AUX LAND ROVER FRELANDER 2 2006 Manual Online

13. CAUTION: Cover fiber opti c cabl e connectorst o mi nimi ze dus t i ngress and avoid bendi ng the cablesi n a radi us of more than 30 mm.
13.
Releas e t he eart h lead.14.
Releas e t he ins trument panel harnes s from t het rans mis s ion t unnel .15.
Remove t he auxi liary juncti on box acces s cover.16.

Remove t he cool ant hos e clamps .
5.
Connect t he A/C pipes t o the TXV and ti ght en t he M6 nut .
T orque: 10 Nm 6.
Inst all t he ECM bracket as s embly and ti ght en t he nut s .
T orque: 10 Nm 7.
Connect t he ECM elect rical connectors .
8.
9. W ARNING: Make sure t hat a new bolt i s ins tal led.
Connect t he s teeri ng col umn l ower s haft and t ight en the bol t.
T orque: 25 Nm 9.
Connect t he drain tube t o t he heater hous i ng.
10.
Connect t he electric boos ter heat er core.
11.
Inst all t he cent er, lower ducts t o t he heater hous i ng.
12.
Inst all t he NVH pad.
13.
Inst all t he ins trument panel wiring harnes s .
14.
Inst all t he auxi liary juncti on box acces s cover.
15.
Secure t he ins trument panel harnes s to the trans mi ss i on tunnel.
16.
Secure and t ighten the eart h l ead.
T orque: 10 Nm 17.
Connect t he body harnes s t o t he i ns t rument panel .
18.
Inst all t he fl oor consol e extens ions.
19.
Inst all t he s el ect or lever mount ing bracket.
20.
Inst all t he transmis si on s elector lever.
Refer t o: Sel ect or Lever As sembl y (307-05 Aut omat ic
Trans mi ss ion/Transaxle Ext ernal Cont rol s , Removal and
Inst all at ion).
21.
Inst all t he LH front s eat .
Refer t o: Front Seat (501-10 Seati ng, Removal and Ins tal lati on).
22.
Inst all both cowl s ide t rim panels .
Refer t o: Cowl Si de Tri m Panel (501-05 Interior Tri m and
Ornament ati on, Removal and Ins tal lat ion).
23.
Secure both scuff pl ate t rim panels .
24.
Inst all t he A-pi llar center t rim panels .
25.

13. CAUTION: Cover fiber opti c cabl e connectors
t o mi nimi ze dus t i ngress and avoid bendi ng the cables
i n a radi us of more than 30 mm.
13. Releas e t he eart h lead.
14. Releas e t he ins trument panel harnes s from t he
t rans mis s ion t unnel .
15. Remove t he auxi liary juncti on box acces s cover.
16.

Remove t he cool ant hos e clamps .
5.
Connect t he A/C pipes t o the TXV and ti ght en t he M6 nut .
T orque: 10 Nm 6.
Inst all t he ECM bracket as s embly and ti ght en t he nut s .
T orque: 10 Nm 7.
Connect t he ECM elect rical connectors .
8.
9. W ARNING: Make sure t hat a new bolt i s ins tal led.
Connect t he s teeri ng col umn l ower s haft and t ight en the bol t.
T orque: 25 Nm 9.
Connect t he drain tube t o t he heater hous i ng.
10.
Secure t he redundant el ect ri c boos t er heater el ect ri cal connector.
11.
Inst all t he cent er, lower ducts t o t he heater hous i ng.
12.
Inst all t he NVH pad.
13.
Inst all t he ins trument panel wiring harnes s .
14.
Inst all t he auxi liary juncti on box acces s cover.
15.
Secure t he ins trument panel harnes s to the trans mi ss i on tunnel.
16.
Secure and t ighten the eart h l ead.
T orque: 10 Nm 17.
Connect t he body harnes s t o t he i ns t rument panel .
18.
Inst all t he fl oor consol e extens ions.
19.
Inst all t he s el ect or lever mount ing bracket.
20.
Inst all t he transmis si on s elector lever.
Refer t o: Sel ect or Lever As sembl y (307-05 Aut omat ic
Trans mi ss ion/Transaxle Ext ernal Cont rol s , Removal and
Inst all at ion).
21.
Inst all t he LH front s eat .
Refer t o: Front Seat (501-10 Seati ng, Removal and Ins tal lati on).
22.
Inst all both cowl s ide t rim panels .
Refer t o: Cowl Si de Tri m Panel (501-05 Interior Tri m and
Ornament ati on, Removal and Ins tal lat ion).
23.
Secure both scuff pl ate t rim panels .
24.
Inst all t he A-pi llar center t rim panels .
25.

Publi s hed: 11-May-2011
Instrument Panel and Console - Floor Console
Removal and Inst all ati on
Removal
Remove t he audi o cont rol s wit ches .
Refer t o: Rear Auxil iary Audi o Control s (415-01 Informat ion andEntertai nment Sys tem, Removal and Ins tal lat ion).
1.
Remove t he gear s elector knob.
Refer t o: Sel ect or Lever Knob (307-05 Aut omati cTrans mi ss ion/Transaxle Ext ernal Cont rol s , Removal andInst all at ion).Refer t o: Gears hi ft Lever Knob (308-06 ManualTrans mi ss ion/Transaxle Ext ernal Cont rol s , Removal andInst all at ion).
2.
Vehicles w ithout terrain response: Remove thes towage compart ment tray.3.
Vehicles w ith terrain response: Remove t he ri de and handl ingopti mizat ion s wit ch.
Refer t o: Ride and Handli ng Opti mizati on Swit ch (204-06 Ride andHandling Opti mizati on, Removal and Ins t al lat ion).
4.
Releas e t he gear s elector cover.5.

Remove t he gear s elector cover.6.
7. CAUTION: Prot ect t he s urroundi ng trim t o avoi ddamage.
Apply t he parking brake cont rol t o it 's hi ghes tpos si ble pos it ion.Di sconnect t he auxi liary input s ocket electricalconnector.Remove t he 8 s crews .Remove t he fl oor consol e.
7.

Refer t o: Ride and Handli ng Opti mizati on Swit ch (204-06 Ride andHandling Opti mizati on, Removal and Ins t al lat ion).
Vehicles w ithout terrain response: Ins tal l the s t owagecompart ment tray.8.
Inst all t he gear s elector knob.
Refer t o: Sel ect or Lever Knob (307-05 Aut omati cTrans mi ss ion/Transaxle Ext ernal Cont rol s , Removal andInst all at ion).Refer t o: Gears hi ft Lever Knob (308-06 ManualTrans mi ss ion/Transaxle Ext ernal Cont rol s , Removal andInst all at ion).
9.
Inst all t he audi o cont rol s wit ches
Refer t o: Rear Auxil iary Audi o Control s (415-01 Informat ion andEntertai nment Sys tem, Removal and Ins tal lat ion).
10.

3-RH rear door control module4-RH rear door handl e and l at ch5-Radio Frequency (RF) receiver6-Remote hands et7-Start cont rol module8-Left-Hand (LH) rear door handle and latch9-LH rear door control module10-LH front door handle and latch
11-LH front door control modul e12-Hood releas e cable13-LH hood l atch14-Hood safety hook15-RH hood l at ch and ajar swit ch16-Central Junction Box (CJB)17-Ins trument panel central locki ng s wit ches18-RH front door control modul e
COMPONENT LOCATION (SHEET 2 OF 2)
• NOTE: LHD shown; RHD s imil ar.
ItemPart NumberDescription1-Lift gate releas e s witch2-Auxili ary Juncti on Box (AJB)3-Fuel filler door actuat or
4-Lift gate latch and ajar s witch

Publi s hed: 11-May-2011
Wipers and Washers - Wipers and Washers
Des cript ion and Operat ion
COMPONENT LOCATION
ItemPart NumberDescription1-W i nds hiel d wiper mot or and linkage as sembl y
2-Automat ic Temperat ure Cont rol (ATC) module
3-Rain s ens or (if fit ted)4-Rear s creen wi per motor
5-Auxi li ary Junct ion Box (AJB)
6-Right Hand (RH) st eering col umn mult i-functi on s wit ch7-Ins t rument clus ter
8-Batt ery Junct ion Box (BJB)
9-Headl amp was her jets10-Headl amp was her pump
11-W i nds hiel d and rear s creen was her pump
12-Cent ral Junct ion Box (CJB)
OVERVIEW
W i nds hiel d wi per and was her operat ion is control led by the CJB i n res ponse to driver input and if fit ted, s ignals from t herai n s ens or. The front wi pers have 4 operat ional st ates :

Contents
4
L
Climate control
AIR VENTS ................................................... 101
MANUAL CLIMATE CONTROL ...................... 102
AUTOMATIC CLIMATE CONTROL ................. 103
HEATED WINDOWS AND MIRRORS ............ 104
AUXILIARY HEATER ..................................... 104
ELECTRIC SUNROOF .................................... 105
Convenience features
SUN VISORS ................................................ 107
CLOCK .......................................................... 107
CIGAR LIGHTER ........................................... 109
ASHTRAY ..................................................... 109
AUXILIARY POWER SOCKETS ..................... 110
CUP HOLDERS ............................................. 111
STORAGE COMPARTMENTS ........................ 112
Starting the engine
GENERAL INFORMATION ............................. 113
STARTING A PETROL ENGINE ..................... 114
STARTING A DIESEL ENGINE ....................... 115
DIESEL PARTICULATE FILTER (DPF) ........... 116
Transmission
MANUAL TRANSMISSION ............................ 118
AUTOMATIC TRANSMISSION ...................... 118
TECHNICAL SPECIFICATIONS ...................... 122
Brakes
PRINCIPLE OF OPERATION .......................... 123
HINTS ON DRIVING WITH ABS .................... 123
PARKING BRAKE .......................................... 124
Parking aid
PRINCIPLE OF OPERATION .......................... 126
USING THE PARKING AID ............................ 127
Driving hints
GENERAL DRIVING POINTS ......................... 128
REDUCED ENGINE PERFORMANCE ............. 128
RUNNING-IN ................................................ 128
ECONOMICAL DRIVING ................................ 129
Cruise control
PRINCIPLE OF OPERATION .......................... 130
USING CRUISE CONTROL ............................ 130
Terrain response
PRINCIPLE OF OPERATION .......................... 132
USING TERRAIN RESPONSE ........................ 132
Hill descent control (HDC)
PRINCIPLE OF OPERATION .......................... 136
USING HDC ................................................... 137
Traction control
USING TRACTION CONTROL ........................ 139
Stability control
PRINCIPLE OF OPERATION .......................... 140
USING STABILITY CONTROL ........................ 141
Fuel and refuelling
SAFETY PRECAUTIONS................................. 142
FUEL QUALITY .............................................. 142
RUNNING OUT OF FUEL................................ 144
FUEL CUT-OFF............................................... 144
FUEL FILLER FLAP ........................................ 144
REFUELLING ................................................. 145
TECHNICAL SPECIFICATIONS ....................... 146
Load carrying
GENERAL INFORMATION.............................. 147
LUGGAGE ANCHOR POINTS ......................... 148
LUGGAGE COVERS ....................................... 149
Towing
TOWING A TRAILER...................................... 150
LEVELLING.................................................... 151
ESSENTIAL TOWING CHECKS ...................... 151
RECOMMENDED TOWING WEIGHTS ............ 152
TOW BAR ...................................................... 153
Vehicle care
CLEANING THE ALLOY WHEELS................... 154
CLEANING THE EXTERIOR ............................ 154
CLEANING THE INTERIOR ............................ 155
REPAIRING MINOR PAINT DAMAGE ............ 156
Maintenance
GENERAL INFORMATION.............................. 157
OPENING AND CLOSING THE BONNET......... 160
ENGINE COMPARTMENT OVERVIEW ........... 161
ENGINE OIL CHECK....................................... 162