transmission MERCEDES-BENZ E-CLASS SALOON 2008 Workshop Manual

Vehicle electronics
345Vehicle electronics
Tampering with the engine electron-
ics
G
Risk of accident
Only have work on the engine electronics
and related components carried out at a
qualified specialist workshop which has the
necessary specialist knowledge and tools
to carry out the work required. Mercedes-
Benz recommends that you use a
Mercedes-Benz Service Centre for this pur-
pose. In particular, work relevant to safety
or on safety-related systems must be car-
ried out at a qualified specialist workshop.
The vehicle's roadworthiness could other-
wise be affected.
! Only have work done on the engine elec-
tronics and its associated parts, such as
control units, sensors and connector leads,
carried out at a qualified specialist work-
shop, e.g. a Mercedes-Benz Service
Centre. Otherwise, vehicle components
may wear more quickly and your vehicle's
warranty and operating permit may be inva-
lidated. Retrofitting electrical and electronic
equipment
Electrical and electronic equipment can jeop-
ardise the operating safety of your vehicle. If
equipment of this kind is retrofitted, it must
be type-approved and bear the emark. The
e mark may be obtained from the equipment
manufacturer or an authorised testing centre.
! Damage or consequential damage arising
from fitting equipment not approved
by Mercedes-Benz is not covered by the
Mercedes-Benz warranty.
If you wish to install two-way radios in the
vehicle, you must obtain formal approval.
Mercedes-Benz approves the installation of
two-way radios if such equipment is installed
professionally and a low-reflection exterior
aerial is used.
The transmission output of the two-way radio
must not exceed the maximum transmission
outputs listed. G
Risk of accident
Two-way radios may interfere with the vehi-
cle electronics and thereby jeopardise the
operational safety of the vehicle and your
own safety if: R
they do not have an exterior aerial
R the exterior aerial is not a low-reflection
aerial
R the exterior aerial has been fitted incor-
rectly G
Risk of injury
Excessive electromagnetic radiation may
also cause damage to your health and the
health of others. Using an exterior aerial
takes into account current scientific dis-
cussions relating to the possible health haz-
ards that may result from electromagnetic
fields.
For this reason, only have the exterior aerial
fitted at a qualified specialist workshop
which has the necessary specialist knowl-
edge and tools to carry out the work
required. Mercedes-Benz recommends
that you use a Mercedes-Benz Service
Centre for this purpose. In particular, work
relevant to safety or on safety-related sys-
tems must be carried out at a qualified
specialist workshop.
i Mercedes-Benz recommends the use of
an approved exterior aerial. This ensures
optimal reception quality for mobile tele- Technical data
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4
2008-02-29T16:57:07+01:00 - Seite 345 ZDateiname: 6515_3416_02_buchblock.pdf; preflight

Engine
349E 350 E 350 4MATIC E 500 E 500 4MATIC
Displacement
3,498 cm
3 3,498 cm
3 5,461 cm
3 5,461 cm
3 Maximum engine
speed 6,500 rpm 6,500 rpm 6,500 rpm 6,500 rpm
E 63 AMG E 200 CDI E 220 CDI E 280 CDI
Rated output 378 kW (514 bhp) 100 kW (136 bhp) 125 kW (170 bhp) 140 kW (190 bhp)
At engine speed 6,800 rpm 3,800 rpm 3,800 rpm 4,000 rpm
Rated torque 630 Nm 340 Nm 400 Nm
400 Nm (440 Nm
38
) At engine speed 5,200 rpm 1,800 – 2,600 rpm 2,000 rpm 1,400 – 3,200 rpm
(1,400 - 2,800 rpm 38
) Number of cylinders 8 4 4 6
Displacement
6,208 cm
3 2,148 cm
3 2,148 cm
3 2,987 cm
3 Maximum engine
speed 7,200 rpm 5,000 rpm 5,000 rpm 4,500 rpm
38
Only on vehicles with automatic transmission. Technical data
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4 2008-02-29T16:57:07+01:00 - Seite 349 ZDateiname: 6515_3416_02_buchblock.pdf; preflight

Performance
3535-speed
Automatic transmis- sion* E 200 CDI E 220 CDI E 280 CDI 4MATIC E 320 CDI 4MATIC
Maximum speed Saloon 211 km/h 225 km/h 234 km/h 244 km/h
Estate 200 km/h 218 km/h 226 km/h 236 km/h
6-speed
Manual transmission E 200 KOMPRESSOR E 230 E 280
Maximum speed Saloon 236 km/h 248 km/h 250 km/h
Estate 225 km/h 233 km/h 246 km/h
6-speed
Manual transmission E 200 CDI E 220 CDI E 280 CDI
Maximum speed Saloon 214 km/h 227 km/h 241 km/h
Estate 202 km/h 218 km/h 231 km/h Technical data
* optional
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4 2008-02-29T16:57:07+01:00 - Seite 353 ZDateiname: 6515_3416_02_buchblock.pdf; preflight

Performance
354 Acceleration from 0 to 100 km/h
E 200 KOMPRESSOR E 230 E 280 E 280 4MATIC
6-speed manual
transmission Saloon 9.1 seconds 8.9 seconds 7.3 seconds –
Estate 9.5 seconds 9.9 seconds 8.1 seconds –
5-speed automatic
transmission Saloon 9.4 seconds – – 7.8 seconds
Estate 9.7 seconds – – 8.3 seconds
7-speed automatic
transmission Saloon – 9.1 seconds 7.3 seconds –
Estate – 9.9 seconds 7.9 seconds –
E 350 E 350 4MATIC E 500 E 500 4MATIC
5-speed automatic
transmission Saloon – 7.1 seconds – 5.5 seconds
Estate – 7.4 seconds – 5.7 seconds
7-speed automatic
transmission Saloon 6.9 seconds – 5.3 seconds –
Estate 7.1 seconds – 5.4 seconds –Technical data
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4 2008-02-29T16:57:07+01:00 - Seite 354Dateiname: 6515_3416_02_buchblock.pdf; preflight

Performance
355E 200 CDI E 220 CDI E 280 CDI
6-speed manual
transmission Saloon 9.9 seconds 8.4 seconds 8.6 seconds
Estate 10.5 seconds 9.1 seconds 9.1 seconds
5-speed automatic
transmission Saloon 9.9 seconds 8.6 seconds –
Estate 10.7 seconds 9.1 seconds –
7-speed automatic
transmission Saloon – – 7.6 seconds
Estate – – 8.2 seconds
E 280 CDI 4MATIC E 320 CDI E 320 CDI 4MATIC E 420 CDI
5-speed automatic
transmission Saloon 8.2 seconds – 7.4 seconds –
Estate 9.0 seconds – 8.1 seconds –
7-speed automatic
transmission Saloon – 6.8 seconds – 6.1 seconds
Estate – 7.3 seconds – –
E 350 CGI E 300 Bluetec E 63 AMG
7-speed automatic
transmission Saloon 6.8 seconds 7.2 seconds 4.5 seconds
Estate 7.0 seconds – 4.6 secondsTechnical data
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4 2008-02-29T16:57:07+01:00 - Seite 355 ZDateiname: 6515_3416_02_buchblock.pdf; preflight

Trailer coupling*
376 Trailer loads
All models except
E 200/E 230 62 E 200
E 230
Permissible trailer load, braked
63 Saloon 1,900 kg
1,700 kg
64 Estate
Vehicles with manual transmission
Vehicles with automatic transmission* 1,900 kg
2,100 kg
1,700 kg
64
2,100 kg Permissible trailer load, unbraked Saloon 750 kg 750 kg
Estate 750 kg 750 kg
Maximum drawbar noseweight
65 Saloon 76 kg 76 kg
Estate 84 kg 84 kg
62
The E 63 AMG model cannot be used to tow a trailer.
63 At a minimum gradient-climbing capability of 12% from a standstill
64 At a minimum gradient-climbing capability of 8 %: 1,900 kg
65 The drawbar noseweight is not included in the trailer load. Technical data
* optional
211_AKB; 2; 5, en-GB
mkalafa
,V ersion: 2.9.4
2008-02-29T16:57:07+01:00 - Seite 376 Dateiname: 6515_3416_02_buchblock.pdf; preflight

Service products and capacities
377Service products and capacities
Notes on service products and capaci-
ties
Service products are:
R fuels (e.g. petrol, diesel)
R lubricants (e.g. engine oil, transmission oil)
R coolant
R brake fluid
R windscreen washer fluid
Mercedes-Benz recommends that you only
use those products which have been tested
and specially approved by Mercedes-Benz for
your vehicle and are listed in the Mercedes-
Benz Owner's Manual in the relevant chapter
since:
R parts and service products are matched
R damage caused by the use of non-approved
service products is not covered by the war-
ranty You can recognise service products approved
by Mercedes-Benz by the following inscrip-
tion on the containers:
R
MB-Freigabe (e.g. MB-Freigabe 229.51)
R MB Approval (e.g. MB Approval 229.51)
Other designations or recommendations that
relate to a level of quality or a specification in
accordance with an MB Approval have not
necessarily been approved by Mercedes-
Benz.
You can obtain further information from any
Mercedes-Benz Service Centre. G
Risk of injury
When handling, storing and disposing of
any service products, please observe the
relevant regulations, as you could other-
wise endanger yourself and others.
Keep service products away from children.
To protect your health, do not allow service
products to come into contact with your eyes or open wounds. See a doctor imme-
diately if any service product is swallowed.
H
Environmental note
Dispose of service products in an environ-
mentally-responsible manner. Fuels
G
Risk of explosion
Fuel is highly flammable. Fire, naked flames
and smoking are therefore prohibited when
handling fuels.
Switch off the engine and the auxiliary heat-
ing* before refuelling. G
Risk of injury
Do not allow fuel to come into contact with
skin or clothing.
Allowing fuels to come into direct contact
with your skin or inhaling fuel vapours is
damaging to your health.
Tank capacity Technical data
* optional
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4
2008-02-29T16:57:07+01:00 - Seite 377 ZDateiname: 6515_3416_02_buchblock.pdf; preflight

Service products and capacities
380 Fuel consumption
The fuel consumption figures stated have been determined in accordance with the currently valid EU guidelines and the data does not relate
to a single vehicle. These values may be different under normal operating conditions. Manual transmission E 200 KOMPRESSOR E 230 E 280
Urban Saloon 11.7 – 12.2 l/100 km 13.3 – 13.5 l/100 km 13.4 – 13.6 l/100 km
Estate 12.4 – 12.6 l/100 km 13.8 – 13.9 l/100 km 13.7 – 13.9 l/100 km
Extra-urban Saloon 6.3 – 6.7 l/100 km 6.9 – 7.0 l/100 km 6.9 – 7.1 l/100 km
Estate 6.7 – 7.0 l/100 km 7.1 – 7.4 l/100 km 7.2 – 7.4 l/100 km
Overall (NEDC) Saloon 8.2 – 8.8 l/100 km 9.2 – 9.4 l/100 km 9.3 – 9.5 l/100 km
Estate 8.9 – 9.1 l/100 km 9.6 – 9.8 l/100 km 9.6 – 9.8 l/100 km
CO
2emissions Saloon 195 – 210 g/km 220 – 223 g/km 222 – 227 g/km
Estate 212 – 217 g/km 229 – 233 g/km 229 – 234 g/kmTechnical data
211_AKB; 2; 5, en-GB
mkalafa,
Version: 2.9.4 2008-02-29T16:57:07+01:00 - Seite 380Dateiname: 6515_3416_02_buchblock.pdf; preflight