tires MAZDA 232 1990 Workshop Manual Suplement
[x] Cancel search | Manufacturer: MAZDA, Model Year: 1990, Model line: 232, Model: MAZDA 232 1990Pages: 677, PDF Size: 61.19 MB
Page 21 of 677
A PRE-DELIVERY INSPECTION
PRE-DELIVERY INSPECTION TABLE
pieziG-
INSPECT and ADJUST, if necessary, the following Items to
specification:
D Glass, exterior bright metal and paint for damage
Cl Wheel tug nuts
9 Trre pressures
LII All weatherstrips for damage or detachment
Z Operation of bonnet release and lock
D Operation of trunk lid, hatch and fuel lid opener
(it equipped)
3 Door operation and alignment
5 Headlight aiming
INSTALL the following parts:
D Wheel caps or rings (if equipped)
D Outside mirror(s)
[ UNDER BONNET-ENGINE OFF )
INSPECT and ADJUST, if necessary, the foIlowIng items to
specification:
Cl Fuel, coolant and hydraulrc lines, fittings, connections and
components for leaks
Cl Engine oil level
0 Power steering fluid level (if equipped)
D Brake master cylinder fluid levels
0 Clutch master cylinder fluid levels (if equipped) q
Windshield washer reservoir fluid level
D Radiator coolant level and specific gravity
Ll Tightness of water hose clamps
I3 Tightness of battery terminals, electrolyte level and specific
gravity
c) Manual transaxle oit level
D Drive belt(s) tension
C; Carburetor linkage (choke control, wide open throttle posi-
tion, etc.) (carburetor model only)
D Accelerator cable and linkage for free movement
D Headlight cleaner and fluid level (if equipped)
BLEED air from fuel line (diesel engine only)
CLEAN the spark plugs (except for diesef engine)
piicis-1
INSTALL the foflowing parts:
C Rubber stopper for inside rear view mirror (if equipped)
c! Fuse for accessories
CHECK the operation of the following items:
Cl Seat controls (sliding and redining) and head rest
ci Seat belts and warnrng system
Z! Ignition swrtch and steering lock
III Power window {if equipped)
0 Door locks including child proof door locks
0 Inhibitor switch
(ATX only)
Z All lights including warning and indicator lights
0 Ignrtron key reminder buyer (if equipped) Cl Horn, wipers and washers (front and rear, if equipped)
D Antenna (if equipped} q
Cigarette lighter and clock (if equipped)
I2 Remote controt outside mirror
(if equipped) q
Heater, defogger and air conditioner at various mode selec-
tions (if equipped)
c3 Sunroof (if equipped)
CHECK
the fotiowing items: q
Presence of spare fuse
c3 Upholstery and interior finish
CHECK and ADJUST, if necessary, the following items:
Cl Operation and fit of windows
D Pedal height and free ptay of brake and clutch pedal
Cl Parking brake
i UNDER BONNET-ENGtNE RUNNING AT ]
1 OPERATtNG TEMPERATURE
CHECK the following items:
Cl Operation of idle-up system for air conditioner or power steer-
ing (if equipped)
13 Automatic transaxle fluid level
D Initial ignition timing
(except disel engine) q
Idle speed
El Operation of throttle position sensor (EGI engine)
13 Operation of cold start device and glow plug warning light
(diesel engine only)
D Operation of dash pot [EGI engine)
t
ON HOtST 1
CHECK the following items:
U Underside fuel, coolant and hydraulic lines, fittings, connec-
tions and components for leaks q
Tires for cuts or bruises
Cl Steering linkage, suspension, exhaust system and all under-
side hardware for
looseness or damage
1 ROAD TEST 1
CHECK the foliowing items:
II Brake operation
D Clutch operation
0 Steering control
c3 Operation of meters and gauges
0 Squeaks, rattles or unusual noises q
Engine general performance
c3 Emergency Iocking retractors
rAFTER ROAD TEST 1
REMOVE the seat and floor mat protective covers
CHECK for the necessary
owner information materials, tools
and spare tire in vehicle
93EOAX-002
A-2
Page 26 of 677
SCHEDULED MAINTENANCE ‘SERVICES (Europe) A
Maintenance Number of months or km (miles), whichever comes first
Monthso - 6 12 18 24 30 36 42 4%
Maintenance Kilometers
1,000 10,000 20,000 30,000 40,000 50,000 60,000 70,000 80,000
(Miles)
(600) (6,000) (12,000) 1(18,000) (24,000) (30,000) (36,000) (42,000) (48,000) Chassis and body (Cont’d)
TIES (lnctud~ng spare tires) wrth infiation
pressure adjustment
Hinges and catches
U nderslde of vehicle
Seat belt
Roao test
Driveshaft dust boots
93GOAX-706
A-7
Page 29 of 677
A SCHEDULED MAINTENANCE SERVICES (Europe)
Maintenance Number of months or km (mires), whichever comes first
Months” - 6 12 18 24 30 1 36 42 48
Maintenance KIlometers 1,000 10,000 20,000 30,000 40,000 50,000 60,000 70,000 80,000
(Miles)
(600) 1 (6,000) j(12,OOO) (18,000) (24,000) (30,000) (36,000) (42,000) \(48,000) Chassis and body [Cont’d)
Steerrng and front suspension I
I
1 1 I I
MTX oil
A A A
R A A A R
Rear axle oil R A A R 1 A A A R
Trabsfercarrter oil
I R I A A R A A A R
B&s. nuts on chassis and body T 1 1 T T
T I T
Body condition (Visual
onfy) t nspect annually
Exhaust system hear shields I i
Tires (tncluding spare ttres) wtth rnflation
pressure adjustment t I I 1
Hinges and catches
A
bA4 ,A3 A
Understde of vehicle
i I I I I
Seat belt
I I I t
Road test
1 I I 1
Driveshafi dust bouts
I I I 1
93GOAX-709
A-10