brake sensor MAZDA 323 1992 Workshop Manual Suplement
[x] Cancel search | Manufacturer: MAZDA, Model Year: 1992, Model line: 323, Model: MAZDA 323 1992Pages: 279, PDF Size: 24.15 MB
Page 13 of 279

GI MAINTENANCE NOTE
VIEWED
.OM BELOW
‘REE
13EGfX-307
I
I t3EGIX-308 CHASSIS DYNAMOMETER CHECK
Caution
l Do not clutch abruptly. l Do not attempt rabbit starts or accelerate quickly.
1. Remove the propeller shaft.
2. Lock the center differential (2WD).
3. Place the front wheets on the roller.
4. Lock the rear wheels and apply the parking brake.
5. Drive the tester roller and check.
6. Upon completion of the test, gradually decelerate with soft
braking and stop the engine.
7. When the test is done, return the differential lclck rod to the
free condition (4WD) and reinstall the propeller shaft.
WHEEL BALANCER (On-the-car Balance)
1.
Jack up all four wheels. Support the wheels to be checked
(front or rear) with the wheel balancer sensor stand and the
remainrng wheels with safety stands.
2. Set the on-the-car balancer. With the center differential in
free condition, drove the tires with the engine; then check.
Page 21 of 279

A PRE-DELIVERY INSPECTION TABLE
PRE-DELIVERY INSPECTION TABLE
[EXTERlORI
INSPECT and ADJUST, of necessary. the followlng Items to
specrfrcatron:
0 Glass, exterior bright metal and paint for damage
0 Wheel lug nuts
0 Tire pressures
0 All weatherstrips for damage or detachment
0 Operation of bonnet release and look
0 Operation of trunk Ild, hatch and fuel lbd opener
(of equipped)
0 Door operation and alignment
0 Headtrght aiming
INSTALL the foltowrng parts
0 Wheel caps or rrngs (if equipped)
0 Outsrde mirror(s)
1 UNDER BONNET-ENGINE OFF j
INSPECT and ADJUST. If necessary, the following items to
specrflcatlon.
0 Fuel, coolant and hydraulic tines, fittings, connectlons and
components for leaks
0 Engine 011 level
0 Power steering fluid level (of equipped)
0 Brake master cylinder fluky levels
0 Clutch master cylinder fturcl levels (If equipped)
0 Wtndshreld washer reservojr flurd level
0 Radiator coolant level and specrfic gravity
0 Tightness of water hose clamps
0 Tightness of battery terminals, electrolyte level and specific
gravity
0 Manual transaxle oil level
0 Drive belt(s) tension
Cl Carburetor lrnkage (choke control, wrde open throttle posi-
tion. etc ) (carburetor model only)
q Accelerator cable and linkage for free movement
0 Headlight cleaner and flurd level (if equipped)
BLEED air from fuel line (diesel engrne only)
CLEAN the spark plugs (except for diesel engine)
piEi6F]
INSTALL the following parts
0 Rubber stopper for rnsrde rear view mirror (if equjpped)
0 Fuse for accessories
CHECK the operation of the following items.
0 Seat controls (sliding and reclining) and head rest
0 Seat belts and warning system
Cl Ign&on switch and steering lock
0 Power window (if equipped)
D Door tacks including child proof door locks
Cl Inhibitor switch (ATX only)
Cl All Ikghts rncluding warning and Indicator lbghts
0 Ignition key reminder buzzer (If equipped)
A-Z
0 Horn, wbpers and washers (front and rear, If equipped)
0 Antenna (tf equipped)
0 Cigarette Ibghter and clock (if equipped)
0 Remote control outside mirror (if equrpped)
0 Heater, defogger and air conditioner at various mode selec-
tions (if equlppedj
0 Sunroof (If equipped)
CHECK the following items
0 Presence of spare fuse
0 Upholstery and Interior finish
CHECK and ADJUST, If necessary, the followjng items:
IJ Operation and fit of windows
0 Pedal height and free play of brake and clutch pedal
0 Parking brake UNDER BONNET-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
0 Operation of Idle-up system for air condbtroner or power steer-
ing (if equrpped)
0 Automatic transaxle flurd levet
0 tnltial ignrtlon timing (except disel engine)
0 Idle speed
0 Operation of throttle positron. sensor (EGI engrne)
0 Operation of cold start device and glow plug warning light
(diesel engine only)
0 Operation of dash pbt (EGI.engine)
fTiGGJ
CHECK the following items.
0 Underside fuel, coolant and hydraulic Irnes, ftttlngs, connec-
tions and components for leaks
0 Trres for cuts or brurses
0 Steering Itnkage, suspensron, exhaust system and all under-
side hardware for .looseness or damage 1 ROAD TEST j
CHECK the following items
0 8rake operation
0 Clutch operation
0 Steering control
!ZI Operation of meters and gauges
Cl Squeaks, rattles or unusual noises
Cl Engine general performance
0 Emergency locking retractors 1 AFTER ROAD TEST ]
REMOVE the seat and floor mat protective covers
CHECK for the necessary owner information materials, took
and spare tire
m vehicle
93EOAX-002
-- MAIN Char3 t: In
A: PC R: F!t T: Ti! Emis! The ed : to t!
Page 98 of 279

M FRONT AXLE
WHEEL HUB, STEERING KNUCKLE
RemovaI / Inspection I Installation
1. Remove in the order shown in the figure, referring to Removal Note.
2. Inspect all parts and repair or replace as necessary.
3. InstaH in the reverse order of removal, referring to Installation Note.
Caution
l Loosely tighten the shock absorber bolts. Lower the vehicle and tighten the bolts to the specified
torque with the vehicle unladen.
4. Adjust the front wheel alianment.
16-22 ]1.6-2.3, 12-161 I
19.0-l 2.0, 65-86.7 I
1. Wheel hub nut
2. Wheel and tire
3. Locknut
Removal Note . . . . . . .._.. . . . . . . . . . . . . . . . . . . . page M-7
installation Note .I.........,..,............ page M-7
4. Brake caliper assembly
Service . _. . . . . . . . . ,__. . . , , . ._. _. , , . . . , . ._ ._. . . . . . Section P
5. Disc plate
lnspectioti .~~*.......*~...,......,,,.....*~...~. Section P
6. ABS wheel speed sensor (if equipped)
7. Tie rod end
Removal Note . . . . . . .._.......... I . .._.....= page M-7
lnstallatiofi Note . . .._... _.__......,....... page M-7
M-6
8. Lower ball joint
9. Steering knuckle, wheel hub, and dust cover
Inspect-wheel hub for cracks and damage
Inspect knuckle spindle for cracks and
damage
Inspect dust cuver for damage and dis-
tortion
Disassembly I Inspection I
Assembly . ..C1..............~...,.....,.....
page M-8
Page 104 of 279

REAR AXLE
WHEEL HUB, KNUCKLE
Removal I Inspection / installation
1. Remove in the order shown in the figure, referring to
Removal Note. 2. Inspect all parts and repair or replace as necessary.
3. Install in the reverse order of removal, referring to Installation Note.
Caution
l Loosely tighten the shock absorber bolts. Lower the vehicle and tighten the bolts to the specified
torque with the vehicle unladen.
4. Adiust the rear wheel alianment.
16-22 1?.6-2.3, 12-16 I
7
IO.o-13.0,
66-66.7 1 1. Wheel and tire
2. Locknut
Removal Note..; . . . . . . . . , . . . . ,.......- -.. page M-f 3
Installation Note .._...,.,...._.__........ page M-13
I$ Brake caliper assembly
Service . . . . . . . . . . . ..e......._......... ,.,...,....
Section P
4. Disc plate
‘Service ..I....................__....... . . . . . . . . . Section P 5. Af3S wheel speed sensor (if equipped)
6. Wheel hub, knuckle
Disassembly I Inspect& /
Assem bty . . . . . . . ..I..........*..*.*...-... page M-14
Inspect wheel hub and knuckle for damage
or cracks
Inspect dust cover for damage or defor-
mation
M-12
Page 219 of 279

INSTRUMENT CLUSTER
ILLUMINATION LAMP
;REFER TO SECTION I-4
c l INSTRUMENT CLUSTER &i WARNING LAMPS 0 .F.R.GERMAI
*....ABS
COMBINATION SWITCH
(SECTION E-l. 21
ENGINE CONTROL UNIT
(SECTIIXJ
B-ICI
SECTION F-2. 3)
l-l rr
II l-l
* * w
,,“,, W/R G/ G/Y Y l-l II
II rl
WY & * 2% l-l II II l-l
R R/B
* Y/L B B/G G/W 6/B 767 G/R
B/O * * L/W V * L
1.J II iH 1G *r- fk io IC pJ ipi * Y/R * W/E R/Y
a 2% 2.3 21 w 28 n- a a x ZB 2A
K 3 34 31 3 Lx+ 3 * a x 33 3*
-02 OIL PRESSURE
SWITCH(E) C-03 BRAKE FLUID SWITCH C-04 PARKING BRAKE
(0 SWITCH(R) C-05 WASHER LEVEL SENSO C-07 WATER THERMOSENSOR
(Fg
(INJ)
pjlfzJ
ma
f
38
Page 263 of 279

0 1 a ANTI-LOCK BRAKE SYSTEM (ABS)
MAIN
B( 0 (F1
4i:b
ABS
1OA
.lR-07@ STOP-
LIGHT
INSTRUMENT SWITCH DIAGNOSIS
CLUSTER (SECTIONCONNECTOR
(SECTEN c) F-2.3) ISECTZN LJ)
G SENSOR
\T- --
/I B/W (F1
1 B/W,(F)
32 23 25 26 43 INSTRUMENT
l
34 53
ABS CONTROL UNIT
NSTRUMENT
LUSTER
SECTION C) I
HEEL SPEED SENSOR ’ -
-03 Ai3S MAIN RELAY(F) O-04 ABS MOTOR RELAY (Fl
I-10 ABS WHEEL SPEEO O-II ABS WHEEL SPEED
SENSOR FR (F) SENSOR RL (R) ARS CONTROL UNIT(FR) IO-02 G SENSOR (FR)
MOTOR (F) O-06 H_VDRAzLIi UN:’ NO.lO-07 HYDRAULIC UNIT NO.dO-%? HYDRAULIC UNIT
I-12 ABS WHEEL SPEED
SENSOR RR IR)
Page 278 of 279

PARTS INDEX
PARTS NAME PAGE
PARTS NAME PAGE
I KNOCK CONTROL UNIT...................30
KNOCK SENSOR.........................30 .82
.82
.82
.82
.82
.32
.26
.72
a LICENSE PLATE LIGHT...............48.5 0
B MAIN RELAY(FUEL INJ)
............... ..2 8
1 NEUTRAL SWITCH.......................3 2
$3 OIL PRESSURE SWITCH..................3 8
OXYGEN SENSOR........................2 8
J PANEL LIGHT CONTROL..................7 0
PARKING BRAKE SWITCH.................3 8
POSITION LIGHT....................44,5 0
POWER DDOR LOCK SWITCH...............7 6
POWER DDOR LOCK TIMER UNIT...........7 6
POWER DOOR LOCK ACTUATOR.............7 6
POWER OUTSIDE MIRROR MOTOR...........7 0
POWER OUTSIDE MIRROR SWITCH..........7 8
POWER STEERING PRESSURE SWITCH.......3 2
POWER WINDOW MAIN SWITCH.............7 4
POWER WINDOW MOTOR...................7 4
e
1 BACK-UP LIGHT SWITCH.................60
BACK-UP LIGHT....
BLOWER MOTOR.....:::::::::::::::::::’
.E
BLOWER SWITCH........................62
BRAKE FLUID SWITCH...................38
POWER WINDOW SWITCH..................74
J D REAR FOG LIGHT RELAY.
REAR FOG LIGHT SWITCH
REAR FOG LIGHT.......
REAR SPEAKER......... ................
................ zz
................
52
................
................ E
................ 42
............... .
..: 2
.Riik+‘::::::::..6 4
SWITCH.........6 4
................
................ :z
................ 62
............. 44, 48
I CIGARETTE LIGHTER..
CIRCUIT OPENING REL
CLUTCH SWITCH...
COMBINATION SWITCH:
CONDENSER.......
COOLING FAN MOTOR::
COOLING FAN RELAY..
COURTESY LAMP.....,
CPU................ . .64
/ii’::::::::::::::..2 8
..................
... 44, 46, 48, 50, 52, %
..................
.................. 2:
..................
.................. 2:
............... 42, 66
B DIAGNOSIS CONNECTOR.....
DIGITAL CLOCK...........
n-rnnc ............
............ E
............
............ %
............
............ ZE
TURN LIGHT....
WASHER MOTOR.. REAR
REAR
REAR
REAR
REAR
REAR
REAR
REAR
-ih .ER
-ER
RESISTOR ASSEMBLY..
RUNNING LIGHT RELAY
il SEAT WARMER...........
SEAT WARMER REALY.....
SEAT WARMER SWITCH....
SHORT CONNECTOR.......
SLIDING SUNROOF MOTOR.
SLIDING SUNROOF RELAY.
SLIDING SUNROOF SWITCH
SLIDING SUNROOF.......
SOLENOID RESISTOR.....
SOLENOID VALVES
PRC HIGH TEMP........
PRC LOW TEMP.........
PURGE CONTROL........
WASTEGATE............
SPEED SENSOR..........
SPOT LAMP.............
STARTER...............
STOPLIGHT CHECKER..... ........
........
........
........
........
........
........
........
........ ....... 84
.......
....... ::
.......
.... 66.2
.......
.... 66, Ei
.......
....... ........
........
........
........
........
........
........
........
........
........
.
. . . . . . z:
. . .
. . . . zoo
. 1 .
. . . . E
. . . .
56, ::
. . 56, 58
. . 56, 58
“J.“LJL................. DISTRIBUTOR ............
DOOR SPEAKER ........... .
DOOR SWITCH........: .... 8
3 ENGINE CONTROL UNIT............ ,28, 30. 32
3 FLASHER UNIT...
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT SIDE TURN
FRONT TURN LIGH
FUEL METER.....
FUEL PUMP REALY
FUEL PUMP UNIT.
FUEL PUMP......
-. -- ............
............ 22 .
. . RiiA‘i 1
SWITCH
i&ii 1 ............ 52
............ .
............ 22
.....................
..................... %
.....................
..................... %
..................... 28 -
tust ....................
B
G SENSOR ................
13 HAZARD SWITCH............
HEADLIGHT CLEANER MOTOR..
HEADLIGHT CLEANER SWITCH.
HEADLIGHT LEVELING ACTUAT
HEADLIGHT LEVELING SWITCH
HEADLIGHT RELAY..........
ENI- IGHT. . . . . .
HORN RELAY...............
HORN SWITCH.............. ...
40, 46, 52, 64
: ........... 82
............ 54
........... .
..: ii
&::::::::..4 6
HORN..................I 1
HYDRAULIC UNIT ..........
01 IC REGURATOR ............
IG KEY CYLINDER LAMP ....
IGNITER .................
IGNITION COIL ...........
ILLUMINATION LAMP .......
AUDIO SYSTEM ...........
BLOWER SWITCH .......... ............
46
............ 44
......... 44, 46
............
............ E
............
............ E
...........
........... 2:
...........
........... 2
...........
........... 5:
...........
........... 5:
...........
........... 5::
...........
........... 5:
..........
.%
;ci:::::::.;;
........... CIGARETTE LIGHTER: ;.I:;::
FRONT FOG LIGHT SWITCH...
HAZARD SWITCH...........
HEADLIGHT CLEANER SWITCH:
HEADLIGHT LEVELING SWITCH
INSTRUMENT CLUSTER.......
REAR FOG LIGHT SWITCH....
REAR WINDOW DEFROSTER SW1
SEAT WARMER SWITCH.......
INDICATOR LAMP...........
...........
........... 33:: ...........
30 STOPLIGHT SWITCH ......
STOPLIGHT .............
0 TAChOMETER...........................3 8
TAILLIGHT.........................48,5 0
TEMP METER...........................3 8
THROTTLE SENSOR......................3 2
TRANSFER PUMP........................2 8
TRUNK COMPARTMENT LAMP SWITCH........6 8
TRUNK COMPARTMENT LAMP...............6 8
TURN SWITCH..........................5 4
q WARNING LAMP.........................3 8
WASHER LEVEL SENSOR..................3 8
WATER THERMOSENSOR................30,3 8
WATER THERMOSWITCH................... 6
WINDSHIELD WASHER MOTOR..............4 0
WINDSHIELD WASHER SWITCH.............4 0
WINDSHIELD WIPER MOTOR...............4 0
WINDSHIELD WIPER SWITCH..............4 0 INJECTOR..........:;.:::::
INJECTOR RESISTOR .........
INSTRUMENT CLUSTER .....
INTERIOR LAMP..........:::
ISC VALVE .................
. . . . . , . . . . .
. . . . . . . . . . . iz:
,..........
30