check engine Lancia Voyager 2013 Owner handbook (in English)

Coolant Level
The coolant bottle provides a quick
visual method for determining that
the coolant level is adequate. With the
engine cold, the level of the engine
coolant (antifreeze) in the coolant re-
covery bottle should be between the
ranges indicated on the bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing the engine
coolant (antifreeze). Advise your ser-
vice attendant of this. As long as the
engine operating temperature is satis-
factory, the coolant bottle only needs
to be checked once a month.
When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill.Points To Remember
NOTE: When the vehicle is
stopped after a few kilometers of
operation, you may observe vapor
coming from the front of the engine
compartment. This is normally a
result of moisture from rain, snow,
or high humidity accumulating on
the radiator and being vaporized
when the thermostat opens, allow-
ing hot engine coolant (antifreeze)
to enter the radiator.
If an examination of your engine com-
partment shows no evidence of radia-
tor or hose leaks, the vehicle may be
safely driven. The vapor will soon dis-
sipate.
 Do not overfill the coolant recovery
bottle.
 Check the engine coolant (anti- freeze) freeze point in the radiator
and in the coolant recovery bottle.
If engine coolant (antifreeze) needs
to be added, contents of the coolant
recovery bottle must also be pro-
tected against freezing.  If frequent engine coolant (anti-
freeze) additions are required, or if
the level in the coolant recovery
bottle does not drop when the en-
gine cools, the cooling system
should be pressure tested for leaks.
 Maintain engine coolant (anti- freeze) concentration at 50% en-
gine coolant (antifreeze) (mini-
mum) and distilled water for
proper corrosion protection of your
engine, which contains aluminum
components.
 Make sure that the radiator and coolant recovery bottle overflow
hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air
conditioning, also keep the front of
the condenser clean.
 Do not change the thermostat for Summer or Winter operation. If re-
placement is ever necessary, install
ONLY the correct type thermostat.
Other designs may result in unsat-
isfactory coolant performance,
poor gas mileage, and increased
emissions.
312

Thousands Of Kilometers 24 48 72 96 120 144 168 192Months 12 24 36 48 60 72 84 96
Inspect and replace PCV valve if necessary. 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if necessary.        
Check operation of lighting system (headlamps, direction indi-
cators, hazard warning lights, luggage compartment, passen-
ger compartment, glove compartment, instrument panel warn-
ing lights, etc.).        
Check operation of windshield washer system and adjust jets if
necessary.        
Check windshield/rear window wiper blade position/wear.        
Check cleanliness of hood and tailgate locks and cleanliness
and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, underbody
protection, pipes and hoses (exhaust - fuel system - brakes),
rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, windshield
washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Check exhaust gas emissions.        
Check engine management system operation (via diagnostic
socket).        
Change the automatic transmission fluid and filter. (*) 
335

Thousands Of Kilometers 24 48 72 96 120 144 168 192Months 12 24 36 48 60 72 84 96
Replace spark plugs. 
Replace air filter cartridge. 
Change engine oil and replace oil filter. (**)
Change brake fluid (or every 24 months). 
Replace pollen filter.        
Change the automatic transmission
fluid and filter(s) at 96 kkm or 48
months if using your vehicle for any of
the following: city driving, short (less
than 7-8 km) and repeated journeys,
or frequent trailer or caravan towing
The oil and oil filter replacement must
be carried out when indicated by a
warning light or message on the in-
strument panel, or in any case every
12 months.
Periodic Checks
Every 1,000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 Power Steering Fluid;
 windshield washer fluid level;  power steering fluid;
 tire inflation pressure and
condition;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3,000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;  dusty roads;
 short, repeated journeys (less than
7-8 km) at sub-zero outside
temperatures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
336

 visually inspect conditions of: en-gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner. MAINTENANCE
SCHEDULE – DIESEL
ENGINE
To help you have the best driving
experience possible, the manufacturer
has identified the specific vehicle
maintenance service intervals that are
required to keep your vehicle operat-
ing properly and safely.
The manufacturer recommends that
these maintenance intervals be per-
formed at your selling dealer. The
technicians at your dealership know
your vehicle best, and have access to
factory trained information, genuine
LANCIA parts, and specially designed
electronic and mechanical tools that
can help prevent future costly repairs. The maintenance intervals shown
should be performed as indicated in
this section.
NOTE: Under no circumstances
should oil change intervals exceed
25,000 km or 12 months, which-
ever comes first.
CAUTION!
Failure to perform the required
maintenance items may result in
damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules
on the following pages for the re-
quired maintenance intervals.
337

Thousands Of Kilometers 20 40 60 80 100 120 140 160 180 200Months 12 24 36 48 60 72 84 96 108 120
Check battery charge status and possibly recharge.          
Check tire condition/wear and adjust pressure, if nec-
essary.          
Check operation of lighting system (headlamps, direc-
tion indicators, hazard warning lights, luggage com-
partment, passenger compartment, glove compart-
ment, instrument panel warning lights, etc.).          
Check operation of windscreen washer system and
adjust jets if necessary.          
Check windshield/rear window wiper blade position/
wear.          
Check cleanliness of hood and tailgate locks and
cleanliness and lubrication of linkages.          
Visually inspect condition of: exterior bodywork, un-
derbody protection, pipes and hoses (exhaust - fuel
system - brakes), rubber elements (boots, sleeves,
bushes, etc.).          
Check conditions and wear of front disc brake pads.          
Check conditions and wear of rear disc brake pads.          
Check and, if necessary, top up fluid levels (brakes,
windshield washer, battery, engine coolant, etc.).          
Visually inspect the condition of accessory drive belt/s.  
Check toothed timing drive belt conditions. 
Check exhaust gas emissions.          
338

Thousands Of Kilometers 20 40 60 80 100 120 140 160 180 200Months 12 24 36 48 60 72 84 96 108 120
Check engine management system operation (via di-
agnostic socket).          
Change the automatic transmission fluid and filter. 
Replace fuel filter (diesel version).  
Replace accessory drive belt/s.  
Replace toothed timing drive belt (*). 
Replace air filter cartridge.          
Change engine oil and replace oil filter (**).
Change brake fluid (or every 24 months).  
Replace pollen filter.          
(*) Regardless of the distance cov-
ered, the timing belt must be changed
every 4 years for particularly de-
manding use (cold climates, city driv-
ing, long periods of idling) or at least
every 5 years.
(**) The oil and oil filter replacement
must be carried out when indicated by
a warning light or message on the
instrument panel, or in any case every
12 months. Periodic Checks
Every
1,000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 Power Steering Fluid;
 windshield washer fluid level;
 power steering fluid;
 tire inflation pressure and
condition;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3,000 km, check and top up, if
required, the engine oil level.
339

Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than7-8 km) at sub-zero outside
temperatures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);  check battery charge and battery
fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
340

Adding Engine Coolant(Antifreeze) . . . . . . . . . . . . . .311
Adding Fuel . . . . . . . . . . . . . . .270
Adding Washer Fluid . . . . . . . . .308
Additives, Fuel . . . . . . . . . . . . . .269
Adjustable Pedals . . . . . . . . . . . .130
Airbag . . . . . . . . . . . . . . . . .44, 50
Airbag Deployment . . . . . . . . . . .51
Airbag Light . . . . . . .49, 53, 66, 172
Airbag Maintenance . . . . . . . . . . .52
Airbag, Side . . . . . . . .47, 48, 49, 50
Airbag, Window (Side Curtain) . . . . . . . . . . . .47, 48, 50
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . . . . . . . . . .303
Air Conditioner Maintenance . . . .306
Air Conditioning Filter . . . . .222, 307
Air Conditioning, Operating Tips . . . . . . . . . . . . . . . . . . .222
Air Conditioning, Rear Zone . . . .220
Air Conditioning Refrigerant . . . . . . . . . . .306, 307
Air Conditioning System . . .215, 306
Air Pressure, Tires . . . . . . . . . . .248
Alarm Light . . . . . . . . . . . . . . .173
Alarm (Security Alarm) . . . . . . . . .15
Alterations/Modifications, Vehicle . . .8
Antifreeze (Engine Coolant) . . . . . . . . .310, 311, 327 Disposal
. . . . . . . . . . . . . . .311
Anti-Lock Warning Light . . . . . .170
Anti-Theft System . . . . . . . . . . . .15
Ashtray . . . . . . . . . . . . . . .145, 147
Auto Down Power Windows . . . . . .26
Automatic Dimming Mirror . . . . . .77
Automatic Door Locks . . . . . . . . .22
Automatic Headlights . . . . . . . . .124
Automatic Oil Change Indicator . .184
Automatic Temperature Control (ATC) . . . . . . . . . . . . . . . . . .215
Automatic Transaxle Adding Fluid . . . . . . . . . . . .315
Fluid Level Check . . . . . . . . .315
Automatic Transmission . . .232, 314,
315
Adding Fluid . . . . . . . . . . . .315
Fluid and Filter Changes . . . .315
Fluid Change . . . . . . . . . . . .315
Fluid Type . . . . . . . . . . . . . .314
Gear Ranges . . . . . . . . . . . . .234
Special Additives . . . . . . . . . .314
Auto Up Power Windows . . . . . . . .26
Battery . . . . . . . . . . . . . . . . . . .305
Jump Starting . . . . . . . . . . . .291
Keyless Transmitter Replacement
(RKE) . . . . . . . . . . . . . . . . . .20
Saving Feature (Protection) . .125Belts, Seat
. . . . . . . . . . . . . . . . . .65
Blind Spot Monitoring . . . . . . . . . .80
Body Mechanism Lubrication . . . .308
B-Pillar Location . . . . . . . . . . . .258
Brake Assist System . . . . . . . . . .244
Brake Control System, Electronic . . . . . . . . . . . . . . .243
Brakes . . . . . . . . . . . . . . . . . . .313
Brake System . . . . . . . . . . . . . . .313
Fluid Check . . . . . . . . . . . . .313
Parking . . . . . . . . . . . . . . . .241
Warning Light . . . . . . . . . . .173
Brake/Transmission Interlock . . . .233
Break-In Recommendations, New Vehicle . . . . . . . . . . . . . . . . . .64
Bulb Replacement . . . . . . . . . . .324
Bulbs, Light . . . . . . . . . . . . .67, 323
Calibration, Compass . . . . .178, 187
Camera, Rear . . . . . . . . . . . . . .138
Capacities, Fluid . . . . . . . . . . . .327
Caps, Filler Fuel . . . . . . . . . . . . . . . . . .270
Oil (Engine) . . . . . . . . . . . . .300
Power Steering . . . . . . . . . . .240
Carbon Monoxide Warning . . . . . .65
Cargo Area Features . . . . . . . . . .154
Cargo Compartment . . . . . . . . . .154
Luggage Carrier . . . . . . . . . .155
342

Cargo (Vehicle Loading). . . . . . .151
Car Washes . . . . . . . . . . . . . . . .316
Cellular Phone . . . . . . . . . . .84, 215
Center High Mounted Stop Light . . . . . . . . . . . . . . . . . .326
Changing A Flat Tire . . . . . . . . .283
Chart, Tire Sizing . . . . . . . . . . . .254
Check Engine Light (Malfunction Indicator Light) . . . . . . . . . . .171
Checking Your Vehicle For Safety . .65
Checks, Safety . . . . . . . . . . . . . . .65
Child Restraint . . . . . . . . . . . .54, 58
Child Restraint Tether Anchors . . . .60
Child Safety Locks . . . . . . . . . . . .30
Child Seat . . . . . . . . . . . . . . . . . .63
Clean Air Gasoline . . . . . . . . . . .268
Cleaning Wheels . . . . . . . . . . . . . . . .316
Climate Control . . . . . . . . . . . . .215
Coat Hook . . . . . . . . . . . . . . . .150
Coin Holder . . . . . . . . . . . . . . .151
Cold Weather Operation . . . . . . .229
Compact Disc (CD) Maintenance . . . . . . . . . . . . .214
Compact Spare Tire . . . . . . . . . .249
Compass . . . . . . . . . .175, 178, 186
Compass Calibration . . . . . .178, 187
Compass Variance . . . . . . . .176, 187 Computer, Trip/Travel
. . . . . . . . .185
Connector UCI . . . . . . . . . . . . . . . . . .193
Universal Consumer Interface
(UCI) . . . . . . . . . . . . . . . . .193
Conserving Fuel . . . . . . . . . . . . .184
Console . . . . . . . . . . . . . . . . . .151
Console, Floor . . . . . . . . . . . . . .151
Console, Overhead . . . . . . . . . . .139
Console, Removable . . . . . . . . . .153
Cool Down, Turbo . . . . . . . . . . .231
Cooling System . . . . . . . . . . . . .309
Adding Coolant (Antifreeze) . .311
Coolant Capacity . . . . . . . . . .327
Coolant Level . . . . . . . .309, 312
Disposal of Used Coolant . . . .311
Drain, Flush, and Refill . . . . .310
Inspection . . . . . . . . . . . . . .312
Points to Remember . . . . . . .312
Selection of Coolant
(Antifreeze) . . . . . .310, 327, 328
Corrosion Protection . . . . . . . . . .315
Cupholders . . . . . . . . . . . .146, 318
Data Recorder, Event . . . . . . . . . .53
Defroster, Windshield . . . . . .66, 219
Diagnostic System, Onboard . . . . .301
Diesel Fuel . . . . . . . . . . . . .269, 328 Diesel Fuel Requirements
. . . . . . .269
Dipsticks Automatic Transaxle . . . . . . .315
Oil (Engine) . . . . . . . . . . . . .302
Power Steering . . . . . . . . . . .240
Disabled Vehicle Towing . . . . . . .295
Disposal Antifreeze (Engine Coolant) . .311
Door Locks . . . . . . . . . . . . . . . . .21
Door Locks, Automatic . . . . . . . . .22
Driving Through Flowing, Rising, or
Shallow Standing Water . . . . .238
Driving to Achieve Maximum Fuel Economy . . . . . . . . . . . . . . . .184
Electrical Power Outlets . . . . . . .143
Electric Remote Mirrors . . . . . . . . .78
Electronic Brake Control System . .243
Brake Assist System . . . . . . . .244
Electronic Speed Control (Cruise Control) . . . . . . . . . . . . . . . .131
Electronic Stability Control (ESC) . . . . . . . . . . . . . . . . . .245
Electronic Vehicle Information Center (EVIC) . . . . . . . .138, 178
Emergency, In Case of Hazard Warning Flasher . . . . .282
Jacking . . . . . . . . . . . .283, 286
Jump Starting . . . . . . . . . . . .291
343

Overheating. . . . . . . . . . . . .282
Engine . . . . . . . . . . . . . . . . . . .300
Air Cleaner . . . . . . . . . . . . .303
Break-In Recommendations . . .64
Checking Oil Level . . . . . . . .302
Compartment . . . . . . . . . . . .299
Compartment Identification . .299
Coolant (Antifreeze) . . . .309, 328
Cooling . . . . . . . . . . . . . . . .309
Exhaust Gas Caution . . . . . . . .65
Fails to Start . . . . . . . . . . . .229
Flooded, Starting . . . . . . . . .229
Fuel Requirements . . . . . . . .327
Oil . . . . . . . . . . . .302, 327, 328
Oil Change Interval . . . .184, 302
Oil Filler Cap . . . . . . . . . . . .300
Oil Filter . . . . . . . . . . . . . . .303
Oil Selection . . . . . . . . .303, 327
Oil Synthetic . . . . . . . . . . . .303
Overheating . . . . . . . . . . . . .282
Starting . . . . . . . . . . . . . . . .227
Temperature Gauge . . . . . . . .174
Enhanced Accident Response Feature . . . . . . . . . . . . . . .50, 52
Entry System, Illuminated . . . . . . .17
Ethanol . . . . . . . . . . . . . . . . . .268
Event Data Recorder . . . . . . . . . . .53
Exhaust Gas Caution . . . . . . . .33, 65 Exhaust System
. . . . . . . . . .65, 304
Exterior Folding Mirrors . . . . . . . .78
Exterior Lights . . . . . . . . . . . . . .67
Fabric Care . . . . . . . . . . . . . . . .317
Filler Location Fuel . . . . . . . . . .172
Filters Air Cleaner . . . . . . . . . . . . .303
Air Conditioning . . . . . .222, 307
Engine Oil . . . . . . . . . .303, 328
Engine Oil Disposal . . . . . . . .303
Flashers Hazard Warning . . . . . . . . . .282
Turn Signal . . . . . . .67, 168, 324
Flash-To-Pass . . . . . . . . . . . . . .126
Flooded Engine Starting . . . . . . .229
Floor Console . . . . . . . . . . . . . .151
Fluid Capacities . . . . . . . . . . . . .327
Fluid Leaks . . . . . . . . . . . . . . . . .67
Fluid Level Checks Automatic Transaxle . . . . . . .315
Brake . . . . . . . . . . . . . . . . .313
Cooling System . . . . . . . . . . .309
Power Steering . . . . . . . . . . .240
Fluids, Lubricants and Genuine Parts . . . . . . . . . . . . . . . . . . .328
Fog Lights . . . . . . . . .125, 168, 325
Fog Light Service . . . . . . . . . . . .325 Fog Lights, Rear
. . . . . . . . . . . .175
Fold in Floor (Stow `n Go) Seating . . . . . . . . . . . . . . . . .112
Freeing A Stuck Vehicle . . . . . . . .293
Fuel . . . . . . . . . . . . . . . . .267, 269
Adding . . . . . . . . . . . . . . . .270
Additives . . . . . . . . . . . . . . .269
Conserving . . . . . . . . . . . . . .184
Diesel . . . . . . . . . . . . .269, 328
Ethanol . . . . . . . . . . . . . . . .268
Filler Cap (Gas Cap) . . .172, 270
Filler Door (Gas Cap) . . . . . .172
Gasoline . . . . . . . . . . . . . . .267
Gauge . . . . . . . . . . . . . . . . .172
Light . . . . . . . . . . . . . . . . . .182
Octane Rating . . . . . . . .267, 328
Requirements . . . . . . . . . . . .327
Saver Mode . . . . . . . . . . . . .184
Specifications . . . . . . . . . . . .328
Tank Capacity . . . . . . . . . . .327
Fueling . . . . . . . . . . . . . . . . . . .270
Fuel Optimizer . . . . . . . . . . . . . .184
Fuel Saver . . . . . . . . . . . . . . . . .184
Fuses . . . . . . . . . . . . . . . . . . . .319
Gas Cap (Fuel Filler Cap) . . . . . .270
Gasoline, Clean Air . . . . . . . . . . .268
Gasoline (Fuel) . . . . . . . . . . . . .267
344