MAZDA MODEL 6 2018 (in English) Service Manual
Manufacturer: MAZDA, Model Year: 2018, Model line: MODEL 6, Model: MAZDA MODEL 6 2018Pages: 863, PDF Size: 14.1 MB
Page 41 of 863
NOTE
(Wagon)
When operating the remote handle, always
heed the following precautions.
xThe speed at which the seatback folds
down while the vehicle is on a down
slope increases.
xThe seatback may not fold down while
the vehicle is on an up slope. If the
seatback does not fold down when using
the remote handle, fold it down using
your hand.
/ R Z H U L Q J W K H V H D W E D F N V
& $ 8 7 , 2 1
Check the position of a front seat before
folding a rear seatback.
Depending on the position of a front seat, it
may not be possible to fold a rear seatback
all the way down because it may hit the
seatback of the front seat which could
scratch or damage the front seat or its
pocket. Lower or remove the head restraint
on the rear outboard seat if necessary.
6 D O R R Q
: L W K U H D U V H D W Z D U P H U
7 X U Q W K H U H D U V H D W Z D U P H U V Z L W F K R I I
5 H I H U W R 6 H D W : D U P H U R Q S D J H
2 S H Q W K H E R R W O L G D Q G S X O O W K H O H Y H U R I
W K H V H D W E D F N \ R X Z D Q W W R I R O G G R Z Q
2 S H Q D U H D U G R R U D Q G I R O G W K H U H D U V H D W
I R U Z D U G
: D J R Q
: L W K U H D U V H D W Z D U P H U
7 X U Q W K H U H D U V H D W Z D U P H U V Z L W F K R I I
5 H I H U W R 6 H D W : D U P H U R Q S D J H
6 H F X U H W K H U H D U V H D W E H O W L Q W K H E H O W
F O L S
Belt clip
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W V
Page 42 of 863
8 V L Q J U H P R W H K D Q G O H
2 S H Q W K H O L I W J D W H D Q G O R Z H U W K H
V H D W E D F N \ R X Z D Q W W R I R O G G R Z Q X V L Q J
W K H U H P R W H K D Q G O H
8 V L Q J S X V K N Q R E
3 U H V V W K H S X V K N Q R E W R I R O G G R Z Q W K H
V H D W E D F N
Using push knob Using remote handle
7 R U H W X U Q W K H V H D W E D F N W R L W V X S U L J K W
S R V L W L R Q
: $ 5 1 , 1 *
When returning a seatback to its upright
position, make sure the 3-point seat belt is
not caught in the seatback and the 3-point
seat belt is not twisted.
If the seat belt is used while it is twisted and
caught in the seatback, the seat belt
cannot function at its full capacity, which
could cause serious injury or death.
When returning a seatback to its upright
position, make sure that it is firmly locked
and the red indication is not visible
(Wagon):
If the red indication is visible behind the
push knob, it means the seatback is not
locked. If the vehicle is driven without the
seatback locked, it could fold down
suddenly and cause an accident.
Locked position
Unlocked position
Red indicator
, Q V H U W W K H S R L Q W V H D W E H O W L Q W R W K H E H O W
F O L S
3 U H V V W K H V H D W E D F N U H D U Z D U G D Q G O R F N L W
L Q S O D F H $ I W H U U H W X U Q L Q J W K H V H D W E D F N
W R L W V X S U L J K W S R V L W L R Q P D N H V X U H L W L V
V H F X U H O \ O R F N H G
▼▼ $ U P U H V W
7 K H U H D U D U P U H V W L Q W K H F H Q W U H R I W K H U H D U
V H D W E D F N F D Q E H X V H G Q R R F F X S D Q W L Q W K H
F H Q W U H V H D W R U S O D F H G X S U L J K W
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W V
Page 43 of 863
: $ 5 1 , 1 *
Never put your hands and
fingers around
the moving parts of the seat and armrest:
Putting your hands and
fingers around the
moving parts of the seat and armrest is
dangerous as they could get injured.
+ H D G 5 H V W U D L Q W V
< R X U Y H K L F O H L V H T X L S S H G Z L W K K H D G
U H V W U D L Q W V R Q D O O R X W E R D U G V H D W V D Q G W K H U H D U
F H Q W U H V H D W 7 K H K H D G U H V W U D L Q W V D U H
L Q W H Q G H G W R K H O S S U R W H F W \ R X D Q G W K H
S D V V H Q J H U V I U R P Q H F N L Q M X U \
: $ 5 1 , 1 *
Always drive with the head restraints
installed when seats are being used and
make sure they are properly adjusted:
Driving with the head restraints adjusted
too low or removed is dangerous. With no
support behind your head, your neck could
be seriously injured in a collision.
▼ + H L J K W $ G M X V W P H Q W
$ G M X V W W K H K H D G U H V W U D L Q W V R W K D W W K H F H Q W U H
L V H Y H Q Z L W K W K H W R S R I W K H S D V V H Q J H U
V
H D U V
7 R U D L V H D K H D G U H V W U D L Q W S X O O L W X S W R W K H
G H V L U H G S R V L W L R Q
7 R O R Z H U W K H K H D G U H V W U D L Q W S U H V V W K H
V W R S F D W F K U H O H D V H W K H Q S X V K W K H K H D G
U H V W U D L Q W G R Z Q
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W V
Page 44 of 863
) U R Q W R X W E R D U G V H D W
5 H D U R X W E R D U G V H D W
5 H D U F H Q W U H V H D W
▼▼ 5 H P R Y D O , Q V W D O O D W L R Q
) U R Q W R X W E R D U G V H D W 5 H D U F H Q W U H V H D W
7 R U H P R Y H W K H K H D G U H V W U D L Q W S X O O L W X S
Z K L O H S U H V V L Q J W K H V W R S F D W F K
7 R L Q V W D O O W K H K H D G U H V W U D L Q W L Q V H U W W K H O H J V
L Q W R W K H K R O H V
5 H D U R X W E R D U G V H D W
7 R U H P R Y H W K H K H D G U H V W U D L Q W S X O O L W X S
Z K L O H S U H V V L Q J E R W K V W R S F D W F K H V
7 R L Q V W D O O W K H K H D G U H V W U D L Q W L Q V H U W W K H O H J V
L Q W R W K H K R O H V
: $ 5 1 , 1 *
Always drive with the head restraints
installed when seats are being used and
make sure they are properly installed:
Driving with the head restraints not
installed is dangerous. With no support
behind your head, your neck could be
seriously injured in a collision.
After installing a head restraint, try lifting it
to make sure that it does not pull out:
Driving with an unsecured head restraint is
dangerous as the effectiveness of the head
restraint will be compromised which could
cause it to unexpectedly detach from the
seat.
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W V
Page 45 of 863
& $ 8 7 , 2 1
¾When installing a head restraint, make
sure that it is installed correctly with the
front of the head restraint facing
forward. If the head restraint is installed
incorrectly, it could detach from the seat
during a collision and result in injury.
¾The head restraints on each of the front
and rear seats are specialized to each
seat. Do not switch around the head
restraint positions. If a head restraint is
not installed to its correct seat position,
the effectiveness of the head restraint
during a collision will be compromised
which could cause injury.
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W V
Page 46 of 863
6 H D W : D U P H U
7 K H I U R Q W V H D W V D U H H O H F W U L F D O O \ K H D W H G 7 K H
L J Q L W L R Q P X V W E H V Z L W F K H G 2 1
3 U H V V W K H V H D W Z D U P H U V Z L W F K Z K L O H W K H
L J Q L W L R Q L V V Z L W F K H G 2 1 W R R S H U D W H W K H V H D W
Z D U P H U 7 K H L Q G L F D W R U O L J K W V W X U Q R Q W R
L Q G L F D W H W K D W W K H V H D W Z D U P H U L V R S H U D W L Q J
7 K H P R G H F K D Q J H V D V I R O O R Z V H D F K W L P H
W K H V H D W Z D U P H U V Z L W F K L V S U H V V H G
) U R Q W
OFF
High
Mid
Low
5 H D U
OFF
High
Mid
Low
: $ 5 1 , 1 *
Be careful when using the seat warmer:
The heat from the seat warmer may be too
hot for some people, as indicated as
follows, and could cause a
low-temperature burn.
¾Infants, small children, elderly people,
and physically challenged people
¾People with delicate skin
¾People who are excessively fatigued
¾People who are intoxicated
¾People who have taken sleep-inducing
medicine such as sleeping pills or cold
medicine
Do not use the seat warmer with anything
having high moisture-retention ability such
as a blanket or cushion on the seat:
The seat may be heated excessively and
cause a low-temperature burn.
Do not use the seat warmer even when
taking a short nap in the vehicle:
The seat may be heated excessively and
cause a low-temperature burn.
Do not place heavy objects with sharp
projections on the seat, or insert needles or
pins into it:
This could cause the seat to become
excessively heated and result in injury from
a minor burn.
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W : D U P H U 6 H D W 9 H Q W L O D W L R Q + H D W H G 6 W H H U L Q J : K H H O
6 R P H P R G H O V
Page 47 of 863
& $ 8 7 , 2 1
¾(Rear)
Before folding a rear seatback, make sure
that the rear seat warmer switch is
off. If
a rear seatback is folded while the rear
seat warmer is in operation, it may heat
the seat excessively and damage the seat
surface.
¾Do not use organic solvents to clean the
seat. It may damage the seat surface and
the heater.
NOTE
xUse the seat warmer when the engine is
running. Leaving the seat warmer on for
long periods with the engine not running
could cause the battery power to be
depleted.
x(Rear)
When the engine is stopped while the
seat warmers are operating and then the
ignition is switched ON, the seat
warmers will not turn back on
automatically. In addition, the seat
warmer operation stops automatically
after the seat warmers have operated for
about 90 minutes.
To turn the seat warmer back on, press
the switch.
xThe temperature of the seat warmer
cannot be adjusted beyond High, Mid
and Low because the seat warmer is
controlled by a thermostat.
6 H D W 9 H Q W L O D W L R Q
7 K H V H D W Y H Q W L O D W L R Q X V H V W K H I D Q V L Q V W D O O H G
R Q W K H V H D W V W R G U D Z D L U D U R X Q G W K H V H D W
V X U I D F H D Q G Y H Q W L O D W H W K H P 7 K H L J Q L W L R Q
P X V W E H V Z L W F K H G 2 1
3 U H V V W K H V H D W Y H Q W L O D W L R Q V Z L W F K Z K L O H W K H
L J Q L W L R Q L V V Z L W F K H G 2 1 W R R S H U D W H W K H V H D W
Y H Q W L O D W L R Q 7 K H L Q G L F D W R U O L J K W V W X U Q R Q W R
L Q G L F D W H W K D W W K H V H D W Y H Q W L O D W L R Q L V
R S H U D W L Q J 7 K H P R G H F K D Q J H V D V I R O O R Z V
H D F K W L P H W K H V H D W Y H Q W L O D W L R Q V Z L W F K L V
S U H V V H G
OFF
High
Mid
Low
& $ 8 7 , 2 1
Do not use organic solvents to clean the
seat. It may damage the seat surface and
the seat ventilation parts.
NOTE
Use the seat ventilation when the engine is
running. Leaving the seat ventilation on
for long periods with the engine not
running could cause the battery power to
be depleted.
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W : D U P H U 6 H D W 9 H Q W L O D W L R Q + H D W H G 6 W H H U L Q J : K H H O
6 R P H P R G H O V
Page 48 of 863
+ H D W H G 6 W H H U L Q J : K H H O
7 K H J U L S V R Q W K H O H I W D Q G U L J K W R I W K H
V W H H U L Q J Z K H H O F D Q E H Z D U P H G X S
Heated steering
wheel switch
Heating area
7 K H L J Q L W L R Q P X V W E H V Z L W F K H G 2 1
3 U H V V W K H V Z L W F K W R W X U Q R Q W K H K H D W H G
V W H H U L Q J Z K H H O 7 K H K H D W H G V W H H U L Q J Z K H H O
R S H U D W H V I R U D E R X W P L Q X W H V D Q G W K H Q
W X U Q V R I I D X W R P D W L F D O O \
7 K H L Q G L F D W R U O L J K W L O O X P L Q D W H V Z K H Q W K H
K H D W H U L V R S H U D W L Q J
7 R W X U Q R I I W K H K H D W H G V W H H U L Q J Z K H H O
E H I R U H W K H P L Q X W H V K D V H O D S V H G S U H V V
W K H V Z L W F K D J D L Q
& $ 8 7 , 2 1
The following types of persons should be
careful not to touch the steering wheel.
Otherwise, it could cause a
low-temperature burn.
¾Infants, small children, elderly people,
and physically challenged people
¾People with delicate skin
¾People who are excessively fatigued
¾People who are intoxicated
¾People who have taken sleep-inducing
medicine such as sleeping pills or cold
medicine
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W : D U P H U 6 H D W 9 H Q W L O D W L R Q + H D W H G 6 W H H U L Q J : K H H O
6 R P H P R G H O V
Page 49 of 863
6 H D W % H O W 3 U H F D X W L R Q V
6 H D W E H O W V K H O S W R G H F U H D V H W K H S R V V L E L O L W \ R I V H Y H U H L Q M X U \ G X U L Q J D F F L G H Q W V D Q G V X G G H Q
V W R S V 0 D ] G D U H F R P P H Q G V W K D W W K H G U L Y H U D Q G D O O S D V V H Q J H U V D O Z D \ V Z H D U V H D W E H O W V
$ O O W K H V H D W V K D Y H O D S V K R X O G H U E H O W V 7 K H V H E H O W V D O V R K D Y H U H W U D F W R U V Z L W K L Q H U W L D O R F N V W K D W
N H H S W K H P R X W R I W K H Z D \ Z K H Q Q R W L Q X V H 7 K H O R F N V D O O R Z W K H E H O W V W R U H P D L Q F R P I R U W D E O H
R Q X V H U V E X W W K H \ Z L O O O R F N L Q S R V L W L R Q G X U L Q J D F R O O L V L R Q
: $ 5 1 , 1 *
Always wear your seat belt and make sure all occupants are properly restrained:
Not wearing a seat belt is extremely dangerous. During a collision, occupants not wearing
seat belts could hit someone or things inside the vehicle or even be thrown out of the vehicle.
They could be seriously injured or even killed. In the same collision, occupants wearing seat
belts would be much safer.
Do not wear twisted seat belts:
Twisted seat belts are dangerous. In a collision, the full width of the belt is not available to
absorb the impact. This puts more force on the bones beneath the belt, which could cause
serious injury or death. So, if your seat belt is twisted, you must straighten the seat belt to
remove any twists and to allow the full width of the belt to be used.
Never use one seat belt on more than one person at a time:
Using one seat belt for more than one person at a time is dangerous. A seat belt used in this
way cannot spread the impact forces properly and the two passengers could be crushed
together and seriously injured or even killed. Never use one belt for more than one person at a
time and always operate the vehicle with each occupant properly restrained.
Do not operate a vehicle with a damaged seat belt:
Using a damaged seat belt is dangerous. An accident could damage the belt webbing of the
seat belt in use. A damaged seat belt cannot provide adequate protection in a collision. Have
an expert repairer, we recommend an Authorised Mazda Repairer inspect all seat belt systems
in use during an accident before they are used again.
Have your seat belts changed immediately if the pretensioner or load limiter has been
expended:
Always have an expert repairer, we recommend an Authorised Mazda Repairer immediately
inspect the seat belt pretensioners and air bags after any collision. Like the air bags, the seat
belt pretensioners and load limiters will only function once and must be replaced after any
collision that caused them to deploy. If the seat belt pretensioners and load limiters are not
replaced, the risk of injury in a collision will increase.
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W % H O W 6 \ V W H P V
Page 50 of 863
Positioning the Shoulder Portion of the Seat Belt:
Improper positioning of the shoulder portion of the seat belt is dangerous. Always make sure
the shoulder portion of the seat belt is positioned across your shoulder and near your neck,
but never under your arm, on your neck, or on your upper arm.
Positioning the Lap Portion of the Seat Belt:
The lap portion of the seat belt worn too high is dangerous. In a collision, this would
concentrate the impact force directly on the abdominal area, causing serious injury. Wear the
lap portion of the belt snugly and as low as possible.
Instructions for Use of Seat Belt Assemblies:
Seatbelts are designed to bear upon the bony structure of the body, and should be worn low
across the front of the pelvis or the pelvis, chest and shoulders, as applicable; wearing the lap
section of the belt across the abdominal area must be avoided.
Seatbelts should be adjusted as firmly as possible, consistent with comfort, to provide the
protection for which they have been designed. A slack belt will greatly reduce the protection
afforded to the wearer.
Care should be taken to avoid contamination of the webbing with polishes, oils and
chemicals, and particularly battery acid. Cleaning may safely be carried out using mild soap
and water. The belt should be replaced if webbing becomes frayed, contaminated or
damaged.
It is essential to replace the entire assembly after it has been worn in a severe impact even if
damage to the assembly is not obvious.
Belts should not be worn with straps twisted.
Each belt assembly must only be used by one occupant; it is dangerous to put a belt around a
child being carried on the occupant's lap.
No modifications or additions should be made by the user which will either prevent the seat
belt adjusting devices from operating to remove slack, or prevent the seat belt assembly from
being adjusted to remove slack.
& $ 8 7 , 2 1
Belt retraction may become difficult if the belts and rings are soiled, so try to keep them clean.
For more details about cleaning the seat belts, refer to "Seat Belt Maintenance" (page 6-70).
Ring
( V V H Q W L D O 6 D I H W \ ( T X L S P H Q W
6 H D W % H O W 6 \ V W H P V