check engine light Lancia Musa 2011 Owner handbook (in English)

173
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MANUTENZIONEE CURA
3
12
45
L0D0488mfig. 5 - 1.6 Multijet versions
1 Engine coolant - 2 Engine oil - 3 Brake fluid - 4 Battery - 5 Windscreen/rear
window washer/wiper
fig. 6 -1.4 8V versions
(for versions/markets, where provided)L0D0258m
ENGINE OIL fig. 6-7-8-9-10
Checking engine oil level
Check the oil level a few minutes
(about 5) after the engine has
stopped, with the car parked on level
ground.
The oil level shall be included be-
tween the MINandMAXmarks on
the dipstick . The range between the
MINandMAXlevels corresponds to
approximately 1 litre of oil.

174
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
Proceed very carefully in-
side the engine compart-
ment when the engine is hot: risk of
burns. Remember that the fan may
start up if the engine is hot: risk of
injury. Pay attention to scarves,
ties and other loose fitting gar-
ments: they could get dragged by
the moving parts.
WARNING
Waste engine oil and oil fil-
ters contains substances
which are dangerous for the
environment. You are ad-
vised to go to a Lancia Dealership to
have the oil and filters replaced.
fig. 9 - 1.3 Multijet 95 HP
versionsL0D0495mfig. 8 - 1.3 Multijet versionsL0D0209m
Engine oil consumption
The maximum engine oil consump-
tion is usually 400 grams every 1000
km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption can only be considered sta-
bilised after the first 5000 - 6000 km.
IMPORTANT The oil consumption
depends on driving style and the con-
ditions under which the car is used.
IMPORTANT Always top up using
engine oil of the same types as that al-
ready in the engine.
fig. 7 - 1.416VversionsL0D0208m
Topping up engine oil
If the oil level is near or even under
theMINline, add oil through the filler
to reach the MAXline. Oil level shall
never exceed the MAXline.
IMPORTANT If the engine oil level
after the check is over the MAXlevel,
go to a Lancia Dealership to have the
correct level restored.
IMPORTANT After adding or chang-
ing the oil, let the engine turn over for
a few seconds and wait a few minutes
after turning it off before you check
the level.

175
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
ENGINE COOLANT fig. 11-12
The coolant level must be checked
when the engine is cold and must be
between the MINandMAXlines on
the vessel.
If the level is so, slowly pour a mixture of
demineralised water and PETRONAS
LUBRICANTSPA R A F L U
UPin a 50-50
proportion.
A 50-50 mixture of PA R A F L U
UPand
distilled water gives freeze protection
to 35°C.
IMPORTANT Do not remove the cap
from the vessel when the engine is
very hot: risk of burns.
fig. 11 - 1.48Vversions
(for versions/markets,
where provided) and 1.4
16V
L0D0210mfig. 12 - 1.3 Multijet
and 1.6 Multijet versionsL0D0211m
When the vehicle is used under par-
ticularly harsh weather conditions, we
recommend using a 60-40 mixture of
PA R A F L U
UPand demineralised wa-
ter.
PA R A F L UUPantifreeze is
used in the engine cooling
system. Use fluid of the same type
contained in the cooling system for
top-ups. PARAFLU
UPmay not be
mixed with other types of fluids. If
this accidentally occurs, do not start
the engine and contact a Lancia
Dealership.
WARNING
The engine cooling system
is pressurized. If required,
replace the cap with an original
spare part so as not to compromise
system efficiency.
WARNING
fig. 10 - 1.6 Multijet versionsL0D0489m

176
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
BRAKE FLUID fig. 14
Release cap: check that the liquid
contained in the tank is at the maxi-
mum level.
Fluid level in the reservoir must not
exceed the MAXmark.
Use the brake fluid shown in the
“Fluids and lubricants” table (see
“Technical Specifications”).
NOTE Carefully clean the cap of
reservoir A and the surrounding sur-
face.
When opening the cap, make sure
that no dirt gets into the reservoir.
For topping up always use a funnel
with built-in filter (mesh smaller than
or equal to 0.12 mm).
IMPORTANT Brake fluid is hygro-
scopic (i.e. it absorbs moisture). For
this reason, if the car is mainly used
in areas with a high degree of atmos-
pheric humidity, the fluid should be
replaced at more frequent intervals
than specified in the “Service sched-
ule”.
fig. 14L0D0213m
Do not travel with the
windscreen washing reser-
voir empty: the action of the wind-
screen washer is essential for im-
proving visibility.
WARNING
Some commercial addi-
tives for windscreen wash-
ing are flammable. The engine
compartment contains hot parts
which could start a fire if they
come into contact.
WARNINGWINDSCREEN/REAR WINDOW
WASHER FLUID fig. 13
To add fluid, lift the cap Aand pour
in a mixture of water and TUTELA
PROFESSIONAL SC35fluid in the
following proportions:
❒30% of TUTELA PROFESSIONAL
SC35and 70% water in summer.
❒50% of TUTELA PROFESSIONAL
SC35and 50% water in summer.
UseTUTELA PROFESSIONAL SC35
neat at temperatures lower than 20°C.
Check level through the reservoir.
fig. 13L0D0212m

177
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
Prevent brake fluid which
is highly corrosive from
coming into contact with
painted parts. Should this
occur, immediately wash with wa-
ter.
Brake fluid is poisonous
and highly corrosive. In
the case of accidental contact, wash
the parts with water and mild soap
and rinse with plenty of water.
Call a doctor immediately if swal-
lowed.
WARNING
Symbolπon the contain
indicates a synthetic brake
fluid, which is different from a
mineral fluid. Use of a mineral
type fluid will damage the special
rubber seals of the braking system
beyond repair.
WARNING
FUEL FILTER
(green filter)
DRAINING CONDENSATION
(Multijet versions)
The presence of water in
the feeding circuit may
cause severe damage to the injec-
tion system and irregular engine
operation. If the warning lights c
on the cluster lights up or a mes-
sage appears on the reconfigurable
multifunctional display (some ver-
sions), contact a Lancia Dealership
to have the system bled. Water may
have been introduced in the tank if
this appears immediately after re-
fuelling: in this case, stop the en-
gine immediately and contact a
Lancia Dealership.
WARNING
CHECKING CHARGE
AND ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner’s Handbook
only by specialised personnel.
Topping must be carried out by spe-
cialised personnel at a Lancia Dealer-
ship.
Battery liquid is poisonous
and corrosive. Avoid con-
tact with the skin and eyes. Keep
naked flames and sources of
sparks away from the battery: risk
of explosion and fire.
WARNING
BATTERY
The battery is of the low maintenance
type and the electrolyte does not need
to be topped up with distilled water in
normal conditions of use.

185
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
Engine compartment
At the end of every winter, wash the
engine compartment thoroughly, tak-
ing care not to aim the jet of water di-
rectly at the electronic control units or
at the windscreen wiper motors. Have
this operation performed at a spe-
cialised workshop.
IMPORTANT Perform this operation
on a cold engine and with the key at
STOP. After the washing operation,
make sure that the various protections
(e.g. rubber caps and guards) have
not removed or damaged.
Never use flammable
products, such as petrol
ether or rectified petrol to clean in-
side the car. The electrostatic
charges which are generated by
rubbing during the cleaning oper-
ation may cause a fire.
WARNING
INTERIOR PLASTIC PARTS
It is advisable to clean interior parts
with a moist cloth and a solution of
water and mild soap. Use specific
products for cleaning plastic, without
solvents and specifically designed to
prevent damage to the appearance
and colour of the treated parts to re-
move grease and tough stains.
IMPORTANT Never use spirit or pe-
troleum to clean the instrument panel.INTERIORS
Periodically check that water is not
trapped under the mats (due to water
dripping off shoes, umbrellas, etc.)
which could cause oxidisation of the
sheet metal.
CLEANING SEATS AND FABRIC
PA R T S
Remove dust with a soft brush or a
vacuum cleaner. It is advisable to use
a moist brush on velvet upholstery.
Rub the seats with a sponge moist-
ened with a solution of water and
neutral detergent.

212
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICA-
TIONS
INDEX
ABS (System) ........................ 85
Accessories purchased by the
owner .................................. 88
Air vents ............................... 48
Ashtray (smoker's kit) .......... 75
Automatic dual-zone climate
system.................................. 52
Battery
. - checking battery charge and
liquid level (electrolyte) ..... 177
- jump starting ..................... 137
- replacement ...................... 178
Bodywork
- maintenance ..................... 182
- version codes .................... 190
Bonnet .................................. 82
Boot ...................................... 80
Boot extension ....................... 80
Brake fluid level .................... 176
Brake lights
- bulb replacement ............. 153Brakes
- fluid level ......................... 176
- handbrake ........................ 116
- technical data ................. 193
Bulb (replacement) ............... 147
Capacities ............................. 201
Car maintenance and care ..... 165
- scheduled maintenance plan 167
Car parked ............................ 116
Car radio
- setup ................................ 87
Carrying children safely ........ 101
Ceiling light ........................... 69
Changing a wheel .................. 142
Checking fluid levels ............. 171
Child lock ............................ 19
Cigar lighter (smoker's kit) .... 75
Clutch ................................... 192
CO
2emissions ....................... 205
Control buttons display .........22-25
Cruise Control ....................... 67Dashboard ........................... 8
Dashboard and controls ........ 7
Dimensions .......................... 198
Dipped beam headlights
- bulb replacement ............. 151
- controls ............................ 62
Direction indicators ............... 63
Direction indicators
- bulb replacement ............. 152
- controls ............................ 63
Dualdrive
(electric power steering) ...... 89
Engine compartment ............. 171
Engine coolant gauge ............ 22
Engine cooling system fluid
level ................................... 174
Engine oil level ..................... 173
Engine oil
- level check ........................ 173
- technical specifications ..... 202
INDEX

213
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICA-
TIONS
INDEX
Engine
- cranking ........................... 20
- features ............................ 191
- power supply ..................... 192
- identification code ........... 188
Environment protection ......... 94
EOBD (system) ..................... 86
Exterior lights ....................... 62
Fire protection system (FPS).. 72
Fix&GO Automatic
(quick tyre repair kit) .........138
Fluids and lubricants ............ 202
Fog lights
- bulb replacement ............. 153
- control buttons ................. 71
FPS (Fire Protection System) 72
Front air bags ........................ 108
- driver's front airbag........... 108
- front airbag passenger side 109
- manually deactivating the
passenger front and side
airbag ............................... 110
Fuel cap ................................ 92Fuel
- consumption ...................... 204
- fuel gauge ......................... 21
- inertia fuel switch ............. 72
Fuses .................................... 156
Gearbox (use) ...................... 117
GSI system ............................. 87
Hazard warning lights
- controls ............................ 71
Head restraints ..................... 44
Headlamp alignment corrector 84
Headlight beam corrector
(electric corrector) .............. 84
Headlights ............................ 84
Identification data ................ 188
Ignition switch ...................... 20
In an emergency .................... 135
Instrument panel ................... 10
Interior ................................. 185
Interior equipment
- card holder ........................ 74- CD holder compartment
with can holder.................. 75
- cup/can holder .................. 74
- current socket .................... 75
- glove compartment ............ 73
- oddment compartments
(upper) .............................. 73
- oddment shelf on roof ........ 74
Isofix child seat ..................... 105
Jack ...................................... 144
Key and door locking kit........ 13
Lancia CODE system ............. 11
Levels
- checking .......................... 171
Lubricants (features) ............. 202
Main beam headlights
- bulb replacement ............. 151
- controls ............................ 62
Manual climate control ......... 48
Mechanical Brake Assist ......... 85