wheel bolt torque MERCEDES-BENZ E320CDI 2005 W211 Owner's Manual

340 OperationTires and wheelsRotating tires
Tire rotation can be performed on vehicles
with tires of the same dimension all
around. If your vehicle is equipped with
tires of the same dimension all around,
tires can be rotated, observing a
front-to-rear rotation pattern that will
maintain the intended rotation (spinning)
direction of the tire (
page 314).
In some cases, such as when your vehicle
is equipped with mixed-size tires (different
tire dimension front vs. rear), tire rotation
is not possible.If applicable to your vehicle's tire configu-
ration, tires can be rotated according to
the tire manufacturer's recommended in-
tervals in the tire manufacturer's warranty
pamphlet located in your vehicle literature
portfolio. If none is available, tires should
be rotated every 3000 to 6 000 miles
(5 000 to 10 000 km), or sooner if neces-
sary, according to the degree of tire wear.
The same rotation (spinning) direction
must be maintained (
page 314).
Rotate tires before the characteristic tire
wear pattern becomes visible (shoulder
wear on front tires and tread center wear
on rear tires).
Thoroughly clean the mounting face of
wheels and brake disks, i.e. the inner side
of the wheels/tires, during each rotation.
Check for and ensure proper tire inflation
pressure, activating the tire pressure mon-
itoring system* if necessary.
For information on wheel change, see the
“Practical hints” section (
page 407) and
(
page 425).
Warning!
G
Rotate front and rear wheels only if they are
of the same size.
If your vehicle is equipped with mixed-size
tires (different tire dimensions front vs.
rear), tire rotation is not possible.
!If your vehicle is equipped with a tire
pressure monitoring system*, there
are electronic components built into
the wheel.
Do not use mounting tools in the area
of the valve as they could damage the
electronic components.
To prevent damage or incorrect instal-
lation, have the tires changed at an au-
thorized Mercedes-Benz Center.Warning!
G
Have the tightening torque checked after
changing a wheel. Wheels could become
loose if not tightened with a torque of
96 lb-ft (130 Nm).
Only use genuine Mercedes-Benz wheel
bolts specified for your vehicle's rims.

431 Practical hints
Flat tire
Lowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.

Remove the jack.
1-5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of 96 lb-ft
(130 Nm).

Before storing the jack in the trunk, it
should be fully collapsed.Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
96 lb-ft (130 Nm).
iWrap the damaged wheel in the protec-
tive film that comes with the spare
wheel and put the wheel in the trunk.
You can also place the damaged wheel
down into the spare wheel well. In this
case, you must stow the holder from
the spare wheel well in the trunk.
Do not activate the tire pressure moni-
toring system until the depressurized
tire is no longer in the vehicle.

475 Technical terms
PTC heating element
(P
ositive T
emperature C
oefficient)
Electronic component that warms up
quickly as electricity is supplied to it
and is used as a ->heater booster sys-
tem in diesel vehicles.
Restraint systems
Seat belts, belt tensioners, air bags and
child restraint systems. As indepen-
dent systems, their protective func-
tions complement one another.
RON
(R
esearch O
ctane N
umber)
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the ->MON (Motor Octane Number)
and RON (Research Octane Number) is
posted at the pump, also known as
ANTI-KNOCK INDEX.SBC
(S
ensotronic B
rake C
ontrol)
Electronically controlled hydraulic
braking system for increased braking
safety and comfort.
Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being moved out of positionP
without the ignition or engine on and
brake pedal depressed.
SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and air bags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.Tele Aid System
(T
elematic A
larm I
dentification on D
e-
mand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.
The Tele Aid system is operational pro-
vided that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.
Telematics*
A combination of the terms “telecom-
munications” and “informatics”.
Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.

499 Index
Temperature
Display mode 157
Sensor 29
Setting interior temperature 197
Setting units in display 157
Tires 321
The coolant level is correct if the
level 308
Tie-down rings (trunk) 261
Tightening torque 431, 475
Time
Setting hours 160
Setting minutes 160, 161
TIN 339
Tire
Vehicle maximum load on 339
Tire and Loading Information 315
Tire and loading terminology 337
Tire care and maintenance 312
Tire Identification Number see TIN
Tire inflation pressure
Checking 320
Setting units 159
Tire inflation pressure see the placard on
the fuel filler flap
Tire inspection 312Tire load rating 339
Tire ply composition and material
used 339
Tire speed rating 329, 339, 476
Tire terminology 337
Tire traction 292
Tires
Direction of rotation 314
Driving instructions 290
Messages in display 399
Messages in the display 396, 397,
398
Retreads 311
Rotating 340
Service life 312
Temperature 321, 336
Tire pressure monitor warning
lamp* 363
Tread depth 313, 341
Wear pattern 340
Winter 341
Tires and wheels
Tire inflation pressure 322
Tools 409Tow-away alarm 95
Arming 95
Disarming 95
Disarming for transport 95
Towing eye bolt (vehicle tool kit)
Installing 442
Towing the vehicle 439
Tracking services
For stolen vehicle 279
Traction 180, 339, 476
Transmission fluid level 308
Tread 339
Tread depth 313
Tread depth (tires 341
Treadwear indicators 339
Trip computer 170
Trip odometer
Resetting 143

501 Index
Vehicle care
Cup holder 353
Distronic* system sensor cover 351
Engine cleaning 350
Gear selector lever 353
Hard plastic trim items 353
Leather upholstery 354
Light alloy wheels 353
Ornamental moldings 350
Paintwork 349
Parktronic* system sensor 351
Plastic and rubber parts 354
Power washer 349
Seat belts 353
Steering wheel 353
Tar stains 349
Vehicle washing 350
Window cleaning 352
Wood trims 354
Vehicle level
Changing 249
Setting 249
Automatic 249
Manual 249
Vehicle level control system*
Airmatic DC* 247Vehicle loading terminology 337
Vehicle maximum load on the tire 339
Vehicle status message memory 153
Calling up 153
Vehicle tool kit 409
Alignment bolt 409
Fuse extractor 409
Hex-socket wrench 409
Open-end wrench 409
Screwdriver 409
Spare fuses 409
Towing eye bolt 409
Universal pliers 409
Wheel wrench 409
Vehicle washing 350
VIN (Vehicle Identification Number) 476
Voice control system* 476W
Warning lamps see Lamps, indicator and
warning
Warning sounds
Distance warning function* 243
Distronic* 237
Drivers seat belts 67
Parking brake 49
Parktronic system* 253
Warranty coverage 447
Washing the vehicle 348
Wear pattern (tires) 340
Weights 460
Wheel change 425
Tightening torque 431
Wheels
Tires and wheels 311
Window curtain airbags 66
Windows see Side windows 218
Windshield
Defogging 198, 211
Refilling washer fluid 310
Replacing wiper blades 424
Washer fluid 310