch fluid, windscreen washer fluid, battery fluid, etc)
Check the handbrake lever stroke and adjust it, if necessary
Check and if necessary adjust the auxiliary
drive belts (excluding engines equipped with automatic tensioners)
Check exhaust fumes/emissions
Visually inspect the condition of the auxiliary drive belt35 70 105 140 175
   
   
   
   
   
   
   
   
   
   

   


CARE AND MAINTENANCE203
5
REGULAR INSPECTIONS
Every 1,000 km or before long journeys, check and top
up if required:
engine coolant fluid level;
brake fluid level;
windscreen washer fluid level;
tyre pressure and condition;
operation of lights (headlights, direction indicators,
hazard lights, etc.);
operation of the windscreen wiper/washer system, po-
sition and wear of windscreen/rearscreen wiper blades;
Every 3,000 km check the following and top-up, if re-
quired: engine oil level.
You are recommended to use FL Selenia products, de-
signed and produced specifically for Lancia cars (see table
“Capacities” in chapter “6”).
DEMANDING USE OF THE CAR
If you use the vehicle mainly under one of the following
especially heavy conditions:
trailer or caravan towing;
dusty roads;
repetitive short distances (less than 7-8 km) with ex-
ternal temperatures below zero;
frequently idling the engine or long distances at low
speed driving (e.g. door-to-door deliveries) or long term
inactivity;
urban routes;

210CARE AND MAINTENANCE
The engine cooling system is pressurized. If
required, replace the cap with an original
spare part so as not to compromise system ef-
ficiency. Do not remove the cap from the vessel when
the engine is hot: risk of burns.
WINDSCREEN/REAR WINDOW
WASHER FLUID C-fig. 1-2-3
To add fluid, remove the cap, pressing the special tab.
Pour a mixture of water and TUTELA PROFESSIONAL
SC35, in the following concentrations:
30% TUTELA PROFESSIONAL SC35 and 70% water in
summer.
50% TUTELA PROFESSIONAL SC35 and 50% water in
winter.
At temperatures below –20°C, use undiluted TUTELA
PROFESSIONAL SC35 fluid.
Check the level through the reservoir.
Close the cap by pressing its central section.
Do not travel with the windscreen washing
reservoir empty: the windscreen washer is
fundamental to improve visibility.
Some commercial windscreen washer additives are
flammable. The engine compartment contains hot
parts which could start a fire if they come into con-
tact.
BRAKE FLUID D-fig. 1-2-3
Undo the cap and check that the liquid contained in the
tank is at the maximum level. Fluid level in the reservoir
must not exceed the MAX mark. Use the brake fluid shown
in the “Fluids and lubricants” table (see chapter “6”).
NOTE Carefully clean the reservoir cap and the sur-
rounding surface.
When opening the cap, make sure that no dirt gets into
the reservoir.
For topping up always use a funnel with built-in filter
(mesh smaller than or equal to 0.12 mm).
IMPORTANT Brake fluid is hygroscopic (i.e. it absorbs
moisture). For this reason, if the car is mainly used in ar-
eas with a high degree of atmospheric humidity, the flu-
id should be replaced at more frequent intervals than spec-
ified in the “Scheduled Service Plan”.

220CARE AND MAINTENANCE
SPRAY NOZZLES
Windscreen washer fig. 7
If the jet of fluid is inadequate, firstly check that there is
fluid in the reservoir: see “Checking fluid levels” in this
section).
Then check that the nozzle holes are not clogged, if nec-
essary use a needle.
The windscreen jets are directed by adjusting the angle
of the nozzles.
Fluid jets should be directed at about 1/3 height from
the window upper edge.
IMPORTANT In versions with a sunroof, make sure that
the sunroof is closed before operating the front jets.
fig. 7L0E0099m
Rear window wiper fig. 8
Rear window washer jets are fixed.
The nozzle holder is on the rear window.
fig. 8 L0E0100m

57 ()–
8/10 –
7.1 –
4.3 () 3.60 ()
4.6 () 3.85 ()
1.87 1.7
– 0.8
6–57 –
8/10 –
5.9 –
2.75 2.4
2.9 3.3
2.4 ()2 ()
– 0.8
6–Unleaded petrol
not less than 95 R.O.N
(Specification EN228)
(
) Diesel fuel for motor vehicles
(Specification EN590)
Mixture of 50% distilled water and
50% PARAFLU UP ()
SELENIA K P.E.
SELENIA WR P.E. ()
TUTELA CAR TECHNYX
TUTELA CAR MATRYX ()
TUTELA TOP 4
Mixture of water and fluid
TUTELA PROFESSIONAL SC 35
242TECHNICAL DATA
CONSUMABLES
() When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU
UP and distilled water.
1.4 Turbo Jet 1.6 Multijet Recommended fuels
litres kg litres kg and original lubricants
Fuel tank:
including a reserve of:
Engine cooling system:
Engine sump:Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit withABS system:
Windscreen/rear window
washer fluid reservoir:

57 –
8/10 –
7.1 –
4.3 3.60
4.9 4.10
3.1 2.63
– 0.8
6–57 –
8/10 –
7.1 –
4.3 3.60
4.9 4.10
3.1 2.63
– 0.8
6–Diesel fuel for motor vehicles
(Specification EN590)
Mixture of 50% distilled water and
50% PARAFLU UP ()
SELENIA WR P.E.
TUTELA CAR TECHNYX
TUTELA TOP 4
Mixture of water and fluid
TUTELA PROFESSIONAL SC 35
TECHNICAL DATA243
6
(*) Values in brackets refer to versions with headlight washer.
(
) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP
and distilled water.
1.9 Twin Turbo Multijet2.0 Multijet Recommended fuels
litres kg litres kg and original lubricants
Fuel tank:
including a reserve of:
Engine cooling system
Engine sump:Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit with
ABS system:
Windscreen/rear window
washer fluid reservoir:

Gearboxes and
differentials manual
(1.6 Multijet versions)
Manual gearboxes and
differentials (petrol ver-
sions and diesel versions
excluding 1.6 Multijet)
Constant velocity joints
differential-side
Constant velocity joints
wheel-side
Hydraulic brakes and
hydraulically operated
clutches
Cooling circuits propor-
tions of use: 50% water
50% PARAFLU UP (
)
To be mixed with diesel
(25 cc per 10 litres)
To be used diluted or
undiluted in wind-
screen/rear window
washer/wiper systems
TECHNICAL DATA245
6
Synthetic lubricant grade SAE 75W-85.
Exceeds API GL-4 PLUS specifications.
FIAT Classification 9.55550-MX3
Synthetic-based lubricant, grade SAE 75W-85.
Exceeds API GL-4 specifications.
FIAT Classification 9.55550-MZ1
Grease for constant velocity joints with low
friction coefficient. Consistency N.L.G.I. 0-1.
FIAT Classification 9.55580
Molybdenum disulphide grease, for use at
high temperatures. Consistency N.L.G.I. 1-2.
FIAT Classification 9.55580
Synthetic fluid for braking and clutch systems
Exceeds specifications: FMVSS n° 116 DOT 4, ISO
4925,SAE J 1704. FIAT Classification 9.55597
Red, protective with antifreeze action, based on inhib-
ited monoethyl glycol with organic formula. Exceeds
CUNA NO 956-16, ASTM D 3306 specifications.
Additive for diesel fuel, protecting Diesel engines.
Mixture of alcohols and surfactants.
Exceeds CUNA NC 956-11 specification.
FIAT Classification 9.55522TUTELA CAR TECHNYX Contractual Technical
Reference N° F010.B05
TUTELA CAR MATRYX Contractual Technical
Reference N°F108.F02
TUTELA STAR 700
Contractual Technical
Reference N°F701.C07
TUTELA ALL STAR
Contractual Technical
Reference N°F702.G07
TUTELA TOP 4
Contractual Technical
Reference N°F001.A93
PARAFLU UP (
)
Contractual Technical
Reference N°F101.M01
TUTELA DIESEL ARTContractual Technical
Reference N°F601.L06
TUTELA
PROFESSIONALSC 35
Contractual Technical
Reference N° F201.D02 Brake
fluid
Protective
for radiators
Additive for
diesel fuel
Liquid for
windscreen
and rearscreen
washers
() IMPORTANT Do not use fluids with different specifications for topping up or mixing.
() When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP and demineralised water.
Lubricants
for petrol
engines Use Qualitative specifications of fluids and lubricants Fluids and lubricants Applications
for correct vehicle operation original