transmission MERCEDES-BENZ E-CLASS COUPE 2009 Workshop Manual

G
Risk of injury
There is ariskofa cidb urns whe njump-start-
ing avehicle du etothe gases which escape
from the battery .Donot lean over the battery
while the engine is being jump-started. G
Risk of explosion
Gases escaping from the battery during jump-
starting may cause mino rexplosions. Avoid
creating sparks. Kee pnaked flames away
from the battery ,and do not smoke.
Compl ywiths afety precautions and take pro-
tective measures whe nhandling batteries. You will find these under "Battery
"inthe
index.
X Make sure that the two vehicle sdonot
touch.
X Appl ythe parking brake firmly.
X Manual transmission: engage neutral.
X Automatic transmission*: shift the trans-
missio ntoposition P.
X Switch off al lelectrical consumers (e.g.
radio, blower, etc.).
X Ope nthe bonne t(Ypage 180). X
Slide cover 0046of positive terminal 0047in
the direction of the arrow .
X Connect positive terminal 0047on your vehi-
cle to positive terminal 008Aof dono rbattery
0087 using the jump lead ,beginning with your
ow nb attery.
X Start the engine of the dono rvehicle and
run it at idling speed.
X Connect negative terminal 0088of dono rbat-
tery 0087to earth point 0086of your vehicle
using the jump lead ,connecting the jump
lead to dono rbattery 0087first.
X Start the engine. X
First, remove the jump lead from earth
point 0086and negative terminal 0088,then
from positive terminal 0047and positive ter-
minal 008A,eacht ime disconnecting from the
battery on your ow nvehicle first.
X Have the battery checke dataqualified
specialist workshop, e.g. aMercedes-Benz
Service Centre. Jump-starting
277Practical advice
*optional
207_AKB
;2;3,en-GB
mkalafa ,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 277 Z

Towin
gand tow-starting Points to remember
G
Ris
kofa ccident
If yo uhavet he vehicl etowed ,you must us ea
rigid towing ba rif:
R the engine is not running.
R there is abrake system malfunction.
R there is amalfunctio ninthe powe rsupply
or the vehicle's electrical system.
The powe rsteerin gand the brake force boos-
ter do not work when the engine is not run-
ning .Greate rbraking force will the nbe
required and brake peda ltravel will be longer.
If necessary ,dep ress the brake peda lwithf ull
force.
Before towing away ,makes uret ha tthe steer-
ing can be moved and is not locked.
If yo utow or tow-start anothe rvehicle, its
weight must not exceed the maximum per-
missibl egross vehicl eweigh tofy ourvehicle. G
Ris
kofa ccident
The vehicl eisbraked when the HOLD function
or DISTRONI CPLUS* is activated .Therefore,
deactivate HOLD and DISTRONI CPLUSift he
vehicl eistobet owed.
It is better to have the vehicl etransported
tha ntoh aveitt owed.
When towing ,obs erve the lega lrequirements
in al lcountrie sconcerned.
! When towing ,pulla wa yslowly and
smoothly. If the tractiv epower is too high,
the vehicles could be damaged.
! Do not us ethe towing ey efor recovery,
as thi scould damage the vehicle. If in
doubt, recover the vehicl ewithac rane.
! Youm aytow the vehicl efor am aximum
of 50 km. Atowing spee dof50k m/h must
not be exceeded.
For towing distances ove r50km, the entire
vehicl emustbel ifted up and transported. !
On vehicles with KEYLESS-GO *, usethe
key instea dofthe Start/Stop button. Turn
the key to position 2in the ignition lock and
shift the automatic transmission to N.Then
tur nthe key back to 0and leav eitinthe
ignition lock.
! Onlysecur ethe tow cable or towing bar
to the towing eyes .You could otherwise
damage the vehicle.
R Vehicle swithana utomatic transmission*
must not be tow-started.
R If yo uaretowing the vehicl eoveral onger
distance, thi smustbed onew itht he rear
axl eraised.
R Th eign ition must be switched off if yo uare
towing the vehicl ewitht he rea raxler aised.
Otherwise, interventio nbyESP®
could
damage the brake system.
R If the vehicl ehassuffered transmission
damage ,onlyt ow it with the propeller shaft
disconnected.
R If the engine does not start, try jump-start-
ing it (Y page 276).
R If it is not possibl etojump-star tthe vehicle,
have it towed to the neares tqualified spe-
cialist workshop ,e.g.aM ercedes-Benz
Service Centre.
R Th ea utomatic transmission* must be in
position Nwhen the vehicl eisbeing towed.
R Before towing the vehicle, make sure that
the battery is connected and charged. Oth-
erwise:
-yo uc annot switch on the ignition.
- yo uc annot shift the transmission to posi-
tion Non vehicles with automatic trans-
mission*.
- yo uh avenos upport when braking.
i Switch off the automatic locking feature
befor ethe vehicl eistowed (Y page 120).
Otherwise, yo ucould be locked ou twhen
pushing or towing the vehicle. 278
Towin
gand tow-startingPractical advice
*optional
207_AKB; 2; 3, en-GB
mkalafa
,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 278

Fitting th
etowing eye
Vehicles with atraile rtow hitch*: if you
inten dtou se thevehicl efor towing, fol dout
th eb all couplin gand connec tthe towbar
(Y page 193) to this.
Opening th ecovers The mounting
sfor th eremovable towin geyes
are locate dinthebumpers .They are located
at th efront and rear behind covers. Coupé (example)
X
Press cover 0046inwards on th emarkin gin
th ed irection of th earrow.
X Tak ecover 0046 off th eopening but do not
remove it.
Securing th etowing eye X
Tak ethe towin geye and th ewheel wrench
from th evehicl etoolkit (Y page 207).
X Screw in th etow inge ye clockwise to the
stop.
X Inser tthe wheel wrench handle int othe
towin geye and tighten it. Towing th
evehicle
! You may to wthe vehicl efor am aximum
of 50 km .Atowings pee dof50k m/hm ust
no tbee xceeded.
Fo rtow ingd istances ove r50km,thee ntire
vehicl emust be lifted up and transported.
! The engin emust be switched off (key in
ignition loc kinposition 0or position 1)if
th ev ehicl eisb eingtow ed wit hthe front
axle raised or if th eparking brak eisbeing
tested on adynamometer. Otherwise,
intervention by ESP ®
could damag ethe
brak esystem.
Vehicles with manua ltra nsmission X
Turn th ekeyto position 2(Y page 65 )in
th ei gnition lock.
X Fully depress th eclutch pedal.
X Shift to neutral.
Vehicles with automatic transmission* X
Turn th ekeyto position 2(Y page 65 )in
th ei gnition lock.
X Shift th etransmission to position N. Tow-starting (emergency engine
starting)
Pleas enote:
R Vehicles wit hanautomatic transmission*
must no tbetow-started.
R The battery must be connected.
R The engin eand catalyti cconverter must be
cold.
R Avoid repeated and lengthy starting
attempts.
Vehicles with manua ltra nsmission X
Turn th ekeyto position 2(Y page 65 )in
th ei gnition lock.
X Fully depress th eclutch pedal. Towin
gand tow-starting
279Practical advice
*optional
207_AKB
;2;3,en-GB
mkalafa, Version:2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 279 Z

X
Shift to neutral.
X Tow the vehicl eorletit roll.
X Shift to asuitabl egeara nd bring the clutch
peda lups lowly. Do not depress the accel-
erator pedal.
The engine is started. Removin
gthe towin geye
X Take the wheel wrench from the vehicle
tool kit (Y page 207).
X Insert the wheel wrench handl einto the
towing ey eand turn it anti-clockwise.
X Unscre wthe towing eye.
X Replace the cove rand press it unti lit
engages.
X Return the towing ey eand the wheel
wrench to the vehicl etool kit. Transporting the vehicle
The towing eyes or traile rcoupling *can be
used to pull the vehicle onto atraile rort rans-
porter if yo uwishtot ransport it.
! Only secure the vehicle by the wheel sor
wheel rims ,not by parts of the vehicle such
as axl eorsteering components. Otherwise,
the vehicle could be damaged.
Vehicles with manual transmission X
Shif tton eutral.
Vehicles with automati ctransmission* X
Turn the key to position 2(Y page 65) in
the ignition lock.
X Move the transmissio ntoposition N. Fuses
Note
sonc hanging fuses
The fuses in your vehicl eserv etoc lose down
faulty circuits. If afuseb lows ,allthe compo-
nents on the circuit and thei rfunctions will
fail.
Blown fuses mus tbereplaced with fuses of
the same rating, which yo ucan recognis eby
the colou rand value .The fus eratings are lis-
ted in the fus ealloc ation chart. AMercedes-
Benz Service Centre will be happy to advise
you. G
Ris
koff ire
Only us efuses that have bee napproved for
Mercedes-Benz vehicles and which have the
correct fus erating for the systems con-
cerned. Do not attempt to repai rorbridge
faulty fuses. Otherwise, acircuit overload
could cause afire .H ave the cause trace dand
rectifie dataq ualified specialist workshop,
e.g. aMercedes-Benz Service Centre.
If the newly inserted fus ealsob lows ,havet he
cause trace dand rectifie dataqualified spe-
cialist workshop, e.g. aMercedes-Benz
Service Centre.
! Only us efuses that have bee napproved
for Mercedes-Benz vehicles and which
have the correct fus erating for the system
concerned. Otherwise, components or sys-
tems could be damaged.
The fuses are locate dinvarious fus eboxes:
R fus eb ox on the driver' ssideoft he dash-
board*
R fus ebox in the engine compartment on the
driver' sside
R fus eb ox in the boo tonthe right-hand side
of the vehicle
Fus eallocatio nchart The fus
ealloc ation chart is locate dwitht he
vehicl etool kit (Y page 207) in the stowage 280
FusesPractical advice
*o
ptional
207_AKB; 2; 3, en-GB
mkalafa
,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 280

Retrofitting of two-wa
yradio sand
mobil ephones (RF transmitter)
Use the Technica lSpecification
ISO/T S21609 44
implementation regulation
when retrofitting RF (radi ofrequency) trans-
mitters.
If your vehicl ehasfittings for two-way radio
equipment (e.g. taxis, hir ecars or officia lvehi-
cles), us ethe power supply or aeria lconnec-
tions intended for us ewitht he basic wiring.
Be sure to observe the manufacturer' saddi-
tiona linstructions when installing the fittings.
! Damage resulting from installation work
that ha snot bee ncarrie doutcorrectly is
not covered by the Mercedes-Benz implied
warranty.
To ensure proper installation, Mercedes-
Benz recommend shaving this work done
at aM ercedes-Benz Service Centre or at a
qualified specialist workshop.
Transmission output Transmission outpu
tatthe aeria lbasem ust
not excee dthe maximum value sbelow. Waveband Maximum trans-
missio
noutput
(PEAK) Short wave
(f <54M Hz) 100 W
4mw
aveband 30 W
2mw
aveband 50 W
Trunked radio/Tetra 35 W
70 cm waveband 35 W
GSM 900/AMPS 10 W
GSM 1800 10 W
UMTS 10 W Aerial positions
The following aeria
lpositions may be used if
RF transmitters have bee nproperly installed: Aerial positions, Coupé
0046
Front roo farea( vehicle swithp anorama
sliding sunroof*: this are aisnot author-
ise dfor use)
0047 Rear roo farea( vehicle swithp anorama
sliding sunroof*: this are aisnot author-
ise dfor use)
008A Rear mudguard (recommended installa-
tion position: on the sid ewhich face sthe
centre of the road)
0088 Boot lid Aerial positions, Cabriolet
0046
Rear mudguard (recommended installa-
tion position: on the sid ewhich face sthe
centre of the road)
44 ISO/T S21609 –Technica lSpecification for Road Vehicles -- (EMC )guideli nesfor installation of aftermarket
radio frequency transmitting equipment. Vehicl
eelect ronics
285Technical data
*optional
207_AKB; 2; 3, en-GB
mkalafa
,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 285 Z

Vehicl
eidentificatio nnumber (VIN)
In additio ntobeing stampe donthe vehicle
identificatio nplate ,t he vehicl eide ntification
numbe r(VIN) is also stampe donto the vehicle
body .Itisloc ate dont he floor in front of the
right-hand front seat. X
Slide the right-hand front sea ttoits rear-
mos tposition.
X Slightl yraise front floor covering 008Aand
fol df loor covering flap 0046upwards.
Yo uw ills ee vehicl eide ntificatio nnumber
(VIN) 0047. Engine number
The engine numbe risstampe donthe crank-
case. Mor einformatio ncan be obtained from
any Mercedes-Benz Service Centre. Servic
eproducts and capacities
Service products includ ethe following:
R fuels (e.g. petrol ,diesel)
R lubricants (e.g. engine oil, transmission oil)
R coolant
R brake fluid
R windscree nwashe rc oncentrate
Mercedes-Benz recommends tha tyou use
products which have been teste dand spe-
ciall yapproved by Mercedes-Benz for your vehicl
eand ar elisted in this Mercedes-Benz
Owner' sManualint he relevant chapte ras:
R parts and service products ar ematched
R damage caused by the us eofnon-approved
service products is not covered by the
implied warranty
Yo uc an recognise service products approved
by Mercedes-Benz by the following inscrip-
tio nont he containers:
R MB-Freigab e(e.g. MB-Freigab e229.51)
R MB Approva l(e.g. MB Approva l229.51)
Othe rdesig nations or recommendations that
relate to alev el of quality or aspecification in
accordance with an MB Shee tnumbe r(such
as MB 229.5) have not necessaril ybeen
approved by Mercedes-Benz.
Yo uc an obtai nfurthe rinformatio nfrom any
Mercedes-Benz Service Centre. G
Ris
kofi njury
Whe nhandling ,storing and disposing of any
service products, please observe the relevant
regulations, as yo ucould otherwise endanger
yoursel fand others.
Kee pservice products away from children.
To protect your health ,donot allo wservice
products to come into contact with your eyes
or open wounds. See adoctor immediatel yif
any service product is swallowed. H
Environmental note
Dispose of service products in an environ-
mentally-responsibl emanner. Fuel
G
Ris
kofe xplosion
Fue lish ighl yf lammable. Fire ,nake dflames
and smoking are therefore prohibited when
handling fuels.
Before refuelling, turn off the engine and the
auxiliary heating *. Service products and capacities
287Technical data
*optional
207_AKB; 2; 3, en-GB
mkalafa,
Version: 2.11.8.1 2009-07-23T10:23:49+02:00-Seite 287 Z

G
Risk of accident
If the boiling point of the brake fluid is too low,
vapou rpockets may form in the brake system
whe nthe brakes are applie dhard( e.g .when
driving downhill) .Thisw ould impai rbraking
efficiency.
Have the brake fluid renewed every two years
with abrake fluid that ha sbeena pproved by
Mercedes-Benz and have this confirmed in
the Service Booklet.
The warranty is only valid if yo uhavet he vehi-
cle topped up with an antifreeze/corrosion
inhibitor which ha sbeena pproved by
Mercedes-Benz.
i There is usuall yanotice in the engine
compartment to remind yo uwhent he next
brake fluid change is due. Windscree
nwasher system
The headlamp cleaning system* and wind-
scree nwashe rsystem are both supplie dfrom
the washe rfluid reservoir.
Further information on windscreen washer
fluid and its mixing rati o(Ypage 183). Vehicl
edata, E200 CGI BlueEFFI-
CIENCY Vehicl
edimensions Vehicl
elen gth (ECE) Coupé
4698 mm
Cabriolet
4698 mm
Vehicl
ewidth including exterio rmirrors Coupé
2028 mm
Cabriolet
2015 mm Vehicl
edimensions Vehicl
eheight 47 Coupé
1393 mm
Cabriolet
1398 mm
Whee
lbase Coupé
2760 mm
Cabriolet
2760 mm
Vehicl
eweigh ts48 Unladen weight (i
naccordance with EC
Directive), manual transmission Coupé
Cabriolet
Unladen weight (i
naccordance with EC
Directive), automati ctransmission Coupé
Cabriolet
The unladen weigh
tincludes the driver
(68 kg), luggage (7 kg) and al lfluid s(fuel
tank 90% full) .Items of optional equipment
increas ethe unladen weigh tand reduce the
maximum payload. Maximum roof
load, Coupé only
100 kg
Maximum boot
load
100 kg
Vehicle-specific weigh
tinformation can be
found on the vehicle identification plate
(Y page 286). 47
The value sspecified may differ from the actual values, depending on the tyres, load, optional equipment
and the state of the suspension.
48 Missing value sweren ot available at time of going to print. Vehicled
ata,E200 CGI BlueEFFICIENCY
291Technical data
*optional
207_AKB
;2;3,en-GB
mkalafa ,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 291 Z

Vehicl
edimensions Cabriolet
2015 mm
Vehicl
eheight 55 Coupé
1398 mm
Cabriolet
1403 mm
Wheel base
Coupé
2760 mm
Cabriolet
2760 mm
Vehicl
eweigh ts56 Unlade
nweigh t(in accordance with EC
directive) Coupé
1715 kg
Cabriolet
The unladen weight includes the driver
(68 kg), luggage (7 kg) and al lfluid s(fuel
tank 90% full) .Items of optiona lequipment
increas ethe unladen weight and reduce the
maximu mpayload. Maximum roof
load, Coupé only 100 kg
Maximum boot
load 100 kg
Vehicle-specific weight information can be
found on the vehicl
eide ntification plate
(Y page 286). Vehicl
edata, E220 CDIBlueEFFI-
CIENCY Vehicl
edimensions Vehicl
elengt h(ECE) Coupé
4698 mm
Cabriolet
4698 mm
Vehicl
ewidth includin gexterior mirrors Coupé
2028 mm
Cabriolet
2015 mm
Vehicl
eheight 57 Coupé
1393 mm
Cabriolet
1398 mm
Wheel base
Coupé
2760 mm
Cabriolet
2760 mm
Vehicl
eweigh ts58 Unlade
nweigh t(in accordance with EC
Directive), manual transmission Coupé
Cabriolet
Unlade
nweigh t(in accordance with EC
Directive), automatic transmission Coupé
55
The value sspecified may differ from the actual values, depending on the tyres, load ,optiona lequipment
and the state of the suspension.
56 Missing value sweren ot available at time of going to print.
57 The value sspecified may differ from the actual values, depending on the tyres, load ,optiona lequipment
and the state of the suspension.
58 Missing value sweren ot available at time of going to print. 294
Vehicl
edata, E220 CDIBlueEFFICIENCYTechnical data
207_AKB; 2; 3, en-GB
mkalafa ,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 294

Vehicl
eweigh ts58 Cabriolet
The unladen weight includes the driver
(68 kg), luggage (7 kg) and al
lfluid s(fuel
tank 90% full) .Items of optiona lequipment
increas ethe unladen weight and reduce the
maximu mpayload. Maximum roof
load, Coupé only
100 kg
Maximum boot
load
100 kg
Vehicle-specific weight information can be
found on the vehicl
eide ntification plate
(Y page 286). Vehicl
edata, E250 CDIBlueEFFI-
CIENCY Vehicl
edimensions Vehicl
elengt h(ECE) Coupé
4698 mm
Cabriolet
4698 mm
Vehicl
ewidth includin gexterior mirrors Coupé
2028 mm
Cabriolet
2015 mm
Vehicl
eheight 59 Coupé
1397 mm
Cabriolet
1402 mm Vehicl
edimensions Wheel base
Coupé
2760 mm
Cabriolet
2760 mm
Vehicl
eweigh ts60 Unlade
nweigh t(in accordance with EC
Directive), manual transmission Coupé
1695 kg
Cabriolet
Unlade
nweigh t(in accordance with EC
Directive), automatic transmission Coupé
1690 kg
Cabriolet
The unladen weight includes the driver
(68 kg), luggage (7 kg) and al
lfluid s(fuel
tank 90% full) .Items of optiona lequipment
increas ethe unladen weight and reduce the
maximu mpayload. Maximum roof
load, Coupé only
100 kg
Maximum boot
load
100 kg
Vehicle-specific weight information can be
found on the vehicl
eide ntification plate
(Y page 286). 58
Missing value sweren ot available at time of going to print.
59 The value sspecified may differ from the actual values, depending on the tyres, load ,optiona lequipment
and the state of the suspension.
60 Missing value sweren ot available at time of going to print. Vehicl
edata, E250 CDIBlueEFFICIENCY
295Technical data
207_AKB; 2; 3, en-GB
mkalafa,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 295 Z

Trailer loads
Al
lm odels Permissibl
etrailer
load, unbraked 750 kg Al
lm odels Permissibl
etrailer
load, braked 71 1800 kg
Maximum drawbar
noseweight
72 75 kg
Permissibl
erear axl eloa dw hent owin gatrailer Coupé Cabriolet
Manual trans-
mission Automatic
transmission Manual trans-
mission Automatic
transmission E2
00 CGIBlueEFFI-
CIENCY 1130 kg 1135 kg 1190 kg 1205 kg
E2
50 CGIBlueEFFI-
CIENCY – 1140 kg – 1210 kg
E3
5073 – 1150 kg – 1230 kg
E3
50 CGIBlueEFFI-
CIENCY – 1155 kg – 1235 kg
E5
00 – 1170 kg – 1240 kg
E2
20 CDIBlueEFFI-
CIENCY 1155 kg 1160 kg 1225 kg 1235 kg
E2
50 CDIBlueEFFI-
CIENCY 1165 kg 1165 kg 1235 kg 1240 kg
E3
50 CDIBlueEFFI-
CIENCY – 1155 kg – 1235 kg
24-GHz radar sensor system (country
overview)
The 24 GHz rada rsensor system requires
separate approva lfor each country .When
yo ua redriving in acountry in which the radar
sensor system is not approved ,you must
deactivate the system using the on-board
compute r(Ypage 120) .The current country
overview can be obtained fro maMercedes-
Benz Service Centre. The rada
rsensor system is automatically
deactivated nea rradio telescop efacilities .If
Distroni cPlus* or PRE-SAFE ®
Brake* are
activated at thi spoint, acorresponding warn-
ing will appear in the multi-functio ndisplay to
tel lyou tha tthe rada rsen sor system is being
switched off .BAS PLUS* is also no longer
available. If the deactivatio ndoesn ot occur
automatically, yo umustd eactivate the radar
sensor system using the on-board computer
(Y page 120). 304
24-GHz radar sensor system (country overvie
w)Technica ldata
*optional
207_AKB; 2; 3, en-GB
mkalafa
,V ersion: 2.11.8.1
2009-07-23T10:23:49+02:00
-Seite 304