steering Lancia Delta 2009 Owner handbook (in English)

144SAFETY
GENERAL WARNINGS
If when turning the key to MAR the warning
light ¬does not turn on or stays on during
car travel (together with the message on the
multifunctional display, where provided), a fail-
ure may have occurred in the restraint systems. In
this case the airbags or pretensioners may not be
deployed after an impact or, in a minor number of
cases, they may be deployed accidentally. Contact
a Lancia Dealership immediately to have the sys-
tem checked before driving off.
Do not cover the front seat backrest with covers if
a Side-bag is fitted.
Do not travel with objects in your lap, in front
of your chest, or between your lips (pipes,
pencils, etc.). In the event of crash with airbag
activation, you may be seriously injured.
Always drive keeping your hands on the
steering wheel crown so that, in the event of
airbag activation, it can inflate without find-
ing obstacles. Do not drive with your body bent for-
ward. Keep the backrest an upright position, cor-
rectly resting your back on it.
If someone tried to steal or damage your car,
and in the event of floods, have the air bag
system checked by a Lancia Dealership.

148STARTING UP AND DRIVING
STARTING THE ENGINE
The car is provided with an electronic engine lock device:
refer to “The Lancia CODE system” paragraph in chap-
ter “1” if you cannot start the engine.
The engine may be noisier during the first few seconds
of operation, particularly after a long period of inactivi-
ty. This does not impair functionality and reliability and
is typical of hydraulic tappets: the distribution system
selected for the petrol engine of your car in order to lim-
it the maintenance required.
In the first period of use, we recommend
avoiding excessive stress for the car (for in-
stance excessive accelerations, extended trav-
el at maximum speed, sudden braking etc.).
With engine off, do not leave the key in the ig-
nition switch on MAR to prevent draining the
battery.
Is is dangerous to let the engine run in en-
closed spaces. The engine depletes oxygen and
discharges carbon dioxide, carbon monoxide
and other toxic gases.
Remember that the brake servo and electric
power steering are not operational until the
engine has been started, therefore more effort
than usual is required on the brake pedal and steer-
ing wheel.

IN AN EMERGENCY159
4
If after several attempts the engine will not start, do not
keep trying but contact a Lancia Dealership.
IMPORTANT Never connect the negative terminals of the
two batteries directly: sparks could ignite explosive gas re-
leased from the battery. If the auxiliary battery is installed
on another car, prevent accidental contact between metal-
lic parts of the two cars.
BUMP STARTING
Never bump start the engine by pushing, towing or dri-
ving downhill.
This could cause a flow of fuel into the catalytic convert-
er and damage it beyond repair.
IMPORTANT Remember that the brake servo and the
power steering system (if present) are not operative until
the engine is started, a greater effort will therefore be re-
quired to press the brake pedal or turn the steering wheel.QUICK TYRE REPAIR KIT -
FIX & GO AUTOMATIC
The quick tyre repair kitFix & Go automatic is placed in
the luggage compartment.
The kit fig. 2 includes:
a cylinder A containing sealing liquid and fitted with:
– a filling pipe B;
– an adhesive label C bearing the words “max. 80
km/h”, to be attached in a position easily visible to
the driver (on the dashboard) after tyre repair;
fig. 2L0E0075m

168IN AN EMERGENCY
Vehicle handling is modified with the small
spare wheel fitted. Avoid violent acceleration
and braking, sharp steering and fast bend-
ing. The overall duration of the small spare wheel
is of about 3000 km, after which the relevant tyre
must be replaced with another one of the same type.
Never install a traditional tyre on a rim designed to
be used as a small spare wheel. Repair and refit the
standard wheel as soon as possible. Using two or
more small spare wheels at the same time is for-
bidden. Do not apply grease to the bolt threads be-
fore assembly: they might come unscrewed.The jack may only be used to replace wheels
on the car which it equips or other cars of the
same model. Never use the jack for other pur-
poses, such as lifting other car models. Never use
the jack to carry out repairs under the car. Incor-
rect positioning of the jack may cause the car to fall.
Do not use the jack for loads higher than those
shown on the label. Never install snow chains on the
small spare wheel; if a front tyre (driving wheel)
is punctured and you need to use snow chains, use
a standard wheel from the rear axle and install the
small spare wheel on the rear axle. This way, with
two normal front driving wheels, you can install the
snow chains on them, thus resolving the emergency.
If the hub cap is not installed properly, it can
detach itself when the vehicle is running. Nev-
er tamper with the inflation valve. Never in-
troduce tools of any kind between rim and tyre.
Check tyre and small spare wheel pressure regu-
larly referring to the values shown in chapter “6”.
Tool box (versions with Bose Hi-Fi)
There is a tool box located in the luggage compartment
for versions with Bose Hi-Fi.
This box contains:
screwdriver;
tow hook;
wheel bolt spanner;
wheel bolt access spanner;
alloy wheel centering;
jack.

192IN AN EMERGENCY
38
38
38
–
38
38
38
38
38
38
38
38F42
F43
F44
F45
F46
F47
F48
F49
F50
F51
F52
F535
30
15
–
20
20
20
5
7.5
5/7.5 (*)
15
7.5
CONSUMERS FUSE AMPERE DIAGRAM
Brake Node, yaw sensor
Windscreen wiper system on steering wheel interface, bi-directional
windscreen/rearscreen washer pump system on steering wheel interface
Cigar lighter/power socket on tunnel,
luggage compartment power socket
Spare
Sunroof motor
Driver-side front electric window
Passenger-side front electric window
Emergency, right, left and central control panels on radio/
radio-navigator (illumination), steering wheel controls (illumination),
controls on front courtesy light (illumination), volume-sensing
alarm control unit, electric sunroof system (controls illumination
control unit), rain/dusk sensor,
electro-chrome mirror, heated front seats controls
Air Bag Node
Cigar lighter (illumination), cruise control control,
Convergence Node, Parking Sensor Node, AQS sensor, climate control
unit, door mirror adjustment, tyre
pressure detection control unit, Lane assistance Node,
control unit on right-hand gas discharge headlight (*)
Rear wiper system on steering wheel interface
Instrument panel, direction indicators

IN AN EMERGENCY193
4
–
40
40
40
40
40
40
40
40
40
40
40
40
40
40
40F08
F09
F10
F11
F14
F15
F16
F17
F18
F19
F22
F22
F23
F24
F30
F85–
20
10
10
15
30
7.5
10
7.5
7.5
15
20
20
5
15
15
FUSE SUMMARY TABLE - Engine compartment control unit
CONSUMERS FUSE AMPERE DIAGRAM
Spare
Headlight washer pump
Horn
Electronic injection secondary loads
Main beam headlights
PTC1 additional heater
Engine Management Node
Electronic injection primary loads
Engine Management Node
Air conditioning compressor
Electronic injection primary loads (1.4 engine)
Electronic injection primary loads (1.8 and diesel engine)
Brake Node (valves)
Electric Steering Node
Fog/cornering lights
Fuel pump

196IN AN EMERGENCY
TOWING THE CAR
The tow ring provided with the car is housed in the tool
box under the luggage compartment mat.
FASTENING THE TOW RING fig. 43-44
Proceed as follows:
release cap A;
take the tow hook B from its seat in the tool support;
tighten the ring on the rear or front threaded pin.
fig. 43L0E0090mfig. 44L0E0091m
Before starting towing operations, turn the ig-
nition key to MAR and then to STOP, without
extracting it. If the key is extracted, the steer-
ing wheel lock will be automatically activated, thus
preventing steering. The power brakes and the elec-
trical power steering will not work while the car is be-
ing towed. More effort on the brake pedal and steer-
ing wheel will therefore be required. Do not use wires
for towing. Do not jerk. Make sure not to damage parts
in contact with the car while towing. Respect the spe-
cific rules of the Highway Code when towing the car
specifically in relation to the towing device and the be-
haviour to maintain on the road. Do not start the en-
gine while towing the car.

CARE AND MAINTENANCE213
5
BATTERY
The battery F-fig, 1-2-3 provided with this vehicle is a
“Reduced maintenance” battery: no top-ups with distilled
water are needed in normal conditions of use.
It should nevertheless be periodically checked by a Lan-
cia Dealership or specialised personnel to check its effi-
ciency.
The battery fluid is poisonous and corrosive.
Avoid contact with the skin and eyes. Keep
naked flames and sources of sparks away
from the battery: risk of explosion and fire.
Running the battery with an excessively low
liquid level will damage the battery beyond
repair and even cause an explosion.
CHANGING THE BATTERY
If required, replace the battery with a genuine spare part
with the same specifications.
If a battery with different specifications is fitted, the ser-
vice intervals given in the “Scheduled Service Plan” will
no longer be valid.
Refer therefore to the instructions provided by the battery
manufacturer.
If the battery is disconnected, the áwarning light will co-
me on (together with a message in the display) to indica-
te that the system must be realigned. To switch the war-
ning light off, carry out the following initialization pro-
cedure:
turn the ignition key to the ON position;
turn the steering wheel fully both clockwise and anti-
clockwise (to move from the position with the wheels
straight);
turn the ignition key to the OFF position and then turn
it back ON.
If the áwarning light does not go out after a few seconds,
seek assistance from a Lancia Dealership.

216CARE AND MAINTENANCE
WHEELS AND TYRES
Check the pressure of each tyre, including the spare wheel,
approximately once every two weeks and before starting
a long journey: this check must be performed with the tyre
rested and cold.
It is normal for the pressure to increase when the car is
used; for the correct tyre inflation pressure, see “Wheels”
in chapter “6”.
Incorrect tyre pressure causes abnormal tyre wear fig. 4:
fig. 4L0E0096m
A normal pressure: evenly worn tread.
B low pressure: tread particularly worn on the edges.
C excessive pressure: tread particularly worn in the mid-
dle.
The tyres must be replaced when the tread is less than 1.6
mm thick. In all cases, follow the laws in force in the coun-
try where you are driving.
IMPORTANT NOTES
Avoid braking suddenly, burning starts and violent
knocks against the curb, potholes or other obstacles
where possible. Long distances on rough roads may
damage the tyres;
check the tyres regularly for cuts on the sides, swelling
or irregular tread wear. Go to a Lancia Dealership if
required;
do not overload your car: this may cause serious dam-
age to wheels and tyres;
if a tyre is punctured, stop immediately and change it
to avoid damage to the tyre, wheel rim, suspension and
steering system;

TECHNICAL DATA225
6
Identification data ............................................................... 226
Engine codes - bodywork versions........................................ 228
Engine ................................................................................ 229
Fuel system .........................................................................231
Transmission ....................................................................... 232
Brakes.................................................................................. 232
Suspension .......................................................................... 233
Steering ............................................................................... 233
Wheels ................................................................................ 234
Dimensions ......................................................................... 238
Performance ........................................................................ 239
Weight ................................................................................ 240
Consumables ....................................................................... 242
Fluids and lubricants ........................................................... 244
Fuel consumption ................................................................ 246
CO
2 emissions ..................................................................... 248