check engine light Lancia Voyager 2013 Owner handbook (in English)

CAUTION!
Do not use chemical flushes in your
power steering system as the
chemicals can damage your power
steering components. Such damage
is not covered by the New Vehicle
Limited Warranty.WARNING!
Fluid level should be checked on a
level surface and with the engine off
to prevent injury from moving parts
and to ensure accurate fluid level
reading. Do not overfill. Use only
manufacturer's recommended
power steering fluid.
If necessary, add fluid to restore to the
proper indicated level. With a clean
cloth, wipe any spilled fluid from all
surfaces. Refer to “Fluids, Lubri-
cants, and Genuine Parts” in “Main-
taining Your Vehicle” for further in-
formation. PARKING BRAKE
Before leaving the vehicle, make sure
that the parking brake is fully applied
and place the shift lever in the PARK
position.
The foot operated parking brake is
positioned below the lower left corner
of the instrument panel. To apply the
park brake, firmly push the park
brake pedal fully. To release the park-
ing brake, press the park brake pedal
a second time and let your foot up as
you feel the brake disengage.
When the parking brake is applied
with the ignition switch in the ON
position, the “Brake Warning Light”
in the instrument cluster will illumi-
nate.NOTE:
 When the parking brake is ap-
plied and the automatic trans-
mission is placed in gear, the
“Brake Warning Light” will
flash. If vehicle speed is de-
tected, a chime will sound to
alert the driver. Fully release the
parking brake before attempting
to move the vehicle.
 This light only shows that the parking brake is applied. It does
not show the degree of brake ap-
plication.
When parking on a hill, it is important
to turn the front wheels toward the
curb on a downhill grade and away
from the curb on an uphill grade. For
vehicles equipped with an automatic
transmission, apply the parking brake
before placing the shift lever in PARK,
otherwise the load on the transmis-
sion locking mechanism may make it
difficult to move the shift lever out of
PARK. The parking brake should al-
ways be applied whenever the driver
is not in the vehicle.
Parking Brake
241

Vehicles Without Wheel Covers
1. Mount the road tire on the axle.
2.
Install the remaining lug nuts with
the cone shaped end of the nut toward
the wheel. Lightly tighten the lug nuts.WARNING!
To avoid the risk of forcing the ve-
hicle off the jack, do not tighten the
wheel nuts fully until the vehicle
has been lowered. Failure to follow
this warning may result in personal
injury.
3. Lower the vehicle to the ground by
turning the jack handle counterclock-
wise.
4. Finish tightening the lug nuts.
Push down on the wrench while at the
end of the handle for increased lever-
age. Tighten the lug nuts in a star
pattern until each nut has been tight-
ened twice. The correct tightness of
each lug nut is 138 N·m. If in doubt
about the correct tightness, have them
checked with a torque wrench by your
authorized dealer or service station. 5. After 40 km check the lug nut
torque with a torque wrench to ensure
that all lug nuts are properly seated
against the wheel.
JUMP-STARTING
If your vehicle has a discharged bat-
tery it can be jump-started using a set
of jumper cables and a battery in an-
other vehicle or by using a portable
battery booster pack. Jump-starting
can be dangerous if done improperly
so please follow the procedures in this
section carefully.
NOTE: When using a portable
battery booster pack follow the
manufacturer’s operating instruc-
tions and precautions.
CAUTION!
Do not use a portable battery
booster pack or any other booster
source with a system voltage
greater than 12 Volts or damage to
the battery, starter motor, alterna-
tor or electrical system may occur.
WARNING!
Do not attempt jump-starting if the
battery is frozen. It could rupture or
explode and cause personal injury.
PREPARATIONS FOR
JUMP-START
The battery in your vehicle is located
on the left side of the engine compart-
ment.
Positive Battery Post
291

To prevent freeze-up of your wind-
shield washer system in cold weather,
select a solution or mixture that meets
or exceeds the temperature range of
your climate. This rating information
can be found on most washer fluid
containers.
The washer fluid reservoir will hold 4
Liters of fluid when the Low Washer
Fluid Light illuminates.WARNING!
Commercially available windshield
washer solvents are flammable.
They could ignite and burn you.
Care must be exercised when filling
or working around the washer solu-
tion.
After the engine has warmed, operate
the defroster for a few minutes to re-
duce the possibility of smearing or
freezing the fluid on the cold wind-
shield. Use All Weather Windshield
Washer Solution or equivalent, used
with water as directed on the con-
tainer, aids cleaning action, reduces the freezing point to avoid line clog-
ging, and is not harmful to paint or
trim.
CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
COOLING SYSTEMWARNING!
 When working near the radiator cooling fan, disconnect the fan
motor lead or turn the ignition
switch to the OFF position. The
fan is temperature controlled and
can start at anytime the ignition
switch is in the ON position.
(Continued)
WARNING!(Continued)
 You or others can be badly burned by hot engine coolant
(antifreeze) or steam from your
radiator. If you see or hear steam
coming from under the hood, do
not open the hood until the radia-
tor has had time to cool. Never try
to open a cooling system pressure
cap when the radiator is hot.CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we
do recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
Coolant Checks
Check the engine coolant (antifreeze)
protection every 12 months (before
the onset of freezing weather, where
309

Thousands Of Kilometers 24 48 72 96 120 144 168 192Months 12 24 36 48 60 72 84 96
Inspect and replace PCV valve if necessary. 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if necessary.        
Check operation of lighting system (headlamps, direction indi-
cators, hazard warning lights, luggage compartment, passen-
ger compartment, glove compartment, instrument panel warn-
ing lights, etc.).        
Check operation of windshield washer system and adjust jets if
necessary.        
Check windshield/rear window wiper blade position/wear.        
Check cleanliness of hood and tailgate locks and cleanliness
and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, underbody
protection, pipes and hoses (exhaust - fuel system - brakes),
rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, windshield
washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Check exhaust gas emissions.        
Check engine management system operation (via diagnostic
socket).        
Change the automatic transmission fluid and filter. (*) 
335

Thousands Of Kilometers 24 48 72 96 120 144 168 192Months 12 24 36 48 60 72 84 96
Replace spark plugs. 
Replace air filter cartridge. 
Change engine oil and replace oil filter. (**)
Change brake fluid (or every 24 months). 
Replace pollen filter.        
Change the automatic transmission
fluid and filter(s) at 96 kkm or 48
months if using your vehicle for any of
the following: city driving, short (less
than 7-8 km) and repeated journeys,
or frequent trailer or caravan towing
The oil and oil filter replacement must
be carried out when indicated by a
warning light or message on the in-
strument panel, or in any case every
12 months.
Periodic Checks
Every 1,000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 Power Steering Fluid;
 windshield washer fluid level;  power steering fluid;
 tire inflation pressure and
condition;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3,000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;  dusty roads;
 short, repeated journeys (less than
7-8 km) at sub-zero outside
temperatures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
336

Thousands Of Kilometers 20 40 60 80 100 120 140 160 180 200Months 12 24 36 48 60 72 84 96 108 120
Check battery charge status and possibly recharge.          
Check tire condition/wear and adjust pressure, if nec-
essary.          
Check operation of lighting system (headlamps, direc-
tion indicators, hazard warning lights, luggage com-
partment, passenger compartment, glove compart-
ment, instrument panel warning lights, etc.).          
Check operation of windscreen washer system and
adjust jets if necessary.          
Check windshield/rear window wiper blade position/
wear.          
Check cleanliness of hood and tailgate locks and
cleanliness and lubrication of linkages.          
Visually inspect condition of: exterior bodywork, un-
derbody protection, pipes and hoses (exhaust - fuel
system - brakes), rubber elements (boots, sleeves,
bushes, etc.).          
Check conditions and wear of front disc brake pads.          
Check conditions and wear of rear disc brake pads.          
Check and, if necessary, top up fluid levels (brakes,
windshield washer, battery, engine coolant, etc.).          
Visually inspect the condition of accessory drive belt/s.  
Check toothed timing drive belt conditions. 
Check exhaust gas emissions.          
338

Thousands Of Kilometers 20 40 60 80 100 120 140 160 180 200Months 12 24 36 48 60 72 84 96 108 120
Check engine management system operation (via di-
agnostic socket).          
Change the automatic transmission fluid and filter. 
Replace fuel filter (diesel version).  
Replace accessory drive belt/s.  
Replace toothed timing drive belt (*). 
Replace air filter cartridge.          
Change engine oil and replace oil filter (**).
Change brake fluid (or every 24 months).  
Replace pollen filter.          
(*) Regardless of the distance cov-
ered, the timing belt must be changed
every 4 years for particularly de-
manding use (cold climates, city driv-
ing, long periods of idling) or at least
every 5 years.
(**) The oil and oil filter replacement
must be carried out when indicated by
a warning light or message on the
instrument panel, or in any case every
12 months. Periodic Checks
Every
1,000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 Power Steering Fluid;
 windshield washer fluid level;
 power steering fluid;
 tire inflation pressure and
condition;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3,000 km, check and top up, if
required, the engine oil level.
339

Adding Engine Coolant(Antifreeze) . . . . . . . . . . . . . .311
Adding Fuel . . . . . . . . . . . . . . .270
Adding Washer Fluid . . . . . . . . .308
Additives, Fuel . . . . . . . . . . . . . .269
Adjustable Pedals . . . . . . . . . . . .130
Airbag . . . . . . . . . . . . . . . . .44, 50
Airbag Deployment . . . . . . . . . . .51
Airbag Light . . . . . . .49, 53, 66, 172
Airbag Maintenance . . . . . . . . . . .52
Airbag, Side . . . . . . . .47, 48, 49, 50
Airbag, Window (Side Curtain) . . . . . . . . . . . .47, 48, 50
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . . . . . . . . . .303
Air Conditioner Maintenance . . . .306
Air Conditioning Filter . . . . .222, 307
Air Conditioning, Operating Tips . . . . . . . . . . . . . . . . . . .222
Air Conditioning, Rear Zone . . . .220
Air Conditioning Refrigerant . . . . . . . . . . .306, 307
Air Conditioning System . . .215, 306
Air Pressure, Tires . . . . . . . . . . .248
Alarm Light . . . . . . . . . . . . . . .173
Alarm (Security Alarm) . . . . . . . . .15
Alterations/Modifications, Vehicle . . .8
Antifreeze (Engine Coolant) . . . . . . . . .310, 311, 327 Disposal
. . . . . . . . . . . . . . .311
Anti-Lock Warning Light . . . . . .170
Anti-Theft System . . . . . . . . . . . .15
Ashtray . . . . . . . . . . . . . . .145, 147
Auto Down Power Windows . . . . . .26
Automatic Dimming Mirror . . . . . .77
Automatic Door Locks . . . . . . . . .22
Automatic Headlights . . . . . . . . .124
Automatic Oil Change Indicator . .184
Automatic Temperature Control (ATC) . . . . . . . . . . . . . . . . . .215
Automatic Transaxle Adding Fluid . . . . . . . . . . . .315
Fluid Level Check . . . . . . . . .315
Automatic Transmission . . .232, 314,
315
Adding Fluid . . . . . . . . . . . .315
Fluid and Filter Changes . . . .315
Fluid Change . . . . . . . . . . . .315
Fluid Type . . . . . . . . . . . . . .314
Gear Ranges . . . . . . . . . . . . .234
Special Additives . . . . . . . . . .314
Auto Up Power Windows . . . . . . . .26
Battery . . . . . . . . . . . . . . . . . . .305
Jump Starting . . . . . . . . . . . .291
Keyless Transmitter Replacement
(RKE) . . . . . . . . . . . . . . . . . .20
Saving Feature (Protection) . .125Belts, Seat
. . . . . . . . . . . . . . . . . .65
Blind Spot Monitoring . . . . . . . . . .80
Body Mechanism Lubrication . . . .308
B-Pillar Location . . . . . . . . . . . .258
Brake Assist System . . . . . . . . . .244
Brake Control System, Electronic . . . . . . . . . . . . . . .243
Brakes . . . . . . . . . . . . . . . . . . .313
Brake System . . . . . . . . . . . . . . .313
Fluid Check . . . . . . . . . . . . .313
Parking . . . . . . . . . . . . . . . .241
Warning Light . . . . . . . . . . .173
Brake/Transmission Interlock . . . .233
Break-In Recommendations, New Vehicle . . . . . . . . . . . . . . . . . .64
Bulb Replacement . . . . . . . . . . .324
Bulbs, Light . . . . . . . . . . . . .67, 323
Calibration, Compass . . . . .178, 187
Camera, Rear . . . . . . . . . . . . . .138
Capacities, Fluid . . . . . . . . . . . .327
Caps, Filler Fuel . . . . . . . . . . . . . . . . . .270
Oil (Engine) . . . . . . . . . . . . .300
Power Steering . . . . . . . . . . .240
Carbon Monoxide Warning . . . . . .65
Cargo Area Features . . . . . . . . . .154
Cargo Compartment . . . . . . . . . .154
Luggage Carrier . . . . . . . . . .155
342

Cargo (Vehicle Loading). . . . . . .151
Car Washes . . . . . . . . . . . . . . . .316
Cellular Phone . . . . . . . . . . .84, 215
Center High Mounted Stop Light . . . . . . . . . . . . . . . . . .326
Changing A Flat Tire . . . . . . . . .283
Chart, Tire Sizing . . . . . . . . . . . .254
Check Engine Light (Malfunction Indicator Light) . . . . . . . . . . .171
Checking Your Vehicle For Safety . .65
Checks, Safety . . . . . . . . . . . . . . .65
Child Restraint . . . . . . . . . . . .54, 58
Child Restraint Tether Anchors . . . .60
Child Safety Locks . . . . . . . . . . . .30
Child Seat . . . . . . . . . . . . . . . . . .63
Clean Air Gasoline . . . . . . . . . . .268
Cleaning Wheels . . . . . . . . . . . . . . . .316
Climate Control . . . . . . . . . . . . .215
Coat Hook . . . . . . . . . . . . . . . .150
Coin Holder . . . . . . . . . . . . . . .151
Cold Weather Operation . . . . . . .229
Compact Disc (CD) Maintenance . . . . . . . . . . . . .214
Compact Spare Tire . . . . . . . . . .249
Compass . . . . . . . . . .175, 178, 186
Compass Calibration . . . . . .178, 187
Compass Variance . . . . . . . .176, 187 Computer, Trip/Travel
. . . . . . . . .185
Connector UCI . . . . . . . . . . . . . . . . . .193
Universal Consumer Interface
(UCI) . . . . . . . . . . . . . . . . .193
Conserving Fuel . . . . . . . . . . . . .184
Console . . . . . . . . . . . . . . . . . .151
Console, Floor . . . . . . . . . . . . . .151
Console, Overhead . . . . . . . . . . .139
Console, Removable . . . . . . . . . .153
Cool Down, Turbo . . . . . . . . . . .231
Cooling System . . . . . . . . . . . . .309
Adding Coolant (Antifreeze) . .311
Coolant Capacity . . . . . . . . . .327
Coolant Level . . . . . . . .309, 312
Disposal of Used Coolant . . . .311
Drain, Flush, and Refill . . . . .310
Inspection . . . . . . . . . . . . . .312
Points to Remember . . . . . . .312
Selection of Coolant
(Antifreeze) . . . . . .310, 327, 328
Corrosion Protection . . . . . . . . . .315
Cupholders . . . . . . . . . . . .146, 318
Data Recorder, Event . . . . . . . . . .53
Defroster, Windshield . . . . . .66, 219
Diagnostic System, Onboard . . . . .301
Diesel Fuel . . . . . . . . . . . . .269, 328 Diesel Fuel Requirements
. . . . . . .269
Dipsticks Automatic Transaxle . . . . . . .315
Oil (Engine) . . . . . . . . . . . . .302
Power Steering . . . . . . . . . . .240
Disabled Vehicle Towing . . . . . . .295
Disposal Antifreeze (Engine Coolant) . .311
Door Locks . . . . . . . . . . . . . . . . .21
Door Locks, Automatic . . . . . . . . .22
Driving Through Flowing, Rising, or
Shallow Standing Water . . . . .238
Driving to Achieve Maximum Fuel Economy . . . . . . . . . . . . . . . .184
Electrical Power Outlets . . . . . . .143
Electric Remote Mirrors . . . . . . . . .78
Electronic Brake Control System . .243
Brake Assist System . . . . . . . .244
Electronic Speed Control (Cruise Control) . . . . . . . . . . . . . . . .131
Electronic Stability Control (ESC) . . . . . . . . . . . . . . . . . .245
Electronic Vehicle Information Center (EVIC) . . . . . . . .138, 178
Emergency, In Case of Hazard Warning Flasher . . . . .282
Jacking . . . . . . . . . . . .283, 286
Jump Starting . . . . . . . . . . . .291
343

Overheating. . . . . . . . . . . . .282
Engine . . . . . . . . . . . . . . . . . . .300
Air Cleaner . . . . . . . . . . . . .303
Break-In Recommendations . . .64
Checking Oil Level . . . . . . . .302
Compartment . . . . . . . . . . . .299
Compartment Identification . .299
Coolant (Antifreeze) . . . .309, 328
Cooling . . . . . . . . . . . . . . . .309
Exhaust Gas Caution . . . . . . . .65
Fails to Start . . . . . . . . . . . .229
Flooded, Starting . . . . . . . . .229
Fuel Requirements . . . . . . . .327
Oil . . . . . . . . . . . .302, 327, 328
Oil Change Interval . . . .184, 302
Oil Filler Cap . . . . . . . . . . . .300
Oil Filter . . . . . . . . . . . . . . .303
Oil Selection . . . . . . . . .303, 327
Oil Synthetic . . . . . . . . . . . .303
Overheating . . . . . . . . . . . . .282
Starting . . . . . . . . . . . . . . . .227
Temperature Gauge . . . . . . . .174
Enhanced Accident Response Feature . . . . . . . . . . . . . . .50, 52
Entry System, Illuminated . . . . . . .17
Ethanol . . . . . . . . . . . . . . . . . .268
Event Data Recorder . . . . . . . . . . .53
Exhaust Gas Caution . . . . . . . .33, 65 Exhaust System
. . . . . . . . . .65, 304
Exterior Folding Mirrors . . . . . . . .78
Exterior Lights . . . . . . . . . . . . . .67
Fabric Care . . . . . . . . . . . . . . . .317
Filler Location Fuel . . . . . . . . . .172
Filters Air Cleaner . . . . . . . . . . . . .303
Air Conditioning . . . . . .222, 307
Engine Oil . . . . . . . . . .303, 328
Engine Oil Disposal . . . . . . . .303
Flashers Hazard Warning . . . . . . . . . .282
Turn Signal . . . . . . .67, 168, 324
Flash-To-Pass . . . . . . . . . . . . . .126
Flooded Engine Starting . . . . . . .229
Floor Console . . . . . . . . . . . . . .151
Fluid Capacities . . . . . . . . . . . . .327
Fluid Leaks . . . . . . . . . . . . . . . . .67
Fluid Level Checks Automatic Transaxle . . . . . . .315
Brake . . . . . . . . . . . . . . . . .313
Cooling System . . . . . . . . . . .309
Power Steering . . . . . . . . . . .240
Fluids, Lubricants and Genuine Parts . . . . . . . . . . . . . . . . . . .328
Fog Lights . . . . . . . . .125, 168, 325
Fog Light Service . . . . . . . . . . . .325 Fog Lights, Rear
. . . . . . . . . . . .175
Fold in Floor (Stow `n Go) Seating . . . . . . . . . . . . . . . . .112
Freeing A Stuck Vehicle . . . . . . . .293
Fuel . . . . . . . . . . . . . . . . .267, 269
Adding . . . . . . . . . . . . . . . .270
Additives . . . . . . . . . . . . . . .269
Conserving . . . . . . . . . . . . . .184
Diesel . . . . . . . . . . . . .269, 328
Ethanol . . . . . . . . . . . . . . . .268
Filler Cap (Gas Cap) . . .172, 270
Filler Door (Gas Cap) . . . . . .172
Gasoline . . . . . . . . . . . . . . .267
Gauge . . . . . . . . . . . . . . . . .172
Light . . . . . . . . . . . . . . . . . .182
Octane Rating . . . . . . . .267, 328
Requirements . . . . . . . . . . . .327
Saver Mode . . . . . . . . . . . . .184
Specifications . . . . . . . . . . . .328
Tank Capacity . . . . . . . . . . .327
Fueling . . . . . . . . . . . . . . . . . . .270
Fuel Optimizer . . . . . . . . . . . . . .184
Fuel Saver . . . . . . . . . . . . . . . . .184
Fuses . . . . . . . . . . . . . . . . . . . .319
Gas Cap (Fuel Filler Cap) . . . . . .270
Gasoline, Clean Air . . . . . . . . . . .268
Gasoline (Fuel) . . . . . . . . . . . . .267
344