battery Lexus GX460 2010 Workshop Manual

644
4-3. Do-it-yourself maintenance
GX460_CANADA (OM60F29U)
CAUTION
■Removed battery and other parts
Keep away from children.
These parts are small and if swallowed by a child, they can cause choking.
NOTICE
■For normal operation after replacing the battery
Observe the following precautions to prevent accidents.
●Always work with dry hands.
Moisture may cause the battery to rust.
●Do not touch or move any other components inside the remote control.
●Do not bend the battery terminals.
GX460_CANADA.book Page 644 Thursday, February 4, 2010 11:54 AM

When trouble arises5
673
GX460_CANADA (OM60F29U)
5-1. Essential informationEmergency flashers................ 674
If your vehicle needs to be towed ............................ 675
If you think something is wrong ....................................... 681
Fuel pump shut off system ..................................... 682
Event data recorder ............. 683 5-2. Steps to take in
an emergency
If a warning light turns on or a warning buzzer
sounds... ................................. 686
If a warning message is displayed................................ 698
If you have a flat tire............... 720
If the engine will not start .... 734
If the shift lever cannot be shifted from P ....................... 736
If you lose your keys ............... 737
If the electronic key does not operate properly.......... 738
If the vehicle battery is discharged .............................. 741
If your vehicle overheats ...... 744
If the vehicle becomes stuck......................................... 747
If your vehicle has to be stopped in an
emergency ............................. 749
GX460_CANADA.book Page 673 Thursday, February 4, 2010 11:54 AM

674
GX460_CANADA (OM60F29U)
5-1. Essential information
Emergency flashers
NOTICE
■To prevent battery discharge
Do not leave the emergency flashers on longer than necessary when the engine is
not running.
Use the emergency flashers if the vehicle malfunctions or is involved in an
accident.
Press the switch to flash all the
turn signal lights. To turn them
off, push the switch once again.
GX460_CANADA.book Page 674 Thursday, February 4, 2010 11:54 AM

716
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)

Power was turned
off due to the
automatic power
off function.
Next time when
starting the
engine, increase
the engine speed
slightly and main-
tain that level for
approximately 5
minutes to
recharge the bat-
tery.
Sounds
onceThe electronic key
has a low battery.Replace the elec-
tronic key battery.
(→ P. 6 4 2 )
Interior
buzzerExterior buzzerWarning messageDetailsCorrection
procedure
GX460_CANADA.book Page 716 Thursday, February 4, 2010 11:54 AM

734
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)
If the engine will not start
If the engine will not start even though correct starting procedures are
being followed (
→P. 179), consider each of the following points:
■The engine will not start even when the starter motor operates
normally
One of the following may be the cause of the problem:
●There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle.
● The engine may be flooded.
Try to restart the engine once more following correct starting
procedures. ( →P. 1 7 9 )
● There may be a malfunction in the engine immobilizer system.
(→ P. 1 1 4 )
■ The starter motor turns over slowly, interior lights and headlights
are dim, or the horn does not sound or sounds at a low volume
One of the following may be the cause of the problem:
● The battery may be discharged. ( →P. 74 1 )
● The battery terminal connections may be loose or corroded.
■ The starter motor does not turn over
The engine starting system may be malfunctioning due to an electri-
cal problem such as an open circuit or a blown fuse. However, an
interim measure is available to start the engine. ( →P. 7 3 8 )
GX460_CANADA.book Page 734 Thursday, February 4, 2010 11:54 AM

5
When trouble arises
735
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)
Emergency start function
When the engine does not start, the following steps can be used as an
interim measure to start the engine if the “ENGINE START STOP” switch
is functioning normally:Set the parking brake.
Shift the shift lever to P.
Turn the “ENGINE START STOP” switch to ACCESSORY
mode.
Press and hold the “ENGINE START STOP” switch for about 15
seconds while depressing the brake pedal firmly.
Even if the engine can be started using the above steps, the system may
be malfunctioning. Have the vehicle inspected by your Lexus dealer.
■ The starter motor does not turn ov er, interior lights and headlights
do not turn on, or the horn does not sound
One of the following may be the cause of the problem:
● One or both of the battery terminals may be disconnected.
● The battery may be discharged. ( →P. 74 1 )
● There may be a malfunction in the steering lock system.
Contact your Lexus dealer if the problem cannot be repaired, or if
repair procedures are unknown.
STEP1
STEP2
STEP3
STEP4
GX460_CANADA.book Page 735 Thursday, February 4, 2010 11:54 AM

738
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)
If the electronic key does not operate properly
Locking and unlocking the doors and key linked functions
Use the mechanical key ( →P. 2 6 )
in order to perform the following
operations (driver’s door only):
Locks all the doors
Closes the windows and moon
roof (turn and hold)
*
Unlocks the door
Tu r n i n g t h e k e y r e a r w a r d u n l o c k s
the driver’s door. Turning the key
once again unlocks the other
doors.
Opens the windows and moon
roof (turn and hold)
*
*
: This setting must be customized at your Lexus dealer.
If communication between the electronic key and vehicle is interrupted
(→ P. 40) or the electronic key cann ot be used because the battery is
depleted, the smart access system with push-button start and wireless
remote control cannot be used. In such cases, the doors can be opened or
the engine can be started by following the procedure below.
GX460_CANADA.book Page 738 Thursday, February 4, 2010 11:54 AM

740
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)
■Stopping the engine
Shift the shift lever to P and press the “ENGINE START STOP” switch as you nor-
mally do when stopping the engine.
■Replacing the key battery
As the above procedure is a temporary measure, it is recommended that the elec-
tronic key battery be replaced immediately when the battery is depleted.
( → P. 6 4 2 )
GX460_CANADA.book Page 740 Thursday, February 4, 2010 11:54 AM

5
When trouble arises
741
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)
If the vehicle battery is discharged
The following procedures may be used to start the engine if the vehicle’s
battery is discharged.
You can call your Lexus dealer, or qualified repair shop.
If you have a set of jumper (or booster) cables and a second vehicle
with a 12 volt battery, you can jump start your Lexus by following the
steps below.
Open the hood. ( →P. 6 0 7 )
Connecting the jumper cables according to the following procedure: Positive (+) battery terminal on your vehicle.
Positive (+) battery terminal on the second vehicle.
Negative (-) battery terminal on the second vehicle.
Connect the jumper cable to ground on your vehicle as shown in the
illustration.
STEP1
STEP2
GX460_CANADA.book Page 741 Thursday, February 4, 2010 11:54 AM

742
5-2. Steps to take in an emergency
GX460_CANADA (OM60F29U)
■Starting the engine when the battery is discharged
The engine cannot be started by push-starting.
■To prevent battery discharge
●Turn off the headlights and the audio system while the engine is off.
●Turn off any unnecessary electrical components when the vehicle is running at a
low speed for an extended period, such as in heavy traffic, etc.
Start the engine of the second vehicle. Increase the engine
speed slightly and maintain at that level for approximately 5
minutes to recharge the battery of your vehicle.
Open and close any of the doors of your vehicle with the
“ENGINE START STOP” switch off.
Maintain the engine speed of the second vehicle and start the
engine of your vehicle by turning the “ENGINE START STOP”
switch to IGNI TION ON mode.
Once your vehicle’s engine has started, remove the jumper
cables in the exact reverse order in which they were con-
nected.
Once the engine starts, have the vehicle checked at your Lexus dealer
as soon as possible.STEP3
STEP4
STEP5
STEP6
GX460_CANADA.book Page 742 Thursday, February 4, 2010 11:54 AM