check engine MERCEDES-BENZ E WAGON 2006 S211 Service Manual

453 Practical hints
Batteries
Disconnecting the battery
Depress parking brake firmly or move
gear selector lever to positionP.

Turn off all electrical consumers.
!Never loosen or detach battery termi-
nal clamps while the engine is running
or the SmartKey is in the starter switch.
Otherwise the alternator and other
electronic components could be se-
verely damaged.
Have the battery checked regularly by
an authorized Mercedes-Benz Center.
Refer to Maintenance Booklet for main-
tenance intervals or contact an autho-
rized Mercedes-Benz Center for further
information.Warning!
G
Do not place metal objects on the battery as
this could result in a short circuit.
Use leak-proof battery only to avoid the risk
of acid burns in the event of an accident.
Warning!
G
The electrohydraulic brake system requires
electrical power to operate.
A malfunction in the vehicle’s power supply
or electrical system may impair brake sys-
tem operation and switch it into its emer-
gency operation mode. The same applies if
battery is disconnected. To brake, the driver
must then apply significantly greater brake
pedal pressure and depress the pedal much
further to obtain the expected braking ef-
fect. If necessary, apply full pressure to the
brake pedal. Brakes may only be applied to
the front wheels. Stopping distance is in-
creased! Adjust your driving style according-
ly. For more information, refer to
“Electrohydraulic brake system”
(page 96).
Warning!
G
With a disconnected battery

you will no longer be able to turn the
SmartKey in the starter switch and
pressing the KEYLESS-GO* start/stop
button on the gear selector lever will
have no effect


the gear selector lever will remain
locked in positionP


456 Practical hintsJump starting
If the battery is discharged, the engine can
be started with jumper cables and the bat-
tery of another vehicle. Observe the follow-
ing:

Jump starting should only be performed
when the engine and catalytic
converter are cold.


Do not start the engine if the battery is
frozen. Let the battery thaw out first.


Only jump start from batteries with the
same voltage rating (12 V). Jump start-
ing with a more powerful battery could
damage the vehicle’s electrical system,
which will not be covered by the
Mercedes-Benz Limited Warranty.


Use only jumper cables with sufficient
cross-section and insulated terminal
clamps.


Always make sure the jumper cables
are not on or near pulleys, fans or other
parts that move when the engine is
started or running.
Warning!
G
Failure to follow these directions will cause
damage to the electronic components, and
can lead to a battery explosion and severe
injury or death.
Never lean over batteries while connecting
or jump starting, you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water, and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and very explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.
Attempting to jump start a frozen battery
can result in it exploding, causing personal
injury.
Read all instructions before proceeding.
!Jump starting may only be performed
on the designated jump start terminals
located in the engine compartment
(page 457).
Avoid repeated and lengthy starting at-
tempts.
Do not attempt to start the engine us-
ing a battery quick charge unit.
If the engine does not run after several
unsuccessful starting attempts, have it
checked at the nearest authorized
Mercedes-Benz Center.
Excessive unburned fuel generated by
repeated failed starting attempts may
damage the catalytic converter.
Make sure the jumper cables do not
have loose or missing insulation.
Make sure the cable clamps do not
touch any other metal part while the
other end is still attached to a battery.

457 Practical hints
Jump starting
The jump-start contacts are located in the
engine compartment.
Make sure the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift gear selector lever to positionP.

Open the hood (
page 315).

Open cover 2 of the positive terminal.

Connect positive terminal 2 and the
positive terminal of the charged battery
with the jumper cable. Clamp cable to
charged battery first. 1Negative (-) terminal
2Cover of Positive (+) terminal

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect negative terminal1 and the
negative terminal of the charged
battery with the jumper cable. Clamp
cable to charged battery first.

Start the engine of the disabled
vehicle.Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
negative terminals on each battery and
then from the positive terminals on
each battery.
Now you can turn on the lights.

Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 322).
!Never invert the terminal connections!
iThe message
Malfunction - electric
consumers switched off
may appear
in the instrument cluster. It will disap-
pear as soon as the battery is suffi-
ciently charged.
!Do not tow-start the vehicle.

488 Technical dataFuels, coolants, lubricants etc.Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 anticorrosion/antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze [equivalent to freeze
protection to approximately - 22°F
(-30°C)]. If you use a solution that is more
than 55% anticorrosion/antifreeze [freeze
protection to approximately - 49°F
(-45°C)], the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.If the coolant level is low, water and MB
325.0 anticorrosion/antifreeze should be
used to bring it up to the proper level (have
cooling system checked for signs of leak-
age). Please make sure the mixture is in
accordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz
Center.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life).Therefore, the following product is strongly
recommended for use in your vehicle:
MB 325.0 anticorrosion/antifreeze agent.
Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.

498 Index
Shift program mode selector
switch 189
Shift program mode selector switch,
Manual shift program E 55
AMG 194
Starting engine 50
Steering wheel gearshift control
one-touch gearshifting E 55
AMG 191
Winter program mode 189
B
Backrest 260
Folding rearward 261
Seat 41
Seat, multicontour 133
Backup lamps
Messages in display 409
Replacing bulbs 431
Bar 350
BAS 93, 491
Batteries, SmartKey
Changing 429, 430
Checking battery condition 110, 117
Batteries, SmartKey with KEYLESS-GO*
Changing 429, 430
Checking battery condition 117Batteries, Vehicle
Charging 454
Disconnecting 453
Installing 454
Jump starting 456
Messages in display 386, 395, 396
Reconnecting 455
Removing 454
Bead 350
Beverage holder see Cup holders
Bi-Xenon headlamps* see Headlamps
Block heater* (Canada only) 356
Brake Assist System see BAS
Brake fluid
Checking 313
Messages in display 399
Brake lamp
Cleaning lenses 365
Messages in display 409
Replacing bulbs 431
Brake pads
Message in display 397
Brakes 302
Warning lamp 374
Break-in period 300
Bulbs see Replacing bulbsC
CAC 491
California retail buyers and lessees, impor-
tant notice for 11
Can holder see Cup holders
CAN system 491
Capacities and recommended
fuel/lubricants 482
Cargo compartment
Fuse box 463
Tie-down rings 264
Cargo compartment cover 270
Cargo management system* 265
Belt reel 267
Cargo tie-down ring 266
Mounting elements 265
Telescoping rod 267
Cargo net 269
Cargo tie-down rings 264
Carpets, cleaning 368
Catalytic converter 310
CD player 162

499 Index
Center console
Lower part 28
PASS AIR BAG OFF indicator
lamp 381
Upper part 27
Centigrate see Temperature display mode
Central locking
Automatic 127, 176
Locking/unlocking from inside 128
Central locking switch 128
Certification label 468
Checking
Oil level 316
Children in the vehicle 77
Air bags 68
Blocking of rear window operation 89
Indicator lamp, front passenger front
air bag
Infant and child restraint systems 78
LATCH-type child seat anchors 88
Occupant Classification System (OCS)
Cigarette lighter 278Climate control system
4-zone automatic climate
control 214
Air conditioning refrigerant 485
Air conditioning, Cooling 212, 227
Air distribution 208, 222
Air recirculation mode 210, 224
Air volume 209, 223
Automatic mode 206, 220
Control panel, Rear 213, 229
Deactivating system 206, 219
Dual-zone automatic climate
control 202
Front defroster 209, 223
Maximum cooling MAX COOL 224
Rear climate control 229
Residual engine heat (REST) 228
Clock 25, 170
Setting time 171
Cockpit 22, 491
Cockpit Management and Data System
see COMAND
Cold tire inflation pressure 350
Collapsible tire 478
Collapsible wheel chock 423
COMAND 492COMAND see separate COMAND operat-
ing instructions
Combination switch 54, 147
Control system 155, 492
Multifunction display 155
Multifunction steering wheel 156
Resetting to factory default 166
Control system menus 158, 159
AUDIO 161
Distronic* 163
NAV* 163
Settings 165
Standard display 161
TEL* 181
Trip computer 180
Vehicle status message memory 164
Control system submenus 157
Convenience 177
Instrument cluster 168
Lighting 172
Time/Date 170
Vehicle 176
Controller Area Network see CAN system
Convenience submenu
Setting parking position for exterior
rear view mirror 178

502 IndexEngine
Belt layout 469
Block heater* (Canada only) 356
Cleaning 364
Compartment 315
Malfunction indicator lamp 375, 400
Maximum engine speed 471
Message in the display 375, 400
Number 468, 492
Starting 50
Starting with KEYLESS-GO* 51
Tachometer 25
Technical data 470
Turning off with KEYLESS-GO* 61
Turning off with the SmartKey 61
Engine compartment
Hood 315
Engine coolant see Coolant
Engine malfunction indicator lamp 375,
400Engine oil
Adding 319
Additives 485
Changing 319
Checking level (Control system) 317
Checking level (Dipstick) 318
Consumption 316
Filler neck 320
Messages in display 317, 405
Recommended engine oils and oil
filter 485
Viscosity 492
Engine oil level 314
ESP
®
93, 492
Four wheel electronic traction system
with ESP
®
99
Messages in display 388
Warning lamp 373
ETD 492
Safety guidelines 70
Exterior rear view mirrors
Parking position 178F
Factory, SmartKey with
KEYLESS-GO* 114
Filler neck, Engine oil 320
First aid kit 419
Flat tire 440
Lowering the vehicle 450
Mounting the spare wheel 445, 447
Preparing the vehicle 440
Sealing tires with TIREFIT 440
Spare wheel 445
TIREFIT kit 440
Flexible Service System see FSS
Floormats 280
Fluids
Automatic transmission fluid 482
Brake fluid 483
Capacities 482
Engine coolant 483
Engine oil 482
Power steering fluid 483
Windshield washer and headlamp
cleaning system 484
Fog lamps 146
Messages in display 409
Replacing bulbs 433

505 Index
Instrument lighting see Instrument cluster,
Illumination brightness
Instrument panel see Instrument cluster
Instruments and controls see Cockpit
Interior lighting
Delayed shut-off 175
Interior rear view mirror 45
Auto-dimming mirrors 197
Interior storage spaces see Storage com-
partments
J
Jack 422
Jump starting 456K
Key, Mechanical 424
Key, SmartKey
Battery check lamp 106
Changing batteries 429
Factory setting 108
Locking/unlocking 34
Locking/unlocking, Global
setting 108
Locking/unlocking, Selective
setting 109
Loss of 111
Messages in display 408
Opening and closing the power
tilt/sliding sunroof* 234
Opening and closing the
windows 234
Positions in starter switch 36
Remote control 106
Starting the engine 50
Turning off engine 61Key, SmartKey with KEYLESS-GO*
Battery check lamp 111
Changing batteries 429, 430
Factory setting 114
Locking, Tailgate 115
Locking/unlocking 35
Locking/unlocking, Selective
setting 115
Loss of 118
Messages in display 407
Opening and closing the power
tilt/sliding sunroof* 234
Opening and closing the
windows 234
Starting the engine 51
Turning off engine 61
Unlocking, Tailgate 117
KEYLESS-GO* 493
KEYLESS-GO* see Key, SmartKey with
KEYLESS-GO*
Kickdown 187, 493
Kilopascal 351

506 IndexL
Labels
Certification 468
Emission control information 468
Emission control vacuum line
routing 468
Lamp sensor
Message in display 411
Lamps, exterior
Light sensor 410, 411
Messages in display 409, 410, 411,
412
Lamps, indicator and warning
ABS 25, 372
Battery (SmartKey) 109, 115
Brakes 374
CHECK ENGINE 375
Coolant 376
Distance warning lamp* 246
Electrohydraulic brake system 96
Engine diagnostics 375
Engine malfunction 25, 375
ESP
®
25, 373
Fog lamps 146
Front passenger front air bag off 27,
72, 382Fuel reserve 25, 377
High beam headlamps 25
Instrument cluster 372, 373, 374,
375, 376, 377, 378, 380
Low beam headlamps 25
Maintenance service indicator 358
Seat belt telltale 25
Seat belts 377
SRS 66
Turn signals 25
Language, Setting 168
LATCH-type child seat anchors see Chil-
dren in the vehicle
License plate lamps 432
Messages in display 410
Replacing bulbs 436
Light alloy wheels, cleaning 367
Light sensor see Lamp sensor
Lighter see Cigarette lighter 278
Lighting
Daytime running lamp mode 144
Lighting, Exterior and interior 143
Limp Home Mode 196
Loading 260
Split rear bench seat* 260
Loading see Vehicle loadingLocator lighting 173
Lock button 493
Door handle (KEYLESS-GO*) 63
Loss of Service and Warranty Information
Booklet 467
Loss of SmartKeys 111, 118
Low beam headlamps 54
Indicator lamp 25
Messages in display 410
Replacing bulbs 432
Switching on 54
Lubricants 482
Lumbar support 133
M
Maintenance 12
Calling up service indicator 360
Clearing service indicator
message 359
FSS (Canada vehicles) 358
Maintenance System (U.S.
vehicles) 358
Resetting service indicator 361
Service indicator 358
Service indicator message 358
Service term exceeded 360

507 Index
Maintenance System (U.S. vehicles) 494
Manual headlamp mode see Headlamps
Manual shift program E 55 AMG 193
Deactivating 196
Maximum inflation pressure 351
Maximum load rating 351
Maximum loaded vehicle weight 351
Mechanical key 424
Memory function 494
Memory function see Seats
Menus see Control system menus
Messages in display see Multifunction dis-
play messages
Mirrors
Adjusting 45
Auto-dimming 197
Exterior rear view mirror 45
Exterior rear view mirror parking
positions 178, 198
Interior rear view mirror 45
MOExtended system* 340, 451
MOExtended tires* 477
MON 313
Motor Octane Number see MONMultifunction display 155, 494
Changing settings see Control system
menus and Control system sub-
menus
Selecting language 168
Multifunction display messages 385
ABS
Batteries 386, 395, 396
Brake fluid 399
Brake lamps 409
Brake pads 397
Check engine 375
Coolant 400, 401, 402
Cruise control 386
Distronic* 386
Door 403
Electrohydraulic brake system 397,
398
Engine oil 317, 404, 405, 406
ESP
®
388, 389
Fog lamps 409, 411
Fuel reserve tank 408
Headlamps 409, 410, 411
Hood 407
Key, SmartKey 408
Key, SmartKey with KEYLESS-GO* 407
Panorama roof with power tilt/sliding
panel* 414
Parking brake 398
Parking lamps 411
Power tilt/sliding sunroof* 414
Seat belts 414
SRS 415
Tailgate 416
Tele Aid 414
Telephone* 416
Tires 413
Turn signals 412
Windshield washer fluid 416
Multifunction steering wheel 26, 156,
494
Button operation 156
N
Navigation system
See separate COMAND operating
instructions 163
Net, parcel 274
Neutral gear position 186
Night security illumination 145
Normal occupant weight 351
Number, vehicle identification (VIN) 468