fuel MERCEDES-BENZ CLK-CLASS 2002 Service Manual

320 Fuels, coolants, lubricants etc.
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Gasoline additives
A major concern among engine manufacturers is carbon
build up caused by gasoline. Mercedes-Benz
recommends the use of only quality gasoline containing
additives that prevent the build up of carbon deposits.
After an extended period of using fuels without such
additives, carbon deposits can build up especially on the
intake valves and in the combustion area, leading to
engine performance problems such as:
•Warm-up hesitation
•Unstable idle
•Knocking/pinging
•Misfire
•Power loss
Do not blend other specific fuel additives with fuel.
They only result in unnecessary cost, and may be
harmful to the engine operation.
Damage or malfunctions resulting from poor fuel
quality or from blending specific fuel additives are not
covered by the Mercedes-Benz Limited Warranty.Coolants
The engine coolant is a mixture of water and
anticorrosion/antifreeze, which provides:
•Corrosion protection
•Freeze protection
•Boiling protection (by increasing the boiling point)
The cooling system was filled at the factory with a
coolant providing freeze protection to approximately
-22
°F (-30
°C) and corrosion protection.
If the antifreeze mixture is effective to -22
°F (-30
°C), the
boiling point of the coolant in the pressurized cooling
system is reached at approximately 266
°F (130
°C).
The coolant solution must be used year-round to provide
the necessary corrosion protection and increase boil-
over protection. You should have it replaced every 15
years or 150 000 miles (250 000 km), whichever comes
first. Coolant system design and coolant used stipulate
the replacement interval. The above replacement
interval is only applicable if MB 325.0 anticorrosion/
antifreeze solution or other Mercedes-Benz approved
products of equal specification (see Factory Approved
Service Products pamphlet) are used to renew the
coolant concentration or bring it back up to the proper
level.
ProCarManuals.com

321 Fuels, coolants, lubricants etc.
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index To provide the important corrosion protection, the
solution must be at least 45% anticorrosion/antifreeze
(equals a freeze protection to approx. - 22
°F [-30
°C]). If
you use a solution that is more than 55% anticorrosion/
antifreeze (freeze protection to approx. - 49
°F [-45
°C]),
the engine temperature will increase due to the lower
heat transfer capability of the solution. Therefore, do not
use more than this amount of anticorrosion/antifreeze.
If the coolant level is low, water and MB 325.0
anticorrosion/ antifreeze should be used to bring it up
to the proper level (have cooling system checked for
signs of leakage).
Please make sure that the mixture is in accordance with
label instructions.
The water in the cooling system must meet minimum
requirements, which are usually satisfied by normal
drinking water. If your are not sure about the water
quality, consult your authorized Mercedes-Benz Center.
Anticorrosion/antifreeze
Your vehicle contains a number of aluminum parts. The
use of aluminum components in motor vehicle engines
necessitates that anticorrosion/antifreeze coolant used
in such engines be specifically formulated to protect the aluminum parts. (Failure to use such anticorrosion/
antifreeze coolant will result in a significantly
shortened service life.)
Therefore the following product is strongly
recommended for use in your vehicle: Mercedes-Benz
325.0 Anticorrosion/Antifreeze Agent.
Before the start of the winter season (or once a year in
the hot southern regions), you should have the
anticorrosion/antifreeze concentration checked. The
coolant is also regularly checked each time you bring
your vehicle to your authorized Mercedes-Benz Center
for service.
Anticorrosion/antifreeze quantity
Model Approx. freeze protection
-35
°F
(-37°C)-49
°F (
-45°C)
CLK 320 4.8 US qt
(4.5 l)5.3 US qt
(5.0 l)
CLK 430 5.9 US qt 6.5 US qt
ProCarManuals.com

326 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
CCapacities
Fuels, coolants, lubricants etc. ............................... 316
Cargo tie-down rings ..................................................... 152
Catalytic converter......................................................... 176
CD changer
See Audio system ...................................................... 136
Cellular telephone ......................................................... 153
Center console .................................................................. 18
Central locking switch .................................................... 33
Central locking system ................................................... 25
Automatic central locking ......................................... 34
Choosing global or selective mode........................... 28
Electronic key .............................................................. 23
Locking and unlocking............................................... 27
Mechanical keys ........................................................... 30
Remote control ............................................................ 25
Changing wheels ........................................................... 263
CHECK ENGINE malfunction indicator lamp............ 224
Check regularly and before a long trip ...................... 222
Checking engine oil level
Via engine oil level indicator .................................. 108
Via oil dipstick........................................................... 252Child restraint .............................................. 53, 58, 59, 69
Child seat
See Infant and child restraint systems .................... 69
Cleaning and care of the vehicle ................................ 300
Clock, setting .................................................................. 102
COMAND, radio and telephone.................................... 174
Combination switch ....................................................... 113
Consumer information ................................................. 322
Control and operation of radio transmitters .............. 174
COOLANT (coolant level) - malfunction and warning
messages ................................................................... 236
Coolant level
Adding coolant.......................................................... 254
Checking .................................................................... 253
COOLANT TEMP. (coolant temperature) - malfunction
and warning messages ............................................ 237
Coolant temperature gauge ............................................ 82
Coolants .......................................................................... 320
Anticorrosion/antifreeze quantity ........................ 320
Cruise control ................................................................. 210
Cup holder
Center console, front ................................................ 149
ProCarManuals.com

327 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
DDaytime running lamps ................................................. 111
Standing water
Driving instructions ................................................. 209
DISPLAY DEFECTIVE (engine control unit) -
malfunction and warning messages ...................... 231
DISPLAY DEFECTIVE (several systems) - malfunction
and warning messages ............................................ 231
Display illumination ........................................................ 81
Doors .................................................................................. 31
Drinking and driving .................................................... 201
Drive sensibly - save fuel .............................................. 201
Driving instructions ....................................................... 201
Driving off .......................................................................203EELEC. STABIL. PROG. - malfunction and warning
messages .................................................................... 241
Electronic key ................................................................... 23
Changing batteries ................................................... 285
Synchronizing remote control ................................ 287
Electronic stability program (ESP)
Control switch ........................................................... 218
Malfunction and warning messages ...................... 241Malfunction indicator lamp .................................... 227
Synchronizing............................................................ 217
Warning lamp ........................................................... 227
Emergency call
See Tele Aid................................................................ 179
Emergency tensioning device (ETD) ............................. 60
Emergency trunk lid release button ............................. 38
Emergency unlocking in case of accident.................... 34
Emission control ............................................................ 177
Emission control label ................................................... 310
Engine compartment .................................................... 250
ENGINE FAN - malfunction and
warning messages ........................................................ 235
Engine malfunction
CHECK ENGINE malfunction indicator lamp ...... 224
Engine oil additives ....................................................... 318
Engine oil consumption ................................................ 109
Engine oil level
Checking............................................................ 108, 252
Warning ..................................................................... 240
ENGINE OIL LEVEL - malfunction and warning
messages ................................................................... 240
Engine oil level indicator .............................................. 108
ENGINE OIL LEVEL NOT WHEN ENGINE ON
(measuring) - multifunction indicator ................... 109
Engine oils....................................................................... 318
ProCarManuals.com

328 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Capacities ................................................................... 316
ESP (Electronic stability program).... 207, 208, 216, 276
Control switch ........................................................... 218
Malfunction and warning messages ...................... 241
Malfunction indicator lamp..................................... 227
Synchronizing ........................................................... 217
Warning lamp ............................................................ 227
Express opening and closing
See Power windows .................................................. 143
Exterior lamp malfunction and
warning message .......................................................... 238
Exterior lamp switch ......................................................110
Exterior lamps ................................................................ 277
Adjusting headlamp aim .......................................... 282
Fog lamps ....................................................................110
Headlamps ..................... 110, 238, 239, 278, 282, 303
Low and high beam .......................................... 113, 279
Parking lamps ................................................... 110, 279
Replacing bulbs ......................................................... 277
Side marker lamp, front ........................................... 281
Standing lamps.................................................. 110, 279
Taillamp assemblies ................................................. 280
Turn signal lamp ............................................... 113, 279
FFirst aid kit ..................................................................... 246
Flat tire
See changing wheels ............................................... 263
Flexible service system (FSS) ...................................... 105
Fuel
Gasoline additives .................................................... 320
Premium unleaded gasoline.................... 176, 317, 319
Fuel cap placement warning ....................................... 226
Fuel filler flap
Manual release ......................................................... 296
Fuel requirements ......................................................... 319
Fuel reserve warning .................................................... 226
Fuels, coolants, lubricants etc. - capacities ............... 316
Fuse box ......................................................................... 248
Fuses, electrical ............................................................. 248GGarage door opener ....................................................... 154
Gasoline
Additives .................................................................... 320
Fuel requirements .................................................... 319
Premium unleaded.................................................... 319
ProCarManuals.com